Listeria monocytogenes survival of UV-C radiation is enhanced by presence of sodium chloride, organic food material and by bacterial biofilm formation

The bactericidal effect on food processing surfaces of ceiling-mounted UV-C light (wavelength 254 nm) was determined in a fish smoke house after the routine cleaning and disinfection procedure. The total aerobic counts were reduced during UV-C light exposure (48 h) and the number of Listeria monocytogenes positive samples went from 30 (of 68) before exposure to 8 (of 68). We therefore in a laboratory model determined the L. monocytogenes reduction kinetics by UV-C light with the purpose of evaluating the influence of food production environmental variables, such as presence of NaCl, organic material and the time L. monocytogenes was allowed to adhere to steel before exposure. L. monocytogenes grown and attached in tryptone soy broth (TSB) with glucose were rapidly killed (after 2 min) by UV-C light. However, bacteria grown and adhered in TSB with glucose and 5% NaCl were more resistant and numbers declined with 4-5 log units during exposure of 8-10 min. Bacteria grown in juice prepared from cold-smoked salmon were protected and numbers were reduced with 2-3 log when UV-C light was used immediately after attachment whereas numbers did not change at all if bacteria had been allowed to form a biofilm for 7 days before exposure. It is not known if this enhanced survival is due to physiological changes in the attached bacterial cells, a physical protection of the cells in the food matrix or a combination. In conclusion, we demonstrate that UV-C light is a useful extra bacteriocidal step and that it, as all disinfecting procedures, is hampered by the presence of organic material.     

Effect of gamma and electron beam irradiation on the survival of pathogens inoculated into salted, seasoned, and fermented oyster

The objective of this study was to identify the efficacy of gamma and electron beam irradiation of the food-borne pathogens including 3-strain cocktail of Listeria monocytogenes (ATCC 19114, 19115, and 19111), Staphylococcus aureus (ATCC 6538, 25923, and 29213), and Vibrio parahaemolyticus (ATCC 17802, 33844, and 27969) in salted, seasoned, and fermented oyster (oyster Jeotkal, 8% salt), commercially available in the market. Irradiation (0, 0.5, 1, 2, and 5 kGy) significantly reduced the initial microbial level not only immediately after irradiation but also during storage at 10 °C for 4 weeks (P ≤ 0.05). No viable cell was detected at 5 kGy of irradiation at a detection limit of 10¹ CFU/g. Gamma irradiation was more effective than electron beam irradiation, and yielded D₁₀ values of 0.60, 0.71, and 0.29 kGy for L. monocytogenes, S. aureus, and V. parahaemolyticus, and those of electron beam irradiation were 0.69, 0.94, and 0.29 kGy, respectively. V. parahaemolyticus was most sensitive to irradiation and storage among all pathogens tested. Sensory quality was not affected by irradiation treatment. Results suggest that a low dose irradiation can improve the microbial quality and reduce the risk by the food-borne pathogens of oyster Jeotkal, which has limited alternative sterilization methods due to the temperature sensitivity of food products.     

Desiccation of adhering and biofilm Listeria monocytogenes on stainless steel: Survival and transfer to salmon products

The foodborne bacterial pathogen, Listeria monocytogenes, commonly contaminates foods during processing, where the microorganisms are potentially subjected to low relative humidity (RH) conditions for extended periods of time. The objective of this study was to examine survival during desiccation (43% RH and 15 °C) of biofilm L. monocytogenes N53-1 cells on stainless steel coupons and to assess subsequent transfer to salmon products. Formation of static biofilm (2 days at 100% RH and 15 °C) prior to desiccation for 23 days significantly (P < 0.05) improved survival of cells desiccated in initial low salt concentrations (0.5%) compared to the survival for non-biofilm cells also desiccated in low salt, indicating the protective effect of the biofilm matrix. Osmoadaptation of cells in 5% NaCl before formation of the static biofilm significantly (P < 0.05) increased long-term desiccation survival (49 days) irrespectively of the initial salt levels (0.5% and 5% NaCl). The efficiency of transfer (EOT) of desiccated biofilm cells was significantly (P < 0.05) lower than EOTs for desiccated non-biofilm bacteria, however, as biofilm formation enhanced desiccation survival more bacteria were still transferred to smoked and fresh salmon. In conclusion, the current work shows the protective effect of biofilm formation, salt and osmoadaptation on the desiccation survival of L. monocytogenes, which in turn increases the potential for cross-contamination during food processing.     

Role of general stress-response alternative sigma factors σ(S) (RpoS) and σ(B) (SigB) in bacterial heat resistance as a function of treatment medium pH

This investigation aimed to determine the role of general stress-response alternative sigma factors σ^S (RpoS) and σ^B (SigB) in heat resistance and the occurrence of sublethal injuries in cell envelopes of stationary-phase Escherichia coli BJ4 and Listeria monocytogenes EGD-e cells, respectively, as a function of treatment medium pH. Given that microbial death followed first-order inactivation kinetics (R² > 0.95) the traditional D_T and z values were used to describe the heat inactivation kinetics.Influence of rpoS deletion was constant at every treatment temperature and pH, making a ΔrpoS deletion mutant strain approximately 5.5 times more heat sensitive than its parental strain for every studied condition. Furthermore, the influence of the pH of the treatment medium on the reduction of the heat resistance of E. coli was also constant and independent of the treatment temperature (average z value = 4.9 °C) in both parental and mutant strains.L. monocytogenes EGD-e z values obtained at pH 7.0 and 5.5 were not significantly different (p > 0.05) in either parental or the ?sigB deletion mutant strains (average z value = 4.8 °C). Nevertheless, at pH 4.0 the z value was higher (z = 8.4 °C), indicating that heat resistance of both L. monocytogenes strains was less dependent on temperature at pH 4.0. At both pH 5.5 and 7.0 the influence of sigB deletion was constant and independent of the treatment temperature, decreasing L. monocytogenes heat resistance approximately 2.5 times. In contrast, the absence of sigB did not decrease the heat resistance of L. monocytogenes at pH 4.0.The role of RpoS in protecting cell envelopes was more important in E. coli (4 times) than SigB in L. monocytogenes (1.5 times). Moreover, the role of σ^S in increasing heat resistance seems more relevant in enhancing the intrinsic resilience of the cytoplasmic membrane, and to a lesser extent, outer membrane resilience.Knowledge of environmental conditions related to the activation of alternative sigma factors σ^S and σ^B and their effects on heat resistance would help us to avoid and/or identify situations that increase bacterial stress resistance. Therefore, more efficient food preservation processes might be designed.     

Mixed species biofilms of Listeria monocytogenes and Lactobacillus plantarum show enhanced resistance to benzalkonium chloride and peracetic acid

We investigated the formation of single and mixed species biofilms of Listeria monocytogenes strains EGD-e and LR-991, with Lactobacillus plantarum WCFS1 as secondary species, and their resistance to the disinfectants benzalkonium chloride and peracetic acid. Modulation of growth, biofilm formation, and biofilm composition was achieved by addition of manganese sulfate and/or glucose to the BHI medium. Composition analyses of the mixed species biofilms using plate counts and fluorescence microscopy with dual fluorophores showed that mixed species biofilms were formed in BHI (total count, 8-9 log₁₀ cfu/well) and that they contained 1-2 log₁₀ cfu/well more L. monocytogenes than L. plantarum cells. Addition of manganese sulfate resulted in equal numbers of both species (total count, 8 log₁₀ cfu/well) in the mixed species biofilm, while manganese sulfate in combination with glucose, resulted in 1-2 log₁₀ more L. plantarum than L. monocytogenes cells (total count, 9 log₁₀ cfu/well). Corresponding single species biofilms of L. monocytogenes and L. plantarum contained up to 9 log₁₀ cfu/well. Subsequent disinfection treatments showed mixed species biofilms to be more resistant to treatments with the selected disinfectants. In BHI with additional manganese sulfate, both L. monocytogenes strains and L. plantarum grown in the mixed species biofilm showed less than 2 log₁₀ cfu/well inactivation after exposure for 15 min to 100 μg/ml benzalkonium chloride, while single species biofilms of both L. monocytogenes strains showed 4.5 log₁₀ cfu/well inactivation and single species biofilms of L. plantarum showed 3.3 log₁₀ cfu/well inactivation. Our results indicate that L. monocytogenes and L. plantarum mixed species biofilms can be more resistant to disinfection treatments than single species biofilms.     

A predictive model for heat inactivation of Listeria monocytogenes biofilm on buna-N rubber

The purpose of this study was to develop a predictive model for the heat inactivation of Listeria monocytogenes in monoculture (strains Scott A and 3990) and with competing bacteria (Pseudomonas sp. and Pantoea agglomerans) formed on buna-N rubber with and without the presence of food-derived soil. Biofilms were produced on rubber disks in dilute Tryptic Soy broth (dTSB) with incubation for 48 h at 25 °C. Duplicate biofilm samples were heat treated for 1, 3, 5, and 15 min at 70, 72, 75, 77 and 80 °C and tested for survivors using enrichment media. The experiment was repeated six times. A predictive model was developed and plots were generated showing the percent probability of L. monocytogenes inactivation in biofilms after heat treatment. For example, to achieve a 95% probability level of complete inactivation required heat treatment of 76 °C for 6 min. The predicted model was validated using a five-strain cocktail of L. monocytogenes. The validated prediction model indicates that with proper maintenance of the time/temperature controls L. monocytogenes in biofilms on rubber surfaces will be inactivated. This model can be used as a tool in the selection of hot water sanitation processes for rubber surfaces.     

Heat resistance of Listeria species to liquid whole egg ultrapasteurization treatment

The lethality of ultrapasteurization treatments (70 °C/1.5 min.) applied at constant temperature (isothermal condition) and at a constantly raising temperature of 2 °C/min (non-isothermal condition) in liquid whole egg (LWE) against two strains of Listeria monocytogenes (STCC 5672 and 4032) and one of Listeria innocua has been investigated. Isothermal survival curves up to 71 °C were obtained, which followed first-order inactivation kinetics. The obtained D_t values indicated that L. innocua was significantly (p < 0.05) more heat resistant than L. monocytogenes strains. Non-significant (p > 0.05) differences were observed among z values (12.4 ± 0.4 °C, 13.1 ± 0.4 °C and 12.2 ± 0.7 °C for L. innocua and L. monocytogenes 5672 and 4032, respectively). Based on obtained D_t and z values, isothermal ultrapasteurization treatment (70 °C/1.5 min.) would provide 3.5-, 5.0-, and 6.5-Log₁₀ cycles of L. innocua and L. monocytogenes 5672 and 4032, respectively. Non-isothermal heating lag phase increased the thermotolerance of Listeria species in LWE. The simulated industrial pasteurization treatment for LWE (heating-up phase from 25 to 70 °C followed by 1.5 min. at 70 °C) would attain 5-Log₁₀ reductions of L. monocytogenes 5672 and 4032, and 3.7-Log₁₀ reductions of L. innocua. Therefore, the safety level of industrial ultrapasteurization concerning L. monocytogenes could be lower than that estimated with data obtained under isothermal conditions.     

Susceptibility of Listeria monocytogenes strains to disinfectants and chlorinated alkaline cleaners at cold temperatures

Minimal inhibitory concentration (MIC), suspension and biofilm tests were used in evaluating the disinfecting efficacy of eight commercially available disinfectants and four chlorinated alkaline cleaners against 10 strains of Listeria monocytogenes at refrigerated temperatures. The adaptive response and cross-adaptation of L. monocytogenes to the disinfectants and chlorinated alkaline cleaners were investigated. The bactericidal components in the agents used were chlorine, quaternary ammonium compound (QAC), peracetic acid, ethanol and isopropanol. With some exceptions the disinfectants were efficient against the L. monocytogenes strains. One alkaline hypochlorite containing disinfectant was not efficient in the suspension and MIC tests at the lowest concentration recommended by the manufacturer. The chlorinated alkaline cleaners were effective against L. monocytogenes. A QAC-based disinfectant was found to be the least-effective agent on both glass bead-blasted polyethylene and stainless-steel surfaces. Adaptive and cross-adaptive responses of L. monocytogenes strains were observed towards the QAC-based agent, but over 2-fold increases to other agents were not observed. These results suggest that the adaptive responses of L. monocytogenes to disinfectants or chlorinated alkaline cleaners are of a minor concern.     

The effects of X-ray radiation on Escherichia coli O157:H7, Listeria monocytogenes, Salmonella enterica and Shigella flexneri inoculated on whole Roma tomatoes

In the last two decades several foodborne disease outbreaks associated with produce were reported. Tomatoes, in particular, have been associated with several multi-state Salmonella outbreaks. Inactivation of inoculated Escherichia coli O157:H7, Listeria monocytogenes, Salmonella enterica and Shigella flexneri on whole Roma tomato surfaces by X-ray at 0.1, 0.5, 0.75, 1.0, and 1.5 kGy was studied. The main purpose of this study was to achieve a 5 log reduction in consistent with the recommendations of the National Advisory Committee on Microbiological Criteria for Foods. Moreover, the effect of X-ray on inherent microflora (mesophilic counts, psychrotrophic counts and yeast and mold counts) of untreated and treated Roma tomatoes, during storage at ambient temperature (22 °C) for 20 days was also determined. Mixtures of three or two strains of each tested organism was spot inoculated (100 μl) onto the surface of Roma tomatoes (approximately 7–9 log per tomato), separately, and air-dried, followed by treatment with X-ray doses at 22 °C and 55–60% relative humidity. Surviving bacterial populations on tomato surfaces were evaluated using a nonselective medium (tryptic soy agar) with a selective medium overlay for each bacteria; E. coli O157:H7 (CT-SMAC agar), L. monocytogenes (MOA), and S. enterica and S. flexneri (XLD). Treatment with X-ray significantly reduced the population of the tested pathogens on whole Roma tomato surfaces, compared with the control. Approximately 4.2, 2.3, 3.7 and 3.6 log CFU reduction of E. coli O157:H7, L. monocytogenes, S. enterica and S. flexneri per tomato were achieved by treatment with 0.75 kGy X-ray, respectively. More than a 5 log CFU reduction per tomato was achieved at 1.0 or 1.5 kGy X-ray for all tested pathogens. Furthermore, treatment with X-ray significantly reduced the inherent microflora on Roma tomatoes. Inherent levels were significantly (p < 0.05) lower than the control sample throughout storage for 20 days.     

Kinetics of resuscitation and growth of L. monocytogenes as a tool to select appropriate enrichment conditions as a prior step to rapid detection methods

Rapid methods still rely on a prior (shortened) enrichment step before application. Quantitative information is a prerequisite for understanding the resuscitation kinetics of the growth during the enrichment step. In this study various basal and newly introduced selective enrichment broths were evaluated. First, growth parameters (λ, μ_max) of both healthy and sub-lethally injured cells were determined. Next, a selection of enrichment broths was compared for their capacity to support detection within 24 h of low numbers of Listeria monocytogenes in artificially and naturally contaminated food samples. Detection was performed either by phage protein-based capture (Listeria Capture kit, Profos, Regensburg, Germany) combined with plating on chromogenic medium or by fluorescence in situ hybridization (FISH) using the VIT-Listeria kit (Vermicon, Munich, Germany). Kinetics of resuscitation and growth of L. monocytogenes in various enrichment broths showed that for detection of low numbers of sub-lethally injured L. monocytogenes cells at least an overnight enrichment was needed. A selective enrichment broth was needed to enable proliferation of L. monocytogenes within the indigenous bacterial flora present in foods. However, combination of an appropriate enrichment condition with advanced detection techniques may enable a 24 h detection of L. monocytogenes.     

Initial adhesion of Listeria monocytogenes to solid surfaces under liquid flow

Some strains of the food borne pathogen Listeria monocytogenes persist in food processing environments. The exact reason behind this phenomenon is not known, but strain differences in the ability to adhere to solid surfaces could offer an explanation. In the present work, initial adhesion of nine strains of L. monocytogenes was investigated under liquid flow at two levels of shear stress on six different surfaces using a flow chamber set-up with microscopy measurements. The surfaces tested were glass and PVC, and glass coated with beef extract, casein, and homogenised and unhomogenised milk. In addition, the effect of prior environmental stress (5% NaCl, low nutrient availability) on initial adhesion was investigated. The hydrophobicity of the investigated surfaces was determined by contact angle measurements and the surface properties of the investigated L. monocytogenes strains were determined using Microbial Adhesion To Solvents (MATS). All surfaces with the exception of PVC were found to be hydrophilic. Strain differences were found to significantly influence the initial adhesion rate (IAR) of all nine strains to all the surfaces (p < 0.05) at both low and high shear stress. Furthermore, there was a significant effect of the surfaces tested (p < 0.05) in the adhesion ability of almost all strains. The IAR was affected by flow rate (shear stress) as seen by a decrease in adhesion at high shear stress for most strains. A significant effect of interactions between strain-surface and strain-shear stress (p < 0.001) was observed but not of interactions between surface-shear stress. No correlation between surface hydrophobicity and IAR was observed. Addition of 5% NaCl during propagation resulted in a decrease in IAR whilst propagation in low nutrient media caused an increase indicating a general change in surface characteristics under these conditions. Known persisting strains did not display general better adherence.     

A comparison between E-beam irradiation and high pressure treatment for cold-smoked salmon sanitation: microbiological aspects

The effectiveness of electron beam irradiation and high pressure treatment for the sanitation of cold-smoked salmon from two points of view, microbial safety and shelf-life extension, was compared. From the response of L. monocytogenes INIA H66a to irradiation, a D value of 0.51 kGy was calculated. For samples stored at 5 °C, 1.5 kGy would be sufficient to attain a Food Safety Objective (FSO) of 2 log₁₀cfu/g L. monocytogenes for a 35-day shelf-life, whereas 3 kGy would be needed in the case of a temperature abuse (5 °C + 8 °C). Pressurization at 450 MPa for 5 min was considered to be an insufficient treatment, since the FSO of 2 log₁₀cfu/g L. monocytogenes was only attained for a shelf-life of 21 days at 5 °C. However, treatment at 450 MPa for 10 min achieved this FSO for samples held during 35 days at 5 °C, or during 21 days under temperature abuse (5 °C + 8 °C) conditions. Irradiation at 2 kGy kept the microbial population of smoked salmon below 6 log₁₀cfu/g after 35 days at 5 °C, with negligible or very light changes in its odor. Pressurization at 450 MPa for 5 min also kept the microbial population below 6 log₁₀cfu/g after 35 days at 5 °C and did not alter odor, but affected negatively the visual aspect of smoked salmon.     

Effect of high-pressure processing on reduction of Listeria monocytogenes in packaged Queso Fresco

The effect of high-hydrostatic-pressure processing (HPP) on the survival of a 5-strain rifampicin-resistant cocktail of Listeria monocytogenes in Queso Fresco (QF) was evaluated as a postpackaging intervention. Queso Fresco was made using pasteurized, homogenized milk, and was starter-free and not pressed. In phase 1, QF slices (12.7 × 7.6 × 1 cm), weighing from 52 to 66 g, were surface inoculated with L. monocytogenes (ca. 5.0 log₁₀ cfu/g) and individually double vacuum packaged. The slices were then warmed to either 20 or 40°C and HPP treated at 200, 400, and 600 MPa for hold times of 5, 10, 15, or 20 min. Treatment at 600 MPa was most effective in reducing L. monocytogenes to below the detection level of 0.91 log₁₀ cfu/g at all hold times and temperatures. High-hydrostatic-pressure processing at 40°C, 400 MPa, and hold time ≥15 min was effective but resulted in wheying-off and textural changes. In phase 2, L. monocytogenes was inoculated either on the slices (ca. 5.0 log₁₀ cfu/g; ON) or in the curds (ca. 7.0 log₁₀ cfu/g; IN) before the cheese block was formed and sliced. The slices were treated at 20°C and 600 MPa at hold times of 3, 10, and 20 min, and then stored at 4 and 10°C for 60 d. For both treatments, L. monocytogenes became less resistant to pressure as hold time increased, with greater percentages of injured cells at 3 and 10 min than at 20 min, at which the lethality of the process increased. For the IN treatment, with hold times of 3 and 10 min, growth of L. monocytogenes increased the first week of storage, but was delayed for 1 wk, with a hold time of 20 min. Longer lag times in growth of L. monocytogenes during storage at 4°C were observed for the ON treatment at hold times of 10 and 20 min, indicating that the IN treatment may have provided a more protective environment with less injury to the cells than the ON treatment. Similarly, HPP treatment for 10 min followed by storage at 4°C was the best method for suppressing the growth of the endogenous microflora with bacterial counts remaining below the level of detection for 2 out of the 3 QF samples for up to 84 d. Lag times in growth were not observed during storage of QF at 10°C. Although HPP reduced L. monocytogenes immediately after processing, a second preservation technique is necessary to control growth of L. monocytogenes during cold storage. However, the results also showed that HPP would be effective for slowing the growth of microorganisms that can shorten the shelf life of QF.     

Change in attachment of Salmonella Typhimurium, Yersinia enterocolitica, and Listeria monocytogenes to pork skin and muscle after hot water and lactic acid decontamination

The attachment of Salmonella enterica subsp. enterica serovar Typhimurium, Yersinia enterocolitica, and Listeria monocytogenes to pig skin and muscle tissue decontaminated with 80 °C water or 55 °C, 1% lactic acid for 5 and 15 s was investigated. Attachment properties differed between skin and muscle surfaces. A significantly higher number of firmly attached bacteria was found on the decontaminated skin surface compared to the non-treated skin surface, both on hot water (P < 0.0001) and on lactic acid treated skin (P < 0.001). At the muscle surfaces, no such difference in attachment were shown between hot water treated surfaces and non-treated surfaces. In contrast, for lactic acid decontamination, significantly fewer bacteria attached to the treated muscle surfaces (P < 0.0001). The study did not show significant differences in surface attachment, between Salmonella, Yersinia and Listeria, which indicate that surface and environmental factors may influence attachment more than bacterial properties. A more profound location of attached bacteria at muscle compared to skin was indicated. Confocal laser scanning microscopy studies showed that bacteria located in deep tissue structures of non-decontaminated and decontaminated skin and muscle surfaces. In the latter, bacteria tended to “hide” between the muscle fibres and may be entrapped at those sites. The finding of changed attachment properties at skin after decontamination may play a role in cross- and recontamination, during subsequent meat processing.     

Use of mild irradiation doses to control pathogenic bacteria on meat trimmings for production of patties aiming at provoking minimal changes in quality attributes

The objectives of the present work were to assess the use of moderate doses of gamma irradiation (2 to 5 kGy) and to reduce the risk of pathogen presence without altering the quality attributes of bovine trimmings and of patties made of irradiated trimmings. Microbiological indicators (coliforms, Pseudomonas spp and mesophilic aerobic counts), physicochemical indicators (pH, color and tiobarbituric acid) and sensory changes were evaluated during storage. 5 kGy irradiation doses slightly increased off flavors in patties. Two pathogenic markers (Listeria monocytogenes and Escherichia coli O157:H7) were inoculated at high or low loads to trimming samples which were subsequently irradiated and lethality curves were obtained. Provided that using irradiation doses ≤ 2.5 kGy are used, reductions of 2 log CFU/g of L. monocytogenes and 5 log CFU/g of E. coli O157:H7 are expected. It seems reasonable to suppose that irradiation can be successfully employed to improve the safety of frozen trimmings when initial pathogenic bacteria burdens are not extremely high.     

Cultured C2C12 cell lines as a model for assessment of bacterial attachment to bovine primary muscle cells

The mechanisms of bacterial attachment to meat tissues need to be understood to enhance meat safety interventions. However, little is known about attachment of foodborne pathogens to meat muscle cells. In this study, attachment of six Escherichia coli and two Salmonella strains to primary bovine muscle cells and a cultured muscle cell line, C₂C₁₂, was measured, including the effect of temperature. At 37 °C, all but one strain (EC623) attached to C₂C₁₂ cells, whereas only five of eight strains (M23Sr, H10407, EC473, Sal1729a and Sal691) attached to primary cells. At 10 °C, two strains (H10407 and EC473) attached to C₂C₁₂ cells, compared to four strains (M23Sr, EC614, H10407 and Sal1729a) of primary cells. Comparing all strains at both temperatures, EC614 displayed the highest CFU per C₂C₁₂ cell (4.60 ± 2.02 CFU/muscle cell at 37 °C), whereas greater numbers of M23Sr attached per primary cell (51.88 ± 39.43 CFU/muscle cell at 37 °C). This study indicates that primary bovine muscle cells may provide a more relevant model system to study bacterial attachment to beef carcasses compared to cell lines such as C₂C₁₂.     

Fate of Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella on fresh-cut celery

Illnesses from Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella have been associated with the consumption of numerous produce items. Little is known about the effect of consumer handling practices on the fate of these pathogens on celery. The objective of this study was to determine pathogen behavior at different temperatures under different storage conditions. Commercial fresh-cut celery was inoculated at ca. 3 log CFU/g onto either freshly cut or outer uncut surfaces and stored in either sealed polyethylene bags or closed containers. Samples were enumerated following storage for 0, 1, 3, 5, and 7 days when held at 4 °C or 12 °C, and after 0, 8, and 17 h, and 1, and 2 days when held at 22 °C. At 4 °C, all populations declined by 0.5–1.0 log CFU/g over 7 days. At 12 °C, E. coli O157:H7 and Salmonella populations did not change, while L. monocytogenes populations increased by ca. 0.5 log CFU/g over 7 days. At 22 °C, E. coli O157:H7, Salmonella, and L. monocytogenes populations increased by ca. 1, 2, or 0.3 log CFU/g, respectively, with the majority of growth occurring during the first 17 h. On occasion, populations on cut surfaces were significantly higher than those on uncut surfaces. Results indicate that populations are reduced under refrigeration, but survive and may grow at elevated temperatures.     

Ultraviolet irradiation: The generator of Vitamin D2 in edible mushrooms

Fresh Shiitake mushrooms (Lentinula edodes), Oyster mushrooms (Pleurotus ostreatus), Button mushrooms (Agaricus bisporus), and Abalone mushrooms (Pleurotus cystidus) were irradiated with Ultraviolet-A (UV-A; wavelength 315–400 nm), Ultraviolet-B (UV-B; wavelength 290–315 nm), and Ultraviolet-C (UV-C; wavelength 190–290 nm). Irradiation of each side of the mushrooms for 1 h, was found to be the optimum period of irradiation in this conversion. The conversions of ergosterol to vitamin D₂ under UV-A, UV-B, and UV-C were shown to be significantly different (p < 0.01). The highest vitamin D₂ content (184 ± 5.71 μg/g DM) was observed in Oyster mushrooms irradiated with UV-B at 35 °C and around 80% moisture. On the other hand, under the same conditions of irradiation, the lowest vitamin D₂ content (22.9 ± 2.68 μg/g DM) was observed in Button mushrooms.     

Fat content increases the lethality of ultra-high-pressure homogenization on Listeria monocytogenes in milk

Listeria monocytogenes CCUG 15526 was inoculated at a concentration of approximately 7.0 log₁₀ cfu/mL in milk samples with 0.3, 3.6, 10, and 15% fat contents. Milk samples with 0.3 and 3.6% fat content were also inoculated with a lower load of approximately 3.0 log₁₀ cfu/mL. Inoculated milk samples were subjected to a single cycle of ultra-high-pressure homogenization (UHPH) treatment at 200, 300, and 400 MPa. Microbiological analyses were performed 2 h after the UHPH treatments and after 5, 8, and 15 d of storage at 4°C. Maximum lethality values were observed in samples treated at 400 MPa with 15 and 10% fat (7.95 and 7.46 log₁₀ cfu/mL), respectively. However, in skimmed and 3.6% fat milk samples, complete inactivation was not achieved and, during the subsequent 15 d of storage at 4°C, L. monocytogenes was able to recover and replicate until achieving initial counts. In milk samples with 10 and 15% fat, L. monocytogenes recovered to the level of initial counts only in the milk samples treated at 200 MPa but not in the milk samples treated at 300 and 400 MPa. When the load of L. monocytogenes was approximately 3.0 log₁₀ cfu/mL in milk samples with 0.3 and 3.6% fat, complete inactivation was not achieved and L. monocytogenes was able to recover and grow during the subsequent cold storage. Fat content increased the maximum temperature reached during UHPH treatment; this could have contributed to the lethal effect achieved, but the amount of fat of the milk had a stronger effect than the temperature on obtaining a higher death rate of L. monocytogenes.     

Efficacy of bacteriophage LISTEXP100 combined with chemical antimicrobials in reducing Listeria monocytogenes in cooked turkey and roast beef

The aim of this study was to verify the effectiveness of the commercially available anti-Listeria phage preparation LISTEX^™P100 in reducing Listeria monocytogenes on ready-to-eat (RTE) roast beef and cooked turkey in the presence or absence of the chemical antimicrobials potassium lactate (PL) and sodium diacetate (SD). Sliced RTE meat cores at 4 and 10 °C were inoculated with cold-adapted L. monocytogenes to result in a surface contamination level of 10³ CFU/cm². LISTEX^TMP100 was applied at 10⁷ PFU/cm² and samples taken at regular time intervals during the RTE product's shelf life to enumerate viable L. monocytogenes. LISTEX^™P100 was effective during incubation at 4 °C with initial reductions of L. monocytogenes of 2.1 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef without chemical antimicrobials (there was no significant difference to the initial L. monocytogenes reductions in the presence of LISTEX^TMP100 for cooked turkey containing PL and roast beef containing SD-PL). In the samples containing no chemical antimicrobials, the presence of phage resulted in lower L. monocytogenes numbers, relative to the untreated control, of about 2 log CFU/cm² over a 28-day storage period at 4 °C. An initial L. monocytogenes cell reduction of 1.5 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef containing no chemical antimicrobials was achieved by the phage at 10 °C (abusive temperature). At this temperature, the L. monocytogenes cell numbers of samples treated with LISTEX™ P100 remained below those of the untreated control only during the first 14 days of the experiment for roast beef samples with and without antimicrobials. On day 28, the L. monocytogenes numbers on samples containing chemical antimicrobials and treated with LISTEX^TMP100 stored at 4 and 10 °C were 4.5 log₁₀ CFU/cm² and 7.5 log₁₀ CFU/cm², respectively, for cooked turkey, and 1.2 log₁₀ CFU/cm² and 7.2 log₁₀ CFU/cm², respectively, for roast beef. In both cooked turkey samples with and without chemical antimicrobials stored at 10 °C, the phage-treated samples had significantly lower numbers of L. monocytogenes when compared to the untreated controls throughout the 28-day storage period (P < 0.0001). For roast beef and cooked turkey containing chemical antimicrobials treated with LISTEX^TMP100 and stored at 4 °C, no more than a 2 log CFU/cm² increase of L. monocytogenes was observed throughout the stated shelf life of the product. This study shows that LISTEX^™P100 causes an initial reduction of L. monocytogenes numbers and can serve as an additional hurdle to enhance the safety of RTE meats when used in combination with chemical antimicrobials.