冷轧压下率对无抑制剂取向硅钢初次再结晶退火的影响

对无抑制剂取向硅钢不同压下率下初次再结晶退火后的显微组织、宏观织构和微观织构进行了研究.结果表明,冷轧板织构主要为α取向线{001}＜110＞、{112}＜110＞和{111}＜110＞织构以及γ取向线{111}＜110＞织构.初次再结晶退火后,α取向线织构减弱,织构主要为γ取向线{111}＜112＞织构.随冷轧压下率的增加,冷轧和初次再结晶织构强度增加.当压下率为88％时,初次再结晶退火后 Goss 织构和{111}＜112＞织构强度最高,最有利于发生二次再结晶.EBSD 分析显示,Goss 取向晶粒大多与{111}＜112＞取向晶粒相邻.提高冷轧压下率,Goss取向晶粒和{111}＜112＞取向晶粒都增加,Goss 取向晶粒偏离理想取向角度减少.     

0.20 mm薄规格取向硅钢的开发及关键工艺探讨

为开发磁性能优良的0.20 mm薄规格取向硅钢,对该取向硅钢的组织特征,不同冷轧压下率和高温退火气氛对磁性能的影响进行了研究。结果表明：所获得的0.20 mm薄规格取向硅钢成品组织二次再结晶完全,铁损（P1.7/50）为0.89 W/kg,磁感（J800）为1.906 T;热轧和常化1/8层的主要织构组分为Goss织构,冷轧织构为较强的{001}〈110〉,退火织构主要为{411}〈148〉,脱碳晶粒尺寸约为21.17 μm,Goss晶粒极少;0.20 mm薄规格取向硅钢合适的冷轧压下率为91.3 %;高温退火升温段合适的气氛为75% N2。     

常化温度对冷轧无取向硅钢薄带磁性能和织构的影响

研究了常化温度对冷轧无取向硅钢薄带磁性能和织构的影响.结果表明,冷轧无取向硅钢薄带生产过程中采用常化工艺能够降低高频铁损值,在900～950℃温度范围内常化能够降低成品硅钢中γ织构不利组分的强度,同时提高{100}面有利织构的强度.过高温度下常化会使成品晶粒尺寸偏大,导致涡流损耗增加,对冷轧无取向硅钢薄带的磁性能不利.     

形变对无取向硅钢冷轧织构的影响

研究了经常化处理的无取向硅钢[w(Si)=3%]异步冷轧织构随形变量的变化.结果表明,异步冷轧织构随形变量的变化而发生改变,快慢辊侧的织构类型不变,但强度有所不同;随形变量增加,冷轧织构组分逐渐向α织构和γ织构组分聚集;高斯织构{110}<001>组分逐渐减少,反高斯{001}<110>织构组分逐渐增强;{111}<110>织构组分出现最大值;当压下率达到84%时,出现了较强的{001}<120>织构组分.     

退火工艺对DC04汽车板再结晶组织和织构的影响

以酒钢CSP工艺DC04冷轧汽车板为原料,通过实验室模拟退火工艺,采用OM、EBSD、ODF技术,研究退火工艺对其组织和织构特征的影响。结果表明,DC04汽车板退火组织为铁素体和少量渗碳体,575℃退火1h再结晶开始,730℃退火1h后再结晶较为充分,并随着退火时间的延长,铁素体晶粒长大。不同压下率的DC04冷轧板和退火板中,主要织构均为bcc金属中典型的α(<110>//RD)纤维织构和γ（<111>//ND）纤维织构。随着压下率增加,{111}<112>织构的取向密度明显大于{111}<110>织构的取向密度。730 ℃退火后,低压下率67%的退火板织构中有微弱的{001}<110>取向,但随着压下率增大,这种织构逐渐消失,而形成较强的{111}<112>、{111}<110>有利织构。增加变形量有利于获得有利的{111}织构而抑制不利{001}织构的生成,从而提高DC04的深冲性能。     

二次冷轧的中间退火温度对2.3Si无取向硅钢组织和性能的影响

试验2.3Si无取向硅钢(/%:0.003C,2.30Si,0.16Mn,≤0.020P,≤0.005S,0.54Al)冷轧板由常化和未常化的2.5 mm热轧板冷轧至0.6 mm(压下率76%),经750~950℃ 2.5 min中间退火后再冷轧至0.5 mm(压下率16.7%),成品板经890℃+960℃ 2.5 min退火。研究了中间退火温度对该钢晶粒尺寸、织构和磁性能的影响。结果表明,随中间退火温度的升高,二次冷轧前晶粒和成品晶粒增大,成品中不利织构组分{111}和{112}减弱,磁性能得到改善。热轧板经过常化时的磁性能明显好于未经常化时的磁性能,但中间退火温度较高时常化对磁性能的有利作用减弱。     

冷轧压下率对连续退火Ti-IF钢组织和织构的影响

以工业生产的Ti-IF钢热轧板为研究材料,结合连续热镀锌线的工艺特点,采用实验室冷轧、盐浴退火方法和金相、X射线织构测试等分析手段,研究了冷轧压下率对组织和织构的影响规律。试验结果表明,随着冷轧压下率从60%提高到90%,冷轧态α取向线上的取向密度不断增强,而且主要形成了{223}110和{114}110织构,γ线上的{111}110和{111}112织构亦有所增强;退火后铁素体晶粒尺寸从9.0级细化到10.5级;试验钢退火后仍具有较强的{223}110和{114}110织构,且随着冷轧压下率的提高,{111}织构有增强的趋势。要获得强的{111}织构,冷轧压下率需在80%以上。     

冷轧压下率对薄规格取向硅钢冷轧和退火织构的影响

实验采用不同厚度的低温取向硅钢热轧板冷轧至0.18 mm。通过XRD分析冷轧板表面和中心层的织构,通过EBSD分析了脱碳板截面的织构。结果表明,冷轧样品表层和中心层,随着压下率增大,{111}面织构总含量有所减少,{100}面织构总含量有所增多;脱碳样品中{111}面织构明显增多,尤其是{111}〈112〉织构组分,{100}面织构明显减少,尤其是{100}〈011〉织构组分,{411}〈148〉织构组分也明显增多;脱碳样品中,随着压下率增大,晶粒尺寸逐渐减小。不利于二次再结晶发展的织构随着压下率的增大明显增加,同时有利的CSL晶界随着压下率的增加会稍有减少。     

二次冷轧压下率对镀锡板组织和性能的影响

 为了开发二次冷轧镀锡板，采用硬度计、拉伸试验机、光学显微镜、透射电镜和X射线衍射仪研究了二次冷轧压下率对镀锡板组织和性能的影响规律。结果表明，随着二次冷轧压下率提高，试验钢的硬度和强度提高，各向异性增加，伸长率降低，当二次冷轧压下率为20%时可获得较高的硬度和伸长率的匹配。同时二次冷轧压下率对织构影响明显，当压下率为20%～40%时，α取向线中最高取向密度出现在{223}〈110〉～{445}〈110〉之间，可达到6.2，并且随变形量增加，γ取向线中{111}〈110〉取向密度逐渐从3.1降低到2.7，{111}〈112〉取向密度逐渐从4.9提高到5.3。     

大压下率冷轧无取向硅钢织构演变及性能

组织和织构是影响无取向硅钢性能的重要因素。为改善产品性能,研究了冷轧压下率(71.7%~87.0%)对高牌号无取向硅钢组织、织构、磁性能和力学性能的影响。结果表明,随冷轧压下率的增加,退火晶粒平均尺寸先减小后增大;高斯和立方织构强度减弱,γ纤维织构增强,α纤维织构转变为较强的α*({ h, 1, 1}〈1/h, 1, 2〉)织构,并随冷轧压下率的增加而增强,同时其峰值逐渐向{111}面移动;工频铁损P1.5/50、高频铁损P1.0/400和磁极化强度J5000同时降低,屈服强度变化不大,表面硬度逐渐增加。当冷轧压下率由84.7%增至87.0%、厚度减至0.30 mm时,高频铁损降幅是工频铁损的11倍,表面硬度增幅变大。以上研究成果对硅钢减薄后织构及组织的优化提供了很好的指导。     

转炉炉壳热应力分析

根据实际转炉建立实体模型。以有限元为手段,考虑了炉衬和炉壳材料的物性参数随温度变化的特点和炉衬与炉壳之间膨胀间隙,计算了转炉炉壳在温度载荷和炉衬膨胀压力同时作用下的热应力。所得结果可为转炉炉壳设计提供依据。     

The effect of amount of possession of the trait of hostility on accuracy of perception of hostility in others.

Some theories of personality hold that an individual's perception of others is influenced by his own personality characteristics; more specifically, that a trait of low social value will be projected more into others, and that insight into the possession of these characteristics reduces this distortion. These 2 hypotheses were tested by having a group of college students rate each other (including themselves) on degree of friendliness or hostility. Agreement with group rating about self yielded the insight score. In general, the hypotheses were supported; the "friendly" Ss were most accurate in their perception of others, and insight was positively associated with accurate perception. From Psyc Abstracts 36:04:4HL16M. (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

Comparison of rates of infection of two methods of emergency ventricular drainage

The rates of infection of two methods of external ventricular drainage in use at Atkinson Morley's Hospital--namely, (a) percutaneous drainage with Rickham reservoirs and (b) tunnelled ventriculostomies--were compared in this retrospective review. Percutaneous drainage of CSF with Rickham reservoirs was associated with a 27% rate of infection as identified by positive microbiological cultures; tunnelled ventriculostomy catheters had a 10% infection rate. The difference in the infection rate between the two methods was statistically significant (P < 0.015). Other variables examined, including the age and sex of the patients and the reasons for ventricular drainage, were not associated with an increased rate of infection. Most infections from either method were caused by a coagulase negative staphylococcus. The average duration of ventricular drainage before identification of positive cultures was 5.7 days for Rickham reservoirs and 6.0 days for ventriculostomies.     

浅析《野草》的版画特征

鲁迅先生一生热爱美术作品,对版画中木刻兴趣尤甚.<野草>作为其"写心之作",亦呈现出一些与木刻版画一致的审美特征:一是具有木刻版画的色彩特征,多对比、多冷色,有阴郁的美感;二是具有木刻版画的力度特征,环境描写、人物刻画处处刀锋毕现,遒劲有力,有一种"力之美".     

四辊破碎机车刀架的改造

针对四辊破碎机车刀架车削中存在的几个问题,详细介绍了电动车刀架的结构和工作原理,建立主要设计参数的数学表达式,并进行适当的分析。改造后,这种电动车刀架运行平稳、可靠、方便、省力,取得了预期的效果。     

焦炭热性能指标意义浅析

通过对焦炭在高炉内的历程及其变化规律的剖析,阐述焦炭热性能指标的意义,形象地把焦炭在高炉内的损耗分为三部分(M1,M2,M3)。指出M2对焦比及焦炭价格有一定的指导作用。     

Results of treatment of cancer of the cardia

Cancer of the cardia is traditionally discussed with cardiac cancer of the lower portion of the esophagus and upper gastric cancer invading the esophagus, and the specific characteristics of cancer of the cardia have never been clearly defined. We reviewed the outcome of 172 patients with adenocarcinoma of the cardia who had undergone radical surgery between 1949 and 1994 in the Division of Gastrointestinal Surgery of the Cancer Institute Hospital. The centers of the tumors were located within 2 cm above and below the boundary between the esophagus and the stomach, and their longitudinal diameter was less than 8 cm. We divided the patients into an early period (1949-1979; n = 79) and a late period (1980-1994; n = 93), and focused on the historical transition. There were no differences in patient gender or histology between the two periods. However, the late period was associated with fewer cases of esophageal invasion and shorter longitudinal diameter, as the age of the population advanced. The number of advanced cancers such as the localized and infiltrative type had decreased, and early cancer and early clinical stage had become more common, but despite the fact that the number of early cancers had increased, extended dissection, such as thoracic and paraaortic lymph node dissection, was performed more frequently. By clinical stage, the long-term outcome markedly improved in Stage I patient in the late period, and tended to improve in Stage II and III patients. This appears to have been attributable to the prevention of micrometastasis by extended dissection, although the number of early cancers is another major potential cause. There were no differences in the outcome of Stage IV patients between the two periods, and further advances in multimodality therapy must be awaited. The range of resection is basically proximal gastrectomy, and if there are adequate indications, the prognosis is favorable. In view of the status of lymphatic flow and lymph node metastasis, and long-term results, lateroaortic lymph node dissection is important. Since the number of early cancer patients has been increasing, if intraabdominal recurrence is prevented, intrathoracic lymph node dissection will contribute greatly to the outcome of such patients.     

Comparison of the results of surgical and conservative treatment of fractures of the diaphysis of the tibia

In this paper is treated the fundamental problematic of the fracture of the diaphysis of the tibia and the therapeutic results after the conservative and operative treatment are confronted. Among 518 patients with 433 open fractures and 35 with closed fractures of the diaphysis of the tibia, successful treatment of more 2/3 was obtained in the period from 1968 to 1972. Following our casuistics and literature, whose results are similar, we find out that the average total treatment of the osteosynthesis of the fracture of the diaphysis was shortened for 2,5 months depending upon the type and the localisation of the fracture. Apolied methods of the operative and conservative and conservative treatment in relation to the velocity of the medical cure as well as to the extreme anatomical-functional results are analised. We noticed that osteosynthesis, made by the intermedullary nail and the extension of the canals or by a small AO table, by the achieved stability makes conditions of immediate motions and an early rehabilitation. Because of that it gives the best functional results.