2004年玻璃纤维质量分析和标准化工作进展

本文简述了我国玻璃纤维工业发展概况,分析了玻璃纤维产品的质量状况,介绍了玻璃纤维标准化工作的进展.     

一步法多单体反应挤出PP/PA6增容体系研究

采用一步法将接枝单体马来酸酐(MAH)和苯乙烯(St)、引发剂过氧化二异丙苯(DCP)与聚丙烯(PP)、尼龙6(PA6)、乙烯辛烯共聚物(POE)等混匀后在双螺杆挤出机中就地反应增容，详细地讨论了MAH／St／DCP用量和PA6含量对共混体系拉伸性能和冲击性能的影响；通过扫描电镜(SEM)分析了MAH／St／DCP用量及PA6含量对共混物的亚微形态、相界面的影响；通过红外光谱(FTIR)的结果分析对PP／PA6共混物增容反应机理进行了初步探讨。结果表明：一步法添加MAH／St／DCP引起PP／PA6共混体系发生了酰亚胺化反应，生成了Pp—(St—MAH)—PA6接枝共聚物有很好的增容作用；PA6与基体PP的界面非常模糊，分散相的颗粒也变得均匀细小，约0．5μm，大大改善了两相之间的粘结；从而使得PP／PA6共混体系的力学性能有了较大的提高，PA6质量分数在20％，MAH／St／DCP添加1～4份时效果最佳，缺口冲击强度提高2倍左右，拉伸强度、断裂伸长率、无缺口冲击强度也有明显改善。     

Carbon nanotubes and onions from carbon monoxide using Ni(acac)2 and Cu(acac)2 as catalyst precursors

New catalyst precursors (copper and nickel acetylacetonates) have been used successfully for the synthesis of carbon nanotubes and onion particles from carbon monoxide. Catalyst nanoparticles and carbon products were produced by metal-organic precursor vapour decomposition and catalytic disproportionation of carbon monoxide in a laminar flow reactor at temperatures between 705 and 1216 °C. Carbon nanotubes (CNTs) were formed in the presence of nickel particles at 923-1216 °C. The CNTs were single-walled, 1-3 nm in diameter and up to 90 nm long. Hollow carbon onion particles (COPs) were produced in the presence of copper particles at 1216 °C. The COPs were from 5 to 30 nm in diameter and consisted of several concentric carbon layers surrounding a hollow core. The results of computational fluid dynamics calculations to determine the temperature and velocity profiles and mixing conditions of the species in the reactor are presented. The mechanisms for the formation of both CNTs and COPs are discussed on the basis of the experimental and computational results.     

一种新的BOC(n,n)型信号的精确捕获算法

针对BOC(n,n)型信号自相关函数存在三个峰值导致伪码捕获模糊性的问题,提出了一种新的基于相关函数的精确无模糊的捕获算法。该算法将信号进行频域的多普勒补偿,通过本地增设QBOC(n,n)支路,利用BOC(n,n)信号自相关以及BOC(n,n)和QBOC(n,n)互相关,经移位±TC/4、取模、求和、平方运算而实现。理论与仿真分析表明,该算法在不改变自相关主峰宽度的情况下完全消除相关副峰的同时,显著提高了主峰峰值;比传统捕获算法的性能好4.5 dB左右,并且捕获精度良好、易于实现。     

Evolution of chemistry and morphology during the carbonization and combustion of rice husk

Both fine carbon/silica and pure silica powders can be obtained by carbonization and combustion of rice husk under non-isothermal conditions, and the products can be used for preparation of high-quality ceramic materials. Studies on the morphology, chemical and physical characteristics of products were carried out by N₂-adsorptionmeter, SEM, XRD, FTIR, ICP-MS and EA. Results indicate that decreasing the heating rate increased the specific surface area, pore volume and pore diameter. At a heating rate of 5 °C/min, the specific surface areas of both the carbon/silica and pure silica powders were 261 and 235 m²/g, and the average pore diameters were 2.2 and 5.4 nm, respectively. The products obtained from various heating rates were all amorphous. Thermogravimetric analysis was employed to study the reaction characteristics during carbonization or combustion, indicating that decomposition process of rice husk could be divided into three temperature zones. This results of the study can also provide the important information on the recovery of biomass material from rice husk.     

常减压蒸馏装置中和缓蚀剂的研制

针对炼油厂常减压塔塔顶冷凝系统现存的腐蚀问题,研制出以有机胺、咪唑啉衍生物为主要组分复配而成的新型中和缓蚀剂。通过模拟蒸馏实验表明:液相部位的缓蚀率达到99%以上,在初馏区露点部位的缓蚀率达到98%以上该中和缓蚀剂性能优良。     

水滑石的制备及其阻燃性能研究进展

由于聚合物受热易燃烧,常存在火灾风险,通常需要引入阻燃剂来提升其阻燃性能。水滑石(LDHs)因其无卤、无毒且抑烟性能优异,在阻燃领域受到了越来越多的关注。基于此,对LDHs的结构、制备方法及其阻燃机理进行了介绍,特别是对提高LDHs阻燃性能的途径即从层板阳离子掺杂、层间阴离子插层和表面改性进行了重点综述,并对不同结构LDHs的阻燃机理及阻燃性能进行了总结,最后展望了LDHs作为阻燃剂今后的发展趋势。     

Practical Design Model for Calculating Bubble Diffuser Contactor Ozone Transfer Efficiency

Ozone transfer to water or wastewater is necessary before desirable, effective ozone reactions occur. Several factors affect ozone transfer efficiency, including water quality characteristics, contactor configuration, and applied ozone characteristics. The design model presented in this paper addresses all factors affecting ozone transfer. The model was used to compare measured transfer efficiency with predicted transfer efficiency at four full-scale wastewater ozone disinfection facilities. A relatively good prediction was obtained at each plant.

The paper presents an example calculation of ozone transfer efficiency. Also, the effect of changes to some of the factors affecting transfer efficiency is presented, such as changes in diffuser depth, plant elevation, ozone concentration, water quality (i.e., ozone demand), pH, detention time, temperature, and acombination of factors. The design model may be used to evaluate the effect of changes in plant design on transfer efficiency, but cannot provide an absolute value for transfer efficiency until difficult-to-measure parameters, such as bubble diameter, are known.     

Use of a sex attractant and an inhibitor for monitoring winter moth and bruce spanworm populations

A single sex pherormone component was isolated from abdominal tip extracts of female Bruce spanworm.Operophtera bruceata (Hulst). This was identified as (Z,Z,Z)-1,3,6,9-nonadecatetraene by capillary gas chromatography (GC), electroantennography, and mass spectrometry. In addition, hexane extracts of female abdominal tips from Bruce spanworm and the winter moth.O. brumata L., were analyzed by GC coupled to an electroantennographic detector (GC-EAD). The extracts ofO. bruceata andO. brumata females elicited only a single response, at the same retention time, from antennae of their conspecific and reciprocal males. In field tests conducted in Saskatchewan, traps baited with the synthetic tetraene captured Bruce spanworm males. In tests carried out on Vancouver Island, British Columbia, where the two species coexist, both Bruce spanworm and winter moth males were captured. The attractancy of lures containing the synthetic pheromone alone and in combination with several structurally related analogs was field tested at both locations. One of these, an isomer of the natural pheromone, (E,Z,Z)-1,3,6,9-nonadecatetraene, inhibited the capture of Bruce spanworm males but had no effect upon the number of winter moth males which were taken. Thus, populations of these two very similar species can be distinguished by employing traps baited with pheromone ± the inhibitor. Coneorifice Hara traps were found useful for field trapping males of both species.Issued as NRCC No. 26107     

保证云存储的数据安全

近几年来,云存储的使用越来越广泛,不仅是中小型企业,而且针对个体用户也可以购买云存储服务,但如何在云存储中保证数据的安全性和机密性,单靠云存储服务供应商的承诺是难以让人信服的。本文提出了一种保证数据安全的云存储框架,并且使用服务等级协议（SLA）作为用户和供应商之间的共同标准。此外,本文还提及了几种保证云存储数据安全的技术,这些技术可以被分成三类：存储保护,传输保护和授权保护。