大庆常压渣油催化裂解反应规律研究

采用小型固定流化床实验装置,以大庆常压渣油为原料,针对Ca-Al裂解催化剂,详细分析了催化裂解气体产品和液体产品的组成,考察了反应温度、剂油比、水油比和停留时间对裂解产物分布的影响。发现各操作条件对大庆常渣催化裂解产物分布具有不同程度的影响,其中反应温度的影响最大;随反应温度的升高,乙烯产率单调增加,而丙烯、丁烯和总低碳烯烃产率均存在一个最大值。在优化的操作条件下,乙烯质量产率可达25%,总低碳烯烃质量产率超过50%。     

The partition coefficients of ethylene between hydrate and vapor for methane + ethylene + water and methane + ethylene + SDS + water systems

The hydrate formation of CH₄+C₂H₄ mixture was studied experimentally in two different cases, with and without the presence of sodium dodecyl sulfate (SDS) in water. The results manifested that the presence of SDS could not only accelerate the hydrate formation process, but also increase the partition coefficient of ethylene between hydrate and vapor drastically. The partition coefficients of ethylene between hydrate and vapor for methane + ethylene + water with the presence of 500 ppm SDS in water were then systematically measured. The experimental temperature ranged from 273.15 to 278.15 K, the pressure ranged from 2.5 to 5.5 MPa, the initial gas-liquid volume ratio ranged from 95 to 240 standard volumes of gas per volume of liquid, and the mole percentage of ethylene in feed gas mixture ranged from 5.28% to 79.36%. The results demonstrated that ethylene could be enriched in hydrate phase and partition coefficients were increased with the presence of SDS in water. This conclusion is of industrial significance; it implies that it is feasible to recover ethylene from gas mixture, e.g., various kinds of refinery gases or cracking gases in ethylene plant, by forming hydrate.     

PCC升降式反应器的两种新式进料结构

Based on the analysis of flow characteristics of the FCC riser feedstock injection zone, two novel feedstock injection structures are put forward. By investigating three flow parameters in the feedstock injection zone under the three different structures (the traditional and the novel No. 1, No. 2 structures): the local density, the particle backmixng ratio, and the jet eigen-concentration, the flow feature under three structures were obtained. The experimental results demonstrate that the flow features under both proposed structures are obviously improved comparing with those under the traditional structure. Especially, the performance of the deflector-structured No. 2 is more desirable than that of No. 1.     

CH4-CaSO4和H2S-Fe2O3反应体系的热力学和动力学研究

The destruction of hydrocarbon in deep carbonate diagenetic environment is one of problems on the formation of oil and gas. Organic-inorganic reactions in the process of TSR(Thermochemical Sulfate Reduction) are the main reason to make disappearance of the hydrocarbons. The work in this field has often been the subject of much research work in recent years. In this paper, the thermodynamics of CH4-CaSO4 and H2S-Fe2O3 systems is discussed to investigate the possibility of reactions. It is found that these two reactions can proceed spontaneously.Increasing temperature is favorite for CH4-CaSO4 system but disfavorite for H2S-Fe2O3 system. Thermal simulation experiments were carried out using autoclave at high temperature and high pressure. The properties of the products were characterized by microcoulometry, FT-IR and XRD methods. On the basis of the experimental data, a reaction kinetic model is developed and kinetic parameters are determined.     

闭世界框架下灰色模糊多属性决策方法

针对D-S 证据理论在融合高度冲突的证据时可能导致与直观结果相悖的问题, 已有的基于修改数据模型的方法更多地考虑如何提高冲突证据结果的聚焦程度, 而没有考虑冲突成因以及如何通过冲突原因判断来削减证据之间的冲突. 对此, 提出一种闭世界框架下的灰色模糊多属性决策方法. 根据一般的灰色关联分析方法的基本思路, 将灰色关联度与欧氏距离有机结合, 构造出一种平均相似度对方案进行评价, 进而得到方案的排序结果. 最后, 通过实例分析验证了所提出方法的可行性和有效性.     

二氧化碳置换法开发天然气水合物的实验研究

考察了温度在270.15～278.15 K,压力在2.3～4.0 MPa条件下应用CO2置换天然气水合物中CH4的置换过程.结果表明,温度和压力是置换反应速度和效率的重要影响因素.温度和压力越高,越有利于反应的进行.而压力的影响没有温度的影响明显.同时,置换过程中进入水合物相的二氧化碳的摩尔量与气相中CH4增加的摩尔量的比率超过了1:1,这可能是由于纯水水合物的甲烷含气量并未达到理论含气量,置换的同时有部分二氧化碳分子进入水合物的空孔穴和游离水中,形成二氧化碳水合物和水溶液.     

伊朗轻质原油减渣馏分油水界面张力的研究

The vacuum residual from Iranian Light crude oil are separated into a series of 16 narrow fractions according to the molecular weight by the supercritical fluid extraction and fractional (SFEF) technology. The chemical element and the UV spectrum of each fraction are analyzed. The effects of several factors on the interfacial tension are investigated, which are the fraction concentration in oil phase, the ratio of oil component, the salts dissolved in the water phase and the pH value. The interfacial tension decreases rapidly as the concentration of the residual fraction in the oil increases, showing a higher interfacial activity of the fraction. The interfacial tension changes, as the amount of absorption or the state of the fractions in the interface changes resulting from different ratios of oil, different kinds or concentrations of salts in water, and different pH values. It is concluded that the intrfacial tension changes regularly, corresponding to the regular molecular parameters of the vacuum residual fractions.     

高频脉冲电场作用下乳状液液滴动力学模型

基于乳状液中液滴在电场中的受力情况的分析，建立了W/O乳状液中液滴振荡固有频率公式，从理论角度分析和解释了高频脉冲电场对W/O乳状液的破乳机理，从力学的角度分析了最佳频率存在的理论基础，并推导出了最佳频率的计算公式。该固有频率与液滴尺寸、界面张力、黏度、温度、密度等有关。为了验证最佳频率公式的可靠性，用正辛烷乳状液进行了室内实验。实验结果表明，理论最佳频率公式的预测结果与实验测得的最佳频率结果吻合，经修正后与白油实验结果也非常接近。     

The structures of VOx/MOx and alkali-VOx/MOx catalysts and their catalytic performances for soot combustion

Vanadium oxides supported on γ-Al₂O₃, SiO₂, TiO₂, and ZrO₂ were studied on their molecular structures and reactive performances for soot combustion. To investigate the effect of different alkali metals on the structures and reactivities of supported-vanadium oxide catalysts, they were doped into the V₄/TiO₂ catalyst which had the best intrinsic activity for soot combustion in the selected supported vanadium oxide catalysts. The experimental results demonstrated that the catalytic properties of these catalysts depended on the vanadium loading amount, support nature, and the presence or the absence of alkali metals. The spectroscopic analysis (FT-IR and UV–vis) and H₂-TPR results revealed that the higher activity of alkali-promoted vanadium oxide catalysts could be related to the ability of alkali metal promoting the redox cycle of the active vanadyl species. TG results showed that adding alkali to V_m/TiO₂ catalyst was beneficial to lowering their melting points. Low melting points could ensure the good surface atom migration ability, which would improve the contact between the catalyst and soot. Due to the alkali metal components promoting the redox ability and the mobility of the catalysts, alkali-modified vanadium oxide catalysts could remarkably improve their catalytic activities for soot combustion. The catalytic activity order for soot combustion followed Li > Na > K > Rb > Cs in the catalyst system of alkali-V₄/TiO₂, and the reason why it followed this sequence was discussed.     

基于模糊灰色关联法的巡航导弹探测体系评价

为了对巡航导弹探测体系方案进行优选和客观评价,必须建立科学的评价体系和选择合理的评价方法.在分析区域巡航导弹探测体系组成与功能的基础上,提出一套巡航导弹探测的评价指标体系,利用模糊灰色关联法对3种巡航导弹探测体系方案进行仿真对比分析.结果表明评价指标体系是科学合理的.