超细镍粉的化学还原制备及其分散剂的作用

采用溶液还原法，以硫酸镍为原料，水合肼为还原剂制备了超细和纳米镍粉。研究了不同分散剂对镍粉粒度和粒度分布的影响。X射线衍射结果表明，所得粉末为纯Ni相，晶粒尺寸约13nm；激光粒度分布测试结果表明，Ni粉粒度分布较窄，中位径集中在0．7～0．8μm，最大粒径不超过2．0μm。透射电镜照片显示粉末近球形，一次颗粒粒径在50～100nm之间，有轻微团聚。改变分散剂种类（PVP、PEG1500、PEG20000、CTAC）和用量可使超细镍粉的比表面积在3．24～57．88m^2／g间变化。     

化学沉淀法制备超细二盐基亚磷酸铅粉体

本研究采用化学沉淀法制备超细二盐基亚磷酸铅粉体，讨论了各种因素对二盐基亚磷酸铅颗粒度的影响。利用透射电子显微镜、激光粒度分析仪和x射线衍射仪等分析手段对粉体进行了表征。结果表明选择合适的反应介质、分散剂及搅拌速度可以得到粒径280nm左右的二盐基亚磷酸铅超细粉体。     

SiC微细颗粒分散特性的研究

采用沉降法,以水、聚乙二醇为介质,对SiC微细颗粒的自然分散行为及分散剂、溶液pH值对其分散行为的影响进行了研究。结果表明:颗粒在不同介质中的自然分散行为有着明显差异;分散剂对分散介质具有选择性,不同分散剂的分散效果不同;分散剂用量及溶液pH值对颗粒的分散也有显著的影响。     

矿渣固化钻井液技术的高温分散剂研究

由于高温深井泥浆本身具有粘度大、密度高以及成分复杂等特点,导致在MTC浆体中泥浆分散剂分散作用甚微,甚至根本无法配浆.从MTC浆体的增稠原理出发,合成出含非离子型基团的多种改性聚氧乙烯类物质的MTC高温分散剂SSOB.该分散剂加量小、分散能力强,不影响MTC浆体的稠化时间、抗压强度等其他性能,与其他外加剂(激活剂、缓凝剂等)相容性好等优点,使MTC浆体具有优良的综合性能,从而为高温深井油气的开发的MTC技术提供了保证,具有广阔的发展和应用前景     

苄基化疏水改性淀粉的合成及水煤浆分散性能

采用氧化淀粉和羟乙基淀粉为原料,氯化苄为疏水剂,引入一定量的疏水基团苄基,制备出两种新型苄基化改性淀粉(氧化苄基化淀粉(OBS)和羟乙基苄基化淀粉(HBS))。将OBS和HBS作为分散剂应用于神华煤制备水煤浆,探讨改性淀粉对浆体的表观黏度、制浆浓度、稳定性和流变性的影响。结果表明:OBS和HBS的最佳添加量为0.50%(质量分数,下同),最大制浆浓度为65%;苄基化疏水改性后制得的淀粉分散剂均具有较好的分散效果,含苄基和羧基更多的OBS分散剂性能更佳,浆体表观黏度为842 mPa·s,7 d析水率为4.3%,煤颗粒表面Zeta电位降至-36.2 mV,体现出较好的稳定性和流变特性。OBS分散剂通过结构中的疏水基团苄基与煤中的硫水区域通过π电子极化作用力结合,形成平躺的线性折叠链式吸附。     

Porous ceramics with tailored pore size and morphology as substrates for coral larval settlement

The growing demand for stony corals as ornamental aquarium animals requires defined aquacultural breeding strategies. For the sexual propagation of corals, material substrates are needed, that attract larvae and support their settlement and development. In this study, five types of highly porous ceramic materials were developed following the example of coral skeleton. The applicability of these settlement substrates was tested using larvae of the stony coral Pocillopora damicornis. Partial sintering of pressed clay pellets, freeze casting of clay and alumina-mullite based slurries and direct foaming of high alkane phase emulsified suspensions (HAPES) using alumina were employed. By the addition of mm-sized spherical polystyrene beads as sacrificial templates during freeze casting (alumina-mullite), superficial pores in the size of the larvae were created. The inorganic substrates featured open porosities between 35% (pressed clay) and 83% (foamed alumina), pore sizes ranging from nm to mm-scale and pore morphologies dominated by interparticle porosity (pressed), lamellar pores (freeze casting) and cellular pore types (direct foaming). The ceramic substrates were incubated in artificial sea water for 3 months to induce necessary biofilm formation and algae growth. Afterwards, individual substrates were exposed to 5 coral larvae, and their settlement behavior was monitored over 14 days. At the end of this period, all ceramic materials were successfully accepted as settlement substrates, with a mean settlement rate of 46.2%, and no significant differences between the substrate types. On samples with large surface superficial pores, a significantly reduced survival of settled larvae (79%) compared to the other porous materials (93–98%) was determined, suggesting a non-ideal surface topography. While alumina foam samples (HAPES) exhibit the most promising results in terms of settlement and survival of larvae, clay-based substrates provide a more economic solution for the sexual propagation of corals in aquaculture.     

常压塔顶系统铵盐结晶诊断与治理方案

随着原油的劣质化,油中的有机氯含量增加,而电脱盐不能脱除这些有机氯,常压塔顶低温部位会有铵盐析出,对设备腐蚀和馏分切割都带来负面影响,甚至会导致装置非计划停车。在分析铵盐结晶问题和调研防治技术的基础上,采用注入分散剂的技术方案进行处理,取得很好效果。     

氧化温度和分散剂种类对Si3N4浆料性能的影响

研究了自蔓延燃烧合成Si₃N₄粉的氧化处理（在空气气氛中分别于400、600、800℃保温3 h）以及添加的分散剂种类（分别为聚丙烯酸钠、六偏磷酸钠、三聚磷酸钠、木质素磺酸钙）对制备的Si₃N₄浆料的抗沉降性、ζ电位和黏度的影响。结果表明：1)在空气气氛中于800℃保温3 h氧化处理后,粉体中Si₂N₂O含量增多;用其制备的浆料的稳定性最好,ζ电位绝对值较大,黏度最小。2)以六偏磷酸钠作为分散剂制备的Si₃N₄浆料的稳定性较好,ζ电位绝对值最大,黏度最小。3)添加0.021%（w）六偏磷酸钠制备的Si₃N₄浆料的ζ电位绝对值最大,黏度较小。     

The effect of sodium polymethacrylate on the rheology of the positive paste and performance of the lead-acid battery

Due to its rheological properties, positive lead-acid battery paste can be difficult to spread on lead current collectors accurately and efficiently under industry machinery and setting. Sodium polymethacrylate dispersant was studied as an effective positive paste additive that could lower the yield stress of the paste without affecting paste density and battery performance. Under a four-blade vane rheometer setup, stress growth and oscillatory amplitude strain sweep experiments evaluated the rheological properties of positive paste with the addition of varying amounts of sodium polymethacrylate. Further, the electrochemical effects of sodium polymethacrylate were also evaluated in 2V batteries by testing positive active material utilization and cycle life.     

复合型丙烯酸系水煤浆分散剂的性能研究

以α-甲基丙烯酸、丙烯磺酸钠为原料合成的阴离子型分散剂PMS,和以α-甲基丙烯酸、丙烯磺酸钠、苯乙烯为原料合成的复合型分散剂MSS,分别用于水煤浆制浆,首先考察2种分散剂对水煤浆的黏度、流变性及稳定性的影响,并采用红外光谱、凝胶色谱等物理方法对产物进行分析。研究发现,与PMS相比,改进后的复合型分散剂MSS性质稳定,改善了水煤浆性能,具有很好的降黏效果,并明显增强了浆体的静态稳定性。