Influence of Al3+ doping for V5+ on the structural,optical, thermal and electrical properties of V2-xAlxO5-δ (x=0–0.20) ceramics

This paper reports an investigation on the structure-properties correlation of trivalent metal oxide (Al₂O₃)-doped V₂O₅ ceramics synthesized by the melt-quench technique. XRD patterns confirmed a single orthorhombic V₂O₅ phase formation with increasing strain on the doping of Al₂O₃ in place of V₂O₅ in the samples estimated by Williamson-Hall analysis. FTIR and Raman investigations revealed a structural change as [VO₅] polyhedra converts into [VO₄] polyhedra on the doping of Al₂O₃ into V₂O₅. The optical band gap was found in a wide semiconductor range as confirmed by UV–visible spectroscopy analysis. The thermal and conductivity behavior of the prepared samples were studied using thermal gravimetric analysis (TGA) and impedance analyzer, respectively. All the prepared ceramics exhibit good DC conductivity (0.22–0.36 Sm^-1) at 400 ?C. These materials can be considered for intermediate temperature solid oxide fuel cell (IT-SOFC)/battery applications due to their good conductivity and good thermal stability.     

粗四氯化钛有机物精制除钒尾渣提钒技术

从四氯化钛有机物精制除钒尾渣中提钒并制备V2O5产品，研究了精制除钒尾渣焙烧温度、浸出剂加入量、液固比、浸出温度、浸出时间对尾渣中钒转化和溶出率的影响。结果表明，焙烧温度大于600℃时，可高效脱除精制除钒尾渣中的碳和氯(?0.1%)，且低价钒被氧化为高价，钒主要以V2O5形式存在。对焙烧后的尾渣以Na2CO3水溶液为浸出剂，液固比6 mL/g及80℃下浸出60 min，钒浸出率为85.5%，浸出液仅含少量Si, Al, Ti杂质，以NH4+:V=2.5:1(摩尔比)直接加铵盐沉钒，得到NH4VO3，经干燥、煅烧制得V2O5产品，可满足99级粉钒指标要求，全流程钒收率为75%。     

钒渣钠化焙烧熟料浸出液除磷工艺研究

以钒渣钠化焙烧熟料浸出后得到的含钒溶液为原料，分析了二水硫酸钙在碱性条件下对含钒溶液中磷的去除机制，研究了二水硫酸钙用量、溶液pH、反应时间、反应温度等因素对磷去除率、钒损失率以及溶液中五氧化二钒与磷质量浓度比的影响。研究结果表明：在弱碱性条件下，二水硫酸钙可有效去除含钒溶液中的磷，磷去除率达到70%以上、钒损失率小于1%、五氧化二钒与磷质量浓度比大于2 300，满足后续沉钒的要求。确定的除磷工艺条件：二水硫酸钙与磷物质的量比为5.3，溶液pH为9.0，反应时间为30 min，反应温度为25 ℃。除磷后的含钒溶液经沉钒、洗涤、煅烧得到五氧化二钒产品，沉钒率大于99%，五氧化二钒产品质量满足YB/T 5304—2011《五氧化二钒》中99级的要求。     

The isothermal reduction kinetics of chromium-bearing vanadium–titanium magnetite sinter

The reduction of chromium-bearing vanadium–titanium magnetite sinter (CVTMS) by CO was investigated at 1123–1223?K. The reduction degree increased with increasing temperature. The isothermal reduction kinetics of CVTMS was analysed, according to Sharp analysis and ln–ln analysis, the kinetic mechanism of reduction process for all samples in different basicity can be represented as f(α)?=?1.61(1?α)[?ln(1?α)]^1–1/1.61. The reaction activation energy of all samples (R?=?1.9, 2.1, 2.3, obtained according to the components of the materials burdening used in sintering process) at different reaction degrees were calculated by the model-free method. And the pre-exponential factors of reaction also were calculated by the mathematical method. The rate controlling step for the reduction process under the present reduction condition was chemical reaction.     

凝胶法制备氮化钒的研究

考察凝胶法制备氮化钒时的氮化温度、氨气流量和氮化时间等因素对产品氮化率的影响。结果表明,氮化温度为750℃,氨气流量为80 m L/min,氮化时间为14 h时,产品氮化率达到95%,其晶粒大小平均在100 nm左右。     

贵州三穗地区钒矿地质特征及成矿规律研究

总结贵州省三穗地区钒矿矿区地层、区域构造和区域岩浆岩特征，探讨矿区钒矿成矿规律。研究表明：区内钒矿赋存在陡山沱组白云岩的上部以及老堡组和九门冲组的下部，含矿岩性为黑色炭质黏土岩；成矿来源主要是由于海底裂谷的热气流作用，携带深部钒等多金属元素向陆棚与台地运动、迁移，出现钒的横向分导现象；沉积下来的钒金属又在后期低温热液作用下，以水云母的形式存在，而炭质吸附的部分钒元素进入水云母晶格中，形成钒矿。     

Extraction of Vanadium(V) from Mixed Chloride/Thiocyanate Solutions with Two Commercial Solvating Extractants

Studies on the extraction and separation of vanadium(V) from mixed hydrochloric acid/ammonium thiocyanate solution with CYANEX 921 and CYANEX 925 in kerosene were carried out. The effects of various factors affecting the extraction process as well as temperature were investigated. Addition of thiocyanate to the chloride solution was found to enhance markedly the extraction of vanadium. HCl solution efficiently stripped V(V). The number of stages required for extraction and stripping of vanadium ions was determined from the McCabe–Thiele diagram. Based on the obtained results, the separation of V(V) from spent catalyst leach indicates the efficiency of the proposed process.     

钙化-酸浸提钒沉钒母液中锰的回收

对钙化?酸浸提钒沉钒母液中锰资源的回收，一方面可以提升提钒工艺的经济效益，另一方面可避免母液循环时锰浓度不断累积而影响氧化钒产品质量，从而有助于实现母液闭路循环而提升全流程的环境效益。本工作提出了采用草酸沉淀法高效回收沉钒母液中的Mn2+，考察溶液体系pH值、草酸加量系数、反应温度和时间对锰回收率及沉淀产物物相组成的影响，以及草酸沉淀分离锰后母液的循环次数对钒浸出过程的影响。结果表明，草酸沉淀法可高效分离沉钒母液中的Mn2+，在溶液体系pH=4.0、草酸加量系数为1.5、反应温度为50℃、反应时间为60 min的条件下，锰回收率达94.33%，所得产物为纯度大于98%的水合草酸锰，为片状晶体，并呈花簇状生长。将脱锰后的沉钒母液循环至酸浸段，对钒浸出率及浸出液中锰的浓度没有明显影响，表明该方法有助于实现钙化?酸浸提钒中废水的闭路循环。     

极端电场环境激励下的VO2相变性能研究与应用

为揭示VXOY薄膜场致相变规律,推广钒氧化物应用于卫星控制系统,指导氧化钒规模制备,将磁控溅射法和真空退火工艺相结合,在Al2O3陶瓷基片上制备出VXOY薄膜,降低了实验对仪器精度的要求,提高了实验的成功率。对基片进行磁控溅射镀膜,在管式炉中进一步氧化处理生成表面均匀的V2O5,然后进行高温退火处理,对不同退火条件下的生成的薄膜进行了XRD表征。测得了电场激励下VXOY薄膜的相变现象,验证了电场激励下焦耳热并非薄膜相变的主导因素;总结了不同组分下VXOY薄膜的相变规律,研究了不同V6O13含量对VO2薄膜临界相变电压的影响规律,可指导VXOY薄膜应用于微纳卫星等极端环境下的设备控制系统。     

某钒钛磁铁矿尾矿资源化利用

承德市某钒钛磁铁矿尾矿钛含量较高,潜在回收价值可观。采用化学分析、XRD衍射分析、粒度分析、矿物解离分析仪(MLA)等手段研究了该尾矿的矿物学特性及钛的赋存状态。在工艺矿物学研究基础上,通过试验研究确立了重选短流程回收钛、选钛尾矿差异化分级利用的综合利用技术工艺,获得含TiO234.60%、回收率53.43%的钛铁矿精矿以及产率66.22%的建筑用商品砂,实现了铁尾矿的资源化综合回收利用,有助于矿山与社会环境和谐发展。