Acidified Sodium Chlorite as an Alternative to Chlorine for Elimination of Salmonella on Alfalfa Seeds

ABSTRACT:  The health and environmental hazard associated with the use of chlorine for food processing has been documented previously. This study was conducted to determine if acidified sodium chlorite (ASC) could be used to replace calcium hypochlorite (Ca[OCl]₂) for disinfection of alfalfa seeds. Contaminated seeds containing approximately 1.5 × 10⁷ CFU/g of Salmonella were treated with ASC or Ca(OCl)₂ at different concentrations and for different periods of time. Results showed that the efficacy of ASC and Ca(OCl)₂ for elimination of Salmonella on contaminated seeds could be improved greatly by extending the treatment time from the traditional 15 to 45 min. Treatment of seeds with 800 ppm of ASC for 45 min reduced the number of Salmonella by 3.9 log units, approximately 1.2 log units higher than that treated with 20000 ppm of Ca(OCl)₂. Treatment of seeds with a lower concentration (100 to 400 ppm) of ASC for 45 min reduced the number of Salmonella by 1.3 to 2.2 log units. Soaking alfalfa seeds in 800 ppm of ASC for 45 min did not affect seed germination. However, soaking seeds in 20000 ppm of Ca(OCl)₂ for 45 min reduced seed germination by 20%. Unlike Ca(OCl)₂, antimicrobial efficiency of ASC was not affected by pre-exposure to alfalfa seeds. Data presented also showed that Salmonella on newly inoculated seeds that had been stored at 4 °C for less than 7 d were more sensitive to sanitizer treatment than those on seeds that had been stored for 4 wk or longer.     

Decontamination Efficacy of Combined Chlorine Dioxide with Ultrasonication on Apples and Lettuce

ABSTRACT:  The bacterial reduction of Salmonella and Escherichia coli O157:H7-inoculated apples and lettuce by ClO₂ at 0, 5, 10, 20, and 40 ppm with and without 170-kHz ultrasonic treatments for 3, 6, and 10 min, respectively, have been studied. The treatments of ClO₂ at 20 and 40 ppm for 3, 6, and 10 min or at 5 and 10 ppm for 6 and 10 min with 170-kHz ultrasonication caused 3.115 to 4.253 log reductions in Salmonella and 2.235 to 3.865 log reduction in E. coli O157:H7 on inoculated apples. Using combined ClO₂ and ultrasonication to treat 4.48 × 10⁴ CFU/g Salmonella and 1.07 × 10⁵ CFU/g E. coli O157:H7-inoculated lettuce, the bacterial reductions were 2.257 to 2.972 and 1.357 to 2.264 log, respectively. The residual ClO₂ decreased with increasing treatment times, over 80% of ClO₂ was detected after the 3-min treatment, and more than 70% remained after the 10-min treatment time. No bacteria were recovered from the posttreatment solutions of ClO₂ or ClO₂ combined with ultrasonication. The temperature of the ClO₂ treatment was 20.1 °C, and it increased to 40.1, 44.9, and 50.3 °C, with 170-kHz ultrasonic treatments for 3, 6, and 10 min, respectively, on apples.     

INFLUENCE OF WASHING TREATMENT ON NATIVE MICROFLORA AND ESCHERICHIA COLI POPULATION OF INOCULATED CANTALOUPES

The influence of chlorine or hydrogen peroxide treatment on populations of Escherichia coli 25922 on the external surface of inoculated cantaloupe was investigated. Surface treatment with 70% EtOH, followed by immersion in 10⁸ CFU/mL E. coli inoculum deposited an average of 4.4 log₁₀CFU/cm² cell population on the cantaloupe surface. The efficncy of washing inoculated cantaloupe was dependent on storage interval between inoculation and treatment. Dipping the cantaloupes in solutions containing 1000 mg/L chlorine or 5% peroxide for 5 min, within 24 h of inoculation, caused a 2 log₁₀ CFU/cm² reduction of the indigenous surface microflora and a 3–4.0 log₁₀ CFU/cm² reduction in E. coli. The efficacy was less when the interval between inoculation and treatment exceeded 24 h. Chlorine appeared in be a better antimicrobial agent than hydrogen peroxide against F. coli ATCC 25922 inoculated on cantaloupe surfaces while hydrogen peroxide was better in reducing surface microflora of cantaloupe.     

EFFECT OF MARINADE AND DRYING TEMPERATURE ON INACTIVATION OF ESCHERICHIA COLI O157:H7 ON INOCULATED HOME DRIED BEEF JERKY

Beef slices were inoculated (5.7–7.5 log CFU/cm²) with a 4-strain composite of E. coli O157:H7, stored (4C, 24 h), marinated (4C, 24 h), dried for 10 h at 62.5C or 68.3C, and stored for 90 days at 21C. Unmarinated beef slices dried for 10 h at 62.5C were used to determine the relative contribution of the marinate versus temperature treatment in the 62.5C trials. Samples were analyzed (bacterial enumeration with selective and nonselective agar media, pH, and a_w) following inoculation, marinating, at 4, 6, 8 and 10 h of drying, and after 30, 60 and 90 days of storage. Marination resulted in slight changes in bacterial populations (−0.3 to + 0.6 log CFU/cm²), but did not enhance bacterial reduction during drying. For all treatments, most bacterial reductions occurred in the first 4 h of drying, with little reduction thereafter. After 10 h of drying, bacterial reductions were 3.2–3.4 log CFU/cm² for unmarinated beef slices dried at 62.5C. Reductions of 2.2 and 3.0–4.6 log CFU/cm² were achieved in marinated jerky slices dried at 62.5C and 68.3C, respectively. No treatment resulted in the recommended 5-log reduction at the end of 10 h drying. However, bacteria did become undetectable by direct plating (<10 CFU/cm²) following 30 days of storage in all treatments except the unmarinated beef slices plated on tryptic soy agar (TSA). Additional work is needed to develop procedures for adequate destruction of E. coli O157:H7 during drying of beef jerky.     

Irradiation compared with chlorination for elimination of Escherichia coli O157:H7 internalized in lettuce leaves: influence of lettuce variety

ABSTRACT:  Pathogenic bacteria internalized in leaf tissues are not effectively removed by surface treatments. Irradiation has been shown to inactivate leaf-internalized bacteria, but many aspects of targeting these protected pathogens remain unknown. Bacterial cells of a cocktail mixture of 3 isolates of Escherichia coli O157:H7 were drawn into the leaves of iceberg, Boston, green leaf, and red leaf lettuce using vacuum perfusion. The inoculated leaves were treated with a 3-min wash with sodium hypochlorite solution (0, 300, or 600 ppm) or various doses of ionizing radiation (0.25 to 1.5 kGy). Leaves were stomached to recover the internalized cells and survivors enumerated. Washes with 0 ppm (water), 300 ppm, and 600 ppm chlorine solutions each gave reductions of less than 1 log. These reductions were statistically significant only in the case of green leaf lettuce. In contrast, irradiation effectively reduced E. coli O157:H7 on all varieties examined, with all doses tested being significantly reduced from the untreated control. The specific variety influenced the efficacy of irradiation. The greatest reduction obtained was 5 logs on iceberg lettuce treated with 1.5 kGy. The D ₁₀ values (the dose necessary to achieve a 1 log reduction) were significantly ( P < 0.05) different among the varieties of lettuce tested, and ranged from 0.30 kGy (iceberg) to 0.45 kGy (Boston). These values were observed to be notably higher than previous irradiation D ₁₀ values for E. coli O157:H7 surface inoculated onto these 4 lettuce varieties. This study has shown that irradiation is able to effectively reduce viable E. coli O157:H7 cells internalized in lettuce, and that the variety of lettuce influences the specific response.     

INCIDENCE AND GERMICIDE SENSITIVITY OF SALMONELLA TYPHI AND VIBRIO CHOLERAE O1 IN ALFALFA SPROUTS

The prevalence of some enteric bacteria in alfalfa sprouts obtained from public markets and supermarkets in Queretaro City was determined. In addition, the antimicrobial effect of several commercial germicides was tested on alfalfa sprouts for reduction of native coliforms and inoculated Vibrio cholerae Ol or Salmonella typhi. Escherichia coli and Salmonella sp. were detected in 74% and 1.1% of 90 of samples, respectively, and no sample tested positive to V. cholerae Ol. Coliforms ranged from 7.3 to 8.5 log₁₀ CFU/g. Treatment of alfalfa sprouts with 200 mg/L of hypochlorite, of a commercial iodophor, or of chlorine dioxide, or with 100 mg/L of Citricidal® for 5 min, reduced native coliforms only by 1–2 log₁₀ CFU/g. Reductions of S. typhi and V. cholerae O1 with 200 mg/L of sodium hypochlorite and 100 mg/L Citricidal® were also no more than J.5 log₁₀ CFU/g. Sprouts from seeds contaminated with V. cholerae O1 that were irrigated daily with water containing 100 mg/L chlorine dioxide, showed significantly lower V. cholerae Ol counts than seeds irrigated with tap water (p<0.05). However , V. cholerae O1 persisted after 8 days of sprouting, when the sprouts are ready for marketing. Treatment of seeds and sprouts with antimicrobials does not appear to be effective for reducing pathogens to safe levels.     

Efficacy of novel organic acid and hypochlorite treatments for eliminating Escherichia coli O157:H7 from alfalfa seeds prior to sprouting

This study investigated novel two-step organic acid/hypochlorite treatments as alternatives to 20000 ppm active chlorine (from calcium hypochlorite) for eliminating Escherichia coli O157:H7 from alfalfa seeds prior to sprouting. Commercially available alfalfa seeds were inoculated with a five-strain E. coli O157:H7 mixture and dried to attain ca. 10(6) CFU/g of seeds. Seeds then underwent one of several soak treatments including: (1) 5% (v/v) lactic acid for 10 min at 42 degrees C; (2) 5% acetic acid (v/v) for 10 min at 42 degrees C; (3) 2.5% lactic acid for 10 min at 42 degrees C followed by 2000 ppm active chlorine (from calcium hypochlorite) for 15 min at 25 degrees C; (4) 5% lactic acid for 10 min at 42 degrees C followed by 2000 ppm active chlorine for 15 min at 25 degrees C; or (5) 20000 ppm active chlorine for 15 min at 25 degrees C. Each treatment reduced numbers of inoculum cells by about 6.0 log10 CFU/g as determined by plating on Sorbitol MacConkey agar (SMac). Plating on non-selective brain heart infusion agar (BHI) showed that treatments 1-4 reduced counts by 2.3-4.1 log10 CFU/g, thus indicating a large proportion of injured cells. Successive lactic acid and hypochlorite treatments (3 and 4) were more lethal than either organic acid alone (1 and 2). No surviving cells were detected on SMac or BHI following treatment with 20000 ppm active chlorine (treatment 5). Regardless of the previous treatment, E. coli O157:H7 counts increased to 10(7)-10(8) CFU/g during sprouting. Germination of seeds was not adversely affected by any of the treatments (germination > 90%). Results of this study show that: (a) non-lethal cell injury must be considered when evaluating intervention treatments against E. coli O157:H7 on alfalfa seeds; (b) reductions of 2-4 log10 CFU/g can be attained without using 20000 ppm active chlorine; (c) successive lactic acid and hypochlorite treatments have greater lethality than organic acid treatments alone; and (d) none of the treatments tested can prevent regrowth of surviving E. coli O157:H7 during sprouting.     

LACTIC ACID INACTIVATION OF SALMONELLA TYPHIMURIUM ATTACHED TO CATFISH SKIN

This study was conducted to test sanitizer efficacy of lactic acid on Salmonella typhimurium populations that were firmly attached or loosely attached on catfish skin with or without mucus. For both cell types, counts of S. typhimurium were reduced from 5.9 log¹⁰ CFU/skin to below the limit of detection of 2.0 log¹⁰ CFU/skin by a 5 min exposure to 2% lactic acid. Exposure for 1 min reduced a 10⁴ CFU/skin inoculum to below the limit of detection. Catfish skin mucus slightly decreased the antimicrobial effect of lactic acid against firmly attached S. typhimurium.     

Efficacy of FIT Produce Wash and Chlorine Dioxide on Pathogen Control in Fresh Potatoes

ABSTRACT:  A commercial fresh pack potato operation was used as a model to evaluate FIT fruit and vegetable wash effectiveness in reducing levels of microorganisms on potatoes and in flume water. Fresh potatoes were washed in flume water with or without FIT, or treated with a spray bar utilizing either FIT, 9 ppm chlorine dioxide (ClO₂), or a water control. Both flume treatments were also evaluated for APC and Gram-negatives. There were no significant differences in reduction of these microorganisms on treated or control potatoes. However, levels of Gram-negative bacteria in FIT-amended flume water were reduced by 5.95 log CFU/g, and the APC was reduced by 1.43 log CFU/g. To validate plant trial findings, this test was repeated using solutions of sterile potato flume water from the fresh pack operation, containing a typical level of dissolved and suspended solids. Treatment solutions prepared with flume water or deionized water containing FIT, 9 ppm ClO₂, or a water control were inoculated with E. coli O157:H7, Salmonella Typhimurium, or Pectobacterium carotovorum ssp. carotovorum . FIT and ClO₂ prepared with deionized water reduced levels of microorganisms by >6.1 to 6.6 log CFU/g to below the detection limit. FIT prepared with flume water reduced levels of all organisms by >6.0 to 6.4 log CFU/g to below the detection limit, whereas ClO₂ prepared from flume water reduced bacterial levels of all organisms by only 0.7 to 1.4 log CFU/g. Neither FIT nor ClO₂ was particularly efficacious against E. coli O157:H7, S. Typhimurium, APC, yeasts, or molds on potato surfaces.     

Comparison of chlorine and a prototype produce wash product for effectiveness in killing Salmonella and Escherichia coli O157:H7 on alfalfa seeds

Outbreaks of Salmonella and Escherichia coli O157:H7 infections associated with alfalfa and other seed sprouts have occurred with increased frequency in recent years. This study was undertaken to determine the efficacy of a liquid prototype produce wash product (Fit), compared with water and chlorinated water, in killing Salmonella and E. coli O157:H7 inoculated onto alfalfa seeds. We investigated the efficacy of treatments as influenced by seeds from two different lots obtained from two seeds suppliers and by two methods of inoculation. The efficacy of treatments was influenced by differences in seed lots and amount of organic material in the inoculum. Significant (alpha = 0.05) reductions in Salmonella populations on seeds treated with 20,000 ppm of chlorine or Fit for 30 min ranged from 2.3 to 2.5 log10 CFU/g and 1.7 to 2.3 log10 CFU/g, respectively. Reductions (alpha = 0.05) in E. coli O157:H7 ranged from 2.0 to 2.1 log10 CFU/g and 1.7 to more than 5.4 log10 CFU/g of seeds treated, respectively, with 20,000 ppm of chlorine or Fit. Compared with treatment with 200 ppm of chlorine, treatment with either 20,000 ppm of chlorine or Fit resulted in significantly higher reductions in populations of Salmonella and E. coli O157:H7. None of the treatments eliminated these pathogens as evidenced by their detection on enrichment of treated seeds. Considering the human health and environmental hazards associated with the use of 20,000 ppm of chlorine, Fit provides an effective alternative to chlorine as a treatment to significantly reduce bacterial pathogens that have been associated with alfalfa seeds.     

SHELF-LIFE OF FRESH FILLED PASTA. HAZARD ANALYSIS AND CRITICAL CONTROL POINTS OF THE MANUFACTURING PROCESS AND HOUSEHOLD PRACTICES

Hazard Analysis and Critical Control Point (HACCP) approach was used to assess the safety of a fresh filling pasta (ricotta-filled ravioli) manufacturing plant in La Plata region, Argentina. Household practices like cooking and holding meals before serving were also evaluated. Samples of ricotta, main raw material of the filling, showed colony counts of Enterobacteriaceae total microorganisms, molds and yeasts of (5 × 10³-1 × 10⁵), (1x10⁵−1x10⁸) and 1 × 10⁵ CFU/g, respectively. E. coli was also detected in one out of five samples, suggesting a hazardous condition of this raw material. Salmonella spp. was not isolated from any of the dough samples tested. Ricotta filling showed high colony counts of mesophilic microorganisms (6 × 10⁶ CFU/g), Enterobacteriaceae (1 × 10⁵ - 1 × 10⁶ CFU/g), while E. Coli was detected in 20% of the samples. Counts of B. cereus, S. aureus were less than 1 × 10² CFU/g in the analyzed materials. In the finished product (ricotta-filled ravioli), the colony counts of mesophilic microorganisms and Enterobacteriaceae were 3 × 10⁸ and 8 × 10⁵ CFU/g, respectively. Critical Control Points found were cooking and holding time before serving. The implementation of suggested corrections allowed the microbial quality of the final product (ricotta-filled ravioli) to be improved considerably. The growth of total microbial counts during refrigerated storage (0, 4, 8 and 10C) were measured and the shelf-life of ricotta and ricotta-filled ravioli was calculated.     

CHARACTERIZATION OF MODEL NITROSYLHEME PIGMENTS WITH VISIBLE, INFRARED AND 15N FOURIER TRANSFORM NUCLEAR MAGNETIC RESONANCE SPECTROSCOPY

Synthetic pigments that model the organic-soluble pigment in heat-processed cured ham were characterized with infrared (IR) and ¹⁵N nuclear magnetic resonance (NMR) spectroscopy. The two pigments synthesized were ¹⁵N nitrosyl (protoporphyrinato- IX) iron (II), or Fe^II PP¹⁵ NO, and ¹⁵N dinitrosyl (protoporphyrinato-IX), or Fe^II PP(¹⁵NO)₂. An NMR spectrum was obtained only for the Fe^II PP¹⁵ NO. The NMR spectrum consisted of a single peak + 1.78 ppm from the Na¹⁵ NO³ and –6.8 from the CH₃NO₂ reference. The IR spectrum included a single NO symmetric stretch at 1801 cm⁻¹. The visible spectrum of Fe^II PPNO did not match the visible spectrum of ham extracts, while it did with FE^II PP(¹⁵NO)₂. An unequivocal structural assignment of Fe^II PP¹⁵ NO was made, but longer NMR runs may be necessary to obtain a spectrum and unequivocal structural assignment of Fe^II PP(¹⁵ NO)₂.     

Inactivation of Escherichia coli O157:H7 and Salmonella enteritidis in Liquid Egg White Using Pulsed Electric Field

ABSTRACT: The effects of temperature and pulsed electric field (PEF) intensity on inactivation of pathogens such as Escherichia coli O157:H7 and Salmonella enteritidis in egg white was investigated. Liquid egg white inoculated with 10⁸ colony-forming units (CFU)/mL of each pathogen was treated with up to 60 pulses (each of 2 JAS width) at electric field intensities of 20 and 30 kV/cm. The processing temperatures were 10°C, 20°C, and 30°C. After treatment, uninjured and total viable cells were enumerated in selective and nonselective agars, respectively. Maximum inactivations of 3.7 and 2.9 log units were obtained for S. enteritidis and E. coli O157:H7, respectively, while injured cells accounted for 0.5 and 0.9 logs for E. coli O157:H7 and S. enteritidis , respectively. For both bacteria, increasing treatment temperature tended to increase the inactivation rate. There was synergy between electric field intensity and processing temperature. The inactivation rate constant k _T values for E. coli O157:H7 on both selective and nonselective agars were 8.2 × 10^-3 and 6.6 × 10^-3/μS, whereas the values for S. enteritidis were 16.2 × 10^-3 and 12.6 × 10^-3/μS, respectively. The results suggest that E. coli O157:H7 was more resistant to heat-PEF treatment compared with S. enteritidis.     

Effects of different disinfection treatments on the natural microbiota of lettuce

In this study, water and eight sanitizing solutions (vinegar at 6, 25, and 50%; acetic acid at 2 and 4%; peracetic acid at 80 ppm, sodium hypochlorite at 200 ppm, and sodium dichloroisocyanurate at 200 ppm) were compared in terms of their effectiveness against the natural microbiota of lettuce. All of the samples were kept in contact with the sanitizing solutions for 15 min, and the effectiveness of a sanitizing agent was evaluated on the basis of the number of decimal reductions of the total aerobic mesophilic count, the mold and yeast count, the total coliform count, and the Escherichia coli count. The average initial levels of these organisms in the samples were 6.94 log10 CFU/g for aerobic mesophilic microorganisms, 5.62 log10 CFU/g for molds and yeasts, and 3.25 log10 CFU/g for total coliforms. Of 10 samples analyzed, only 4 contained E. coli, and the average initial level of this microorganism in these 4 samples was 1.64 log10 CFU/g. Salmonella was not detected in any of the samples tested. The decimal reductions of the populations of aerobic mesophilic microorganisms, molds and yeasts, total coliforms, and E. coli were 0.78, 0.87, 0.82, and >0.14 log10 CFU/g, respectively, in water; 2.89, >3.41, >2.21, and >0.26 log10 CFU/g, respectively, in 50% vinegar; 2.42, >3.20, >1.99, and >0.26 log10 CFU/g, respectively, in 25% vinegar; 1.83, 2.57, 1.58, and >0.26 log10 CFU/g, respectively, in 6% vinegar; 3.91, >3.58, >2.25, and >0.26 log10 CFU/g, respectively, in 4% acetic acid; 3.37, >3.53, >2.25, and >0.26 log10 CFU/g, respectively, in 2% acetic acid; 1.85, 2.32, 1.44, and >0.20 log10 CFU/g, respectively, in 80 ppm of peracetic acid; 2.63, 2.75, 1.91, and >0.26 log10 CFU/g, respectively, in 200 ppm of sodium hypochlorite; and 3.23, >3.08, >1.95, and >0.26 log10 CFU/g, respectively, in 200 ppm of sodium dichloroisocyanurate. Statistical analysis of the results showed that the effectiveness levels for all of the sanitizing agents tested were equivalent to or higher than that for sodium hypochlorite at 200 ppm.     

Empirical Distribution Models for Escherichia coli 57:H7 in Ground Beef Produced by a Mid-size Commercial Grinder

ABSTRACT: The purpose of this research was to develop empirical models that describe the amount and distribution of ground beef contaminated with Escherichia coli O157:H7 when a contaminated beef trim is introduced into a batch of uncontaminated beef before processing in a mid-size commercial grinder (34 g/s). A beef trim was inoculated with a rifampacin-resistant strain of E. coli O157:H7 and added to a batch of noncontaminated trims at the grinding step. To study the distribution of the E. coli O157:H7^rif in the ground beef, 6 treatments with different inoculum levels (1 to 6 log₁₀ colony-forming units [CFU]) were tested. Removal or pick up of the residual contamination with E. coli O157:H7^rif left in the grinder was evaluated. E. coli O157:H7^rif was detected in 9% to 86% of the total ground beef for the 1 to 6 log₁₀ CFU inoculum levels, respectively. E. coli O157:H7^rif contamination was detected in the collar that fixes the grinder's die and blade to the hub. An exponential algorithm described the relationship between the quantities of ground beef containing E. coli O157:H7^rif and the inoculum level ( R ²= 0.82). Distribution models based on a Chi-squared algorithm were developed for each inoculum level describing the contamination level as a function of the batch fraction processed ( R ²= 0.81 to 0.99). The results of this study corroborate that when beef processors test for pathogenic contamination in a mid-scale grinder, they should test the beef residues in the collar that fixes the grinder's die and blade to the hub.     

Comparison of chemical treatments to eliminate enterohemorrhagic Escherichia coli O157:H7 on alfalfa seeds.

The focus of this study was to determine the efficacy of various chemicals in eliminating 2.04 to 3.23 log10 CFU/g of Escherichia coli O157:H7 from alfalfa seeds and to determine the survivability of the pathogen on seeds stored for prolonged periods at three temperatures. Significant (P < or = 0.05) reductions in populations of E. coli O157:H7 on inoculated seeds were observed after treatments with 500 and 1,000 ppm of active chlorine (as Ca[OCl]2) for 3 but not 10 min and with > or =2,000 ppm of Ca(OCl)2 regardless of pretreatment with a surfactant. Treatment with 20,000 ppm of active chlorine failed to kill 2.68 log10 CFU/g of seeds. Acidified NaClO2 (500 ppm) was effective in reducing populations of the pathogen by >2 logs per g. Acidified ClO2 significantly reduced populations of E. coli O157:H7 on seeds at concentrations > or =100 ppm, and 500 ppm of ClO2 reduced the pathogen from 2.7 log10 CFU/g to <0.5 CFU/g. Chlorine (as NaOCl) was not effective at concentrations < or =1,000 ppm; significant reduction was achieved only after treatment with 2,000 ppm for 3 or 10 min. Notable reduction in populations was observed after treatment with 30 or 70% C2H3OH, but there was a dramatic decrease in germination percentage. Treatment with 0.2% H2O2 significantly reduced populations, and the organism was not detected by direct plating after treatment with > or =1% H2O2. Significant reduction in population of E. coli O157:H7 occurred after treatment with 1% trisodium phosphate, 40 ppm of Tsunami and Vortexx, and 1% Vegi-Clean. A significant decrease in the number of E. coli O157:H7 on dry seeds was observed within 1 week of storage at 25 and 37 degrees C, but not at 5 degrees C. Between 1 and 38 weeks, populations on seeds stored at 5 degrees C remained relatively constant. The pathogen was recovered from alfalfa seeds initially containing 3.04 log 10 CFU/g after storage at 25 or 37 degrees C for 38 weeks but not 54 weeks.     

Combination of Carbon Dioxide and Cinnamon to Inactivate Escherichia coli O157:H7 in Apple Juice

ABSTRACT: Pasteurized apple juice with CO2 (0, 1, and 4%) and cinnamon (0 and 0.3%) was inoculated with Escherichia coli O157:H7 at 104 CFU/mL, and stored at 5 and 20 °C. Counts on nonselective and selective media, and thin agar layer (TAL; selective medium overlaid with nonselective medium) were determined at 1 h and 1, 3, 7, and 14 d. Inactivation was greater at 20 °C. Samples with 1 and 4% CO₂, alone and combined with cinnamon, presented < 0.7 log CFU/mL in 3 d. Counts in apple juice inoculated at 10² CFU/mL, a low-level E. coli O157:H7 contamination, were nondetectable at 3 d. The TAL method was as effective as nonselective medium to recover injured cells.     

REMOVAL OF SALMONELLA TYPHIMURIUM ATTACHED TO CHICKEN SKIN BY RINSING WITH TRISODIUM PHOSPHATE SOLUTION: SCANNING ELECTRON MICROSCOPIC EXAMINATION

The effect of trisodium phosphate (TSP) on Salmonella typhimurium attached to chicken skin was investigated by using scanning electron microscopy (SEM). Chicken drumsticks were inoculated with Salmonella typhimurium (2 × 10⁸ CFU/mL) for 30 min. Both inoculated and non-inoculated drumsticks were rinsed with 10% TSP solution at 10 or 50C for 15 s, and skin pieces were cut and fixed for SEM examination. For inoculated skins, a significant difference was noticed between TSP-rinsed and control skins (water-rinsed) at both temperatures. While control skins were covered with salmonellae (4 × 10⁵∼ 1 × 10⁶ CFU/cm²) and miscellaneous debris, TSP-rinsed skins, either at 10 or 50C, showed clean skin surfaces (<8×10³ CFU/cm²). For non-inoculated skins, it was difficult to see the difference in the number of attached bacteria due to their low numbers, however, water-rinsed skins still showed the debris on the surface. Above observations suggest that one of the major mechanisms of TSP on salmonellae reduction is detachment of contaminants from the skin surface.     

The Effectiveness of Sanitizer Treatments in Inactivation of Salmonella spp. from Bell Pepper, Cucumber, and Strawberry

ABSTRACT: Four different postharvest treatments for removal of Salmonella from bell pepper and cucumber were examined, including washes with chlorinated water (HOCl; 200 ppm), acidified sodium chlorite (ASC; 1200 ppm), and peroxyacetic acid (PAA; 75 ppm), and treatment with gaseous chlorine dioxide (ClO₂; total 100 mg). Only ClO₂ gas was evaluated for decontamination of strawberries. Each produce was inoculated with approximately 1.0 × 10⁷ colony-forming units (CFU) of a 5-serovar cocktail of Salmonella on artificially created wounds, smooth surfaces, and stem scar tissue. For tests involving smooth surface inoculation, ASC and PAA treatments decreased contamination to undetectable levels on bell pepper and cucumber, while the chlorine treatment of bell pepper reduced contamination by approximately 2-logs. For stem scar contamination on bell pepper, ASC and PAA treatments both showed >2-log unit reductions, and chlorine treatment showed a <1-log unit reduction. For puncture wounds on bell pepper, HOCl, ASC, and PAA treatments reduced bacterial levels approximately 2-, 3-, and 1-log units, respectively, indicating that HOCl and ASC were more effective than PAA. These aqueous treatments of cucumber with puncture wounds reduced bacterial levels approximately 1-, 2-, and 2-log units, respectively. ClO₂ treatment decreased counts to undetectable levels on all inoculation sites on cucumber and on strawberry smooth surfaces, but failed to completely eliminate Salmonella from bell pepper and from the stem scar and the puncture wounds of strawberry. ASC treatment of bell pepper and ClO₂ gas treatments of cucumber showed the best efficiency for inactivation of Salmonella. ClO₂ treatments effectively reduced Salmonella cells inoculated on the smooth surface and stem scar of strawberries compared with unsanitized control.     

Survival and death of Salmonella typhimurium and Campylobacter jejuni in processing water and on chicken skin during poultry scalding and chilling

Salmonella Typhimurium and Campylobacter jejuni were inoculated in scalding water, in chilled water, and on chicken skins to examine the effects of scalding temperature (50, 55, and 60 degrees C) and the chlorine level in chilled water (0, 10, 30, and 50 ppm), associated with the ages of scalding water (0 and 10 h) and chilled water (0 and 8 h), on bacterial survival or death. After scalding at 50 and 60 degrees C, the reductions of C. jejuni were 1.5 and 6.2 log CFU/ml in water and <1 and >2 log CFU/cm2 on chicken skins; the reductions of Salmonella Typhimurium were <0.5 and >5.5 log CFU/ml in water and <0.5 and >2 log CFU/cm2 on skins, respectively. The age of scalding water did not significantly (P > 0.05) affect bacterial heat sensitivity. However, the increase in the age of chilled water significantly (P < 0.05) reduced the chlorine effect. In 0-h chilled water. C. jejuni and Salmonella Typhimurium were reduced by 3.3 and 0.7 log CFU/ml, respectively, after treatment with 10 ppm of chlorine and became nondetectable with 30 and 50 ppm of chlorine. In 8-h chilled water, the reduction of C. jejuni and Salmonella Typhimurium was <0.5 log CFU/ml with 10 ppm of chlorine and ranged from 4 to 5.5 log CFU/ml with 50 ppm of chlorine. Chlorination of chilled water did not effectively reduce the bacteria attached on chicken skins. The D-values of Salmonella Typhimurium and C. jejuni were calculated for the prediction of their survival or death in the poultry scalding and chilling.