Changes in viscosity and pectolytic enzymes of tomato and strawberry juices processed by high-intensity pulsed electric fields

The effects pulse frequency (50–250 Hz), pulse width (1.0–7.0 μs) and polarity (monopolar or bipolar) of high-intensity pulsed electric field treatments (35 kV cm⁻¹ and 1000 μs) on viscosity and the pectin methylesterase (PME) and polygalacturonase (PG) activities were evaluated using a response surface methodology. Second-order expressions were accurate enough to fit experimental results. Tomato juice apparent viscosity increased within the range of the assayed conditions, achieving the highest values at 250 Hz and 7.0 μs in bipolar mode. At the same conditions the lowest residual PME (RA_PME = 10%) and PG (RA_PG = 45%) activities were observed in the juice. Apparent viscosity of strawberry juices slightly rose when frequencies higher than 100 Hz and 1-μs monopolar pulses were applied to the juice. Treatments causing the greatest increase in strawberry juice apparent viscosity also led to the lowest RA_PME (10%) and RA_PG (75%) values. In contrast, viscosity loss was promoted under the rest of assayed HIPEF conditions despite the low RA_PME values (<20%) achieved. Moreover, RA_PG did not decrease below 75% throughout the range of studied conditions.     

THE RHEOLOGICAL CONDITIONS ASSOCIATED WITH JUDGEMENT OF POURABILITY AND SPREADABILITY OF SALAD DRESSINGS

A panel of 25 students compared the pourability and spreadability of two commercial brand salad dressings (non-Newtonian) and a CMC-sugar solution (Newtonian). Correlation of their responses with visco-metric data for the 3 samples indicated that the shear stress and shear rate associated with the sensory evaluation of these two properties are 190–430 dyne cm⁻² and 0.9–6.3 s⁻¹, and < 190 dyne cm⁻² and < 0.9⁻¹, respectively.     

Quartz plates for determining sun protection in vitro and testing photostability of commercial sunscreens

Testing plate made of optical quartz has been developed for the purpose of determination of sun protection factor (SPF) _in vitro by the method of diffusion transmission spectroscopy; the plates were coarsened by sanding and grinding to surface roughness values (Ra) of 18 μm. The plate was coated with a film of sunscreen by an application of 2 mg cm⁻² as that used for determination of SPF _in vivo by the COLIPA method. The transmission values measured were converted into the SPF _in vitro and the protection factor in ultraviolet A light, UVAPF _{in vitro} . The testing plate was tested with commercial sunscreens. The found values of SPF _in vitro fit well with the values determined by means of the COLIPA method in vivo . The plates coated with sunscreen film were irradiated with light simulating the sun radiation. The values of protection factors obtained before and after irradiation were compared, and the differences were used for estimation of photostability of the UV filters included.     

DEVELOPMENT AND DISTRIBUTION OF ACTINIDIN IN KIWIFRUIT (ACTINIDIA CHINENSIS) AND ITS PARTIAL CHARACTERIZATION

The actinidin activity in kiwifruit increased 3-fold after 3 weeks postharvest ripening at 5°C with a 15% decrease in specific activity. Actinidin activity is highest in the pulp of ripe fruit at 27,600 U/kg fruit. The thiol protease actinidin from kiwifruit was extracted and purified 26-fold to a specific activity of 57 U/mg with K_m= 91 μM and k_cat= 101 s⁻¹ towards N-α-CBZ-lysine p-nitrophenyl ester at pH 6.0 and 25°C.     

APPLICATION OF CHLORINE TO REDUCE POPULATIONS OF ESCHERICHIA COLI ON BEEF

The effects of chlorine against 2 strains of E. coli attached to the surface of beef carcass tissue (BCT) were examined using a model carcass washer. Lean and adipose BCT with approximately 5 log ₁₀ CFU/cm ² E. coli bacteria were spray-treated with water and sodium hypochlorite (NaOCl) to give chlorine concentrations of 50, 100, 250, 500, or 800ppm, incubated for 24 h, 4C, and E. coli populations enumerated. Spray treatments with water did significantly (P < 0.05) reduce the bacterial populations of either organism attached to lean or adipose BCT, as compared to populations of controls; however, reductions were less than 0.60 log ₁₀ CFU/cm ². Treatments with 500 and 800 ppm chlorine against E. coli ATCC 25922 attached to BCT resulted in the greatest reductions of 1.22 and 1.28 log ₁₀ CFU/cm ², respectively. At 800 ppm chlorine , E. coli O157:H7 ATCC 43895 attached to BCT was reduced by 1.04 log ₁₀ CFU/cm ², whereas spray treatments with 50, 100, 250, and 500 ppm chlorine resulted in reductions of < 1 log ₁₀ CFU/cm ². Spray treatments with chlorine from sodium hypochlorite solutions reduced populations of E. coli, however, these reductions were not sufficient to completely inactivate the bacteria attached to red meat .     

CHARACTERIZATION OF MODEL NITROSYLHEME PIGMENTS WITH VISIBLE, INFRARED AND 15N FOURIER TRANSFORM NUCLEAR MAGNETIC RESONANCE SPECTROSCOPY

Synthetic pigments that model the organic-soluble pigment in heat-processed cured ham were characterized with infrared (IR) and ¹⁵N nuclear magnetic resonance (NMR) spectroscopy. The two pigments synthesized were ¹⁵N nitrosyl (protoporphyrinato- IX) iron (II), or Fe^II PP¹⁵ NO, and ¹⁵N dinitrosyl (protoporphyrinato-IX), or Fe^II PP(¹⁵NO)₂. An NMR spectrum was obtained only for the Fe^II PP¹⁵ NO. The NMR spectrum consisted of a single peak + 1.78 ppm from the Na¹⁵ NO³ and –6.8 from the CH₃NO₂ reference. The IR spectrum included a single NO symmetric stretch at 1801 cm⁻¹. The visible spectrum of Fe^II PPNO did not match the visible spectrum of ham extracts, while it did with FE^II PP(¹⁵NO)₂. An unequivocal structural assignment of Fe^II PP¹⁵ NO was made, but longer NMR runs may be necessary to obtain a spectrum and unequivocal structural assignment of Fe^II PP(¹⁵ NO)₂.     

RHEOLOGICAL INDICES OF FRUIT CONTENT IN JAMS: EFFECT OF FORMULATION ON FLOW PLASTICITY OF SHEARED STRAWBERRY AND PEACH JAMS

The effect of formulation factors on Casson yield values measured at low shear rates (0.08 ≤γ≤ 1.01s^-1) (σ₀₁) and at medium shear rates (2.58 ≤γ≤ 387.30s^-1) (σ₀₂) was analyzed in previously sheared strawberry and peach jams. Twenty three samples of each fruit jam were prepared according to a second order composite rotatable design. Composition ranges were: fruit content, 25–55%; soluble solids content, 60–70° Brix; added pectin in strawberry jams, 0.3–0.7% and in peach jams, 0.1–0.5%. Variation of σ₀₁ values in strawberry jams depended mainly on the interactions between fruit and soluble solids and between fruit and pectin, while in peach jams, it depended on fruit-soluble solids and soluble solids-pectin interactions. Patterns of change of σ₀₂ values with composition were similar to those observed for σ₀₁ in both strawberry and peach jams. Predictive power of σ₀₁ and σ₀₂ values for estimation of fruit content was low, but taken in conjunction with soluble solids content and total pectin values, 79.5% of the variability of fruit content in strawberry jams and 91.1% of same in peach jams could be explained.     

Inactivation of Escherichia coli O157:H7 and Salmonella enteritidis in Liquid Egg White Using Pulsed Electric Field

ABSTRACT: The effects of temperature and pulsed electric field (PEF) intensity on inactivation of pathogens such as Escherichia coli O157:H7 and Salmonella enteritidis in egg white was investigated. Liquid egg white inoculated with 10⁸ colony-forming units (CFU)/mL of each pathogen was treated with up to 60 pulses (each of 2 JAS width) at electric field intensities of 20 and 30 kV/cm. The processing temperatures were 10°C, 20°C, and 30°C. After treatment, uninjured and total viable cells were enumerated in selective and nonselective agars, respectively. Maximum inactivations of 3.7 and 2.9 log units were obtained for S. enteritidis and E. coli O157:H7, respectively, while injured cells accounted for 0.5 and 0.9 logs for E. coli O157:H7 and S. enteritidis , respectively. For both bacteria, increasing treatment temperature tended to increase the inactivation rate. There was synergy between electric field intensity and processing temperature. The inactivation rate constant k _T values for E. coli O157:H7 on both selective and nonselective agars were 8.2 × 10^-3 and 6.6 × 10^-3/μS, whereas the values for S. enteritidis were 16.2 × 10^-3 and 12.6 × 10^-3/μS, respectively. The results suggest that E. coli O157:H7 was more resistant to heat-PEF treatment compared with S. enteritidis.     

Influence of vitamin E supplementation on spontaneous oxidized flavour of milk in dairy buffaloes

Twenty-four Murrah buffaloes (60 days pre-partum) were divided into four equal groups (T ₁ , T ₂ , T ₃ and T ₄ ) and were supplemented with 0, 1000, 1500 and 2000 IU α-tocopheryl acetate per day up to 30 days of lactation, and half of these doses from 30 to 60 days of lactation. Milk samples collected fortnightly were analysed for vitamin E, fat, and development of oxidized flavour, with and without copper addition by a panel of judges, and chemically by the thiobarbituric acid test. Scores for oxidized flavour ranged from 0 to 10 with 0–4 as definite, 5–7 as light and 8–10 having no defect. The α-tocopherol content in milk fat (µg/g) averaged 20.55, 25.56, 29.98 and 31.38 in T ₁ , T ₂ , T ₃ and T ₄ groups, respectively. The addition of Cu in the milk significantly increased milk fat oxidation. Better stability of milk in T ₃ and T ₄ groups was observed, which might be due to a higher level of milk α-tocopherol. Addition of 1500 IU α-tocopheryl acetate in the diet of buffaloes helped in improving the oxidative stability of milk.     

The rheological properties of ketchup as a function of different hydrocolloids and temperature

The flow properties of ketchup were assessed upon addition of commonly used food thickeners: guar, xanthan and CMC gum at three different concentrations (0.5%, 0.75% and 1%) and four temperatures (25, 35, 45 and 55 °C). The ketchup without supplementation served as a control. All ketchup formulations exhibited non-Newtonian, pseudoplastic behaviour at all temperatures and hydrocolloid levels. The Power-law and Herschel-Buckley model were successfully applied to fit the shear stress versus shear rate data. The flow behaviour indices, n and n' , varied in the range of 0.189–0.228 and 0.216–0.263, respectively. The consistency coefficients, k and k' , were in the range of 8.42–27.22 and 6.56–20.10 Pa s ⁿ , respectively. The addition of hydrocolloids increased the yield point (τ₀) and apparent viscosity of the ketchup in comparison to that of the control. The Arrhenius equation was successfully used to describe the effects of temperature on the apparent viscosity of the prepared formulations. The E _a value appeared in the range between 5492.6 and 21475.8 J mol⁻¹.     

Relationship between energies of water sorption and diffusion in grains

The relationship between activation energy for diffusion, E _D and the BET heat of sorption, E ₁, was determined from literature data for maize, rice, sorghum, soybean and wheat and gave E _D/ E ₁= 0.5. Given that E _D < E ₁, diffusion was interpreted in terms of a mechanism involving the hopping of water molecules from one adsorption site to another.     

The increase of CO2 permeability of paper packaging with increasing hydration

CO₂ transport through hydrated paper was studied using gas chromatography to measure CO₂ permeability (P) and diffusivity (D). With increasing water content from 0 to 0.8 g water/g paper, P and D increased from 3.47 to 9.03 × 10⁻⁶ m³ m⁻² s⁻¹ bar⁻¹ and from 1.35 to 3.51 × 10⁻⁵ m² s⁻¹, respectively. This resulted from structural changes in the cellulose network as reported in the literature; water sorption isotherms were used to explain these changes using BET theory.     

Effects of pulsed electric fields on bioactive components, colour and flavour of green tea infusions

Green tea is an unfermented tea containing a higher quantity of bioactive components. In this paper, the effects of pulsed electric field (PEF) treatments on the bioactive components (polyphenols, catechins and free amino acids), colour and flavour of green tea infusions were studied. PEF as a promising non-thermal sterilisation technology could efficiently retain polyphenols, catechins and original colour of green tea infusions with electric field strength from 20 to 40 kV cm⁻¹ for 200 μs. PEF treatments caused a significant increase in the total free amino acids of green tea infusions. The total free amino acids increased by 7.5% after PEF treatment at 40 kV cm⁻¹. The increase in total amino acids induced by PEF treatment, especially to theanine, is beneficial for the quality of commercial ready-to-drink green tea infusion products. There was no significant effect of PEF treatment at 20 or 30 kV cm⁻¹ on flavour compounds of green tea infusions. However, PEF treatment caused losses of volatiles in green tea infusions to different extents when PEF dosage was higher than a critical level. The total concentration of volatiles lost was approximately 10% after PEF treatment at 40 kV cm⁻¹ for 200 μs.     

COMPARISON OF STEADY SHEAR RHEOLOGICAL PROPERTIES AND SMALL AMPLITUDE DYNAMIC VISCOELASTIC PROPERTIES OF FLUID FOOD MATERIALS

Small amplitude dynamic viscoelastic properties of apple butter, mustard, tub margarine, and mayonnaise are compared with their respective properties in steady shear flow in the range of shear rates and frequencies of 0.1-100 sec⁻¹ using a Rheometrics Mechanical Spectrometer. Comparison of dynamic and steady viscosities shows that dynamic viscosities (η*) are much larger than steady viscosities (η). Consequently the Cox-Merz rule is not obeyed. Moreover the obvious nonlinearity suggests that shift-factor type relationships are not obeyed either. The in-phase (η') component of the dynamic viscosity shows similar behavior when compared to the steady viscosity (η).
Comparison of G'/ω² and Ψ₁ also suggests that any of the results predicted by classical theories of viscoelasticity are not obeyed. G'/ω² is always much larger than Ψ₁ and the relationship between these two material functions is nonlinear.     

Low resolution pulse nuclear magnetic resonance study of water equilibration in dried carrots

Samples taken during air drying of carrots were analysed after different equilibration times. Low resolution NMR measurements were made and the longitudinal ( T ₁) and the transverse ( T ₂) relaxation times calculated. Both T ₁ and T ₂ decreased with the equilibration time for water contents above 0.30 and 0.47 kg water kg^-1 dry matter, respectively. The decrease in relaxation time increased with the water content. For the same water contents, grated carrots gave lower T ₁ values and smaller T ₁ decreases with equilibration time than 3-mm cubes. Low resolution NMR is a technique which is well suited to the monitoring of the tempering phases of industrial drying cycles.     

Extraction of ginger rhizome: partition constants and other equilibrium properties in organic solvents and in supercritical carbon dioxide

Equations have been derived for the direct and indirect methods of determining partition constants for constituents extracted from food and other natural materials. A careful distinction is drawn between mass and volume partition constants. The direct method has been applied to the extraction of [6]-gingerol from Jamaican ginger rhizome with supercritical carbon dioxide and the indirect method to its extraction with acetone, dichloromethane, ethanol and isopropanol. The resulting average mass partition constants were 0.2₉ and 0.3₉, respectively. The content of [6]-gingerol in the original ginger rhizome was found to be 31–32μmol g⁻¹. The extent of oleoresin extraction from the ground ginger and the degree of swelling and organic solvent uptake were also measured.     

PURIFICATION AND CHARACTERIZATION OF TWO TOMATO POLYGALACTURONASEISOENZYMES

The properties of tomato polygalacturonases at two ripening stages were investigated. Two isoenzymes, PG I and II, were isolated from underripe fruits with an orange skin color. Fully ripe fruits contained only polygalacturonase II. PG I and II were purified by chromatography on DEAE-Sephadex A-50, Sephacryl S-200 and CM-agarose chromatography. PG I had a M_r of 199,500 as determined by Sephacryl S-300 gel filtration and was 50% inactivated at 66.5°C and pH 4.5 after incubation for 5 min. It had an activation energy (E_a) of 16.8 Kcallmol (70.3 times 10³ Jlmol), V_max of 27.7 units/mg protein and K_m value of 7.5 times 10⁻² mM polygalacturonic acid. PG II had a M_r of 45,700 and was 50% inactivated at 58°C under the same conditions. Both isozymes had a pH optimum of 4.6. PG II had an E_a value of 14.8 Kcallmol (61.9 times 10³ Jlmol), V_max value of 58.8 units/mg protein and K_m value of 3.8 times 10⁻² mM polygalacturonic acid. PGI gave rise to only one band during electrophoresis in polyacrylamide gels, whereas PG II showed one major and one minor band both with PG activity. Gel electrophoresis in the presence of sodium dodecyl sulfate resulted in two major bands (M_r= 47,500 and 41,000) for PG I and only one major band (M_r= 47,500) for PG II. PG I is composed of several subunits, all of which are glycoproteins.     

In vitro evaluation of the cutaneous penetration of sprayable sunscreen emulsions with high concentrations of UV filters

The aim of this study was to evaluate the possible penetration through human skin of organic and inorganic filters contained in sunscreen emulsions packaged in aerosol cans, using an in vitro method. Experiments were carried out on two different types of emulsion: W/Si and W/O. This study was conducted using static diffusion cells (Franz cells). The determination of organic UV filters [Methylene Bis Benzotriazolyl Tetramethylbutylphenol (MBBT); Bis-Ethylhexyloxyphenol Methoxyphenyl Triazine (BEMT); Diethylamino Hydroxybenzoyl Hexyl Benzoate (DHHB); Ethylhexyl Methoxycinnamate (EMC); and 2-Ethylhexyl Dimethyl PABA (ED-PABA)] was performed by High Performance Liquid Chromatography (HPLC). Therefore, it was important to develop a single analytical method for the quantification of the five organic filters with the aim of facilitating the experiment. The determination of inorganic filters [titanium dioxide (TiO₂) and zinc oxide (ZnO)] was performed using an emission spectrometric analysis method (ICP-OES). The HPLC and ICP-OES methods were validated. After a penetration test of 24 h duration, the results showed very low penetration only for two of the organic filters (maximum penetration of 1.21 μg cm⁻² h⁻¹ for EMC and 0.14 μg cm⁻² h⁻¹ for MBBT) and no penetration for the inorganic filters. Moreover, more than 50% of each sunscreen agent stayed on the surface on the skin. These results are consistent with those in the literature that presents similar experiments. This study showed that the sprayable sunscreen products developed, which contained high concentrations of UV filters, presented a low level of skin penetration.     

The air drying behaviour of fresh and osmotically dehydrated banana slices

Ripe banana, cut to 10mm thick slabs were osmotically treated in sugar solutions of 35, 50 and 65° Brix for 36h. The initial moisture content fell from a value of 3.13kg H₂O DM to 2.19, 1.63 and 1.16kg H₂O kg⁻¹ for treatment in the three solutions, respectively. These slabs, with Total Soluble Solids (TSS) contents of 26, 34 and 39° Brix, respectively, as well as freshly cut but untreated slabs (15° Brix) were air dried in a cabinet type tray drier to near equilibrium conditions at fixed temperatures from 40 to 80°C and at a constant air speed of 0.62m s⁻¹. Drying was found to occur in the falling rate period only for both banana types and two drying constants K₁ and K₂ were established for a first and second falling rate period of drying. Increasing the drying air temperature significantly enhanced the drying rate and the K-values, except at 80°C when the rates fell, possibly because of case hardening of the slabs. Reducing the slab thickness also improved the drying rate, but increasing the air speed to 1.03m s⁻¹ did not have any profound effect. As the sugar content of the banana slabs increased through the osmotic treatment, drying rates fell. Calculated apparent moisture diffusivities at 60°C ranged from 34.8× 10⁻¹⁰ m² s⁻¹ (fresh slab) to 8.8×10⁻¹⁰ m² s⁻¹ for dried (39° Brix) slabs. The moisture diffusivity was significantly lowered as the moisture content dropped in drying and with increased levels of sugar. Previously osmosed and then air dried banana slabs showed appealing colour and texture compared to the fresh banana.     

ORAL PERCEPTION OF VISCOSITY IN FLUID FOODS AND MODEL SYSTEMS

The perceived in-mouth thickness ( T ) of a range of fluid foods and model systems was assessed by a trained sensory panel, using a ratio scaling technique, and correlated with objective measurements of viscosity (η_N). For Newtonian samples a simple linear correlation (r²= 0.98) is observed between log T and log η with exponent η= 0.22. The linear relationship between log T and log η for Newtonian materials was used to calculate the equivalent Newtonian viscosity (η_N) from subjective panel scores for the non-Newtonian samples studied. The shear rate at which observed viscosity is equal to η_N decreases with η_N, as reported previously by Shama and Sherman, but also decreases with increasing shear-rate dependence of viscosity. This implies oral perception of viscosity over a range of shear rates. Comparison of flow curves for samples assigned similar thickness scores, but showing very different shear thinning behaviour, suggests that the perceived thickness of extremely shear-thinning materials is dominated by their high viscosity at low rates of shear. As a simple practical index, viscosity at 10 s⁻¹ shows a better correlation (r²= 0.95) with the perceived thickness of the samples studied than values calculated by the methods suggested by Wood, or by Shama and Sherman (r²= 0.90 in both cases). The close agreement between panel scores for perceived thickness and perceived stickiness previously observed for concentrated solutions of random coil polysaccharides does not apply for several of the food systems studied, or for very concentrated solutions of xanthan.