Influence of dietary oils and protein level on pork quality. 1. Effects on muscle fatty acid composition, carcass, meat and eating quality

This study evaluated the effects of three dietary oils - palm kernel (PKO), palm (PO) and soyabean (SBO) - and two protein levels - high (HP) and low (LP) in a 3×2 factorial design involving 60 pigs on growth performance, muscle fatty acid composition and content, carcass, meat and eating qualities. Oil type did not have a significant effect on growth and carcass quality. PKO significantly reduced the polyunsaturated (PUFA) to saturated (SFA) fatty acid (P:S) ratio in longissimus muscle (P<0.001). PKO increased the concentrations of lauric (12:0), myristic (14:0), palmitic (16:0) and stearic (18:0) fatty acids and decreased linoleic acid (18:2). The LP diet increased intramuscular fat (IMF) from 1.7g/100g muscle in HP to 2.9g/100g (P<0.001), increased tenderness by 0.6 units (P<0.01) and juiciness by 0.5 units (P<0.01) on the 1-8 scale, but at the expense of lower daily weight gain (P<0.01), lower feed conversion efficiency (P<0.01), reduced P:S ratio (P<0.001) and increased lipid oxidation (P<0.01). The results suggest that PKO and PO could be used in tropical developing countries as cheaper alternatives to SBO for the production of good quality and healthy pork, but their limits of inclusion need to be determined.  

废工业棕榈油制备生物柴油的研究

利用固体酸作催化剂对酸值较高的废棕榈油进行预酯化,采用正交试验优化预酯化的工艺条件,最佳工艺条件是:反应温度为70 ℃,反应时间为4.0 h,固体酸催化剂的用量为3.0%,预处理后废棕榈油的酸值为2.18 mg KOH/g.研究了预酯化后的废棕榈油与甲醇进行的酯交换反应,得到最优工艺条件是:反应温度为65 ℃,反应时间为1.0 h,催化剂KOH的用量为1.0%,酯交换反应的转化率为96.85%,生物柴油总得率为93.2%.以废棕榈油为原料制备的生物柴油,除倾点较高外,其主要性能均符合柴油标准.  

马来西亚对油棕种植材料研究及棕榈油产品生产

油棕种植业与棕榈油加工业是马来西亚国民经济重要组成部分。我国与马来西亚有大量棕榈 油进口贸易,检验检疫工作繁重且多样。该文探讨马来西亚对油棕种植材料研究现状及主要棕榈油产 品生产过程和用途。  

芝麻油掺棕榈油鉴别方法的研究

以4种不同熔点棕榈油与4种芝麻油所配制的128个掺伪芝麻油样品为原料,分别采用全样脂肪酸组成分析法、Sn-2位脂肪酸组成分析法和甘三酯结构分析法对芝麻油中掺棕榈油的鉴别方法进行了研究。结果表明:在全样脂肪酸组成分析法中,当以棕榈酸为标准与芝麻油纯样和国标数据比较时,检出限分别为5%和15%。在Sn-2位脂肪酸组成分析法和甘三酯结构分析法中,当与芝麻油纯样数据比较,分别以亚油酸与棕榈酸含量比值(18:2/16:0)和β-POO(Sn-1-棕榈酸-2,3-二油酸甘油酯)含量为判断标准时,检出限分别为20%和12%。综合这3种方法的检出限高低及分析操作难易程度,初步得出结论:在芝麻油掺棕榈油的鉴别方法中,全样脂肪酸组成分析法是最好的鉴别方法,其余2种方法一般不优先采用,但可作为对上述方法的验证与补充。  

3种食用油在薯条煎炸过程中的品质变化

以大豆油、葵花籽油、棕榈油为研究对象,探讨在(180±5)℃条件下煎炸薯条,每天连续煎炸4h,共煎炸5d后各食用油理化指标的变化。结果表明:随着煎炸时间延长,3种食用油的色泽加深、黏度增加;酸价(AV)显著增加,但未超过国家标准;碘价(IV)则随着煎炸过程进行而逐步降低;过氧化值(POV)在煎炸过程中均先上升后下降,其中大豆油和葵花籽油的POV呈波动性;煎炸3d后,大豆油、葵花籽油的羰基值(CV)超过或非常接近国家标准50meq O2/kg,煎炸4d后,两种油的极性化合物(TPM)含量超过国家标准;整个煎炸过程中棕榈油的CV和TPM含量均低于大豆油和葵花籽油。  

油棕壳制活性炭的工艺研究

本文探讨了利用油棕壳制活性炭的生产方法与工艺条件，并研究了各种工艺参数对产品性能的影响，摸索出油棕壳生产活性炭的较佳工艺条件。  

Crystallization kinetics of palm oil in blends with palm-based diacylglycerol

Crystallization kinetics of palm oil (PO) in the presence of different concentrations (2, 5, 10, 30 and, 50% w/w) of palm-based diacylglycerol (PB-DAG) were investigated over different ranges of crystallization temperatures. Addition of 30 and 50% (w/w) of PB-DAG (high concentrations) increased significantly (P < 0.05) the melting point and crystallization onset while addition of 2 and 5% PB-DAG did not have significant (P > 0.05) effect. PO and PO blends with 2 and 5% of PB-DAG showed crystal transformation at crystallization temperatures (T_Cr) of 26, 26, 26.5 °C, respectively as reflected in corresponding changes of the Avrami parameters at below and above these T_Cr. This was especially evident for the blends containing 2 and 5% of PB-DAG. Individual comparison of induction time (T_i), Avrami exponent (n), Avrami constant (k) and half-time of crystallization (t_1/2) of blends classified under various supercooling ranges based on the supercooling closeness (± 0.1 °C), showed that addition of 5% of PB-DAG in most of the supercooling ranges significantly (P < 0.05) reduced nucleation rate as well as crystal growth velocity of PO. This was reflected in the significantly (P < 0.05) higher T_i and t_1/2 and lower k. Although the presence of 2% of PB-DAG was found to have inhibitory effect on PO crystallization, this effect was not significant (P > 0.05). Mode of crystal growth attributed to n was changed significantly only in presence of 5% of PB-DAG. Furthermore, presence of 10% PB-DAG showed ??'-stabilizing effect on PO. On the other hand, high concentrations of PB-DAG were found to significantly (P < 0.05) reduce T_i as well as t_1/2 and also increase k suggesting their promoting effects on nucleation and crystallization rate of PO even with the close supercoolings. In addition, they changed crystal growth mode of PO. Amongst the different concentrations of PB-DAG investigated, blend containing 50% of PB-DAG as compared to PO, not only, have healthier benefits but also, may have greater potential applications in plastic fat products due to its unique physical properties.  

植物油脂水解工艺及不饱和脂肪酸组成研究

研究了碱性水解小桐子油脂制备脂肪酸的较佳工艺条件：油水比（g/g）为2：1,乙醇-水比（v/v）为2：1,皂化时间1.5h、温度70℃,在该条件下脂肪酸得率、酸值和碘值的平均值分别为：98.25%、203.67mgKOH/g和109.89g/100g。采用桐油、光皮油、棕榈油和大豆油等植物油脂考察了该工艺的原料适用程度,该水解工艺条件下各种油脂制备所得的脂肪酸得率和酸值都接近98%和199mgKOH/g。采用GC-MS分析五种植物油脂脂肪酸组成和含量,其不饱和脂肪酸含量依次为：桐油（94.88%）〉大豆油（84.07%）〉光皮油（81.90%）〉小桐子油（77.84%）〉棕榈油（77.19%）;其中多价不饱和脂肪酸含量次序为桐油（85.36%）〉大豆油（58.01%）〉棕榈油（56.81%）〉光皮油（55.31%）〉小桐子油（42.16%）。大豆油、棕榈油、光皮油和小桐子油四种植物油脂脂肪酸成分基本相同,主要是亚油酸、7,10-十八碳二烯酸、油酸。桐油中脂肪酸组成与其他植物油脂有较大区别,含大量三价不饱和脂肪酸,其主要成分有油酸（9-十八烯酸）13.83%、8,11-十八碳二烯酸24.37%、亚麻酸（9,12,15-十八碳三烯酸和6,9,15-十八碳三烯酸）60.01%。  

Droplet characterization and stability of soybean oil/palm kernel olein O/W emulsions with the presence of selected polysaccharides

Droplet characteristics, flow properties and stability of egg yolk-stabilized oil-in-water (O/W) emulsions as affected by the presence of xanthan gum (XG), carboxymethyl cellulose (CMC), guar gum (GG), locust bean gum (LBG) and gum Arabic (AG) were studied. The dispersed phase (40%) of the emulsions was based on soybean oil/palm kernel olein blend (70:30) that partially crystallized during extended storage at 5 °C. In freshly prepared emulsions, the presence of XG, CMC, GG and LBG had significantly decreased the droplet mean diameters. XG, LBG, GG and CMC emulsions exhibited a shear-thinning behavior but AG emulsion exhibited a Bingham plastic behavior and control (without gum) emulsion almost exhibited a Newtonian behavior. Both control and AG emulsions exhibited a severe phase separation after storage (30 days, 5 °C). The microstructure of stored XG emulsion showed the presence of partially coalesced droplets, explaining a large increase in its droplet mean diameters. Increases in droplet mean diameters and decreases in flow properties found for stored GG and LBG emulsions were attributed to droplet coalescence. Nevertheless, the occurrence of droplet coalescence in these emulsions was considered to be small as no free oil could be separated under centrifugation force. Increases in flow properties and excellent stability towards phase separation found for stored CMC emulsion suggested that CMC could retard partial coalescence. Thus, the results support the ability of CMC, GG and LBG in reducing partial coalescence either by providing a sufficiently thick continuous phase or by acting as a protective coating for oil droplets.  

植物油脂多不饱和脂肪酸的分离与富集研究

利用低温冷冻结晶和尿素包合法在同一工艺条件下考察了五种植物油脂中多不饱和脂肪酸的分离和富集效果。低温冷冻结晶初步分离得到的脂肪酸I中，仅含少量饱和脂肪酸，总不饱和脂肪酸含量达到95％以上，达到PUFAs的预浓缩目的。尿素包合法富集PUFAs实验中，光皮油、棕桐油脂中PUFAs的分离效果最好，亚油酸纯度达到96．67％和97．18％；小桐子油和大豆油脂中亚油酸含量分别为81．74％和91．75％；桐油中PUFAs的富集效果不明显，总PUFAs纯度仅由原来的85．36％提高到91．62％。