Evaluation of Antibacterial Activity of Whey Protein Isolate Coating Incorporated with Nisin,Grape Seed Extract,Malic Acid,and EDTA on a Turkey Frankfurter System

ABSTRACT: The effectiveness of whey protein isolate (WPI) coatings incorporated with grape seed extract (GSE), nisin (N), malic acid (MA), and ethylenediamine tetraacetic acid (EDTA) and their combinations to inhibit the growth of Listeria monocytogenes, E. coli O157:H7, and Salmonella typhimurium were evaluated in a turkey frankfurter system through surface inoculation (approximately 10⁶ CFU/g) of pathogens. The inoculated frankfurters were dipped into WPI film forming solutions both with and without the addition of antimicrobial agents (GSE, MA, or N and EDTA, or combinations). Samples were stored at 4 °C for 28 d. The L. monocytogenes population (5.5 log/g) decreased to 2.3 log/g after 28 d at 4 °C in the samples containing nisin (6000 IU/g) combined with GSE (0.5%) and MA (1.0%). The S. typhimurium population (6.0 log/g) was decreased to approximately 1 log cycles after 28 d at 4 °C in the samples coated with WPI containing a combination of N, MA, GSE, and EDTA. The E. coli O157:H7 population (6.15 log/g) was decreased by 4.6 log cycles after 28 d in samples containing WPI coating incorporated with N, MA, and EDTA. These findings demonstrated that the use of an edible film coating containing nisin, organic acids, and natural extracts is a promising means of controlling the growth and recontamination of L. monocytogenes, S. typhimurium, and E. coli O157:H7 in ready‐to‐eat poultry products.     

Inhibition of Listeria monocytogenes using nisin with grape seed extract on turkey frankfurters stored at 4 and 10 degrees C

Recontamination of cooked ready-to-eat (RTE) chicken and beef products with Listeria monocytogenes has been a major safety concern. Natural antimicrobials in combinations can be an alternative approach for controlling L. monocytogenes. Therefore, the objectives of this study were to evaluate the inhibitory activities against L. monocytogenes of nisin (6,400 IU/ ml), grape seed extract (GSE; 1%), and the combination of nisin and GSE both in tryptic soy broth with 0.6% yeast extract (TSBYE) and on the surface of full-fat turkey frankfurters. TSBYE was incubated at 37 degrees C for 72 h and turkey frankfurters at 4 or 10'C for 28 days. Inocula were 6.7 or 5 log CFU per ml or g for TSBYE or frankfurters, respectively. After 72 h in TSBYE, nisin alone did not show any inhibitory activity against L. monocytogenes. The combination of nisin and GSE gave the greatest inhibitory activity in both TSBYE and on turkey frankfurters with reductions of L. monocytogenes populations to undetectable levels after 15 h and 21 days, respectively. This combination of two natural antimicrobials has the potential to control the growth and recontamination of L. monocytogenes on RTE meat products.     

Effect of partial replacement of potassium lactate and sodium diacetate by natural green tea and grape seed extracts and postpackaging thermal treatment on the growth of Listeria monocytogenes in hotdog model system

Low‐ (5%) and high‐fat (20%) chicken and turkey hotdogs were formulated in three groups: no antimicrobials (control), chemical preservatives (potassium lactate and sodium diacetate) alone and partial replacement of chemical preservatives by green tea (GTE) and grape seed extracts (GSE), surface inoculated (c. 10³ CFU g^?1) with Listeria monocytogenes, treated with or without heat treatment (65 °C for 104 s) to determine the growth of L. monocytogenes until spoilage (28 days). Maximum growth inhibitions (c. 2.0 CFU g^?1) were observed in the treatments having chemical preservatives and plant extracts regardless of the meat and fat type. Furthermore, plant extracts along with chemical preservatives demonstrated additional inhibitory effect on the growth of L. monocytogenes survivors in chicken hotdog samples followed by postpackaging heat treatment. Results demonstrated that natural GTE and GSE can partially replace the chemical preservatives and further enhance the antilisterial activities when combined with heat treatment.     

Transmission electron microscopy study of Listeria monocytogenes treated with nisin in combination with either grape seed or green tea extract

The objective of this study was to use transmission electron microscopy to investigate the morphological changes that occurred in Listeria monocytogenes cells treated with grape seed extract (GSE), green tea extract (GTE), nisin, and combinations of nisin with either GSE or GTE. The test solutions were prepared with (i) 1% GSE, 1% GTE, 6,400 IU of nisin, and the combination of these dilutions with nisin or with (ii) the pure major phenolic constituents of GSE (0.02% epicatechin plus 0.02% catechin) or GTE (0.02% epicatechin plus 0.02% caffeic acid) and their combinations with 6,400 IU of nisin in tryptic soy broth with 0.6% yeast extract (TSBYE). Test solutions were inoculated with L. monocytogenes at approximately 10(6) CFU/ml and incubated for 3 or 24 h at 37 degrees C. After 3 h of incubation, cells were harvested and evaluated under a transmission electron microscope (JEOL-100 CX) operating at 80 kV (50,000X). Microscopic examination revealed an altered cell membrane and condensed cytoplasm when L. monocytogenes cells were exposed to a combination of nisin with either GSE or GTE or to pure compounds of the major phenolic constituents in combination. After 24 h of incubation at 37 degrees C, the combinations of nisin with GSE and nisin with GTE reduced the L. monocytogenes population to undetectable levels and 3.7 log CFU/ml, respectively. These observations indicate that the combination of nisin with either GSE or GTE had a synergistic effect, and the combinations of nisin with the major phenolic constituents were most likely associated with the L. monocytogenes cell damage during inactivation in TSBYE at 37 degrees C.     

Antimicrobial Effects of Essential Oils,Nisin, and Irradiation Treatments against Listeria monocytogenes on Ready‐to‐Eat Carrots

The study aimed at using essential oil (EO) alone or combined EO with nisin and low dose γ‐irradiation to evaluate their antibacterial effect against Listeria monocytogenes during storage of carrots at 4 °C. Minicarrots were inoculated with L. monocytogenes at a final concentration of approximately 7 log CFU/g. Inoculated samples were coated by nisin at final concentration of 10³ International Unit (IU)/mL or individual mountain savory EO or carvacrol at final concentration of 0.35%, w/w) or nisin plus EO. The samples were then irradiated at 0, 0.5, and 1.0 kGy. The treated samples were kept at 4 °C and microbial analysis of samples were conducted at days 1, 3, 6, and 9. The results showed that coating carrots by carvacrol plus nisin or mountain savory plus nisin and then irradiating coated carrots at 1 kGy could reduce L. monocytogenes by more than 3 log at day 1 and reduced it to undetectable level from day 6. Thus, the combined treatments using nisin plus carvacrol or nisin plus mountain savory and irradiation at 1.0 kGy could be used as an effective method for controlling L. monocytogenes in minicarrots.     

Inactivation of Listeria monocytogenes in Skim Milk and Liquid Egg White by Antimicrobial Bottle Coating with Polylactic Acid and Nisin

ABSTRACT: This study was to develop an antimicrobial bottle coating method to reduce the risk of outbreaks of human listeriosis caused by contaminated liquid foods. Liquid egg white and skim milk were inoculated with Listeria monocytogenes Scott A and stored in glass jars that were coated with a mixture of polylactic acid (PLA) polymer and nisin. The efficacy of PLA per nisin coating in inactivating L. monocytogenes was investigated at 10 and 4 °C. The pathogen grew well in skim milk without PLA/nisin coating treatments, reaching 8 log CFU/mL after 10 d and then remained constant up to 42 d at 10 °C. The growth of Listeria at 4 °C was slower than that at 10 °C, taking 21 d to obtain 8 log CFU/mL. At both storage temperatures, the PLA coating with 250 mg nisin completely inactivated the cells of L. monocytogenes after 3 d and throughout the 42-d storage period. In liquid egg white, Listeria cells in control and PLA coating without nisin samples declined 1 log CFU/mL during the first 6 d at 10 °C and during 28 d at 4 °C, and then increased to 8 or 5.5 log CFU/mL. The treatment of PLA coating with 250 mg nisin rapidly reduced the cell numbers of Listeria in liquid egg white to undetectable levels after 1 d, then remained undetectable throughout the 48 d storage period at 10 °C and the 70 d storage period at 4 °C. These data suggested that the PLA/nisin coating treatments effectively inactivated the cells of L. monocytogenes in liquid egg white and skim milk samples at both 10 and 4 °C. This study demonstrated the commercial potential of applying the antimicrobial bottle coating method to milk, liquid eggs, and possibly other fluid products.     

Evaluation of Changes in Listeria monocytogenes Populations on Frankfurters at Different Stages from Manufacturing to Consumption

ABSTRACT: This study evaluated the fate of inoculated Listeria monocytogenes on frankfurters stored under conditions simulating those that may be encountered between manufacturing and consumption. Frankfurters with or without 1.5% potassium lactate and 0.1% sodium diacetate (PL/SD) were inoculated (1.8 ± 0.1 log CFU/cm²) with a 10‐strain composite of L. monocytogenes, vacuum‐packaged, and stored under conditions simulating predistribution storage (24 h, 4 °C), temperature abuse during transportation (7 h, 7 °C followed by 7 h, 12 °C), and storage before purchase (60 d, 4 °C; SBP). At 0, 20, 40, and 60 d of SBP, samples were exposed to conditions simulating delivery from stores to homes or food establishments (3 h, 23 °C), and then opened or held vacuum‐packaged at 4 or 7 °C for 14 d (SHF). Pathogen counts remained relatively constant on frankfurters with PL/SD regardless of product age and storage conditions; however, they increased on product without antimicrobials. In vacuum‐packaged samples, during SHF at 4 °C, the pathogen grew faster (P < 0.05) on older product (20 d of SBP) compared to product that was fresh (0 d of SBP); a similar trend was observed in opened packages. At 7 °C, the fastest growth (0.35 ± 0.02 log CFU/cm²/d) was observed on fresh product in opened packages; in vacuum‐packages, growth rates on fresh and aged products were similar. By day 40 of SBP the pathogen reached high numbers and increased slowly or remained unchanged during SHF. This information may be valuable in L. monocytogenes risk assessments and in development of guidelines for storage of frankfurters between package opening and product consumption.     

Effect of Salts of Organic Acids on Listeria monocytogenes,Shelf Life,Meat Quality,and Consumer Acceptability of Beef Frankfurters

The objective of this study was to evaluate anti‐listerial efficacy of salts of organic acids, and their impact on the quality of frankfurters. Beef frankfurters were manufactured by incorporating organic acids in 5 different combinations: (1) control (no marinade addition; C); (2) sodium lactate (2% wt/wt; SL); (3) potassium lactate (2% wt/wt; PL); (4) sodium citrate (0.75% wt/wt; SC); and (5) sodium lactate (2% wt/wt)/sodium diacetate (0.25% wt/wt; SL/SD). Cooked frankfurters were inoculated with streptomycin‐resistant (1500 μg/mL) L. monocytogenes (7 log₁₀ CFU/frank). Inoculated and noninoculated frankfurters were vacuum packaged and stored at 4 °C. Samples were taken weekly up to 10 wk for estimation of L. monocytogenes as well as aerobic plate count (APC) and psychrotrophs (PSY), respectively. Total of 2 independent trials of the entire experiment were conducted. Noninoculated beef frankfurters were evaluated weekly by untrained sensory panelists for 7 wk. SL, PL, and SC treatments did not (P > 0.05) adversely affect consumer acceptability through 8 wk although, SL/SD treatment was significantly (P ≤ 0.05) less preferred across all sensory attributes. SL/SD treatment negatively affected product quality, but was able to control APC, PSY, and L. monocytogenes levels. SC performed similar to the control throughout the 8, 9, and 10 wk storage periods, providing no benefit for inhibiting L. monocytogenes (increasing from 7 logs CFU/frank to 10 logs CFU/frank throughout storage) or extending shelf life of the beef frankfurters. In conclusion, 2% SL and PL, and 2% SL/0.25% SD may be effective L. monocytogenes inhibitors (maintaining inoculation levels of 7 logs CFU/frank during storage), but changes in SL/SD treatment formulation should be studied to improve product quality.     

Inhibition of Listeria monocytogenes and Salmonella by Combinations of Oriental Mustard,Malic Acid,and EDTA

The antimicrobial activities of oriental mustard extract alone or combined with malic acid and EDTA were investigated against Salmonella spp. or Listeria monocytogenes at different temperatures. Five strain Salmonella or L. monocytogenes cocktails were separately inoculated in Brain Heart Infusion broth containing 0.5% (w/v) aqueous oriental mustard extract and incubated at 4 °C to 21 °C for 21 d. For inhibitor combination tests, Salmonella Typhimurium 02:8423 and L. monocytogenes 2–243 were individually inoculated in Mueller Hinton broth containing the mustard extract with either or both 0.2% (w/v) malic acid and 0.2% (w/v) EDTA and incubated at 10 °C or 21 °C for 10 to 14 d. Mustard extract inhibited growth of the L. monocytogenes cocktail at 4 °C up to 21 d (2.3 log₁₀ CFU/mL inhibition) or at 10 °C for 7 d (2.4 log₁₀ CFU/mL inhibition). Salmonella spp. viability was slightly, but significantly reduced by mustard extract at 4 °C by 21 d. Although hydrolysis of sinigrin in mustard extract by both pathogens was 2 to 6 times higher at 21 °C than at 4 °C to 10 °C, mustard was not inhibitory at 21 °C, perhaps because of the instability of its hydrolysis product (allyl isothiocyanate). At 21 °C, additive inhibitory effects of mustard extract with EDTA or malic acid led to undetectable levels of S. Typhimurium and L. monocytogenes by 7 d and 10 d, respectively. At 10 °C, S. Typhimurium was similarly susceptible, but combinations of antimicrobials were not more inhibitory to L. monocytogenes than the individual agents.     

Reduction of Listeria monocytogenes in cold‐smoked salmon by bacteriophage P100, nisin and lauric arginate,singly or in combinations

Three GRAS antimicrobials including, lauric arginate (LAE), bacteriophage P100 (phage P100) and bacteriocin nisin, were evaluated either singly or in combinations for the reduction of initial load of Listeria monocytogenes in cold‐smoked salmon (CSS). The stability of phage P100 in the presence of LAE (200 ppm) and nisin (500 ppm) or at 10× and 100× of these concentrations was determined at 4 °C or 30 °C for 24 h in a broth model. Phage P100 was found to be highly stable in the presence of these antimicrobial agents as plaque‐forming units (PFU) did not vary between control and antimicrobial‐treated phage. The survival of L. monocytogenes in the presence of phage P100, nisin and LAE showed remarkable reduction within 24 h both at 4 °C or 30 °C in broth. Treatment of CSS containing 3.5 log CFU cm^?2 L. monocytogenes with phage P100 (10⁸ PFU mL^?1), nisin (500 ppm) and LAE (200 ppm) showed strong listericidal action and reduced the L. monocytogenes by 2–3 log CFU cm^?2 after 24 h. Among the combined treatments, phage P100 + LAE or nisin + LAE exhibited the most listericidal action in which L. monocytogenes cells were reduced to undetectable level within 24 h in CSS.     

Application of enterocins A and B, sakacin K and nisin to extend the safe shelf-life of pressurized ready-to-eat meat products

The efficiency of food preservation systems is determined by the technologies that are combined, the intrinsic properties of the food products and the target microorganisms. In the present study, the bacteriocins nisin, enterocins A and B and sakacin K were applied to cooked and dry cured ham spiked with Listeria monocytogenes, Salmonella enterica and Staphylococcus aureus and submitted to a high pressure treatment of 600 MPa. Before pressurization nisin produced significant reductions to the counts of L. monocytogenes and S. aureus, especially in dry cured ham. After the pressurization, Salmonella and L. monocytogenes were not detected in 25 g of both cooked and dry cured ham and remained at this level during the entire storage (57 days at 4 °C + 63 days at 15 °C). S. aureus levels, in contrast, only decreased below the detection limit (1 log CFU/g) in the nisin batches. Afterward, when storage was performed at an abusive temperature, the ability of S. aureus to grow was dependant on the bacteriocin applied and the kind of meat product. Thus, at the end of storage, while S. aureus counts were <1 log CFU/g in all dry cured ham batches, only nisin could inhibit its growth in cooked ham.     

Thermal Destruction of Listeria monocytogenes in a Meat Slurry and in Ground Beef

Thermal destruction of Listeria monocytogenes cells was determined in phosphate buffer, a meat slurry (20% ground beef/80% water) and in ground beef. D-values at 60°C, 65°C and 70°C in phosphate buffer, and in the meat slurry were 0.63, 0.29 and 0.15, and 2.54, 0.75 and 0.23 min, respectively. Heating of ground beef (80% lean) in a 75°C water bath to 50°C, 60°C or 65°C required 6.2, 8.4 and 10.6 min, respectively, and resulted in 0.2-0.9, 1.6-3.4 and 4.4-6.1 log reductions in L. monocytogenes cells, from the initial inoculation level of 8.08 log CFU/g. Viable cells were also detected after cold (21 days) or selective enrichment (24 hr) in eight out of nine samples of ground beef inoculated with 7.84-8.08 log CFU/g and cooked to 70°C.     

Inhibition of Listeria monocytogenes by food antimicrobials applied singly and in combination

Abstract: Combining food antimicrobials can enhance inhibition of Listeria monocytogenes in ready-to-eat (RTE) meats. A broth dilution assay was used to compare the inhibition of L. monocytogenes resulting from exposure to nisin, acidic calcium sulfate, ɛ-poly-L-lysine, and lauric arginate ester applied singly and in combination. Minimum inhibitory concentrations (MICs) were the lowest concentrations of single antimicrobials producing inhibition following 24 h incubation at 35 °C. Minimum bactericidal concentrations (MBCs) were the lowest concentrations that decreased populations by ≥3.0 log₁₀ CFU/mL. Combinations of nisin with acidic calcium sulfate, nisin with lauric arginate ester, and ɛ-poly-L-lysine with acidic calcium sulfate were prepared using a checkerboard assay to determine optimal inhibitory combinations (OICs). Fractional inhibitory concentrations (FICs) were calculated from OICs and were used to create FIC indices (FIC_Is) and isobolograms to classify combinations as synergistic (FIC_I < 1.00), additive/indifferent (FIC_I= 1.00), or antagonistic (FIC_I > 1.00). MIC values for nisin ranged from 3.13 to 6.25 μg/g with MBC values at 6.25 μg/g for all strains except for Natl. Animal Disease Center (NADC) 2045. MIC values for ɛ-poly-L-lysine ranged from 6.25 to 12.50 μg/g with MBCs from 12.50 to 25.00 μg/g. Lauric arginate ester at 12.50 μg/g was the MIC and MBC for all strains; 12.50 mL/L was the MIC and MBC for acidic calcium sulfate. Combining nisin with acidic calcium sulfate synergistically inhibited L. monocytogenes; nisin with lauric arginate ester produced additive-type inhibition, while ɛ-poly-L-lysine with acidic calcium sulfate produced antagonistic-type inhibition. Applying nisin along with acidic calcium sulfate should be further investigated for efficacy on RTE meat surfaces. Practical Application: This study demonstrates the potential for combinations of antimicrobials to result in greater pathogen inhibition as compared to the application of a single antimicrobial. The data presented in this study can aid the food industry in developing more efficient and effective application of antimicrobials. These findings should also prompt further studies validating the inhibitory effect of combinations of antimicrobials on ready-to-eat surfaces.     

Growth or Survival of Listeria monocytogenes in Ready-to-Eat Meat Products and Combination Deli Salads During Refrigerated Storage

Growth or survival of Listeria monocytogenes in cold‐smoked salmon; sliced, cooked ham; sliced, roasted turkey; shrimp salad; and coleslaw obtained at retail supermarkets stored at 5 °C, 7 °C, or 10 °C (41 °F, 45 °F, or 50 °F, respectively) for up to 14 d was evaluated. Cold‐smoked salmon, ham, and turkey were obtained in case‐ready, vacuum packages. All food products were stored aerobically to reflect additional handling within the retail supermarket. Cold‐smoked salmon, ham, and turkey supported the growth of L. monocytogenes at all 3 storage temperatures. Fitted growth curves of initial populations (about 3 log₁₀ colony‐forming units [CFU]/g) in cold‐smoked salmon, ham, and turkey stored at 5 °C achieved maximal growth rates of 0.29, 0.45, and 0.42 log₁₀ CFU/g growth per day, respectively. Storage at 10 °C increased the estimated maximal growth rate of the pathogen by 0.56 to 1.08 log₁₀ CFU/ g growth per day compared with storage at 5 °C. A decline in populations of L. monocytogenes was observed in shrimp salad and coleslaw, and the rate of decline was influenced by storage temperature. Retention of viability was higher in shrimp salad than in coleslaw, where populations fell 1.2, 1.8, and 2.5 log₁₀ CFU/g at 5 °C, 7 °C, and 10 °C, respectively, after 14 d of storage. Inability of shrimp salad and coleslaw to support the growth of L. monocytogenes may be attributed to the acidic pH (4.8 and 4.5, respectively) of the formulations used in this study. Results show that the behavior of L. monocytogenes in potentially hazardous ready‐to‐eat foods is dependent upon the composition of individual food products as well as storage temperature.     

Effect of Hops Beta Acids on the Survival of Unstressed‐ or Acid‐Stress‐Adapted‐Listeria Monocytogenes and on the Quality and Sensory Attributes of Commercially Cured Ham Slices

This study evaluated the antilisterial activity of hops beta acids (HBA) and their impact on the quality and sensory attributes of ham. Commercially cured ham slices were inoculated with unstressed‐ and acid‐stress‐adapted (ASA)‐L. monocytogenes (2.2 to 2.5 log CFU/cm²), followed by no dipping (control), dipping in deionized (DI) water, or dipping in a 0.11% HBA solution. This was followed by vacuum or aerobic packaging and storage (7.2 °C, 35 or 20 d). Samples were taken periodically during storage to check for pH changes and analyze the microbial populations. Color measurements were obtained by dipping noninoculated ham slices in a 0.11% HBA solution, followed by vacuum packaging and storage (4.0 °C, 42 d). Sensory evaluations were performed on ham slices treated with 0.05% to 0.23% HBA solutions, followed by vacuum packaging and storage (4.0 °C, 30 d). HBA caused immediate reductions of 1.2 to 1.5 log CFU/cm² (P < 0.05) in unstressed‐ and ASA‐L. monocytogenes populations on ham slices. During storage, the unstressed‐L. monocytogenes populations on HBA‐treated samples were 0.5 to 2.0 log CFU/cm² lower (P < 0.05) than control samples and those dipped in DI water. The lag‐phase of the unstressed‐L. monocytogenes population was extended from 3.396 to 7.125 d (control) to 7.194 to 10.920 d in the HBA‐treated samples. However, the ASA‐L. monocytogenes population showed resistance to HBA because they had a higher growth rate than control samples and had similar growth variables to DI water‐treated samples during storage. Dipping in HBA solution did not adversely affect the color or sensory attributes of the ham slices stored in vacuum packages. These results are useful for helping ready‐to‐eat meat processors develop operational procedures for applying HBA on ham slices.     

Effect of rapeseed protein–gelatin film containing grapefruit seed extract on ‘Maehyang’ strawberry quality

To develop a packaging film for ‘Maehyang’ strawberries, an edible film containing antimicrobial grapefruit seed extract (GSE) was manufactured. Addition of GSE to the rapeseed protein–gelatin (RG) film inhibited the growth of pathogenic bacteria such as Escherichia coli O157:H7 and Listeria monocytogenes. Packaging of ‘Maehyang’ strawberries with the RG film containing 1.0% GSE decreased the populations of total aerobic bacteria and of yeast and moulds in the strawberries by 1.03 and 1.34 log CFU g^?1, respectively, after 14 days of storage, compared to that of the control. Sensory evaluation of the GSE‐RG film‐packaged strawberries produced better sensory scores than did the control. These results suggest that RG film containing GSE can be used to package strawberries and to extend shelf life.     

Effect of Salt Reduction on Growth of Listeria monocytogenes in Meat and Poultry Systems

Abstract: Reducing sodium in food could have an effect on food safety. The objective was to determine differences in growth of Listeria monocytogenes in meat and poultry systems with salt substitutes. For phase 1, fresh ground beef, pork, and turkey with NaCl, KCl, CaCl₂, MgCl₂, sea salt, or replacement salt added at 2.0% were inoculated with L. monocytogenes to determine growth/survival during 5 d at 4 °C to simulate a pre‐blend process. L. monocytogenes populations significantly decreased (0.41 log CFU/g) during the storage time in beef, but no differences (P > 0.05) were observed over time in pork or turkey. Salt type did not affect (P > 0.05) L. monocytogenes populations during pre‐blend storage. MgCl₂ and NaCl allowed significant growth of aerobic populations during storage. For phase 2, emulsified beef and pork products were processed with 2% NaCl, KCl, sea salt, or a NaCl/KCl blend and post‐process surface‐inoculated with L. monocytogenes to determine growth/survival at 4 °C for 28 d. Pork products showed significantly greater L. monocytogenes population growth at all sampling times (0, 7, 14, 21, and 28 d) than beef products, but salt type had no effect on L. monocytogenes populations with sampling times pooled for data analysis. Although salt types had no impact on L. monocytogenes populations in preblend and emulsified meat products, pork and turkey preblends and emulsified pork had greater L. monocytogenes populations compared with beef products. These studies demonstrate that sodium may not affect the safety of preblends and emulsified meat and poultry products. Practical Application: odium reduction in food is an important topic because of sodium's unfavorable health effects. This research shows that reducing sodium in pre‐blends and emulsified meat and poultry products would have no effect on Listeria monocytogenes populations, but replacement of NaCl with MgCl₂ may affect growth of aerobic populations.     

Antibacterial Effect of Grapefruit Seed Extract (GSE) on Makgeolli‐Brewing Microorganisms and Its Application in the Preservation of Fresh Makgeolli

To develop a new preservation method, the antimicrobial activity of grapefruit seed extract (GSE) against Makgeolli‐brewing microorganisms and food‐borne pathogens was assessed, and a general analysis and sensory evaluation of fresh Makgeolli with added GSE was made. The minimum inhibitory concentration (MIC) values of GSE against 10 strains of Makgeolli‐brewing microorganism were 0.0122 to 1.5625 μL/mL. The MIC values against 6 strains of food‐borne pathogens were 0.0061 to 0.7813 μL/mL. On addition of 0.1% (v/v) and 0.2% GSE in bottled fresh Makgeolli, no significant difference in the pH, or the contents of total acids, ethanol, or methanol in the Makgeolli, were observed compared with control Makgeolli (with no GSE), during the preservation period (8 weeks) at 10 °C. In the Makgeolli with 0.1% and 0.2% GSE, the total bacterial counts decreased significantly by 4.9% (P < 0.01) and 11.2% (P < 0.001), respectively, versus the control. The decreases in yeast count were significantly lessened by 15.33% and 15.24% (both P < 0.001), respectively, after 8 weeks of storage, compared with the control. In the sensory evaluation of Makgeolli with 0.1% and 0.2% GSE, the refreshment and overall acceptability received significantly better scores than the control (P < 0.01), with no change in sweetness, bitterness, sourness, turbidity, color, or odor. These results suggest that GSE controls the growth of Makgeolli‐brewing microorganisms and extends the shelf life (ca. 2 wk), without decreasing overall acceptance.     

Retardation of Listeria Monocytogenes Growth in Mozzarella Cheese Using Antimicrobial Sachets Containing Rosemary Oil and Thyme Oil

An antimicrobial sachet containing microcellular foam starch (MFS) with embedded rosemary oil and thyme oil was developed to reduce bacterial growth in shredded mozzarella cheese. The efficacy of the volatiles of oils at various concentrations in reducing Listeria monocytogenes as well as the release of the oils from the MFS have been also determined in this study. The cheese, inoculated with a cocktail of 5 strains of L. monocytogenes (approximately 3 log CFU/g), was packaged in a Nylon/EVOH/PE bag. A paper sachet containing MFS embedded with rosemary oil and thyme oil, separately or together, was inserted into the bag. Rosemary and thyme oil volatiles released from the sachet restricted the growth of L. monocytogenes, resulting in a 2.5 log CFU/g reduction on day 9 at 10 °C. The volatile oils also showed inhibitory effects on the growth of lactic acid bacteria (LAB) and total aerobic bacteria (TAB). After 15 d at 10 °C, the numbers of LAB and TAB in the samples containing the sachet with both oils experienced a 1.2 and 1.4 log CFU/g reduction, respectively, compared to untreated samples. Nonetheless, the sachet treatment produced a distinct odor, unfavorably received by the panelists. The results suggest the potential for application of the sachet system for the reduction of growth of L. monocytogenes, LAB, and TAB in food products.     

Effectiveness of Zataria multiflora Boiss essential oil and grape seed extract impregnated chitosan film on ready-to-eat mortadella-type sausages during refrigerated storage

BACKGROUND: The effectiveness of chitosan films containing Zataria multiflora Boiss essential oil (ZEO) (5 and 10 g kg^?1) and grape seed extract (GSE) (10 g kg^?1) on lipid oxidation and microbial (lactic acid bacteria, aerobic mesophiles and inoculated Listeria monocytogenes) characteristics of mortadella sausage at 4 °C for 21 days was evaluated. The release of total phenolics (TPs) into sausage was also assessed. RESULTS: All films exhibited antibacterial activity against L. monocytogenes on agar culture media. Chitosan films containing ZEO were the most effective on the growth of bacteria. The growth of L. monocytogenes was significantly inhibited by ZEO‐GSE containing films especially during storage of the sausages for 6 days. Aerobic mesophiles and lactic acid bacteria were the most sensitive and resistant groups to films by 0.1–1.1 and 0.1–0.7 log cycles reduction, respectively. Sausages wrapped by 10 g kg^?1 GSE + 10 g kg^?1 ZEO films had the lowest degrees of lipid oxidation, which was 23% lower than the control. The TPs of ZEO films decreased to zero after 6 days, whereas TPs of GSE films followed a slight decrease during the storage. CONCLUSION: Antimicrobial/antioxidant chitosan film could be developed by incorporating GSE and ZEO for extending the shelf life of mortadella sausage. Copyright © 2011 Society of Chemical Industry