首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到18条相似文献,搜索用时 156 毫秒
1.
含碳铬团块熔融还原的实验室研究   总被引:2,自引:0,他引:2  
为预测工业性试验时铬团块的高温还原速度,对含碳铬团块进行了熔融还原的实验室研究,试验了熔池温度,铬团块的预热对还原速度的影响,并与文献数据进行对比,附带对不同预还原度的巴西氧化铁球团进行了高温下碳还原的试验。  相似文献   

2.
通过含碳铬铁矿粉矿成球及还原实验,研究还原温度、内配碳量、还原时间和添加剂对铬铁矿球团预还原结果的影响.结果表明:还原温度和内配碳量对预还原球团的金属化指标影响非常明显,温度高于1200℃时,铬铁矿预还原球团的金属化指标开始明显增加,内配碳比Ic/o=1.2为铬铁矿预还原球团的较佳配比;高温(≥1 300℃)时,可实现含碳铬铁矿球团的快速还原(f≤1 h);低温时,铁优先于铬还原,总还原反应完成时间需3~4 h.添加剂强化含碳铬铁矿球团预还原的实验结果表明,不同添加剂对还原反应的影响具有较大差异;不同温度下,相同添加剂的催化能力也有一定的差异;实验所涉及的添加剂中以NaCl、Na2B4O7·10H2O和Na2CO3的催化效果较好.  相似文献   

3.
含碳球团还原过程动力学及模型   总被引:9,自引:0,他引:9  
本文研究了不同条件下含碳球团在N_2气氛中的还原过程.结果发现,球团中心的还原速度大于其边缘速度,固相反应Fe_xO_y+yC=xFe+yCO不是含碳球团还原过程的主要反应;以往的含碳球团还原过程模型不能正确地描述其反应过程.本文提出了含碳球团还原过程的新观点,并以此观点为基础建立了含碳球团还原过程模型,试验证明该模型能很好地描述含碳球团的还原过程.  相似文献   

4.
吴光亚 《上海金属》1994,16(3):20-24
研究开发了冷固结含碳铁矿球团的还原工艺,它与环形转底炉相结合,形成快速直接还原新工艺,生产金属此球团,具有一系列优点,如:设备简单,生产效率高、能耗低等等。  相似文献   

5.
含碳球团还原过程中反应分数,还原度和金属化率的关系   总被引:2,自引:0,他引:2  
推导了含碳球团的反应分数、还原度和金属化率间的关系。根据这些关系处理失重试验的数据可确定含碳球团中金属Fe、FeO、Fe2O3的变化。  相似文献   

6.
Li2CO3在含碳球团还原中催化机理的研究   总被引:4,自引:0,他引:4  
通过在氧化铁中添加碳粉和少量Li2CO3添加剂,考察了碱金属化合物和温度对含碳才还原过程的影响,探讨了碱金属化合物的催化机理,实验结果表明,球团还原率随着碱金属化合物添加量而增大,但增大幅度随添加剂增多,温度升高而减小,在球团还原初期,Boudouard反应是还原的限制环节,添加Li2CO3可以降低反应活化能,较高温度下还原后期,氧化铁的气相还原是反应的限制性环节,添加Li2Co3可以加快Fe/F  相似文献   

7.
Li_2CO_3在含碳球团还原中催化机理的研究   总被引:1,自引:0,他引:1  
通过在氧化铁中添加碳粉和少量Li2CO3添加剂,考察了碱金属化合物和温度对含碳球团还原过程的影响,探讨了减金属化合物的催化机理,实验结果表明,球团还原车随着碱金属化合物添加量而增大,但增大幅度随添加剂增多、温度升高而减小在球团还原初期,Boudouard反应是还原的限制环节,添加Li2CO3可以降低反应活化能较高温度下球团还原后期,氧化铁的气相还原是反应的限制性环节,添加Li2CO3可以加快Fe/FeO界面上FeO的还原反应,实验条件范围内,温度升高和Li2CO3添加量增加,促进反应限制环节从Boudouard反应向氧化铁还原的转化  相似文献   

8.
电弧炉粉尘球团直接还原的热传导模型   总被引:1,自引:0,他引:1  
对电弧炉炼钢粉尘加上还原剂碳混合制粒成的球团还原过程的热传导行为进行了研究,根据实验推导了球团导热模型的结构参数,并试图建立热传导模型。  相似文献   

9.
王元荪 《上海金属》2006,28(4):63-64
1在利用煤和细矿的炼铁过程中回收含铁粉尘和淤泥的装置和方法;2一种防止热轧钢带扁卷的卷取方法;3含碳球团自热熔融还原的方法.  相似文献   

10.
在实验室条件下研究了Na_2CO_3对硼铁矿含碳球团还原熔分行为、脱硫率以及熔分富硼渣性能的影响。Na_2CO_3在一定程度上可以提高硼铁矿含碳球团的还原速率。随着Na_2CO_3配比的增加,含碳球团的熔分效果逐渐变差,主要原因在于Na_2CO_3会显著提高富硼渣的熔点,导致球团难以熔分。当球团中Na_2CO_3的质量分数从0增加至6%时,珠铁中的硫含量(质量分数)逐渐从0.27%降低至0.084%。与此同时,缓冷富硼渣的萃取率从86.46%降低至59.52%。实验结果表明,Na_2CO_3的加入会对硼铁矿含碳球团的熔分效果和富硼渣中硼的提取产生不利影响。  相似文献   

11.
1. Introduction Iron carbide has some advantages over products of direct reduction iron and has been put into production in industrial scale[1,21, however, the present process only uses natural gas and hematite as material to prepare iron carbide, which has a great limit to the source of kind of reactant gas and iron ore. In recent years, people have done some investigations on preparation of iron carbide using other kind of reactant gas. For example, Hayashi et al[~1 made some investigation …  相似文献   

12.
The reduction behavior of iron ore pellets containing carbon under non-isothermal condition in the temperature range from 573 to 1373K has been investigated in a laboratory scale setup. The test results show that carbon content has no obvious effect on reduction degree of composite pellets (C/O mole ratio=1.0) by CO in the temperature range from 575 to 1373K under linear temperature-rising program; reduction degree of iron ore pellets containing carbon is larger in 90%CO-10%CO2 mixture than that of in 100%CO atmosphere or in 80%CO-20%CO2 mixture; the s type temperature-rising program has a better effect than that of linear one to increase the reduction degree; and reduction degree of slower linear temperature-rising program is greater than that of faster one, but the final reduction degrees, i.e., those at the highest temperature are about same for various CO partial pressures or temperature-rising programs. The kinetic analysis also shows that the reduction of iron ore-carbon composite pellets by CO or CO-CO2 mixture under non-isothermal condition should be controlled 6y surface reaction, and the apparent reduction activation energy changes with the reduction progress under various test conditions.  相似文献   

13.
钒钛磁铁矿熔融还原速度研究   总被引:2,自引:0,他引:2  
用铁浴法对钒钛磁铁矿在高温熔态下还原动力学进行了研究。结果表明:钒钛磁铁矿熔融还原速度有三个高峰期,而普通海南矿则只有一个高峰期,在相同条件下,钒钛磁铁矿熔融还原速度低于海南矿的还原速度;铁浴量增加,还原速度明显增高,提出了钒钛磁铁矿在有铁浴和无铁浴条件下熔融还原反应速度方程。  相似文献   

14.
1.IntroductionItisimportanttoinvestigatethekineticsofreductionofironoxideinslagswithcarbonsaturatedinmoltenironforunderstandingboththeslag-metalreactioninthehearthofblastfurnaceandthefinalreductionbehavioursofprereductionironorepelletscontainingcarboninironbathreactor.Theprevious.......h..sll--7]focusedtheirattentionsmainlyonthereductionrateofpureironoxideortheredlltionrateofironoxideinsimpleslags.Thoseresultsarenotconsistentwiththatoftilerealsituation.Throughanalyzinggascompositionattheoutlet…  相似文献   

15.
周取定  郭春泰 《金属学报》1986,22(6):95-102
本文研究了碱金属和氟或两者综合,以及它们的不同存在状态对球团矿还原膨胀的影响。在模拟包钢工业球团的碱金属和氟含量的条件下,通过分步还原,发现球团矿的异常还原膨胀主要发生在第一还原阶段,并出现了严重的铁氧化物晶体开裂。只有在含碱金属特高的样品中在第三还原阶段出现严重的铁须。此外还研究了碱金属和氟对球团矿渣相热稳定性的影响.采用x射线衍射及Mossbauer谱分析了碱金属在铁氧化物不同还原阶段的赋存状态及其对它们的晶体结构的影响,借助于TDA对含碱金属铁氧化物的还原进行动力学分析,提出了碱金腻导致铁氧化物晶体开裂及铁须生长的机理模型。  相似文献   

16.
This paper studied the changing principles of carbon content in direct reduction iron (DRI) and liquid iron in the COREX melting gasifier. Under the normal working conditions of experimental equipment, liquid nitrogen was poured into the melting gasifier from its tuyere to cool down quickly. And then seven cross sections were made to study the carburization reaction and its characteristics of the solid iron and the liquid iron, and also the reaction of carbon between the slag and the metal. According to the results, the influences of the thickness of the semi-coke layer and the temperature on the carbon content of liquid iron in the COREX melting gasifier were confirmed.  相似文献   

17.
This paper presents the effects of chemical compositions of austempered ductile iron (ADI) on casting quality,heat treatment process parameters and mechanical properties of final products.Through exper...  相似文献   

18.
A comparative study was made of the reduction kinetics for high temperature smeltingof vadium-titanium-containing magnetite,together with Hainan iron ore,using iron bathmethod.Three peaks were revealed on the reduction rate curves for the magnetite,whileone peak only for Hainan ore.Under the same conditions,the smelting reduction rateof the magnetite was found to be lower than that of Hainan ore.The rate increasesevidently with the increase of the bath volume.The expressions of smelting reductionrate were suggested for the reduction with and without iron bath respectively.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号