Determination of trichothecenes in cereals and cereal-based products by liquid chromatography-tandem mass spectrometry

A sensitive, accurate and precise method for the simultaneous determination of nivalenol (NIV), deoxynivalenol (DON), T-2 toxin (T-2) and HT-2 toxin (HT-2) in different food matrices, including wheat, maize, barley, cereal-based infant foods, snacks, biscuits and wafers, has been developed. The method, using liquid chromatography coupled with atmospheric pressure chemical ionization triple quadrupole mass spectrometry (LC-APCI-MS/MS), allowed unambiguous identification of the selected trichothecenes at low µg per kg levels in such complex food matrices. A clean-up procedure, based on reversed phase SPE Oasis® HLB columns, was used, allowing good recoveries for all studied trichothecenes. In particular, NIV recoveries significantly improved compared to those obtained by using Mycosep® #227 columns for clean-up of the extracts. Limits of detection in the various investigated matrices ranged 2.5-4.0 µg kg^-1 for NIV, 2.8-5.3 µg kg^-1 for DON, 0.4-1.7 µg kg^-1 for HT-2 and 0.4-1.0 µg kg^-1 for T-2. Mean recovery values, obtained from cereals and cereal products spiked with NIV, DON, HT-2 and T-2 toxins at levels from 10 to 1000 µg kg^-1, ranged from 72 to 110% with mean relative standard deviation lower than 10%. A systematic investigation of matrix effects in different cereals and cereal products was also carried out by statistically comparing the slopes of standard calibration curve with matrix-matched calibration curve for each of the four toxins and the eight matrices tested. For seven of the eight matrices tested, statistically significant matrix effects were observed, indicating that, for accurate quantitative analysis, matrix-matched calibration was necessary. The method was applied to the analysis of 57 samples of ground wheat originated from South Italy and nine cereal food samples collected from retail markets.     

Natural contamination of oat with group A trichothecene mycotoxins in Poland

Ninety-nine naturally contaminated oat grain samples were collected in 12 plant breeding stations in different parts of Poland. T-2 toxin, HT-2 toxin and diacetoxyscirpenol (DAS) levels were determined by gas chromatography with mass selective detection (GC-MS). HT-2 was the major toxin with an incidence of 24% and its average level in positive samples was 21 μg kg^-1. The incidence of T-2 and DAS was 15 and 12%, and their average levels were 60 and 23 μg kg^-1, respectively. The highest concentrations of HT-2, T-2 and DAS were 47, 703 and 111 μg kg^-1, respectively. Sixty-five samples were free of detectable amounts of the toxic metabolites analysed.     

A survey on the occurrence of Fusarium mycotoxins in Bavarian cereals from the 1987 harvest

Bavarian cereals and wheat flour from the 1987 harvest were analysed for nivalenol (NIV) and deoxynivalenol (DON) using high performance liquid chromatography (HPLC) and for T-2 toxin and zearalenone (ZEA) by enzyme-linked-immunosorbent assay (ELISA). The study included 190 field samples of wheat, barley, rye and oat with visibly damaged ears, 45 samples of wheat intended for feed production and two series of wheat flour (type 550) and whole wheat flour collected in October 1987 and June 1988. The field samples examined showed a high DON contamination of wheat (87%) with an average of 3.96 mg/kg and a maximum of 43.8 mg/kg. Mean levels between 0.33 mg/kg and 0.27 mg/kg DON could be detected in barley, rye and oat. Of the wheat samples, 58% contained ZEA with a maximum of 1.560 mg/kg. The highest levels of ZEA were detected in samples which also showed high concentrations of DON. The NIV and T-2 toxin levels were comparatively low. Thirty percent of the samples showed NIV concentrations between 0.04 mg/kg and 0.29 mg/kg and 38% contained between 0.005 and 0.60 mg/kg of T-2. In the wheat samples for feed production, only DON was detected with an average of 0.190 mg/kg and a maximum of 0.75 mg/kg. The highest DON levels (0.58 mg/kg) from October 1987 were found in the wheat flour samples which were lower than the highest DON concentration (3.24 mg/kg) detected in the samples collected during June 1988. This fact was probably due to a substantial amount of non-contaminated wheat from 1986. The toxin concentrations in the whole wheat flour were not higher than in the type 550 flour.(ABSTRACT TRUNCATED AT 250 WORDS)     

Fusarium toxins in wheat flour collected in an area in southwest Germany

A total of 60 samples of wheat flour were collected during the first 6 months of 1999 from mills and food stores in an area in southwest Germany. Samples included whole-grain and two types of white flour with these three groups characterized by a high, medium and low ash content. The contents of deoxynivalenol (DON), nivalenol (NIV), 3- and 15-acetyldeoxynivalenol, HT-2 toxin (HT-2), T-2 toxin (T-2) and fusarenon-X (FUS-X) were determined by gas chromatography/mass spectrometry, and those of zearalenone (ZEA), alpha- and beta-zearalenol (alpha- and beta-ZOL) by high performance liquid chromatography with fluorescence detection. FUS-X, alpha- and beta-ZOL were not detected in any sample. Based on incidence and level, DON was the predominant toxin followed by NIV and ZEA for all three flour types. The overall degree of toxin contamination was lower with decreasing ash content. This suggests a localization of the toxins analyzed primarily in the outer parts of the original wheat kernels. The median DON content was significantly (P<0.05) higher for wheat flour originating from wheat of conventional than of organic production.     

Incidence of trichothecenes and zearalenone in poultry feed mixtures from Slovakia

A total of 50 samples of poultry feed mixtures of Slovakian origin were analyzed for eight toxicologically significant Fusarium mycotoxins, namely zearalenone (ZON), A-trichothecenes: diacetoxyscirpenol (DAS), T-2 toxin (T-2) and HT-2 toxin (HT-2) and B-trichothecenes: deoxynivalenol (DON), 3-acetyl-deoxynivalenol (3-ADON), 15-acetyl-deoxynivalenol (15-ADON) and nivalenol (NIV). The A-trichothecenes and the B-trichothecenes were detected by means of high pressure liquid chromatography with tandem mass spectrometry detection (HPLC-MS/MS) and gas chromatography electron capture detection (GC-ECD), respectively. Reversed phase-high performance liquid chromatography with a fluorescence detector (RP-HPLC-FLD) was used for ZON detection. The most frequent mycotoxin detected was T-2, which was found in 45 samples (90%) in relatively low concentrations ranging from 1 to 130 microg kg(-1) (average 13 microg kg(-1)), followed by ZON that was found in 44 samples (88%) in concentrations ranging from 3 to 86 microg kg(-1) (average 21 microg kg(-1)). HT-2 and DON were detected in 38 (76%) and 28 (56%) samples, respectively, in concentrations of 2 to 173 (average 18 microg kg(-1)) for HT-2 and 64 to 1230 microg kg(-1) sample (average 303 microg kg(-1)) for DON. The acetyl-derivatives of DON were in just four samples, while NIV was not detected in any of the samples investigated. In as many as 22 samples (44%), a combination of four simultaneously co-occurring mycotoxins, i.e. T-2, HT-2, ZON and DON, was revealed. Despite the limited number of samples investigated during this study poultry feed mixtures may represent a risk from a toxicological point of view and should be regarded as a potential source of the Fusarium mycotoxins in Central Europe. This is the first reported study dealing with zearalenone and trichothecene contamination of poultry mixed feeds from Slovakia.     

Application of capillary gas chromatography to a survey of wheat for five trichothecenes

A previously published method for the determination of deoxynivalenol (DON) and nivalenol (NIV) in grains by capillary gas chromatography (GC) with electron-capture detection (ECD) has been modified to include HT-2 toxin (HT-2), T-2 toxin (T-2) and diacetoxyscirpenol (DAS). Recoveries of the five trichothecenes from wheat averaged 71-92% in the range 0.8-4 micrograms/g. Detection or quantitation limits found in two laboratories were from 0.02 to 0.4 micrograms/g, with those for T-2 and DAS at the high end of this range. The method proved of practical use in survey work for the screening and determination of these trichothecenes in wheat from the 1987 western Canadian crop. There were no false positives for HT-2, T-2 and DON in durum and HY-320 wheat. However, interferences precluded the determination of 4- and 15-monoacetoxyscirpenol (MAS) by GC-ECD. The natural occurrence of HT-2 toxin (0.06-0.59 micrograms/g) was demonstrated by GC-ECD and confirmed by GC-mass spectrometry (MS) in 23 samples of durum and HY-320 wheats (1986 and 1987 crops); it was almost always accompanied by DON and in one sample a low concentration of NIV (0-05 micrograms/g). False positives for HT-2 and DAS in red spring wheat detected in 1987 by GC-ECD were 6% (nearly all identified as variety Katepwa) and 8%, respectively. Hence confirmation of suspected HT-2 and DAS by GC-MS is necessary, particularly with red spring wheat.     

A survey on the occurrence of Fusarium mycotoxins in Bavarian cereals from the 1987 harvest

Summary Bavarian cereals and wheat flour from the 1987 harvest were analysed for nivalenol (NIV) and deoxynivalenol (DON) using high performance liquid chromatography (HPLC) and for T-2 toxin and zearalenone (ZEA) by enzyme-linked-immunosorbent as say (ELISA). The study included 190 field samples of wheat, barley, rye and oat with visibly damaged ears, 45 samples of wheat intended for feed production and two series of wheat flour (type 550) and whole wheat flour collected in October 1987 and June 1988. The field samples examined showed a high DON contamination of wheat (87%) with an average of 3.96 mg/kg and a maximum of 43.8 mg/kg. Mean levels between 0.33 mg/kg and 0.27 mg/kg DON could be detected in barley, rye and oat. Of the wheat samples, 58% contained ZEA with a maximum of 1.560 mg/kg. The highest levels of ZEA were detected in samples which also showed high concentrations of DON. The NIV and T-2 toxin levels were comparatively low. Thirty percent of the samples showed NIV concentrations between 0.04 mg/kg and 0.29 mg/kg and 38% contained between 0.005 and 0.60 mg/kg of T-2. In the wheat samples for feed production, only DON was detected with an average of 0.190 mg/kg and a maximum of 0.75 mg/kg. The highest DON levels (0.58 mg/kg) from October 1987 were found in the wheat flour samples which were lower than the highest DON concentration (3.24 mg/kg) detected in the samples collected during June 1988. This fact was probably due to a substantial amount of non-contaminated wheat from 1986. The toxin concentrations in the whole wheat flour were not higher than in the type 550 flour. The regional distribution of the mean DON concentrations showed the highest levels in Middle and Lower-Franconia.

---

Vorkommen von Fusarium Mykotoxinen in bayerischem Getreide der Ernte 1987

Zusammenfassung Cerealien und Weizenmehle der bayerischen Ernte 1987 wurden mittels hochauflösender Flüssigchromatographie (HPLC) auf Nivalenol (NIV) und Deoxynivalenol (DON) Bowie mit Enzymimmunoassay auf T-2 Toxin und Zearalenon (ZEA) analysiert. Die Untersuchungen umfaßten 190 Feldproben von Weizen, Gerste, Roggen und Hafer, die alle optisch erkennbaren Fusarienbefall aufwiesen, 45 Futterweizenproben Bowie zwei Probenserien von Weizenmehlen der Type 550 und Vollkornweizenmehlen, die im October 1987 und im Juni 1988 gezogenwurden. — Die Untersuchungen der Feldproben ergaben eine hohe DON-Kontamination des Weizens (87%) mit einem durchschnittlichen Gehalt von 3,96 mg/kg und einem Maximalgehalt von 43,8 mg/kg. In Gerste, Roggen und Hafer konnten durchschnittlich zwischen 0,33 mg/kg und 0,27 mg/kg DON-nachgewiesen werden. 58% der Winterweizenproben wiesen Zearalenon mit einem Maximalgehalt von 1,56 mg/kg auf. Die höchsten ZEA-Werte wurden in Proben ermittelt, die gleichzeitig einen hohen DON-Gehalt aufwiesen. Die Konzentrationen von NIV und T-2 Toxin waren vergleichsweise niedrig. 30% der Proben hatten NIV-Gehalte zwischen 0,04 mg/kg und 0,29 mg/kg und 38% enthielten T-2 Toxin zwischen 0,005 mg/kg und 0,06 mg/kg. In den Futterweizenproben konnte DON als einziges Toxin mit einem Gehalt von durchschnittlich 0,19 mg/kg und maximal 0,75 mg/kg festgestellt werden. Die Weizenmehle, die im October 1987 gezogen wurden, wiesen maximal 0,58 mg/kg DON auf. Die Gehalte lagen damit medriger als die der Mehlproben vom Juni 1988, die maximal 3,24 mg/kg und durchschnittlich 0,26 mg/kg DON enthielten. Dieser Sachverhalt könnte auf Anteile von nicht kontaminiertem Weizen der Ernte 86 an den im October gezogenen Mehlproben zurückgeführt werden. Die Toxingehalte der Vollkornmehle waren nicht höher als die der Weizenmehle der Type 550. Die höchsten Durchschnittsgehalte von DON wurden in Mittel- und Unterfranken festgestellt.

     

Quantitative analysis of Fusarium mycotoxins in maize using accelerated solvent extraction before liquid chromatography/atmospheric pressure chemical ionization tandem mass spectrometry

A method for the simultaneous quantitative determination of deoxynivalenol (DON), fumonisin B1 (FB1) and zearalenone (ZEN) in maize by liquid chromatography-atmospheric pressure chemical ionization tandem mass spectrometry (LC-APCIMS/MS), using stable isotopically labelled and structural analogues internal standards, is described. The procedure involves accelerated solvent extraction followed by two solid-phase clean-up steps on strong anion exchange resin and a Mycosep® column. Typical recoveries were calculated by spiking blank maize at three different concentrations for deoxynivalenol (200, 400 and 1000 μg kg^-1) at 70%, for fumonisin B1 (100, 200 and 1000 μg kg^-1) at 90%, and for zearalenone (50, 100 and 200 μg kg^-1) at 40%. LC-APCIMS/MS analyses were realized in collision-induced dissociation on an ion-trap instrument to provide a high degree of selectivity and sensitivity. Extraction of ions from two transition reactions, monitored by LC-APCIMS/MS for each analyte, enabled a limit of detection for DON, FB1 and ZEN at, respectively, 10, 20 and 3 μg kg^-1, and a limit of quantification at, respectively, 50, 50 and 10 μg kg^-1. The robustness of the method was also evaluated with the analysis of wheat samples.     

Occurrence of mycotoxins and ergosterol in maize harvested over 5 years in Northern Italy

Maize samples collected from storage bins and feed mills in Northern Italy between 1995 and 1999 were surveyed for the occurrence of aflatoxin B₁ (AFB₁), zearalenone (ZEA), deoxynivalenol (DON) and fumonisin (FB₁); further, ergosterol was analysed as a fungal growth marker. The incidence and mean content of AFB₁ were generally low; nevertheless, a remarkable contamination was found in two samples (109 and 158 μg kg^-1), while five others exceeded 20 μg kg^-1. DON and ZEA mean levels were significantly higher in 1996 (2716 and 453 μg kg^-1) with respect to the other years, when mean contents ranged from 7 to 30% and from 3 to 17%, respectively, expressed in per cent of 1996 contents. FB₁ was present in all samples and was by far the most remarkable mycotoxin in Northern Italian maize, with the exception of samples from 1996. The average level was 3064 μg kg^-1, 69.6% of samples resulted over 1000 μg kg^-1 and 16.9% over 5000 μg kg^-1. Significant correlations were found between ergosterol and the major mycotoxin(s) in each year (FB₁ in 1995 and 1997-99; ZEA + DON in 1996). Consequently, ergosterol seems to be a good index of the toxicological quality of maize. Climatic conditions influenced the growth of different fungal species. In 1996, the first 20 days of October were extremely rainy; these weather conditions delayed the harvest until the first week of November and favoured the growth of DON and ZEA producing fungi and the synthesis of mycotoxins. On the contrary, the temperate and dry climate of the other years supported the growth of FB₁-producing fungi.     

Natural co-occurrence of deoxynivalenol and fumonisins B1 and B2 in Italian marketed foodstuffs

A survey was performed to obtain the frequency and levels of contamination by deoxynivalenol (DON) and fumonisins B₁ and B₂ (FB1, FB2) mycotoxins in Italian marketed foods. Of 202 samples investigated, including raw materials and processed cereal foods (bread, pasta, breakfast cereals, biscuits, baby and infant foods), 84% were contaminated with DON at levels from 0.007 to 0.930 μg g^-1 (median 0.065 μg g^-1); 26% contained FB1 ranging from 0.010 to 2.870 μg g^-1 (0.070 μg g^-1); 35% contained FB2 at 0.010-0.790 μg g^-1 (0.080 μg g^-1). The highest levels of DON and FB1 were detected in raw cereals and wholemeal flours. The highest levels of FB2 were detected in durum wheat pasta. A widespread DON contamination was found in baby and infant foods at levels varying from 0.007 to 0.166 μg g^-1.     

Residues of DDT and HCH in wheat samples collected from different states of India and their dietary exposure: A multicentre study

Under a multicentre study conducted by the Indian Council of Medical Research, 1712 samples of wheat grain/flour were collected from urban and rural areas in 11 states representing different geographical regions of India. These samples were analysed for residues of DDT (2,2-bis (p-chlorophenyl)-1,1,1-trichloro ethane) and different isomers of HCH (1,2,3,4,5,6-hexachloro cyclohexane, a mixture of isomers) by gas-liquid chromatography. Residues of DDT were detected in 59.4% of 1080 samples of wheat grain and in 78.2% of 632 samples of wheat flour. Different isomers of HCH were present in about 45-80% of the samples of wheat grain/flour. Medians of DDT and total HCH, respectively, for pooled samples of wheat grain were 0.013 and 0.035 mg kg^-1, while those for wheat flour were 0.01 and 0.02 mg kg^-1. Estimated daily intakes of DDT and different isomers of HCH through the consumption of wheat contaminated at their median and 90th percentiles constituted a small proportion of their acceptable daily intakes. Amongst the pesticide residues analysed, statutory maximum residue limits have been fixed only for γ-HCH in wheat in India, as 0.1 mg kg^-1 in wheat grain and zero in wheat flour. Residue levels of γ-HCH exceeded these maximum residue limits in five of 1080 samples of wheat grain and in 340 of 632 samples of wheat flour. The failure to meet the requirement of the γ-HCH maximum residue limit in large number of wheat flour samples was attributed to the fixation of practically unachievable zero limit. Comparing the previous studies and the present one, the levels of residues of DDT and HCH in wheat were significantly decreased.     

Transfer of Fusarium mycotoxins and ‘masked’ deoxynivalenol (deoxynivalenol-3-glucoside) from field barley through malt to beer

The fate of five Fusarium toxins — deoxynivalenol (DON), sum of 15- and 3-acetyl-deoxynivalenol (ADONs), HT-2 toxin (HT-2) representing the main trichothecenes and zearalenone (ZON) during the malting and brewing processes — was investigated. In addition to these ‘free’ mycotoxins, the occurrence of deoxynivalenol-3-glucoside (DON-3-Glc) was monitored for the first time in a beer production chain (currently, only DON and ZON are regulated). Two batches of barley, naturally infected and artificially inoculated with Fusarium spp. during the time of flowering, were used as a raw material for processing experiments. A highly sensitive procedure employing high-performance liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) was validated for the analysis of ‘free’ Fusarium mycotoxins and DON-conjugate in all types of matrices. The method was also able to detect nivalenol (NIV), fusarenon-X (FUS-X) and T-2 toxin (T-2); nevertheless, none of these toxins was found in any of the samples. While steeping of barley grains (the first step in the malting process) apparently reduced Fusarium mycotoxin levels to below their quantification limits (5–10 µg kg^?1), their successive accumulation occurred during germination. In malt, the content of monitored mycotoxins was higher compared with the original barley. The most significant increase was found for DON-3-Glc. During the brewing process, significant further increases in levels occurred. Concentrations of this ‘masked’ DON in final beers exceeded ‘free’ DON, while in malt grists this trichothecene was the most abundant, with the DON/DON-3-Glc ratio being approximately 5:1 in both sample series. When calculating mass balance, no significant changes were observed during brewing for ADONs. The content of DON and ZON slightly decreased by a maximum of 30%. Only traces of HT-2 were detected in some processing intermediates (wort after trub removal and green beer).     

Acrylamide in Asian foods in Hong Kong

About 400 food samples, mainly Asian foods available in Hong Kong, were tested for acrylamide by an LC-MS/MS method using [1, 2, 3-¹³C₃]-acrylamide as surrogate. The acrylamide levels in the more commonly consumed food items in the food groups such as rice and rice products, noodles, bakery and batter-based products, were generally less than 60 μg kg^-1. Higher levels were found in the food groups such as biscuit-related products and crisps. The highest levels were detected in potato crisps (1500-1700 μg kg^-1). Lower levels were found in rye flour-based crisps (440 μg kg^-1), followed by corn-based (65 to 230 μg kg^-1) and wheat flour-based crisps (61-200 μg kg^-1), and then rice flour-based crisps (15-42 μg kg^-1). The acrylamide formation during deep frying of a wheat flour-based product, Chinese fried fritter, was studied. Deep-frying at 170°C resulted in gentle but steady rise in acrylamide content. A steep rise for frying at 210°C was recorded. The moisture content of the product decreased with frying time, but the fat content increased. It is proposed that the reaction for the formation of acrylamide was initiated on the surface and then penetrated into the interior of the food matrix by heat transfer via radiation/conduction and diffusion of hot oil.     

Transfer of Fusarium mycotoxins and 'masked' deoxynivalenol (deoxynivalenol-3-glucoside) from field barley through malt to beer

The fate of five Fusarium toxins--deoxynivalenol (DON), sum of 15- and 3-acetyl-deoxynivalenol (ADONs), HT-2 toxin (HT-2) representing the main trichothecenes and zearalenone (ZON) during the malting and brewing processes--was investigated. In addition to these 'free' mycotoxins, the occurrence of deoxynivalenol-3-glucoside (DON-3-Glc) was monitored for the first time in a beer production chain (currently, only DON and ZON are regulated). Two batches of barley, naturally infected and artificially inoculated with Fusarium spp. during the time of flowering, were used as a raw material for processing experiments. A highly sensitive procedure employing high-performance liquid chromatography coupled with tandem mass spectrometry (LC-MS/MS) was validated for the analysis of 'free' Fusarium mycotoxins and DON-conjugate in all types of matrices. The method was also able to detect nivalenol (NIV), fusarenon-X (FUS-X) and T-2 toxin (T-2); nevertheless, none of these toxins was found in any of the samples. While steeping of barley grains (the first step in the malting process) apparently reduced Fusarium mycotoxin levels to below their quantification limits (5-10 microg kg(-1)), their successive accumulation occurred during germination. In malt, the content of monitored mycotoxins was higher compared with the original barley. The most significant increase was found for DON-3-Glc. During the brewing process, significant further increases in levels occurred. Concentrations of this 'masked' DON in final beers exceeded 'free' DON, while in malt grists this trichothecene was the most abundant, with the DON/DON-3-Glc ratio being approximately 5:1 in both sample series. When calculating mass balance, no significant changes were observed during brewing for ADONs. The content of DON and ZON slightly decreased by a maximum of 30%. Only traces of HT-2 were detected in some processing intermediates (wort after trub removal and green beer).     

Determination of trichothecenes in cereals and cereal-based products by liquid chromatography–tandem mass spectrometry

A sensitive, accurate and precise method for the simultaneous determination of nivalenol (NIV), deoxynivalenol (DON), T-2 toxin (T-2) and HT-2 toxin (HT-2) in different food matrices, including wheat, maize, barley, cereal-based infant foods, snacks, biscuits and wafers, has been developed. The method, using liquid chromatography coupled with atmospheric pressure chemical ionization triple quadrupole mass spectrometry (LC–APCI–MS/MS), allowed unambiguous identification of the selected trichothecenes at low µg per kg levels in such complex food matrices. A clean-up procedure, based on reversed phase SPE Oasis® HLB columns, was used, allowing good recoveries for all studied trichothecenes. In particular, NIV recoveries significantly improved compared to those obtained by using Mycosep® #227 columns for clean-up of the extracts. Limits of detection in the various investigated matrices ranged 2.5–4.0 µg kg^?1 for NIV, 2.8–5.3 µg kg^?1 for DON, 0.4–1.7 µg kg^?1 for HT-2 and 0.4–1.0 µg kg^?1 for T-2. Mean recovery values, obtained from cereals and cereal products spiked with NIV, DON, HT-2 and T-2 toxins at levels from 10 to 1000 µg kg^?1, ranged from 72 to 110% with mean relative standard deviation lower than 10%. A systematic investigation of matrix effects in different cereals and cereal products was also carried out by statistically comparing the slopes of standard calibration curve with matrix-matched calibration curve for each of the four toxins and the eight matrices tested. For seven of the eight matrices tested, statistically significant matrix effects were observed, indicating that, for accurate quantitative analysis, matrix-matched calibration was necessary. The method was applied to the analysis of 57 samples of ground wheat originated from South Italy and nine cereal food samples collected from retail markets.     

Survey of ochratoxin A and deoxynivalenol in stored grains from the 1999 harvest in the UK

Three hundred and twenty samples from the 1999 UK harvest comprising wheat (201 samples), barley (106) and oats (13) were analysed for ochratoxin A and deoxynivalenol. A small number of organic samples was also obtained. Samples were collected from farms, central stores, mills, maltings and ports from across the UK from February to April 2000. Ochratoxin A and deoxynivalenol analysis was by affinity column clean up and high-performance liquid chromatography with fluorescence and ultraviolet light detection, respectively, with limits of detection of 0.2 and 20 μg kg^-1. The survey found ochratoxin A at below 5 μg kg^-1 in 97% of the samples indicating satisfactory storage conditions. The remaining 3% of the samples contained ochratoxin A at levels between 5.2 and 231 μg kg^-1, but none of these samples was intended for human consumption. Deoxynivalenol was detected in 88% of all samples, with 83% below 100 μg kg^-1; the maximum level was 600 μg kg^-1. Twenty samples containing deoxynivalenol at or above 150 μg kg^-1 by high-performance liquid chromatography were all confirmed by gas chromatography/mass spectrometry. Nivalenol was also detected by gas chromatography/mass spectrometry at levels of 50 μg kg^-1 or higher in 18 of 20 samples where deoxynivalenol was confirmed.     

Annual variation of deoxynivalenol in Danish wheat flour 1998-2003 and estimated daily intake by the Danish population

The occurrence of deoxynivalenol (DON) in Danish wheat flour was studied during the period 1998-2003 by either capillary gas chromatography with electron capture detection and liquid chromatography coupled to an ion trap mass spectrophotometer. A total of 151 samples were collected from mills and the retail market in Denmark. Contamination levels varied considerably from year-to-year with the highest concentrations occurring in samples from the 2002 harvest with mean and median concentrations of 255 and 300 µg kg^-1, respectively. Compared to other harvest years, 2002 had the highest amount of precipitation around flowering time, i.e. from the end of June to the beginning of July covering weeks 25-27. The lowest average levels were found in samples from the 2001 harvest, where weeks 25-27 were dry compared with other harvest years. The highest value (705 µg kg^-1) was obtained in a flour sample from the 2002 harvest, but none of the tested samples exceeded the maximum limit of 750 µg kg^-1, which has been recently introduced by the European Commission for DON in flour used as raw materials in food products. Calculation of chronic or usual intake by a deterministic approach showed that intake did not exceed the TDI of 1 µg kg^-1 bw day^-1 either for the whole population or for children. A probabilistic approach also showed that intake in general was below the TDI, but intake for children in the 99% percentile amounted to more than 75% of the TDI. The highest intake is calculated to be 2.5 µg kg^-1 bw day^-1.     

Occurrence of aflatoxins in layer feed and corn samples in Konya province, Turkey

The natural occurrence ofaflatoxin was investigated in layer feed and corn samples brought to Konya Veterinary Control and Research Institute Laboratory between 15 April and 15 December 2002. Seventy-eight samples (52 feeds, 26 corn samples) were analysed for total aflatoxin (B₁ + B₂ + G₁ + G₂) by an ELISA screening method. Aflatoxin contamination was determined in 37 feed samples (71.1%) and 15 corn samples (57.7%), with a range of1.5-133 μg kg^-1. However, a majority ofthe aflatoxin contamination was less than 5 μg kg^-1 (50% within the positive samples). Two feed samples and two corn samples exceeded the maximum tolerated levels in feed (20 μg kg^-1) and feedstuffs (50 μg kg^-1) for total flatoxin.     

Fusariotoxins in Russian Federation 2005–2010 grain harvests

Monitoring results of food grain contamination with fusariotoxins–deoxynivalenol (DON), zearalenone (ZEN), fumonisins (FB1&FB2), T-2 and HT-2 toxins–are presented. Harvests of 2005–2010 in different regions of Russia were investigated. The occurrence of DON in wheat was 8%, barley 9%, oats 4%, rye 2% and maize 2%. The highest frequency of ZEN contamination was found in oats, the lowest in wheat. Calculated average daily intake of DON varied from 0.066 to 0.096 µg/kg body weight, the highest being found in the Southern region, but substantially lower than the provisional maximum tolerable daily intake. The results of enzyme-linked immunosorbent assay and high-performance liquid chromatography–mass spectrometry analysis demonstrated the presence of T-2 toxin in 14% and HT-2 toxin in 17% of all samples. The maximum level of T-2 toxin was exceeded only in one sample of barley. Relatively high frequency and levels of FB1&FB2 contamination were found in maize.     

Effects of Fusarium toxin-contaminated wheat and feed intake level on the biotransformation and carry-over of deoxynivalenol in dairy cows

An experiment was carried out to examine the effects of feeding Fusarium toxin-contaminated wheat (8.21 mg deoxynivalenol (DON) and 0.09 mg zearalenone (ZON) per kg dry matter) at different feed intake levels on the biotransformation and carry-over of DON in dairy cows. For this purpose, 14 ruminal and duodenal fistulated dairy cows were fed a diet containing 60% concentrate with a wheat portion of 55% (Fusarium toxin-contaminated wheat (mycotoxin period) or control wheat (control period)) and the ration was completed with maize- and grass silage (50 : 50) on a dry matter basis. Daily DON intakes ranged from 16.6 to 75.6 mg in the mycotoxin period at dry matter intakes of 5.6-20.5 kg. DON was almost completely biotransformed to de-epoxy DON (94-99%) independent of the DON/feed intake, and the flow of DON and de-epoxy DON at the duodenum related to DON intake ranged from 12 to 77% when the Fusarium toxin-contaminated wheat was fed. In the serum samples, de-epoxy DON was detected in the range of 4-28 ng ml^-1 in the mycotoxin period, while concentrations of DON were all below the detection limit. The daily excretion of DON and de-epoxy DON in the milk of cows fed the contaminated wheat varied between 1 and 10 µg and between 14 and 104 µg, respectively. The total carry-over rates as the ratio between the daily excretion of DON and de-epoxy DON into milk and DON intake were in the ranges of 0.0001-0.0002 and 0.0004-0.0024, respectively. Total carry-over rates of DON as DON and de-epoxy DON into the milk increased significantly with increasing milk yield. In the urine samples, de-epoxy DON was the predominant substance as compared with DON with a portion of the total DON plus de-epoxy DON concentration to 96% when the Fusarium toxin-contaminated wheat was fed, whereas the total residues of DON plus de-epoxy DON in faeces ranged between 2 and 18% of DON intake in the mycotoxin period. The degree of glucuronidation of de-epoxy DON was found to be approximately 100% in serum. From 33 to 80% of DON and from 73 to 92% of de-epoxy DON, and from 21 to 92% of DON and from 86 to 100% of de-epoxy DON were glucuronidated in the milk and urine, respectively. It is concluded that DON is very rapidly biotransformed to de-epoxy DON in the rumen and only negligible amounts of DON and de-epoxy DON were transmitted into the milk within the range of 5.6-20.5 kg day^-1 dry matter intake and milk yields (fat corrected milk) between 10 and 42 kg day^-1.