Antimicrobial and antioxidant activities of natural extracts in vitro and in ground beef

Inhibition of Escherichia coli O157:H7, Salmonella Typhimurium, and Listeria monocytogenes by grape seed extract (ActiVin) and pine bark extract (Pycnogenol) and the effect of these natural extracts on the oxidative stability of raw ground beef were studied. In an agar dilution test, the MICs of ActiVin and Pycnogenol were determined to be 4.0 mg/ml for 4.43 log CFU per plate of E. coli O157:H7 and 4.0 mg/ml for 4.38 log CFU per plate of L. monocytogenes. In an inhibition curve test, populations of E. coli O157:H7, Salmonella Typhimurium, and L. monocytogenes fell to below the detection limit (10 CFU/ml) after 16 h of incubation. The numbers of E. coli O157:H7, L. monocytogenes, and Salmonella Typhimurium declined by 1.08, 1.24, and 1.33 log CFU/g, respectively, in raw ground beef treated with 1% Pycnogenol after 9 days of refrigerated storage. ActiVin (1%) and oleoresin rosemary (1%) resulted in an approximately 1-log CFU/g reduction in the populations of all three pathogens after 9 days. The addition of 1% ActiVin and Pycnogenol contributed to the maintenance of an acidic pH of 5.80 and 5.58, respectively, in raw ground beef. Compared to the control, all treatments increased in L* (lightness), with the exception of ActiVin. ActiVin and oleoresin rosemary had the highest a* (redness) and b* (yellowness) values, respectively. ActiVin most effectively retarded lipid oxidation, followed by Pycnogenol. The results suggest that these natural extracts have potential to be used with other preservative methods to reduce pathogenic numbers, lipid oxidation, and color degradation in ground beef.     

Application of reuterin produced by Lactobacillus reuteri 12002 for meat decontamination and preservation

Lactobacillus reuteri strain 12002 was used for reuterin production in the two-step fermentation process. A batch culture fermentation was used to produce a maximum biomass of L. reuteri. Then cells were harvested, resuspended in a glycerol-water solution, and anaerobically incubated to produce reuterin. The lyophilized supernatants (approximately 4000 activity units (AU) of reuterin per ml) were diluted in distilled water for decontamination and preservation trials. The MIC values of reuterin for Escherichia coli O157:H7 and Listeria monocytogenes were 4 and 8 AU/ml, respectively. In meat decontamination experiments, the surface of cooked pork was inoculated with either L. monocytogenes or E. coli O157:H7 at a level of approximately log10 5 CFU/cm2, incubated for 30 min at 7 degrees C, and decontaminated by exposure to reuterin (500 AU/ml). The bactericidal effect of reuterin was analyzed 15 s and 24 h after exposure at 7 degrees C. After 15 s of exposure to reuterin, viable numbers decreased by 0.45 and 0.3 log10 CFU/cm2 for E. coli O157:H7 and L. monocytogenes, respectively. After 24 h the numbers decreased by 2.7 log10 CFU/cm2 for E. coli O157:H7 and by 0.63 log10 CFU/cm2 for L. monocytogenes. In the same experiment, the combined effect of reuterin and lactic acid was also investigated. Adding lactic acid (5%, vol/vol) to reuterin significantly enhanced (P < or = 0.05) the efficacy of reuterin. No additional effect (P < or = 0.05) was found when ethanol (40%) was added to the mixture of reuterin and lactic acid. To evaluate the preservative effect of reuterin during meat storage, reuterin was added to raw ground pork contaminated with E. coli O157:H7 or L. monocytogenes. Reuterin at a concentration of 100 AU/g resulted in a 5.0-log10 reduction of the viability of E. coli O157:H7 after 1 day of storage at 7 degrees C. Reuterin at a concentration of 250 AU/g reduced the number of the viable cells of L. monocytogenes by log10 3.0 cycles after 1 week of storage at 7 degrees C.     

Validation of the use of organic acids and acidified sodium chlorite to reduce Escherichia coli O157 and Salmonella typhimurium in beef trim and ground beef in a simulated processing environment

A study was conducted to determine if acidified sodium chlorite (1,200 ppm) and acetic and lactic acids (2 and 4%) were effective in reducing foodborne pathogens in beef trim prior to grinding in a simulated processing environment. The reduction of Salmonella Typhimurium and Escherichia coli O157:H7 at high (4.0 log CFU/g) and low (1.0 log CFU/g) inoculation doses was evaluated at various processing steps, including the following: (i) in trim just after treatment application, (ii) in ground beef just after grinding, (iii) in ground beef 24 h after refrigerated storage, (iv) in ground beef 5 days after refrigerated storage, and (v) in ground beef 30 days after frozen storage. All antimicrobial treatments reduced the pathogens on the trim inoculated with the lower inoculation dose to nondetectable numbers in the trim and in the ground beef. There were significant reductions of both pathogens in the trim and in the ground beef inoculated with the high inoculation doses. On the trim itself, E. coli O157:H7 and Salmonella Typhimurium were reduced by 1.5 to 2.0 log cycles, with no differences among all treatments. In the ground beef, the organic acids were more effective in reducing both pathogens than the acidified sodium chlorite immediately after grinding, but after 1 day of storage, there were no differences among treatments. Overall, in the ground beef, there was a 2.5-log reduction of E. coli O157:H7 and a 1.5-log reduction of Salmonella Typhimurium that was sustained over time in refrigerated and frozen storage. Very few sensory differences between the control samples and the treated samples were detected by a consumer panel. Thus, antimicrobial treatments did not cause serious adverse sensory changes. Use of these antimicrobial treatments can be a promising intervention available to ground beef processors who currently have few interventions in their process.     

Effects of vacuum or modified atmosphere packaging in combination with irradiation for control of Escherichia coli O157:H7 in ground beef patties

The efficacy of controlling Escherichia coli O157:H7 in ground beef patties by combining irradiation with vacuum packaging or modified atmosphere packaging (MAP) was investigated. Fresh ground beef patties were inoculated with a five-strain cocktail of E. coli O157:H7 at 5 log CFU/g. Single patties, packaged with vacuum or high-CO(2) MAP (99.6% CO(2) plus 0.4% CO), were irradiated at 0 (control), 0.5, 1.0, or 1.5 kGy. The D(10)-value for this pathogen was 0.47 ± 0.02 kGy in vacuum and 0.50 ± 0.02 kGy in MAP packaging. Irradiation with 1.5 kGy reduced E. coli O157:H7 by 3.0 to 3.3 log, while 0.5 and 1.0 kGy achieved reductions of 0.7 to 1.0, and 2.0 to 2.2 log, respectively. After irradiation, the numbers of survivors of this pathogen on beef patties in refrigerated storage (4°C) did not change significantly for 6 weeks. Temperature abuse (at 25°C) resulted in growth in vacuum-packaged patties treated with 0.5 and 1.5 kGy, but no growth in MAP packages. This study demonstrated that combining irradiation with MAP was similar in effectiveness to irradiation with vacuum packaging for control of E. coli O157:H7 in ground beef patties during refrigerated storage. However, high-CO(2) MAP appeared to be more effective after temperature abuse.     

Survival of Escherichia coli O157:H7 in ground-beef patties during storage at 2, -2, 15 and then -2 degrees C, and -20 degrees C

The survival of Escherichia coli O157:H7 and of a nonpathogenic control strain of E. coli was monitored in raw ground beef that was stored at 2 degrees C for 4 weeks, -2 degrees C for 4 weeks, 15 degrees C for 4 h and then -2 degrees C for 4 weeks, and -20 degrees C. Irradiated ground beef was inoculated with one E. coli control strain or with a four-strain cocktail of E. coli O157:H7 (ca. 10(5) CFU/g), formed into patties (30 to 45 g), and stored at the appropriate temperature. The numbers of the E. coli control strain decreased by 1.4 log 10 CFU/g, and pathogen numbers declined 1.9 log 10 CFU/g when patties were stored for 4 weeks at 20 degrees C. When patties were stored at -2 degrees C for 4 weeks, the numbers of the E. coli control strain and the serotype O157:H7 strains decreased 2.8 and 1.5 log 10 CFU/g, respectively. Patties stored at 15 degrees C for 4 h prior to storage at -2 degrees C for 4 weeks resulted in 1.6 and 2.7 log 10-CFU/g reduction in the numbers of E. coli and E. coli O157:H7, respectively. Storage of retail ground beef at 15 degrees C for 4 h (tempering) did not result in increased numbers of colony forming units per gram, as determined with violet red bile, MRS lactobacilli, and plate-count agars. Frozen storage (-20 degrees C) of ground-beef patties that had been inoculated with a single strain of E. coli resulted in approximately a 1 to 2 log 10-CFU/g reduction in the numbers of the control strain and individual serotype O157:H7 strains after 1 year. There was no significant difference between the survival of the control strain and the O157:H7 strains, nor was there a difference between O157:H7 strains. These data demonstrate that tempering of ground-beef patties prior to low-temperature storage accelerated the decline in the numbers of E. coli O157:H7.     

Inactivation of Escherichia coli O157:H7 in packaged ground beef by allyl isothiocyanate

Commercial allyl isothiocyanate (AIT) was examined for its ability to reduce numbers of Escherichia coli O157:H7 inoculated in fresh ground beef packaged under nitrogen and stored refrigerated or frozen. A five-strain cocktail of E. coli O157:H7 containing 3 or 6 log10 cfu/g was inoculated into 100 g ground beef and formed into 10x1-cm patties. A 10-cm diameter filter paper disk treated with AIT suspended in sterile corn oil was placed on top of a single patty. One patty and paper disk were placed in a bag of Nylon/EVOH/PE with O2 permeability of 2.3 cm3 m(-2) 24 h atm at 23 degrees C. The bags were back-flushed with 100% nitrogen, heat-sealed and stored at 10, 4 and -18 degrees C for 8, 21 or 35 days, respectively. During storage, the AIT levels in the package headspaces were determined by gas liquid chromatography, and mesophilic bacteria and E. coli O157:H7 were counted. The mesophilic aerobic bacteria in ground beef patties were largely unaffected by the addition of AIT. At an initial population of 3 log10 cfu/g, E. coli O157:H7 was reduced by AIT to undetectable levels after 18 days at 4 degrees C or 10 days at -18 degrees C. In samples inoculated with 6 log10 cfu/g, a >3 log10 reduction of E. coli O157:H7 was observed after 21 days at 4 degrees C, while a 1 log10 reduction was observed after 8 and 35 days at 10 and -18 degrees C, respectively. The final AIT concentrations in the headspaces after storage at 10, 4, and -18 degrees C were 444, 456, and 112 microg/ml at 8, 21, and 35 days, respectively. Results showed that AIT can substantially reduce numbers of E. coli O157:H7 in fresh ground beef during refrigerated or frozen storage.     

Use of mustard flour to inactivate Escherichia coli O157:H7 in ground beef under nitrogen flushed packaging

This study was undertaken to determine whether the glucosinolates naturally present in non-deheated mustard flour could serve as a source of allyl and other isothiocyanates in sufficient quantity to kill Escherichia coli O157:H7 inoculated in ground beef at three different levels, during refrigerated storage of the meat under nitrogen. Mustard flour was mixed at 5%, 10% or 20% (w/w) with freshly ground beef, then the beef was inoculated with a cocktail of five strains of E. coli O157:H7 at either 3, 6 or < or =1.6 log10 cfu/g. The ground beef was formed into 100 g patties and each was placed in a bag of Nylon/EVOH/PE, which was back-flushed with 100% N2, heat-sealed and stored at 4 degrees C for < or =21 days. During storage, the allyl isothiocyanate (AIT) levels in package headspaces were determined by gas liquid chromatography. By 21 days, the levels present in treatments were not significantly different. After 21 days storage, there were 0.5, 3 and 5.4 log10 decreases in numbers of E. coli O157:H7 from the initial levels of 6 log10 cfu/g in meat containing 5%, 10% and 20% mustard flour, respectively. When inoculated at 3 log10 cfu/g, E. coli O157:H7 was reduced to undetectable levels after 18, 12 and 3 days with 5%, 10% and 20% mustard flour, respectively. When immunomagnetic separation (IMS) was used for E. coli recovery following its inoculation at < or =1.6 log10 cfu/g, 5% mustard did not completely eliminate the pathogen from ground beef stored for 6 days. The natural microflora of the ground beef which developed in vacuum packages was unaffected by the addition of 5% mustard flour but some inhibition was found at higher concentrations. Sensory evaluation of the cooked ground beef showed that there were no significant differences in the acceptability of meat treated with 5 or 10% mustard flour. However, panelists could distinguish untreated controls from mustard treatments, but considered the mustard-treated meat to be acceptable. These results showed that it is possible to use mustard flour at levels of >5-10% to eliminate E. coli O157:H7 from fresh ground beef.     

Liquid Smoke Effects on Escherichia Coli O157:H7, and its Antioxidant Properties in Beef Products

Experiments were performed to evaluate the antibacterial properties of liquid smoke (LS), against E. coli O157:H7, in model (agar) and meat systems. The effects of 8% LS on growth of E. coli O157:H7 attached to ground beef, and 1.5% LS on warmed-over flavor (WOF) in precooked beef patties were also studied. E. coli O157:H7 growth was reduced (p<0.05) 2.3 log₁₀ CFU/g in ground beef patties after 3d refrigerated storage. TBA numbers, aroma scores and pH values were lower (p<0.05) in LS treated beef patties. LS reduced undesirable flavor development and may help assure the safety of beef products.     

Growth of Escherichia coli O157:H7 in raw ground beef stored at 10 degrees C and the influence of competitive bacterial flora,strain variation,and fat level

Pure-culture broth-based models of the growth of Escherichia coli O157:H7 have been used to estimate its behavior in ground beef, even though these models have not been adequately validated for this food product. This situation limits accurate estimates of the behavior of E. coli O157:H7 in ground beef and introduces uncertainties in risk assessments. In the present study, the growth of single and multiple strains of E. coli O157:H7 were measured in retail ground beef stored at 10 degrees C for up to 12 days, and the results were compared with estimates generated by the U.S. Department of Agriculture's Pathogen Modeling Program (PMP; version 5.1). At pH 5.9, the PMP predicted a maximum population density (MPD) of 9.13 log10 CFU/g, an exponential growth rate (EGR) of 0.052 log10 CFU/h, and a lag time of 56.3 h. Similar parameter values were observed for sterilized ground beef; however, no lag phase was observed. In contrast, the mean MPD and EGR for retail ground beef were 5.09 log10 CFU/g and 0.019 log10 CFU/h, respectively, and no lag phase was observed. Both the EGR and the MPD increased with decreasing fat levels. There was low variation in the MPD and EGR parameters for the nine E. coli O157:H7 ground beef isolates. Two isolates of competitive native flora were separately added to sterilized ground beef, and the EGR and MPD decreased as the ratio of competitive flora to E. coli O157:H7 increased. For one strain, at ratios of 1:1, 10:1, and 100:1, the EGRs were 0.033, 0.025, and 0.018 log10 CFU/h, respectively, and the MPDs were 6.14, 5.08, and 4.84 log10 CFU/g, respectively. These results demonstrate that existing broth-based models for E coli O157:H7 must be validated for food and that models should consider the effects of the food matrix, the competitive microflora, and potential pathogen strain variation.     

Antibacterial effect of lactoferricin B on Escherichia coli O157:H7 in ground beef.

The antibacterial activity of lactoferricin B on enterohemorrhagic Escherichia coli O157:H7 in 1% peptone medium and ground beef was studied at 4 and 10 degrees C. In 1% peptone medium, 50 and 100 microg of lactoferricin B per ml reduced E. coli O157:H7 populations by approximately 0.7 and 2.0 log CFU/ml, respectively. Studies comparing the antibacterial effect of lactoferricin B on E. coli O157:H7 in 1% peptone at pH 5.5 and 7.2 did not reveal any significant difference (P > 0.5) at the two pH values. Lactoferricin B (100 microg/g) reduced E. coli O157:H7 population in ground beef by about 0.8 log CFU/g (P < 0.05). No significant difference (P > 0.5) was observed in the total plate count between treatment and control ground beef samples stored at 4 and 10 degrees C. The antibacterial effect of lactoferricin B on E. coli O157:H7 observed in this study is not of sufficient magnitude to merit its use in ground beef for controlling the pathogen.     

Inactivation of Escherichia coli O157:H7 in ground beef by single-cycle and multiple-cycle high-pressure treatments

The effect of single- and multiple-cycle high-pressure treatments on the survival of Escherichia coli CECT 4972, a strain belonging to the O157:H7 serotype, in ground beef was investigated. Beef patties were inoculated with 10(7) CFU/g E. coli O157:H7, and held at 4 degrees C for 20 h before high-pressure treatments. Reduction of the E. coli O157:H7 population by single-cycle treatments at 400 MPa and 12 degrees C ranged from 0.82 log CFU/g for a 1-min cycle to 4.39 log CFU/g for a 20-min cycle. Multiple-cycle treatments were very effective, with four 1-min cycles at 400 MPa and 12 degrees C reducing the E. coli O157:H7 population by 4.38 log CFU/g, and three 5-min cycles by 4.96 log CFU/g. The color parameter L* increased significantly with high-pressure treatments in the interior and the exterior of beef patties, whereas a* decreased in the interior, and b* increased in the exterior-changes that might diminish consumer acceptance of the product. Kramer shear force and energy were generally higher in pressurized than in control ground beef. Maximum values for these texture parameters, which corresponded to tougher patties, were reached after one 10-min cycle in the case of single-cycle treatments or two 5-min cycles in the case of multiple-cycle treatments. High-pressure treatments had no significant effect on Warner-Bratzler shear force.     

Reduction of Escherichia coli O157:H7 and Salmonella in ground beef using lactic acid bacteria and the impact on sensory properties

Studies were conducted to determine whether four strains of lactic acid bacteria (LAB) inhibited Escherichia coli O157: H7 and Salmonella in ground beef at 5 degrees C and whether these bacteria had an impact on the sensory properties of the beef. The LAB consisted of frozen concentrated cultures of four Lactobacillus strains, and a cocktail mixture of streptomycin-resistant E. coli O157:H7 and Salmonella were used as pathogens. Individual LAB isolates at 10(7) CFU/ml were added to tryptic soy broth containing a pathogen concentration of 10(5) CFU/ml. Samples were stored at 5 degrees C, and pathogen populations were determined on days 0, 4, 8, and 12. After 4 days of storage, there were significant differences in numbers of both pathogens exposed to LAB isolates NP 35 and NP 3. After 8 and 12 days of storage, all LAB reduced populations of both pathogens by an average of 3 to 5 log cycles. A second study was conducted in vacuum-packaged fresh ground beef. The individual LAB isolates resulted in an average difference of 1.5 log cycles of E. coli O157:H7 after 12 days of storage, and Salmonella populations were reduced by an average of 3 log cycles. Following this study, a mixed concentrated culture was prepared from all four LAB and added to ground beef inoculated with pathogen at 10(8) CFU/g. After 3 days of storage, the mixed culture resulted in a 2.0-log reduction in E. coli O157:H7 compared with the control, whereas after 5 days of storage, a 3-log reduction was noted. Salmonella was reduced to nondetectable levels after day 5. Sensory studies on noninoculated samples that contained LAB indicated that there were no adverse effects of LAB on the sensory properties of the ground beef. This study indicates that adding LAB to raw ground beef stored at refrigeration temperatures may be an important intervention for controlling foodborne pathogens.     

Antimicrobial effect of herb extracts against Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella typhimurium associated with beef

The effects of plant extracts against pathogenic bacteria in vitro are well known, yet few studies have addressed the effects of these compounds against pathogens associated with muscle foods. A series of experiments was conducted to determine the effectiveness of a commercially available, generally recognized as safe, herb extract dispersed in sodium citrate (Protecta One) or sodium chloride (Protecta Two) against Escherichia coli O157:H7, Salmonella typhimurium, and Listeria monocytogenes associated with beef. In the first experiment, E. coli O157:H7, Salmonella typhimurium, and L. monocytogenes inoculated onto beef and subjected to surface spray treatments with 2.5% solutions of Protecta One or Protecta Two were not affected by immediate application (day 0) of the herbal extracts. However, after 7 days of storage at 4 degrees C, E. coli O157:H7 was reduced by >1.3 log10 CFU/cm2 by Protecta Two; L. monocytogenes was reduced by 1.8 and 1.9 log10 CFU/cm2 by Protecta One and Protecta Two, respectively; Salmonella typhimurium was not reduced >0.3 log10 CFU/cm2 by either extract by day 7. In the second experiment, 2.5% Protecta Two (wt/vol or wt/wt) added to inoculated lean and adipose beef trim, processed, and packaged as ground beef chubs (80% lean, 20% adipose), did not reduce pathogen populations >0.5 log10 CFU/g up to 14 days at 4 degrees C. In the third experiment, surface spray treatments of beef with 2.5% lactic acid or 2.5% solutions of Protecta One or Protecta Two, vacuum packaged, and stored up to 35 days at 4 degrees C did reduce E. coli O157:H7, L. monocytogenes, and Salmonella Typhimurium slightly. These studies suggest that the use of herb extracts may afford some reductions of pathogens on beef surfaces; however, the antimicrobial activity may be diminished in ground beef by adipose components.     

Evaluation of consumer-style cooking methods for reduction of Escherichia coli O157:H7 in ground beef

The objective of this study was to evaluate the thermal inactivation of Escherichia coli O157:H7 in ground beef cooked to an internal temperature of 71.1 degrees C (160 degrees F) under conditions simulating consumer-style cooking methods. To compare a double-sided grill (DSG) with a single-sided grill (SSG), two different cooking methods were used for the SSG: for the one-turnover (OT-SSG) method, a patty was turned once when the internal temperature reached 40 degrees C, and for the multiturnover (MT-SSG) method, a patty was turned every 30 s. Patties (100 g, n = 9) inoculated with a five-strain mixture of E. coli O157: H7 at a concentration of 10(7) CFU/g were cooked until all three temperature readings (for two sides and the center) for a patty were 71.1 degrees C. The surviving E. coli O157:H7 cells were enumerated on sorbitol MacConkey (SMAC) agar and on phenol red agar base with 1% sorbitol (SPRAB). The order of the cooking methods with regard to the cooking time required for the patty to reach 71.1 degrees C was as follows: DSG (2.7 min) < MT-SSG (6.6 min) < OT-SSG (10.9 min). The more rapid, higher-temperature cooking method was more effective (P < 0.01) in destroying E. coli O157:H7 in ground beef. E. coli O157:H7 reduction levels were clearly differentiated among treatments as follows: OT-SSG (4.7 log10 CFU/g) < MT-SSG (5.6 log10 CFU/g) < DSG (6.9 log10 CFU/g). Significantly larger numbers of E. coil O157:H7 were observed on SPRAB than on SMAC agar. To confirm the safety of ground beef cooked to 71.1 degrees C, additional patties (100 g, n = 9) inoculated with lower concentrations of E. coli O157:H7 (10(3) to 10(4) CFU/g) were tested. The ground beef cooked by the OT-SSG method resulted in two (22%) of nine samples testing positive after enrichment, whereas no E. coli O157:H7 was found for samples cooked by the MT-SSG and DSG methods. Our findings suggest that consumers should be advised to either cook ground beef patties in a grill that cooks the top and the bottom of the patty at the same time or turn patties frequently (every 30 s) when cooking on a grill that cooks on only one side.     

Inoculation of beef with low concentrations of Escherichia coli O157:H7 and examination of factors that interfere with its detection by culture isolation and rapid methods

Currently used industry testing programs require the ability to detect Escherichia coli O157:H7 in samples of beef trim or ground beef at levels as low as 1 CFU/375 g. We present a reliable protocol for generating a control inoculum for verification testing at this low concentration and evaluate its use. Results show that half of all samples received no cells when 1 CFU was the target concentration and that targets greater than 3 CFU were much more reliable. Detection by culture isolation and two commercial assays, Qualicon BAX-MP and BioControl GDS, detected 94% ± 11%, 92% ± 10%, and 92% ± 7% of samples inoculated with 5.4 CFU (range 1 to 9 CFU), respectively. We also examined the effect of background aerobic plate count (APC) bacteria and fat content effects on the detection of E. coli O157:H7. At APC concentrations below 6 log CFU/g, the rapid methods detected all beef trim samples inoculated with 26 CFU of E. coli O157:H7 per 65 g. At an APC of 6.7 log CFU/g, culture, BAX-MP, and GDS detected 100, 75, and 13%, respectively, of inoculated samples. Neither commercial method detected E. coli O157:H7 in the samples when APC was 7.7 log CFU/g, whereas culture was able to detect 63% of E. coli O157:H7 in the samples when APC was at this concentration. Increased fat content correlated with decreasing recovery of immunomagnetic separation beads, but this was not observed to interfere with detection of E. coli O157:H7.     

Thermal inactivation of Escherichia coli O157:H7 in beef treated with marination and tenderization ingredients

Internalization of Escherichia coli O157:H7 in nonintact beef products during mechanical tenderization or during injection of marination and tenderization ingredients is of concern if such products are undercooked. This study tested organic acids (0.2% citric acid and 0.3% acetic acid), potassium and calcium salts (1.8% potassium lactate, 0.63% calcium lactate, 0.86% calcium ascorbate, and 0.23% calcium chloride), and sodium chloride (2.5%) for their influence on thermal destruction of E. coli O157:H7 in ground beef serving as a model system. Ground beef batches (700 g; 5% fat) were mixed with equal volumes (22 ml) of each treatment solution or distilled water and portions (30 g) of treated ground beef were extruded in test tubes (2.5 by 10 cm). A five-strain mixture of E. coli O157:H7 (0.3 ml; 7 log CFU/g) was introduced at the center of the sample with a pipette. After overnight storage (4 degrees C), simulating product marination, samples were heated to 60 or 65 degrees C internal temperature, simulating rare and medium rare doneness of beef, in a circulating water bath. At 65 degrees C, treatments with citric and acetic acid showed greater (P < 0.05) reduction (4 to 5 log CFU/g) of E. coli O157:H7 than all the other ingredients and the control (3 to 4 log CFU/g). Sodium chloride reduced weight losses (16 to 18% compared with 20 to 27% by citric or acetic acid) and resulted in a 4-log reduction in counts during cooking to 65 degrees C. Ingredients such as citric or acetic acid may improve thermal inactivation of E. coli O157:H7 internalized in nonintact beef products, while sodium chloride may reduce cooking losses in such products.     

Comparison of methods for detection and isolation of cold- and freeze-stressed Escherichia coli O157:H7 in raw ground beef

A comparison was made of the relative efficiencies of three enrichment media, RapidChek Escherichia coli O157:H7 enrichment broth (REB), R&F broth (RFB), and modified E. coli broth containing novobiocin (mEC+n), and four selective plating media for detection of cold- and freeze-stressed E. coli O157:H7 in raw ground beef. Ground beef (25 g) was inoculated with E. coli O157:H7 at < or =0.5 and < or =2 CFU/g, and samples were then enriched immediately or were stored at 4 degrees C for 72 h or at -20 degrees C for 2 weeks and then enriched. After 8 or 20 h of enrichment, the cultures were plated onto R&F E. coli O157: H7 chromogenic plating medium, cefixime-tellurite sorbitol MacConkey agar, CHROMagar O157, and Rainbow agar O157 and tested using the RapidChek E. coli O157 lateral flow immunoassay and a multiplex PCR assay targeting the E. coli O157: H7 eae, stx1, and stx2 genes. Recovery of E. coli O157:H7 on the four agar media was 4.0 to 7.9 log CFU/ml with the REB enrichment, 1.4 to 7.4 log CFU/ml with RFB, 1.7 to 6.7 log CFU/ml with mEC+n incubated at 42 degrees C, and 1.3 to 3.3 log CFU/ml from mEC+n incubated at 35 degrees C. The percentages of positive ground beef samples containing nonstressed, cold-stressed, and freeze-stressed E. coli O157:H7 as obtained by plating, the immunoassay, and the PCR assay were 97, 88, and 97%, respectively, with REB, 92, 81, and 78%, respectively, with RFB, 97, 58, and 53%, respectively, with mEC+n incubated at 42 degrees C, and 22, 31, and 25%, respectively, with mEC+n incubated at 35 degrees C. Logistic regression analyses of the data indicated significant main effects of treatment, type of medium, enrichment time, inoculum concentration, and detection method. In particular, a positive result was 1.1 times more likely to occur after 20 h of enrichment than after 8 h, 25 times more likely with RFB and REB than with mEC+n at 35 degrees C, 3.7 times more likely with an initial inoculum of < or = 2.0 CFU/g than with < or = 0.5 CFU/g, 2.5 to 3 times more likely using freeze-stressed or nonstressed bacteria than with cold-stressed bacteria, and 2.5 times more likely by plating than by the immunoassay or the PCR assay. REB had better overall performance for enrichment of cold- and freeze-stressed E. coli O157:H7 present in ground beef than did the other media examined.     

Distribution patterns of Escherichia coli O157:H7 in ground beef produced by a laboratory-scale grinder

This study determined the distribution patterns of Escherichia coli O157:1H7 in ground beef when a contaminated beef trim was introduced into a batch of uncontaminated beef trims prior to grinding in a small-scale laboratory grinder. A beef trim (15.3 +/- 2 g) was inoculated with a rifampicin-resistant strain of E. coli O157:H7 (E. coli O157:H7rif) and introduced into a stream of noncontaminated beef (322 +/- 33 g) prior to grinding. Seven inoculum levels (6, 5, and 4 total log CFU [high]; and 3, 2, 1, and 0 total log CFU [low]) were studied in triplicate. E. coli O157:H7rif was not detected in 3.1 to 43% of the ground beef inoculated with the high levels or in 3.4 to 96.9% of the ground beef inoculated with the low levels. For all inoculum levels studied, the five ground beef fractions (each 7.8 +/- 0.6 g) with the highest pathogen levels accounted for 59 to 100% of the total pathogens detected. For all inoculum levels, there was a linear relationship between the quantity of ground beef containing E. coli O157:H7rif and the inoculum level. The quantity of E. coli O157:H7rif in the beef remaining in the grinder was proportional to the inoculum level and was related to the location in the grinder. Different components of the grinder accumulated E. coli O157:H7rif in different quantities, with the most significant accumulation being in the nut (collar) that attaches the die to the blade. This study determined specific distribution patterns of E. coli O157:H7rif after the grinding of a contaminated beef trim along with uncontaminated trims, and the results indicate that the grinding operation should be regarded as a means of distribution of microbial contamination in risk analyses of ground beef operations.     

Impact of pH enhancement on populations of Salmonella,Listeria monocytogenes,and Escherichia coli O157:H7 in boneless lean beef trimmings

Boneless lean beef trimmings were inoculated with multiple strains of salmonellae, Listeria monocytogenes, and Escherichia coli O157:H7 at levels of ca. 6 log10 CFU/g. pH enhancement with ammonia gas was then used to increase the pH of the trimmings to ca. 9.6. The product was then frozen, chipped, and compressed into blocks. pH enhancement reduced the populations of salmonellae, L. monocytogenes, and E. coli O157:H7 by approximately 4, 3, and 1 log10 cycles, respectively. After the product had been frozen and compressed into blocks, no salmonellae or E. coli O157:H7 were detectable by enumeration or after enrichment and isolation. The final populations of L. monocytogenes were reduced by ca. 3 log10 cycles relative to the initial populations. When uninoculated pH-enhanced lean boneless trimmings were blended with inoculated ground beef to a final concentration of 15% (wt/wt), pathogen populations in the ground beef were reduced by approximately 0.2 log10 cycles.     

Survival of Salmonella enterica, Escherichia coli O157:H7, and Listeria monocytogenes on inoculated walnut kernels during storage

The survival of single strains or cocktails of Salmonella, Escherichia coli O157:H7, and Listeria monocytogenes was evaluated on walnut kernels. Kernels were separately inoculated with an aqueous preparation of the pathogens at 3 to 10 log CFU/g, dried for 7 days, and then stored at 23°C for 3 weeks to more than 1 year. A rapid decrease of 1 to greater than 4 log CFU/g was observed as the inoculum dried. In some cases, the time of storage at 23°C did not influence bacterial levels, and in other cases the calculated rates of decline for Salmonella (0.05 to 0.35 log CFU/g per month) and E. coli O157:H7 (0.21 to 0.86 log CFU/g per month) overlapped and were both lower than the range of calculated declines for L. monocytogenes (1.1 to 1.3 log CFU/g per month). In a separate study, kernels were inoculated with Salmonella Enteritidis PT 30 at 4.2 log CFU/g, dried (final level, 1.9 log CFU/g), and stored at -20, 4, and 23°C for 1 year. Salmonella Enteritidis PT 30 declined at a rate of 0.10 log CFU/g per month at 23°C; storage time did not significantly affect levels on kernels stored at -20 or 4°C. These results indicate the long-term viability of Salmonella, E. coli O157:H7, and L. monocytogenes on walnut kernels and support inclusion of these organisms in hazard assessments.