硫酸盐侵蚀下硬化水泥浆体微结构演变及膨胀过程的数值模拟

硅酸盐通报 ›› 2022, Vol. 41 ›› Issue (12): 4128-4138.

所属专题：水泥混凝土

硫酸盐侵蚀下硬化水泥浆体微结构演变及膨胀过程的数值模拟

刘云强, 左晓宝, 黎亮, 邹欲晓

南京理工大学理学院土木工程系,南京 210094

收稿日期:2022-07-05 修订日期:2022-08-21 出版日期:2022-12-15 发布日期:2023-01-11
通信作者: 左晓宝,博士,教授。E-mail:xbzuo@sina.com
作者简介:刘云强(1997—),男,硕士研究生。主要从事混凝土耐久性数值模拟的研究。E-mail:lyq19971998@163.com
基金资助:
国家自然科学基金面上项目(52078252);江苏省研究生科研与实践创新计划项目(KYCX21_0331)

Numerical Simulation on Microstructure Evolution and Expansion Process of Hardened Cement Paste under Sulfate Attack

LIU Yunqiang, ZUO Xiaobao, LI Liang, ZOU Yuxiao

Department of Civil Engineering, School of Science, Nanjing University of Science and Technology, Nanjing 210094, China

Received:2022-07-05 Revised:2022-08-21 Online:2022-12-15 Published:2023-01-11

摘要/Abstract

摘要： 根据硫酸盐侵蚀机理,利用改进的CEMHYD3D水化模型和随机概率方法,建立了硫酸盐侵蚀下硬化水泥浆体的微结构演变模型。在微观层次上,模拟了浆体孔溶液中硫酸根离子的自由扩散、随机碰撞和转化反应,分析了膨胀性侵蚀产物生长导致的微结构损伤和体积膨胀,计算了侵蚀过程中石膏和钙矾石的生成量及浆体的膨胀应变,并与已有试验结果对比分析验证了模型的合理性。在此基础上,数值模拟了硫酸盐侵蚀下不同水灰比水泥浆体的微结构演变及膨胀过程。结果表明:同一硫酸盐浓度下,硬化水泥浆体中氢氧化钙和含铝物相与孔隙的接触面积越小,浆体的膨胀应变越低;水灰比为0.25、0.30和0.35的硬化水泥浆体的孔隙填充程度分别达到9.09%、9.27%和9.41%时,浆体膨胀应变开始快速增大;硫酸盐侵蚀溶液浓度增大,浆体体积快速膨胀的时间提前。

关键词: 硫酸盐侵蚀, 硬化水泥浆体, 微结构, 石膏, 钙矾石, 体积膨胀, 数值模拟

Abstract: Based on the mechanism of sulfate attack, a microstructure evolution model of hardened cement paste under sulfate attack was established by using the improved CEMHYD3D hydration model and random probability method. At the microscopic level, the free diffusion, random collision and transformation reaction of sulfate ions in the pore solution of hardened cement paste were simulated, and the microstructure damage and volume expansion induced by the growth of expansive erosion products were analyzed. Meanwhile, the content of gypsum and ettringite and the expansion strain of paste in the process of sulfate attack were calculated, and the model was verified by comparing with the experimental results in present literature. On the basis of the model, the microstructure evolution and expansion process of hardened cement pastes with different water-cement ratios under sulfate attack were numerically simulated. The results show that under the same sulfate concentration, the smaller the decrease in the contact area of calcium hydroxide and phase containing aluminum with pores is,the lower the expansion strain of hardened cement paste is. For hardened cement pastes with water-cement ratios of 0.25, 0.30 and 0.35, their expansion strain begins to increase rapidly when the pore filling degree reaches 9.09%, 9.27% and 9.41%, respectively. As the sulfate concentration increases, the time for rapid expansion of hardened cement paste is advanced.

Key words: sulfate attack, hardened cement paste, microstructure, gypsum, ettringite, volume expansion, numerical simulation

中图分类号:

TU528

刘云强, 左晓宝, 黎亮, 邹欲晓. 硫酸盐侵蚀下硬化水泥浆体微结构演变及膨胀过程的数值模拟[J]. 硅酸盐通报, 2022, 41(12): 4128-4138.

LIU Yunqiang, ZUO Xiaobao, LI Liang, ZOU Yuxiao. Numerical Simulation on Microstructure Evolution and Expansion Process of Hardened Cement Paste under Sulfate Attack[J]. BULLETIN OF THE CHINESE CERAMIC SOCIETY, 2022, 41(12): 4128-4138.

参考文献

[1] 仵江涛,何锐,王笑风,等.硫酸盐侵蚀混凝土内外影响因素及影响机理研究进展[J].硅酸盐通报,2019,38(1):110-117.
WU J T, HE R, WANG X F, et al. Research progress on inside and outside factors and influence mechanism of sulfate attack concrete[J]. Bulletin of the Chinese Ceramic Society, 2019, 38(1): 110-117 (in Chinese).
[2] 吴凯,徐玲琳,施惠生,等.集料含量对掺矿物掺合料水泥基材料抗硫酸盐侵蚀性能的影响[J].东南大学学报(自然科学版),2016,46(2):419-426.
WU K, XU L L, SHI H S, et al. Effects of aggregate volume content on sulfate resistance properties of cement based materials with supplementary cementitious materials[J]. Journal of Southeast University (Natural Science Edition), 2016, 46(2): 419-426 (in Chinese).
[3] 张晓佳,张高展,孙道胜,等.水泥基材料硫酸盐侵蚀机理的研究进展[J].材料导报,2018,32(7):1174-1180.
ZHANG X J, ZHANG G Z, SUN D S, et al. Progress of the mechanism of sulfate attack on cement-based materials[J]. Materials Review, 2018, 32(7): 1174-1180 (in Chinese).
[4] LIU K, DENG M, MO L, et al. Deterioration mechanism of Portland cement paste subjected to sodium sulfate attack[J]. Advances in Cement Research, 2015, 27(8):477-486.
[5] ZHANG G Z, WU C, HOU D S, et al. Effect of environmental pH values on phase composition and microstructure of Portland cement paste under sulfate attack[J]. Composites Part B: Engineering, 2021, 216: 108862.
[6] 李涛,朱鹏涛,张彬,等.硫酸盐侵蚀下混凝土内腐蚀反应-扩散过程的实验研究[J].硅酸盐通报,2020,39(1):50-55.
LI T, ZHU P T, ZHANG B, et al. Experimental study on corrosion reaction-diffusion process of concrete under sulfate attack[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(1): 50-55 (in Chinese).
[7] SCHMIDT T, LOTHENBACH B, ROMER M, et al. Physical and microstructural aspects of sulfate attack on ordinary and limestone blended Portland cements[J]. Cement and Concrete Research, 2009, 39(12): 1111-1121.
[8] RAGOUG R, METALSSI O O, BARBERON F, et al. Durability of cement pastes exposed to external sulfate attack and leaching: physical and chemical aspects[J]. Cement and Concrete Research, 2019, 116: 134-145.
[9] 刘超,马忠诚,刘浩云.水泥混凝土硫酸盐侵蚀综述[J].材料导报,2013,27(7):67-71.
LIU C, MA Z C, LIU H Y. An overview on sulfate corrosion of cement concrete[J]. Materials Review, 2013, 27(7): 67-71 (in Chinese).
[10] 刘赞群,邓德华,SCHUTTER G,等.“混凝土硫酸盐结晶破坏”微观分析(Ⅱ)—混凝土[J].硅酸盐学报,2012,40(5):631-637.
LIU Z Q, DENG D H, SCHUTTER G, et al. Micro-analysis of “sulfate salt weathering distress on concrete”: concrete[J]. Journal of the Chinese Ceramic Society, 2012, 40(5): 631-637 (in Chinese).
[11] 吴晓杰,张跃博.硫酸盐侵蚀-干湿循环作用对混凝土力学性能与微结构的影响[J].混凝土,2021(10):10-13.
WU X J, ZHANG Y B. Study on the sulfate erosion and dry-wet cycling effects on the mechanical performance and microstructure of concrete[J]. Concrete, 2021(10): 10-13 (in Chinese).
[12] 李华,孙伟,左晓宝.矿物掺合料改善水泥基材料抗硫酸盐侵蚀性能的微观分析[J].硅酸盐学报,2012,40(8):1119-1126.
LI H, SUN W, ZUO X B. Effect of mineral admixtures on sulfate attack resistance of cement-based materials[J]. Journal of the Chinese Ceramic Society, 2012, 40(8): 1119-1126 (in Chinese).
[13] FENG P, MIAO C W, BULLARD J W. A model of phase stability, microstructure and properties during leaching of Portland cement binders[J]. Cement and Concrete Composites, 2014, 49: 9-19.
[14] GU Y S, DANGLA P, MARTIN R P, et al. Modeling the sulfate attack induced expansion of cementitious materials based on interface-controlled crystal growth mechanisms[J]. Cement and Concrete Research, 2022, 152: 106676.
[15] 吴大江,佘伟,缪昌文,等.基于改进的CEMHYD3D模型模拟水泥水化微结构演变过程[J].建筑材料学报,2020,23(1):11-17.
WU D J, SHE W, MIAO C W, et al. Simulation of cement hydration microstructure evolution process based on improved CEMHYD3D model[J]. Journal of Building Materials, 2020, 23(1): 11-17 (in Chinese).
[16] DA SILVA ANDRADE NETO J, DE LA TORRE A G, KIRCHHEIM A P. Effects of sulfates on the hydration of Portland cement: a review[J]. Construction and Building Materials, 2021, 279: 122428.
[17] LIAO K X, ZHANG Y P, ZHANG W P, et al. Modeling constitutive relationship of sulfate-attacked concrete[J]. Construction and Building Materials, 2020, 260: 119902.
[18] MERZOUKI T, BOUASKER M, HOUDA KHALIFA N E, et al. Contribution to the modeling of hydration and chemical shrinkage of slag-blended cement at early age[J]. Construction and Building Materials, 2013, 44: 368-380.
[19] YIN G J, ZUO X B, SUN X H, et al. Macro-microscopically numerical analysis on expansion response of hardened cement paste under external sulfate attack[J]. Construction and Building Materials, 2019, 207: 600-615.
[20] ZUO X B, WANG J L, SUN W, et al. Numerical investigation on gypsum and ettringite formation in cement pastes subjected to sulfate attack[J]. Computers and Concrete, 2017, 19(1): 19-31.
[21] 王金川,陈登.水灰比和硫酸钠浓度对水泥基材料劣化过程的影响[J].混凝土与水泥制品,2021(7):21-25.
WANG J C, CHEN D. Influence of W/C and sulfate concentration on deterioration process of cement based material[J]. China Concrete and Cement Products, 2021(7): 21-25 (in Chinese).

硫酸盐侵蚀下硬化水泥浆体微结构演变及膨胀过程的数值模拟

Numerical Simulation on Microstructure Evolution and Expansion Process of Hardened Cement Paste under Sulfate Attack

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	齐晓, 肖前慧, 邱继生, 刘书林. 冻融循环与硫酸盐侵蚀共同作用下再生混凝土的微观结构研究[J]. 硅酸盐通报, 2023, 42(4): 1194-1204.
[2]	王杰, 王勇, 王宇强, 王彩萍, 叶圣茂, 高鹏. 循环流化床燃煤固硫灰的CBR特性及膨胀机理研究[J]. 硅酸盐通报, 2023, 42(4): 1323-1332.
[3]	余海燕, 徐晴, 王英翔, 董德宇. 不同环境下碳铝酸钙的稳定性研究[J]. 硅酸盐通报, 2023, 42(3): 845-853.
[4]	赵立, 孙江涛, 吴定略, 李志堂, 何涛, 关业程, 沈卫国. 石屑湿喷混凝土的制备与性能研究[J]. 硅酸盐通报, 2023, 42(3): 1016-1024.
[5]	卓耀彬, 吕碧飞, 宋小文, 杨辰龙, 叶晓平, 陈旭绍. 玻璃管水平拉制成型过程的数值模拟[J]. 硅酸盐通报, 2023, 42(3): 1096-1105.
[6]	王家燕, 董博, 余超, 邓承继, 丁军, 祝洪喜. 四元矿化剂对硅砖微观形貌及物理性能的影响[J]. 硅酸盐通报, 2023, 42(3): 1115-1121.
[7]	刘德嵩, 杨忠德, 林鑫, 谢虎, 张菡欣, 王开, 黄守武, 刘振英. 轻质氧化镁含量对方镁石-镁铝尖晶石砖性能的影响[J]. 硅酸盐通报, 2023, 42(3): 1122-1129.
[8]	王含, 沈瑞麟, 王鸿妹, 汪庆卫. 晶相组成对硅质耐火材料抗碱侵蚀性能的影响[J]. 硅酸盐通报, 2023, 42(3): 1130-1136.
[9]	王振军, 史文涛, 张婷, 李梦, 王泽辉. PNIPAM温敏凝胶对水泥材料抗硫酸盐侵蚀性能的影响[J]. 硅酸盐通报, 2023, 42(2): 429-438.
[10]	李广, 李北星, 黄安, 邓俊双. 养护温度和矿物掺合料对蒸养混凝土脆性的影响[J]. 硅酸盐通报, 2023, 42(2): 487-495.
[11]	李宇航, 温勇, 韩国旗, 郝恩泽, 刘佳, 马丽莎. 持续荷载和锂渣取代量对混凝土抗氯离子渗透性能的影响[J]. 硅酸盐通报, 2023, 42(2): 598-606.
[12]	陈辛, 曾祥会, 方伟, 何漩, 杜星, 王大珩, 李薇馨, 赵雷, 陈辉. 二次铝灰制备高强度陶粒及其性能研究[J]. 硅酸盐通报, 2023, 42(2): 618-625.
[13]	樊璐洋, 金子豪, 苏英, 崔程嘉, 王斌. 基于响应面法的半水磷石膏复合胶凝材料优化设计及性能研究[J]. 硅酸盐通报, 2023, 42(2): 626-636.
[14]	罗国夫, 陈开圣, 骆弟普. 磷石膏稳定红黏土的压缩特性及微观机理[J]. 硅酸盐通报, 2023, 42(2): 644-656.
[15]	李妤茜, 乔秀臣. 外部因素对钙矾石晶体结构及形貌的影响综述[J]. 硅酸盐通报, 2023, 42(1): 31-47.