Comparative evaluation of a phage protein ligand assay with real-time PCR and a reference method for the detection of Escherichia coli O157:H7 in raw ground beef and trimmings

Enterohemorrhagic Escherichia coli O157:H7 is an important pathogen associated with infections caused by consumption of undercooked raw meat. Sensitive and rapid detection methods for E. coli O157:H7 are essential for the meat industry to ensure a safe meat supply. This study was conducted to compare the sensitivity of the VIDAS ultra performance E. coli test (ECPT UP) with a noncommercial real-time (RT) PCR method and the U.S. Department of Agriculture, Food Safety and Inspection Service (USDA-FSIS) reference method for detecting E. coli O157:H7 in raw ground beef. Optimal enrichment times and the efficacy of testing different types of raw meat, either as individual samples (25 g) or as composites (375 g), were examined. For 25-g samples of each type of raw ground beef tested, 6 h of enrichment was sufficient for both the VIDAS ECPT UP and RT-PCR methods, but for 375-g samples, 24 h of enrichment was required. Both the VIDAS ECPT UP and RT-PCR methods produced results similar to those obtained with the USDA-FSIS reference method after 18 to 24 h of enrichment. The primer specificity of the RT-PCR assay and the highly specific phage ligand used in the VIDAS ECPT UP for target recognition enabled the detection of low levels of E. coli O157:H7 in 25 g of various types of raw ground beef. The tests also allowed the detection of E. coli O157:H7 in composite raw ground beef and trimmings in samples of up to 375 g.     

Application of a multiplex PCR for the simultaneous detection of Escherichia coli O157:H7, Salmonella and Shigella in raw and ready-to-eat meat products

Escherichia coli O157:H7, Salmonella and Shigella might contaminate similar types of meat products and cause deadly diseases in humans. Traditional microbiological analyses to detect these pathogens are labor-intensive and time-consuming. The objective of this study was to apply a multiplex PCR for simultaneous detection of the pathogenic bacteria in certain raw and ready-to-eat meat matrices. The tested samples had aerobic plate counts ranging from non-detectable, in chicken nuggets and salami, to 8.36log(10)CFU/g in ground pork. The pH of homogenates spanned from 6.86, in ground beef, to 7.17 in salami. Following a 24-h enrichment, the multiplex PCR assay could concurrently detect the three pathogens at 0.2log(10)CFU/g in ground beef, roast beef, beef frankfurters, chicken nuggets, salami and turkey ham, and 1.2log(10)CFU/g in ground pork. This multiplex PCR offers an efficient microbiological tool for presumptive detection of E. coli O157:H7, Salmonella and Shigella in meat.     

Detection of Escherichia coli O157:H7 in 10- and 25-gram ground beef samples with an evanescent-wave biosensor with silica and polystyrene waveguides

A portable evanescent-wave fiber-optic biosensor was used to detect Escherichia coli O157:H7 in seeded 10- and 25-g ground beef samples. The biosensor works by launching light from a 635-nm laser diode into specially designed optical fiber probes, generating an evanescent field that extends approximately 1,000 nm from the fiber surface. Fluorescent molecules within the evanescent field are excited, and a portion of their emission recouples into the fiber probe. The return path emission is transported by an optical fiber to a photodiode within the biosensor that detects and quantifies the fluorescent signal. A sandwich immunoassay was performed on the fiber probes with cyanine 5 dye-labeled polyclonal anti-E. coli O157:H7 antibodies for generation of the specific fluorescent signal. Biotin-streptavidin interactions were used to attach polyclonal anti-E. coli O157:H7 antibodies to the surface of the fiber probe. A centrifugation method was developed to obtain samples suitable for biosensor analysis from 10- and 25-g ground beef samples. The assay was shown to be sensitive and repeatable. One hundred percent correct identification of positive samples was demonstrated at 9.0 x 10(3) CFU/g for 25-g ground beef samples with silica waveguides and at 5.2 x 10(2) CFU/g for 10-g ground beef samples with polystyrene waveguides. The reaction was highly specific. No false positives were observed for 10-g ground beef samples not spiked with the pathogen. In addition, when samples were spiked with high concentrations of a variety of non-E. coli O157:H7 organisms, no false positives were observed. The method was rapid, with results being obtained within 25 min of sample processing.     

The use of a fluorescent bacteriophage assay for detection of Escherichia coli O157:H7 in inoculated ground beef and raw milk.

The objective of this study was to develop a fluorescent bacteriophage assay (FBA) for the detection of E. coli O157:H7 in ground beef and raw milk. The FBA is a two step assay that combines immunomagnetic separation, to separate the target organism from mixed culture, with a highly specific fluorescently stained bacteriophage to label the E. coli O157:H7 cells. When used in conjunction with flow cytometry, the FBA was able to detect 2.2 CFU/g of artificially contaminated ground beef following a 6 h enrichment. Between 10(1) and 10(2) CFU/ml of artificially contaminated raw milk were detectable after a 10 h enrichment step. The results show that the FBA is potentially useful as a rapid technique for the preliminary detection of E. coli O157:H7 in food.     

Validation of time and temperature values as critical limits for the control of Escherichia coli O157:H7 during the production of fresh ground beef

In order to provide beef processors with valuable data to validate critical limits set for temperature during grinding, a study was conducted to determine Escherichia coli o157:H7 growth at various temperatures in raw ground beef. Fresh ground beef samples were inoculated with a cocktail mixture of streptomycin-resistant E. coli O157:H7 to facilitate recovery in the presence of background flora. Samples were held at 4.4, 7.2, and 10 degrees C, and at room temperature (22.2 to 23.3 degrees C) to mimic typical processing and holding temperatures observed in meat processing environments. E. coli O157:H7 counts were determined by direct plating onto tryptic soy agar with streptomycin (1,000 microg/ml), at 2-h intervals over 12 h for samples held at room temperature. Samples held under refrigeration temperatures were sampled at 4, 8, 12, 24, 48, and 72 h. Less than one log of E. coli O157:H7 growth was observed at 48 h for samples held at 10 degrees C. Samples held at 4.4 and 7.2 degrees C showed less than one log of E. coli O157:H7 growth at 72 h. Samples held at room temperature showed no significant increase in E. coli O157:H7 counts for the first 6 h, but increased significantly afterwards. These results illustrate that meat processors can utilize a variety of time and temperature combinations as critical limits in their hazard analysis critical control point plans to minimize E. coli O157:H7 growth during the production and storage of ground beef.     

Growth of Escherichia coli O157:H7 in raw ground beef stored at 10 degrees C and the influence of competitive bacterial flora,strain variation,and fat level

Pure-culture broth-based models of the growth of Escherichia coli O157:H7 have been used to estimate its behavior in ground beef, even though these models have not been adequately validated for this food product. This situation limits accurate estimates of the behavior of E. coli O157:H7 in ground beef and introduces uncertainties in risk assessments. In the present study, the growth of single and multiple strains of E. coli O157:H7 were measured in retail ground beef stored at 10 degrees C for up to 12 days, and the results were compared with estimates generated by the U.S. Department of Agriculture's Pathogen Modeling Program (PMP; version 5.1). At pH 5.9, the PMP predicted a maximum population density (MPD) of 9.13 log10 CFU/g, an exponential growth rate (EGR) of 0.052 log10 CFU/h, and a lag time of 56.3 h. Similar parameter values were observed for sterilized ground beef; however, no lag phase was observed. In contrast, the mean MPD and EGR for retail ground beef were 5.09 log10 CFU/g and 0.019 log10 CFU/h, respectively, and no lag phase was observed. Both the EGR and the MPD increased with decreasing fat levels. There was low variation in the MPD and EGR parameters for the nine E. coli O157:H7 ground beef isolates. Two isolates of competitive native flora were separately added to sterilized ground beef, and the EGR and MPD decreased as the ratio of competitive flora to E. coli O157:H7 increased. For one strain, at ratios of 1:1, 10:1, and 100:1, the EGRs were 0.033, 0.025, and 0.018 log10 CFU/h, respectively, and the MPDs were 6.14, 5.08, and 4.84 log10 CFU/g, respectively. These results demonstrate that existing broth-based models for E coli O157:H7 must be validated for food and that models should consider the effects of the food matrix, the competitive microflora, and potential pathogen strain variation.     

Rapid and simultaneous quantitation of Escherichia coli 0157:H7, Salmonella, and Shigella in ground beef by multiplex real-time PCR and immunomagnetic separation

The objective of this study was to establish a multiplex real-time PCR for the simultaneous quantitation of Escherichia coli O157:H7, Salmonella, and Shigella. Genomic DNA for the real-time PCR was extracted by the boiling method. Three sets of primers and corresponding TaqMan probes were designed to target these three pathogenic bacteria. Multiplex real-time PCR was performed with TaqMan Universal PCR Master Mix in an ABI Prism 7700 Sequence Detection System. Final standard curves were calculated for each pathogen by plotting the threshold cycle value against the bacterial number (log CFU per milliliter) via linear regression. With optimized conditions, the quantitative detection range of the real-time multiplex PCR for pure cultures was 10(2) to 10(9) CFU/ml for E. coli O157:H7, 10(3) to 10(9) CFU/ml for Salmonella, and 10(1) to 10(8) CFU/ml for Shigella. When the established multiplex real-time PCR system was applied to artificially contaminated ground beef, the detection limit was 10(5) CFU/g for E. coli O157:H7, 10(3) CFU/g for Salmonella, and 10(4) CFU/g for Shigella. Immunomagnetic separation (IMS) was further used to separate E. coli O157:H7 and Salmonella from the beef samples. With the additional use of IMS, the detection limit was 10(3) CFU/g for both pathogens. Results from this study showed that TaqMan real-time PCR, combined with IMS, is potentially an effective method for the rapid and reliable quantitation of E. coli 0157:H7, Salmonella, and Shigella in food.     

Incidence of Escherichia coli O157:H7 in frozen beef patties produced over an 8-hour shiftt

A ground beef patty processor detected Escherichia coli O157:H7 in five production lots during routine testing with polymerase chain reaction (PCR) technology. This finding stimulated research to determine the incidence and potential entry points of the pathogen during processing. One of these lots (53,960 kg) was divided into 71 pallets (760 kg each) of food service ground beef patties. Ten cartons (19 kg each) were removed from each pallet, for a total of 710 cartons. Four patties were taken from each carton and subdivided to provide comparable samples for E. coli O157:H7 analyses by three different laboratories. Two laboratories employed different immunoassay tests, and one used PCR to screen samples. One sample set was analyzed for aerobic plate, coliform, and E coli Biotype I counts to determine if any relationship existed between these microbial groups and the incidence of E. coli O157:H7. For 73 samples, presumptive positive results for E. coli O157:H7 were obtained by one or more methods. For 48 of these 73 samples, positive results for the pathogen were culture confirmed. The largest number (29) of culture-confirmed positive E. coli O157:H7 results were detected by PCR. Most positive results were obtained during a short segment of processing. All culture-confirmed E. coli O157:H7 strains were further characterized by two genetic subtyping techniques, resulting in two to four different patterns, depending on the subtyping procedure employed. For any sample tested, the aerobic plate count was < 3.0 log CFU/g, and coliform and E. coli Biotype I counts were < or = 1.00 log CFU/g. The results of this study suggest that most positive samples were associated with a contaminated batch of raw material introduced just before the 1725- to 1844-h processing segment. These results also indicate that more aggressive sampling plans and genetic screening technologies such as PCR may be used to better detect low levels of E. coli O157:H7 in ground beef products.     

Effects of using reduced volumes of nonselective enrichment medium in methods for the detection of Escherichia coli O157:H7 from raw beef

Recent work from our laboratory revealed that tryptic soy broth (TSB) was a superior enrichment medium for use in test-and-hold Escherichia coli O157:H7 methods at levels down to a ratio of three volumes of medium to one volume of sample. Lower ratios were examined for their effect on results obtained from culture isolation, the BAX E. coli O157:H7 MP assay, and the Assurance GDS E. coli O157:H7 assay. Ground beef and boneless beef trim were inoculated with a high level (170 CFU/65 g of ground beef and 43 CFU/65 g of trim) and a low level (17 CFU/65 g of ground beef and 4 CFU/65 g of trim) of E. coli O157:H7 and enriched in 3, 1, 0.5, and 0 volumes of TSB. The volume of TSB used did not affect E. coli O157:H7 detection by culture isolation, Assurance GDS detection in ground beef or trim, or the BAX MP assay detection in ground beef. However, BAX MP assay detection of E. coli O157:H7 in beef trim was 50, 42, and 33% positive when enrichment volumes of 0.5x, 1x, and 3x, respectively, were used. Optimum results with all methods were obtained using 1 volume of TSB. We concluded that detection test results can be considered valid as long as enrichment medium is used, even when it is less than the specified 3 or 10 volumes.     

Antimicrobial and antioxidant activities of natural extracts in vitro and in ground beef

Inhibition of Escherichia coli O157:H7, Salmonella Typhimurium, and Listeria monocytogenes by grape seed extract (ActiVin) and pine bark extract (Pycnogenol) and the effect of these natural extracts on the oxidative stability of raw ground beef were studied. In an agar dilution test, the MICs of ActiVin and Pycnogenol were determined to be 4.0 mg/ml for 4.43 log CFU per plate of E. coli O157:H7 and 4.0 mg/ml for 4.38 log CFU per plate of L. monocytogenes. In an inhibition curve test, populations of E. coli O157:H7, Salmonella Typhimurium, and L. monocytogenes fell to below the detection limit (10 CFU/ml) after 16 h of incubation. The numbers of E. coli O157:H7, L. monocytogenes, and Salmonella Typhimurium declined by 1.08, 1.24, and 1.33 log CFU/g, respectively, in raw ground beef treated with 1% Pycnogenol after 9 days of refrigerated storage. ActiVin (1%) and oleoresin rosemary (1%) resulted in an approximately 1-log CFU/g reduction in the populations of all three pathogens after 9 days. The addition of 1% ActiVin and Pycnogenol contributed to the maintenance of an acidic pH of 5.80 and 5.58, respectively, in raw ground beef. Compared to the control, all treatments increased in L* (lightness), with the exception of ActiVin. ActiVin and oleoresin rosemary had the highest a* (redness) and b* (yellowness) values, respectively. ActiVin most effectively retarded lipid oxidation, followed by Pycnogenol. The results suggest that these natural extracts have potential to be used with other preservative methods to reduce pathogenic numbers, lipid oxidation, and color degradation in ground beef.     

Rapid detection of Escherichia coli O157:H7 by immunomagnetic separation and real-time PCR

A method combining immunomagnetic separation (IMS) and real-time (5'-nuclease) PCR was developed to detect Escherichia coli O157:H7. Monoclonal antibody specific for the E. coli O157 antigen was added to protein A-coated magnetic particles to create antibody-coated beads. The beads specifically captured E. coli O157:H7 from bacterial suspensions. The cells were eluted from the beads and lysed by heating; the eluate was then assayed by real-time PCR, using primers and probe specifically targeting the eaeA gene of E. coli O157:H7. Approximately 50% of the cells in suspension were captured by the beads and detected by real-time PCR. No cross-reactivity was detected when other strains of E. coli were tested. This method was applied to detect E. coli O157:H7 from ground beef. Both cell capture efficiency and real-time PCR efficiency were reduced by meat-associated inhibitors. However, we were still able to detect up to 8% of E. coli O157:H7 from inoculated ground beef samples. The detection sensitivity varied among ground beef samples. The minimum detection limit was <5x10(2) cells ml(-1) for suspensions of E. coli O157:H7 in buffer and 1.3x10(4) cells g(-1) for E. coli O157:H7 in ground beef. The combination of IMS and real-time PCR results in rapid, specific and quantitative detection of E. coli O157:H7 without the need for an enrichment culture step.     

Predicting pathogen growth during short-term temperature abuse of raw pork, beef, and poultry products: use of an isothermal-based predictive tool

A computer-based tool (available at: www.wisc.edu/foodsafety/meatresearch) was developed for predicting pathogen growth in raw pork, beef, and poultry meat. The tool, THERM (temperature history evaluation for raw meats), predicts the growth of pathogens in pork and beef (Escherichia coli O157:H7, Salmonella serovars, and Staphylococcus aureus) and on poultry (Salmonella serovars and S. aureus) during short-term temperature abuse. The model was developed as follows: 25-g samples of raw ground pork, beef, and turkey were inoculated with a five-strain cocktail of the target pathogen(s) and held at isothermal temperatures from 10 to 43.3 degrees C. Log CFU per sample data were obtained for each pathogen and used to determine lag-phase duration (LPD) and growth rate (GR) by DMFit software. The LPD and GR were used to develop the THERM predictive tool, into which chronological time and temperature data for raw meat processing and storage are entered. The THERM tool then predicts a delta log CFU value for the desired pathogen-product combination. The accuracy of THERM was tested in 20 different inoculation experiments that involved multiple products (coarse-ground beef, skinless chicken breast meat, turkey scapula meat, and ground turkey) and temperature-abuse scenarios. With the time-temperature data from each experiment, THERM accurately predicted the pathogen growth and no growth (with growth defined as delta log CFU > 0.3) in 67, 85, and 95% of the experiments with E. coli 0157:H7, Salmonella serovars, and S. aureus, respectively, and yielded fail-safe predictions in the remaining experiments. We conclude that THERM is a useful tool for qualitatively predicting pathogen behavior (growth and no growth) in raw meats. Potential applications include evaluating process deviations and critical limits under the HACCP (hazard analysis critical control point) system.     

Rapid detection of Escherichia coli O157:H7 inoculated in ground beef,chicken carcass,and lettuce samples with an immunomagnetic chemiluminescence fiber-optic biosensor

A biosensor was evaluated with regard to its usefulness in the rapid detection of Escherichia coli O157:H7 inoculated in ground beef, chicken carcass, and romaine lettuce samples. The biosensor consisted of a chemiluminescence reaction cell, a fiber-optic light guide, and a luminometer linked to a personal computer in conjunction with immunomagnetic separation. The samples inoculated with E. coli O157:H7 were first centrifuged and suspended in buffered peptone water and then incubated with anti-E. coli O157 antibody-coated magnetic beads and horseradish peroxidase (HRP)-labeled anti-E. coli O157 antibodies to form antibody-coated bead-bacterium-HRP-labeled antibody sandwich complexes. Finally, the sandwich complexes were separated from the samples in a magnetic field and reacted with luminol in the reaction cell. The number of E. coli O157:H7 cells was determined by collecting the HRP-catalyzed chemiluminescence signal from the bead surface through a fiber-optic light guide and measuring the signal with a luminometer. The chemiluminescence biosensor was specific for E. coli O157:H7 in samples containing other bacteria, including Salmonella Typhimurium, Campylobacter jejuni, and Listeria monocytogenes. The chemiluminescence signal was linear on a log scale from 10(2) to 10(5) CFU of E. coli O157:H7 per ml in samples. Detection could be completed within 1.5 h without any enrichment. The detection limits for ground beef, chicken carcass, and lettuce samples were 3.2 x 10(2), 4.4 x 10(2), and 5.5 x 10(2) CFU of E. coli O157:H7 per ml, respectively.     

Bactericidal effects of Lactobacillus reuteri and allyl isothiocyanate on Escherichia coli O157:H7 in refrigerated ground beef

Two naturally occurring antimicrobial agents were tested in packages of refrigerated ground beef for their ability to reduce the viability of Escherichia coli O157:H7 during storage. Allyl isothiocyanate (AITC) and Lactobacillus reuteri were tested separately and together for their action against a cocktail of five strains of E. coli O157:H7 in ground beef held at 4 degrees C for 25 days. Ground beef prepared from whole, raw inside round beef roasts was inoculated with low (3 log CFU/g) or high (6 log CFU/g) levels of the E. coli O157:H7 mixture. The beef was treated with AITC (about 1,300 ppm), L. reuteri, or both, along with 250 mM of glycerol per kg of meat at two levels (3 and 6 log CFU/g) and according to a design that yielded 8 controls plus 10 different treatments. Samples were analyzed for E. coli O157:H7 survivors, numbers of total bacteria, and lactic acid bacteria on days 0 to 25 at 5-day intervals. L. reuteri at both input levels with glycerol killed E. coli O157:H7 at both inoculated levels before day 20. AITC completely eliminated E. coli O157:H7 at the low-inoculum level (3 log CFU/g) and reduced viability >4.5 log CFU/g at the high-inoculum level (6 log CFU/g) by the end of the storage period. The combination of L. reuteri and AITC did not yield an additive effect against E. coli O157:H7 viability. L. reuteri in the presence of glycerol was highly effective against E. coli O157:H7 in ground beef during refrigerated storage (4 degrees C) in modified atmosphere packages. Sensory testing is planned to evaluate effects of treatments.     

Evaluation of Escherichia coli O157:H7 growth media for use in test-and-hold procedures for ground beef processing

Since the mid-1990s, the beef industry has used a process called test and hold, wherein beef trim and ground beef are tested to keep products contaminated with Escherichia coli O157:H7 out of commerce. Current O157:H7 detection methods rely on a threshold level of bacterial growth for detection, which is dependent on the growth medium used. Twelve media were examined for growth and doubling time: buffered peptone water (BPW), SOC (which contains tryptone, yeast extract, KCl, MgCl2, and glucose), buffered peptone water plus SOC (BPW-SOC), Bacto-NZYM, RapidChek E. coli O157:H7 medium, BioControl EHEC8 culture medium, Neogen Reveal for E. coli O157:H7--Eight Hour medium (Neogen Reveal 8), BAX System medium for E. coli O157:H7 (BAX) BAX System medium for E. coli O157:H7 MP (BAX-MP), modified E. coli broth, nutrient medium, and tryptic soy broth (TSB). All media were tested at 37 or 42 degrees C under static or shaking conditions. The eight media with the highest total CFU per milliliter and most rapid doubling times were BPW-SOC, NZYM, RapidChek, EHEC8, Neogen Reveal 8, BAX, BAX-MP, and TSB. The ability of these eight media to enrich E. coli O157:H7 in ground beef was further evaluated through time-course experiments using immunomagnetic separation. Of these media, TSB was the easiest to prepare, had a wide application base, and was the least expensive. In the test-and-hold process, the normal ratio of medium to product is 1:10. In this study, a 1:3 ratio worked as well as a 1:10 ratio. Processors using test-and-hold procedures could use 1 liter of TSB to enrich for E. coli O157:H7 in a 375-g sample instead of the usual 3.375 liters, thus saving reagents, time, and labor while maintaining accuracy.     

Comparison of methods for detection and isolation of cold- and freeze-stressed Escherichia coli O157:H7 in raw ground beef

A comparison was made of the relative efficiencies of three enrichment media, RapidChek Escherichia coli O157:H7 enrichment broth (REB), R&F broth (RFB), and modified E. coli broth containing novobiocin (mEC+n), and four selective plating media for detection of cold- and freeze-stressed E. coli O157:H7 in raw ground beef. Ground beef (25 g) was inoculated with E. coli O157:H7 at < or =0.5 and < or =2 CFU/g, and samples were then enriched immediately or were stored at 4 degrees C for 72 h or at -20 degrees C for 2 weeks and then enriched. After 8 or 20 h of enrichment, the cultures were plated onto R&F E. coli O157: H7 chromogenic plating medium, cefixime-tellurite sorbitol MacConkey agar, CHROMagar O157, and Rainbow agar O157 and tested using the RapidChek E. coli O157 lateral flow immunoassay and a multiplex PCR assay targeting the E. coli O157: H7 eae, stx1, and stx2 genes. Recovery of E. coli O157:H7 on the four agar media was 4.0 to 7.9 log CFU/ml with the REB enrichment, 1.4 to 7.4 log CFU/ml with RFB, 1.7 to 6.7 log CFU/ml with mEC+n incubated at 42 degrees C, and 1.3 to 3.3 log CFU/ml from mEC+n incubated at 35 degrees C. The percentages of positive ground beef samples containing nonstressed, cold-stressed, and freeze-stressed E. coli O157:H7 as obtained by plating, the immunoassay, and the PCR assay were 97, 88, and 97%, respectively, with REB, 92, 81, and 78%, respectively, with RFB, 97, 58, and 53%, respectively, with mEC+n incubated at 42 degrees C, and 22, 31, and 25%, respectively, with mEC+n incubated at 35 degrees C. Logistic regression analyses of the data indicated significant main effects of treatment, type of medium, enrichment time, inoculum concentration, and detection method. In particular, a positive result was 1.1 times more likely to occur after 20 h of enrichment than after 8 h, 25 times more likely with RFB and REB than with mEC+n at 35 degrees C, 3.7 times more likely with an initial inoculum of < or = 2.0 CFU/g than with < or = 0.5 CFU/g, 2.5 to 3 times more likely using freeze-stressed or nonstressed bacteria than with cold-stressed bacteria, and 2.5 times more likely by plating than by the immunoassay or the PCR assay. REB had better overall performance for enrichment of cold- and freeze-stressed E. coli O157:H7 present in ground beef than did the other media examined.     

Evaluation of universal preenrichment broth for growth of heat-injured pathogens.

Universal preenrichment broth (UPB) was developed to enable enrichment of injured foodborne pathogens of different genera simultaneously in lieu of having to undergo separate simultaneous enrichment cultures for subsequent detection or isolation of each pathogen. Enrichment conditions in UPB for growth of injured pathogens to populations that will enable pathogen detection by rapid immuno-based or polymerase chain reaction (PCR)-based assays have not been defined. Hence, studies were done to determine recovery and growth rates of heat-injured Escherichia coli O157:H7, Salmonella enterica ser. Typhimurium, Salmonella enterica ser. Enteritidis. and Listeria monocytogenes in UPB. Bacterial cells were heat injured in tryptic phosphate broth at 57.2 degrees C and inoculated at populations of ca. 0.17 to 63 injured cells per ml with raw ground beef, fresh chicken, lettuce, and environmental sponge samples. Enrichment cultures were sampled at 1, 2, 3, 4, 5, 6, and 24 h at 37 degrees C postinoculation, and pathogens were enumerated on appropriate selective media. Results revealed that recovery and growth of pathogens during the first 6 h of enrichment were not sufficient to ensure adequate numbers of bacteria (> 10(3) CFU/ ml) for detection by most immunoassays or PCR assays. Cells often required 3 to 4 h for recovery before growth was initiated. Salmonella Typhimurium, Salmonella Enteritidis, E. coli O157:H7, or L. monocytogenes cell populations in enrichment cultures with ground beef or lettuce at 6 h were 0.5 to 2.9 log10 CFU/ml. At 24 h of incubation, cell counts of enrichment samples for the three pathogens from all food and environmental sponge samples ranged from 4.0 to 8.3 log10 CFU/ml. Enrichment in UPB at 37 degrees C of foods or environmental sponge samples containing heat-injured cells of Salmonella Typhimurium, Salmonella Enteritidis, E. coli O157:H7, or L. monocytogenes reliably provides at 24 h of incubation-but not at 6 h-sufficient cell populations for detection by rapid immunoassay or PCR assay procedures that can detect at least 4 log10 CFU/ml. These results raise questions regarding the sensitivity of rapid detection methods that employ an abbreviated enrichment protocol of 6 h or less.     

Optimizing enrichment culture conditions for detecting Helicobacter pylori in foods

The survival and growth of Helicobacter pylori under enrichment conditions in fresh, autoclaved and irradiated ground beef were determined. H. pylori grew in autoclaved ground beef at 37 degrees C under microaerobic conditions in brain heart infusion broth with 7% horse serum at pH 7.3 after 3 to 7 days of lag time but did not grow within 7 days in irradiated (10 kGy) ground beef under the same enrichment conditions. Adjustment of the enrichment broth to pH 5.5 enabled the growth (ca. 2 log10 CFU/ml) of H. pylori within 7 days in the presence of irradiated ground beef and the prolific growth (ca. 3 to 4 log10 CFU/ml) of H. pylori within 3 days in the presence of autoclaved beef. H. pylori in fresh ground beef could not be isolated from enrichment media with antibiotics; however. H. pylori ureA could be detected by polymerase chain reaction (PCR) in such enrichment media after 1 to 3 days of incubation at 37 degrees C. The addition of supplements, i.e., 0.3% mucin, 0.05% ferrous sulfate, and 0.05% sodium pyruvate or 0.008 M urea, or the adjustment of the enrichment broth pH to 5.5 or 4.5 enabled the detection of H. pylori ureA in enrichment media incubated for 1, 2, 3, and/or 7 days at 37 degrees C. H. pylori in sterile milk refrigerated at 4 degrees C at an initial level of 10(6) CFU/ml was inactivated to an undetectable level within 6 days; however, H. pylori was not detected either by a PCR assay or by the plating of enrichment cultures of 120 raw bovine milk samples.     

Magnetic nanoparticle-antibody conjugates for the separation of Escherichia coli O157:H7 in ground beef

The immunomagnetic separation with magnetic nanoparticle-antibody conjugates (MNCs) was investigated and evaluated for the detection of Escherichia coli O157:H7 in ground beef samples. MNCs were prepared by immobilizing biotin-labeled polyclonal goat anti-E. coli antibodies onto streptavidin-coated magnetic nanoparticles. For bacterial separation, MNCs were mixed with inoculated ground beef samples, then nanoparticle-antibody-E. coli O157:H7 complexes were separated from food matrix with a magnet, washed, and surface plated for microbial enumeration. The capture efficiency was determined by plating cells bound to nanoparticles and unbound cells in the supernatant onto sorbitol MacConkey agar. Key parameters, including the amount of nanoparticles and immunoreaction time, were optimized with different concentrations of E. coli O157:H7 in phosphate-buffered saline. MNCs presented a minimum capture efficiency of 94% for E. coli O157:H7 ranging from 1.6 x 10(1) to 7.2 x 10(7) CFU/ml with an immunoreaction time of 15 min without any enrichment. Capture of E. coli O157:H7 by MNCs did not interfere with other bacteria, including Salmonella enteritidis, Citrobacter freundii, and Listeria monocytogenes. The capture efficiency values of MNCs increased from 69 to 94.5% as E. coli O157:H7 decreased from 3.4 x 10(7) to 8.0 x 10(0) CFU/ml in the ground beef samples prepared with minimal steps (without filtration and centrifugation). An enrichment of 6 h was done for 8.0 x 10(0) and 8.0 x 10(1) CFU/ml of E. coli O157:H7 in ground beef to increase the number of cells in the sample to a detectable level. The results also indicated that capture efficiencies of MNCs for E. coli O157:H7 with and without mechanical mixing during immunoreaction were not significantly different (P > 0.05). Compared with microbeads based immunomagnetic separation, the magnetic nanoparticles showed their advantages in terms of higher capture efficiency, no need for mechanical mixing, and minimal sample preparation.     

Liquid Smoke Effects on Escherichia Coli O157:H7, and its Antioxidant Properties in Beef Products

Experiments were performed to evaluate the antibacterial properties of liquid smoke (LS), against E. coli O157:H7, in model (agar) and meat systems. The effects of 8% LS on growth of E. coli O157:H7 attached to ground beef, and 1.5% LS on warmed-over flavor (WOF) in precooked beef patties were also studied. E. coli O157:H7 growth was reduced (p<0.05) 2.3 log₁₀ CFU/g in ground beef patties after 3d refrigerated storage. TBA numbers, aroma scores and pH values were lower (p<0.05) in LS treated beef patties. LS reduced undesirable flavor development and may help assure the safety of beef products.