高温固硫矿物3CaO·3A1_2O_3·CaSO_4的热力学数据的计算与验证(英文)

Calcium sulfoaluminate,3CaO·3Al2O3·CaSO4,has been widely recognized in the realms of high-temperature combustion and cement chemistry.However,the lack of relevant thermodynamic data limits the progress of its research and development.Through comparative calculations using several different approaches,we obtain the thermochemical properties of 3CaO·3Al2O3·CaSO4 in this work,such as its standard formation enthalpy,Gibbs free en- ergy of formation,entropy,and molar heat capacity.With these fundamental data,the...     

Microstructures and Corrosion Resistance of Al2O3—C Based Refractories to the Melts Containing Titania

The corrosion resisance of the Al2O3-C based refrac-tories in melts containing titania has been studied by quasi-station immersion and rotary immersionThe corrosion rate is decreased with the addition of graphite carbon and ZrO2 in the refractories.The corrosion mehanism of Al2O3-C refractories is the oxidization of graphite carbon by the oxides of the melts and the formation of deteriorate layer,For the Al2O3-C-ZrO2 refractories,the corrosion behavior is due to the interaction between melts and refrac-tories,The new compounds of FeO.SiO2,SiZrO4,Feo.3CaO,2CaO.SiO2 and CaO.SiO2 are formed in the deteriorate layer.     

CH4-CaSO4和H2S-Fe2O3反应体系的热力学和动力学研究

The destruction of hydrocarbon in deep carbonate diagenetic environment is one of problems on the formation of oil and gas. Organic-inorganic reactions in the process of TSR(Thermochemical Sulfate Reduction) are the main reason to make disappearance of the hydrocarbons. The work in this field has often been the subject of much research work in recent years. In this paper, the thermodynamics of CH4-CaSO4 and H2S-Fe2O3 systems is discussed to investigate the possibility of reactions. It is found that these two reactions can proceed spontaneously.Increasing temperature is favorite for CH4-CaSO4 system but disfavorite for H2S-Fe2O3 system. Thermal simulation experiments were carried out using autoclave at high temperature and high pressure. The properties of the products were characterized by microcoulometry, FT-IR and XRD methods. On the basis of the experimental data, a reaction kinetic model is developed and kinetic parameters are determined.     

甲烷/空气射流燃烧中氮氧化物生成模型的研究

With the development of reaction kinetics and transfer science, the modeling of NOx formation plays more and more important roles in the protection of environment and the design of combustion reactors; in this case, turbu-lence-chemistry model and NOx formation model are the two most important aspects. For thermal NOx mechanism, this article studied the CH4/air system and applied a set of latest NO formation rate constants published at the Leed University which replaced the original model code in FLUENT to increase its precision on prediction of NO concentration. The realizable k-ε model, Reynold Stress model and standard k-ε model were also investigated to predict the turbulent combustion reaction, which indicated that the simulation results of velocities, temperatures and concentrations of combustion productions by the standard k-ε model were in good accordance with the experimental data. With the application of the simulation results to the experimental data to fit some important kinetic parameters in the equation of O atom model and revision of the equation later, this article obtained a new NO formation rate model. It has been proved that the prediction of the developed model coincides well with the measurements.     

钛酸酯偶联剂NDZ-3与3（CaO·A12O3）·CaSO4界面的XPS研究

借助X射线光电子能谱(XPS)定量地研究了钛酸酯偶联剂NDZ-3和3(CaO*Al2O3)*CaSO4 界面结合情况.结果表明:钛酸酯偶联剂NDZ-3的烷氧基与3(CaO*Al2O3)*CaSO4表面羟基产生化学反应,生成(Ti-O-M)[M=Al, Ca]化学键,这样钛酸酯偶联剂NDZ-3在3(CaO*Al2O3)*CaSO4表面形成偶联剂单分子层,使3(CaO*Al2O3)*CaSO4得到改性,因而改善了它与有机聚合物亲和性.     

La2O3助剂对甲烷干燥重整催化剂 Ni-γ-Al2O3支撑作用的研究简

The nature of support and type of active metal affect catalytic performance. In this work, the effect of using La203 as promoter and support for Ni/γ-A1203 catalysts in dry reforming of methane was investigated. The reforming reactions were carried out at atmosphenc pressure in the temperature range of 500-2700℃. The activity and stability of the catalyst, carbon formation, and syngas （H2/CO） ratio were determined. Various techniques were applied for characterization of both fresh and used catalysts. Addition of La2O3 to the catalyst matrix improved the dispersion of Ni and adsorption of CO2, thus its activity and stability enhanced.     

The Microstructure and Properties of Alumina—Rich Spinel and Its Products

The paper describes the effect of chemical composition on the microstructure and properties of spinel specimens synthesized from bauxite and magnesite,The alumina-rich spinel with higher ratio of Al2O3/MgO,with smaller spinel grain,contains more titaniferous mineral and silicate phase compared to the spinel with lower Al2O3/MgO ratio.In the products obtained from alumina-rich spinel and magnesite clinker,the ratio of Al2O3/MgO of spinel decreases,ti-taniferous mineral and silicate phase in the spinel aggregate are changed,and its content tends to degradation,contrasted with original alumina-rich spinel,The products have good high temperature properties.     

Study of the Corrosion of High Alumina Refractories by Al2O3-CaO Slag as a Reactive Impregnation Mechanism

The corrosion of refractories results from reactive transport,namely,transport of agents and chemical reactions of these agents with impregnated medium. On one hand,the transport involves either diffusion or impregnation depending on the state of the corrosive agents and the microstructure of the host media. On the other hand,chemical reactions may be very numerous and complex.This study focused on the reactive impregnation of Al2O3- CaO slag into porous high alumina refractory. The transport properties of the refractory material were identified by means of a dedicated capillary rising test. Chemical reactions between the solid high alumina skeleton and Al2O3- CaO slag involve successive dissolution / precipitation mechanisms forming aluminates of lime. Contrary to the thermodynamic properties of the binary system,the kinetics of these solid / liquid reactions is not well known.Corrosion tests associated with the quenching method,XRD analyses were performed for a better understanding of the kinetics. The results of this study open up a coupling approach for predicting the corrosion wear of refractory.     

The fouling properties of SiO_2–CaO–P_2O_5 system in high-temperature rotary kiln phosphoric acid process

Kiln phosphoric acid (KPA) technology could produce P_2O_5 with high purity and has been applied in thermal phosphoric acid industry;however the formation of fouling in the high-temperature rotary kiln restricts the stable and long-term operation.In this paper,the reaction of phosphate ores with gaseous P_2O_5 was investigated in a high-temperature reactor,and the Ca O–SiO_2–P_2O_5 ternary phase diagram was analyzed to understand the fouling formation mechanism.The results showed that the low-melting-point products,such as Ca(PO_3)_2and Ca_2P_2O_7,are responsible for the fouling in the KPA process.In addition,a small amount of impurities,e.g.,aluminum and iron,could facilitate the generation of the low-melting-point products and cause serious fouling.Based on the high-temperature SiO_2–P_2O_5 and CaO–SiO_2–P_2O_5 phase diagram analysis,the control of Si/Ca molar ratio(e.g.,Si/Ca=2.0) was found to avoid fouling formation in the kiln.These results could provide the operation parameters of reaction temperature and feeds composition to suppress the fouling in the kiln reactor for the phosphoric acid production in industry.     

矿物3CaO·3Al2O3·BaSO4 高温稳定性研究

矿物3CaO·3Al2O3·BaSO4是一种新型胶凝矿物, 而关于其高温稳定性的研究却有多种结论.本工作综合运用IR, TG-DT A,EPMA,XRD和QXDA等多种测试方法, 系统研究了3CaO·3Al2O3·BaSO4 的高温稳定性问题.研究表明, 在温度低于1 350 ℃的条件下, 矿物3CaO·3Al2O3·BaSO4的晶相结构稳定; 而温度高于1 360 ℃时, 3CaO·3Al2O3·BaSO 4发生分解并形成新的晶相.3CaO·3Al2O3·BaSO4的分解方程式可表述为: 3CaO·3Al2O3·BaSO4→CaO·Al2O3+12CaO·7Al2O3+Ba O·Al2O3+SO2↑+O2↑鉴于矿物BaO·Al2O3的形成机理与该问题紧密相关, 本文也讨论了BaO·Al2 O3的形成机理.BaO·Al2O3的形成机理有两种:温度低于1 350 ℃时, BaO·Al2O 3由原料组分发生反应而形成的; 而温度大于1 360 ℃时, 该矿物是由3CaO·3Al2O 3·BaSO4分解形成的.     

硫酸铁改性颗粒活性氧化铝除氟的等温线研究

The adsorption equilibrium of a fluoride solution on 1-2 mm granular activated alumina modified by Fe2(SO4)3 solution was investigated. The experiments were conducted using a wide range of initial fluoride concentrations (0.5 to 180 mg•L1 at pH ~7.0) and an adsorbent dose of 1.0 g•L1. The application of Langmuir and Freundlich adsorption isotherm models (linear and nonlinear forms) generally showed that a single Langmuir or Freundlich equation cannot fit the entire concentration gap. Experimental data on low equilibrium concentrations (0.1 to 5.0 mg•L1) was in line with both Langmuir and Freundlich isotherm models, whereas that of high equilibrium concentrations (5.0 to 150 mg•L1) was more in line with the Freundlich isotherm model. A new Langmuir- Freundlich function was used for the entire concentration gap, as well as for low and high concentrations.     

25℃下Na+,K+,Mg2+//Cl-,NO-3-H2O五元体系液固相平衡

The solubilities of the quinary system Na + ,K + ,Mg 2+ //Cl ,NO 3 -H2O and its two quaternary subsystems, Na + ,K + ,Mg 2+ //NO 3 -H2O and K + ,Mg 2+ //Cl ,NO 3 -H2O,were studied by isothermal method at 25°C and their phase diagrams were plotted.In the equilibrium phase diagram of quaternary system Na + ,K + ,Mg 2+ //NO 3 -H2O, there are one invariant point,three univariant curves and three regions of crystallization with one salt:NaNO3, KNO3 and Mg(NO3)2·6H2O.In the equilibrium phase diagram of quaternary system K + ,Mg 2+ //Cl ,NO 3 -H2O,there are three invariant points,seven univariant curves and five regions of crystallization with one salt:KNO3,KCl, Mg(NO3)2·6H2O,MgCl2·6H2O and KCl·MgCl2·6H2O.In the equilibrium phase diagram of the quinary system Na + , K + ,Mg 2+ //Cl ,NO 3 -H2O,there are four invariant points,and seven regions of crystallization with one salt:NaCl, KCl,NaNO3,KCl·MgCl2·6H2O,KNO3,MgCl2·6H2O and Mg(NO3)2·6H2O.     

硫酸水溶液中3-甲基吡啶透过Nafion膜的渗透

引　言Nafion膜是美国Dupont公司开发的一类全氟磺酸型阳离子交换膜, 由疏水性骨架与亲水性磺酸基团组成, 具有优良的离子选择透过性和化学稳定性, 广泛用于膜电解制碱工业. 在质子交换膜燃料电池、膜分离、有机电合成等领域的应用研究进展迅速[1~5]. 在直接燃料电池中, Nafio     

多孔介质中水合物生成与分解的电阻率性质

A new one-dimensional system for resistivity measurement for natural gas hydrate (NGH) exploitation is designed, which is used to study the formation and decomposition processes of NGH.The experimental results verify the feasibility of the measurement method, especially in monitoring the nucleation and growth of the NGH.Isovolumetric formation experiment of NGH is performed at 2 ℃ and 7.8 MPa.Before the NGH formation, the ini-tial resistivity is measured to be 4-7 Ω·m, which declines to the minimum value of 2-3 Ω·m when NGH begins to nucleate after the pressure is reduced to 3.3 MPa.As the NGH grows, the resistivity increases to a great extent, and finally it keeps at 11-13 Ω·m, indicating the completion of the formation process.The NGH decomposition ex-periment is then performed.When the outlet pressure decreases, NGH begins to decompose, accordingly, the resis-tivity declines gradually, and is at 5-9 Ω·m when the decomposition process ends, which is slightly higher than the resistivity value before the formation of NGH.The occurrence and distribution uniformity of NGH are determined by the distribution and magnitude of the resistivity measured on an one-dimensional sand-packed model.This study tackles the accurate estimation for the distribution of NGH in porous medium, and provides an experimental basis for further study on NGH exploitation in the future.     

流加操作与稀释添加耦合辅助高浓度变性蛋白质复性动力学

研究了流加操作与稀释添加耦合辅助高浓度变性还原溶菌酶的复性,建立了相关的过程动力学模型.利用三态复性的过程模型对实验数据进行了拟合,获得了较好的拟合效果.利用模型分析了复性过程的动力学特性,结果表明,两者耦合可在较低的盐酸胍浓度(1 mol•L^-1)存在下使较高浓度的（5 mg•ml^-1）变性溶菌酶获得80%以上的复性收率;并且发现添加剂乙酰胺的辅助复性作用与盐酸胍相同,降低盐酸胍浓度,适当提高乙酰胺浓度即可使聚集体生成速率常数最小,酶的复性收率最大;但甘油与盐酸胍具有协同作用,只有在适当的盐酸胍浓度下添加甘油才可获得理想的复性效果.     

苇浆CEH漂白废水的毒性及毒性排放负荷

采用发光细菌法对苇浆CEH三段漂白废水进行了毒性研究,其中C段废水的毒性最大,其EC₅₀为17.39%,属于强毒级别;E段、H段废水的EC₅₀分别为163.6%、252.4％,均属于无毒级别.苇浆CEH漂白工艺总毒性排放因子（TEF）为472.021 TU•m³•（吨浆）^-1,其中C段废水的毒性最大,其TEF为393.88 TU•m³•（吨浆）^-1,约占总量的83.45％,其次是E段废水,约占10.03％,H段最小,约占6.52％.     

PDMS/陶瓷复合膜用于正丁醇-水体系的渗透汽化分离

Pervaporation has attracted considerable interest owing to its potential application in recovering biobutanol from biomass acetone-butanol-ethanol (ABE) fermentation broth. In this study, butanol was recovered from its aqueous solution using a polydimethylsiloxane (PDMS)/ceramic composite pervaporation membrane. The effects of operating temperature, feed concentration, feed flow rate and operating time on the membrane pervaporation per-formance were investigated. It was found that with the increase of temperature or butanol concentration in the feed, the total flux through the membrane increased while the separation factor decreased slightly. As the feed flow rate increased, the total flux increased gradually while the separation factor changed little. At 40 C and 1% (by mass) butanol in the feed, the total flux and separation factor of the membrane reached 457.4 g•m2•h1 and 26.1, respec-tively. The membrane with high flux is suitable for recovering butanol from ABE fermentation broth.     

青铜在土壤中局部腐蚀过程的化学行为

用模拟闭塞电池法(O.C.)对青铜文物在模拟土壤溶液（0.028 mol•L^-1NaCl + 0.01 mol•L^-1Na₂SO₄+0.016 mol•L^-1NaHCO₃）中的腐蚀行为进行了研究,清楚地演示了青铜局部腐蚀过程中环境介质离子、阳极腐蚀产生的阳离子等物质的迁移、富集和沉积规律,得出铜的溶解因子f_Cu随通电时间的变化关系,即从最初锡的溶解速度大于铜的溶解速度逐渐演变为铜的溶解速度大于锡的溶解速度.闭塞区内的阳离子明显地向主体溶液中迁移.     

含酚废水处理的吸附和臭氧氧化动力学模型

A three phase fluidized bed reactor was used to investigate the combined effect of adsorption and oxidation for phenolic wastewater treatment.Aqueous solutions containing 10 mg·L 1of phenol and ozone were continuously fed co-currently as upward flow into the reactor at constant flow rate of 2 and 1 L·min1,respectively.The phenolic treatment results in seven cases were compared:(a)O3 only,(b)fresh granular activated carbon(GAC),(c) 1st reused GAC,(d)2nd reused GAC,(e)fresh GAC enhanced with O3,(f)1st reused GAC enhanced with O3,and (g)2nd reused GAC enhanced with O3.The phenolic wastewater was re-circulated through the reactor and its concentration was measured with respect to time.The experimental results revealed that the phenolic degradation using GAC enhanced with O3 provided the best result.The effect of adsorption by activated carbon was stronger than the effect of oxidation by ozone.Fresh GAC could adsorb phenol better than reused GAC.All cases of adsorption on GAC followed the Langmuir isotherm and displayed pseudo second order adsorption kinetics.Finally,a differential equation for the fluidized bed reactor model was used to describe the phenol concentration with respect to time for GAC enhanced with O3.The calculated results agree reasonably well with the experimental results.     

A2O工艺中反硝化除磷及过量曝气对生物除磷的影响

如何有效提高城市污水厂除磷效率一直是研究的热点,而反硝化除磷菌可以在碳源不足的条件下,通过“一碳两用”的方式同时实现反硝化脱氮和吸磷作用,是一种新型高效的技术.试验以啤酒废水为研究对象,验证了厌氧-缺氧-好氧（A²O）工艺中反硝化除磷现象的存在及其对系统脱氮除磷的影响.试验结果表明,A²O系统稳定运行时,反硝化聚磷菌在缺氧区可利用在厌氧段储存的PHB大量吸磷,同时氮也得到去除,计算表明缺氧除磷量可占厌氧总释磷量的71.3%,另外可节约曝气能耗25%.无论系统进水COD浓度从200 mg•L^-1变化为400 mg•L^-1,COD、总氮和总磷去除率总能保持较高水平,平均出水总氮和总磷浓度分别小于10 mg•L^-1和0.30 mg•L^-1.另外发现,过量曝气对系统除磷具有明显的影响,导致除磷效率降低,甚至会产生不吸磷现象,系统需要经过约一个污泥龄时间才能恢复其吸磷能力,所以应加强系统曝气的控制.