红外辐射联合回火与冷激杀菌技术对胡萝卜粉品质的影响

首先研究不同红外辐射温度(100,110,120℃)及辐射时间(2.5,5,10 min)对胡萝卜粉微生物及品质的影响,然后根据栅栏效应原理研究红外辐射-回火、红外辐射-冷激联合杀菌对胡萝卜粉微生物、色调值、类胡萝卜素含量等品质的影响。结果表明:100℃、10 min的红外辐射处理使细菌和真菌分别降低了1.9 lg(CFU/g)和2.32 lg(CFU/g),110℃、5 min的红外辐射处使细菌和真菌分别降低了1.58 lg(CFU/g)和2.57 lg(CFU/g)。在上述两种处理条件下胡萝卜粉的水分活度从0.238分别降至0.123和0.147,胡萝卜粉中总类胡萝卜素含量从308.8μg/g降至227.8μg/g和238.8μg/g,色差值(ΔE)为9.11和7.89。与红外辐射单独作用相比,联合回火后的处理没有显著影响细菌数目,处理后保持在5.40~5.80 CFU/g,霉菌、酵母数却在处理过程中显著减少,然而减少量较低,总数仍不低于4.5 lg(CFU/g)。红外辐射-冷激联合处理相比红外辐射单独处理,100℃、10 min联合冷激7 d处理可将细菌数量降低0.25 lg(CFU/g),可将霉菌与酵母数量降低0.28 lg(CFU/g),110℃、5 min联合冷激7 d处可将细菌数量降低0.26 lg(CFU/g),可将霉菌、酵母数量降低0.40 lg(CFU/g),且这些处理下胡萝卜粉的色调值、水分活度、类胡萝卜素含量变化不显著。本试验结果表明,红外辐射-冷激处理具有协同效应,且处理过程中胡萝卜粉的色调值及总类胡萝卜素含量不受影响,这为低水分粉体食品红外辐射联合杀菌提供了参考。     

胡萝卜浓缩汁中耐热菌的分离及特性研究

对胀袋胡萝卜浓缩汁中的耐热菌进行了分离,通过形态观察和ITS rDNA基因序列分析方法鉴定耐热菌,通过碳源利用试验考查菌株的部分生理生化特性,通过热和酸碱处理考察菌株的热稳定性和酸碱稳定性,利用超声波破壁技术考察细胞中多糖、还原糖和色素情况。结果表明:胀袋胡萝卜浓缩汁中分离得到一株耐热菌SR-1,经形态学和分子生物学技术鉴定为肉色掷孢酵母,该菌经80℃热处理5~30min,生长良好;经90℃热处理15 min仍能生长,处理20 min后不能生长;在pH 6.0~8.0环境中生长良好,pH 3.0以下不能生长。超声波破壁后上清液还原糖含量为6.02~7.86mg/mL,多糖含量为32.93~41.78 mg/mL,菌体色素在414,539,634nm处有吸收峰。     

石榴-胡萝卜复合饮料理化性质、抗氧化活性及其货架期的研究

以石榴、胡萝卜为原料,按质量比1∶3、1∶1、3∶1混合配制石榴-胡萝卜汁复合饮料,研究常温(25±1)℃下60 d的储存期内其物理化学性质(pH值、可溶性固形物、总酸度)、抗坏血酸、总酚以及抗氧化活性的变化,并对复合汁进行感官评价。结果表明,3个样品的pH值分别为4.04、3.92和3.38,可溶性固形物分别为5.02%、6.14%和8.13%,总酸度分别为0.74、0.74 g/100 mL和0.77 g/100 mL,在60 d的货架期pH值有所降低,可溶固形物含量没有明显的变化,而总酸度有所增加。抗坏血酸含量以质量比为1∶3的混合汁占优,总酚含量、DPPH自由基清除率以质量比为3∶1的混合汁占优,3项指标在货架周期内呈总体下降趋势。质量比为1∶1的石榴-胡萝卜复合汁感官评价得分最高。     

The influence of the carrier addition and spray drying temperatures on physicochemical properties of microencapsulated carrot juice powder

The objective of this study was to determinate the influence of carrier addition and spray drying temperatures (160 or 200°C) on physicochemical properties of spray-dried carrot juice powder. As carriers, maltodextrin and gum Arabic in different proportions were used. In powders were determined the following: moisture content, water activity, apparent density, size of particles, colour and carotenoids content. The content of carotenoids in powders prepared from solutions with juice to carrier ratio 2:3 was 324.3–406.6 mg/kg d.m., while in powders with a J:C = 3:2 values ranged from 576.7 to 637.7 mg/kg d.m. The highest content of carotenoids and the most yellow colour were observed in powders with 1:3 gum Arabic to maltodextrin ratio. Powders with the highest amount of gum Arabic have the highest diameter and the lowest water activity. High inlet temperature caused brighter colour of powders, higher dry matter content, lower water activity and apparent density of powders.     

多学科结合,实现裂缝控制——读《钢筋混凝土结构裂缝控制指南》

对《指南》中的一些观点进行了讨论,认为将补偿收缩混凝土等抗裂新材料排斥在《指南》之外,仅强调"好好打"存在局限性。赞赏"抗放兼施"的混凝土抗裂原则,提倡只有多学科结合,才能实现混凝土结构的裂缝控制。     

Improvement of the quality of gluten‐free sponge cake using different levels and particle sizes of carrot pomace powder

In this study, carrot pomace powder (CPP) with particle sizes of 210 μm (CPP210) and 500 μm (CPP500) was added in the gluten‐free sponge cake recipe. Flour (rice and corn flour, 1:1, w/w) was replaced with 0, 10, 20 and 30% CPP. With increasing the level and particle size of CPP, batter density, viscosity, consistency and firmness increased. The control cake had a dense, hard texture, irregular shape and low sensory scores. These properties improved with addition of CPP so that the cake density, hardness and cohesiveness reduced, while symmetry index and sensory scores increased. Varying the particle size of CPP had no considerable effects on most of the batter and cake properties, while increasing the level of CPP had great positive effects on the quality of batter and cake. Overall, addition of 30% CPP with either of the particle sizes resulted in an acceptable gluten‐free cake.     

Anthocyanin profile of red fruits and black carrot juices,purees and concentrates by HPLC‐DAD‐ESI/MS‐QTOF

A fast and reliable method for anthocyanin extraction and identification by HPLC‐DAD‐ESI/MS‐QTOF was used to analyse the anthocyanin composition of commercial red fruit juices (blackberry, redcurrant and pomegranate), purees (strawberry, cherry and raspberry) and concentrates (elderberry, blueberry and red grape). The anthocyanin profile of black carrot juice is also reported. The extraction and analysis method allowed us to detect and quantify a wide range of individual anthocyanins in a simple and rapid way. Pelargonidin‐3‐glucoside was detected in redcurrant for the first time and petunidin‐3‐galactoside quantified for the first time in blueberries. Considering the health benefits that have been associated with anthocyanin consumption, all these fruit and vegetables processed products could appear as a good source of this group of phytochemical compounds for their direct consumption or their use as ingredients for the design of new food product or food supplements.     

Clarification and pasteurisation effects on monomeric anthocyanins and percent polymeric colour of black carrot (Daucus carota L.) juice

Black carrots (BCs) are a rich source of stable anthocyanins (ACNs). The purpose of this study was to evaluate the effects of clarification and pasteurisation on ACNs of black carrot juice (BCJ). Monomeric ACNs, ACN profile and percent polymeric colour were determined during processing of BCJ. While depectinisation and bentonite treatments resulted in 7% and 20% increases in monomeric ACN content of BCJ, respectively, gelatine–kieselsol treatment and pasteurisation resulted in 10% and 3–16% reduction. Percent polymeric colour decreased after clarification, but substantially increased in samples subjected to heat. ACNs of BCJ samples were identified by HPLC–MS. Unclarified BCJ contained cyanidin-3-galactoside-xyloside-glucoside-ferulic acid as the major ACN, followed by cyanidin-3-galactoside-xyloside-glucoside-coumaric acid, and cyanidin-3-galactoside-xyloside-glucoside. After depectinisation, two more ACNs (cyanidin-3-galactoside-xyloside and cyanidin-3-galactoside-xyloside-glucoside-sinapic acid) were also identified. These results indicated that depectinisation and bentonite treatment had positive effect on the colour of BCJ, while gelatin–kieselsol treatment and pasteurisation had negative effect.