Vapor linker exchange of partially amorphous metal–organic framework membranes for ultra-selective gas separation

Metal–organic framework (MOF) membranes are promising for efficient separation applications. However, the uncontrollable pathways at atomic level impede the further development of these membranes for molecular separation. Herein we show that vapor linker exchange can induce partial amorphization of MOF membranes and then reduce their transport pathways for precisely molecular sieving. Through exchanging MOF linkers by incoming ones with similar topology but higher acidity, the resulted metal-linker bonds with lower strength cause the transformation of MOF membranes from order to disorder/amorphous. The linker exchange and partial amorphization can narrow intrinsic apertures and conglutinate grain boundary/crack defects of membranes. Because of the formation of ultra-microporous amorphous phase, the MOF composite membrane shows competitive H₂/CO₂ selectivity up to 2400, which is about two orders of magnitude higher than that of conventional MOF membranes, accompanied by high H₂ permeance of 13.4 × 10⁻⁸ mol m⁻² s⁻¹ Pa⁻¹ and good reproducibility and stability.     

提升机启动操作中制动油泵软性停转的分析与排除

同一个多功能集控器件长期使用后，其不同故障程度对应有不同故障现象，为了加快现场技术管理人员对提升机疑难故障的有效排除进度，着重分析了制动油泵停转的控制通道，根据提升机启动操作中制动油泵停转后的排查处理结果，圈定了故障范围为变频控制器件。制动油泵在提升机启动操作中停转的不确定性，查找故障时整机电控系统处于非故障状态，接近更换变频主控板D6时启动提升机操作中制动油泵软性停转次数有所增多、启动中无发生制动油泵停转的全程提升未见异常，上述因素使制动油泵软性停转成为疑难杂症。故障现象恶化为每次操作至制动手把推向松闸位置制动油泵均停转，用梯形图确定D6故障是症结所在。对D6的自身故障精确定位功能且在变频控制柜人机界面RJ2显示故障信息认识不足，导致故障长时存在。此副井提升机有关人员应做到:对故障反映到位、深刻了解器件性能特征、透析有关动作过程后方可采取针对性措施、确定故障元件、最终排除故障。可恢复性的轻故障发生后必须采取相应措施，避免故障扩大导致停机延误提升。将变频就绪与故障的实时信息显示于司控台面，弥补了技改缺陷。     

Design of 25 Gbit/s half-rate CDR with 1:2 demultiplexer for 100 GbE optical interconnects

A 25 Gbit/s clock and data recovery(CDR) circuit with 1:2 demultiplexer for 100 Gbit/s Ethernet(100 Gb E) optical interconnects has been designed and fabricated in Taiwan Semiconductor Manufacture Company(TSMC) 65 nm complementary metal-oxide-semiconductor(CMOS) technology. A novel quadrature voltage-controlled-oscillator(QVCO) structure adopts two pairs of transconductance cell and inverters to acquire rail-to-rail output swing. A half-rate bang-bang phase detector adopts four flip-flops array to sample the 25 Gbit/s input data and align the data phase, so the 25 Gbit/s data are retimed and demultiplexed into two paths 12.5 Gbit/s output data. Experimental results show that the recovered clock exhibits a peak-to-peak jitter of 7.39 ps and the recovered data presents a peak-to-peak jitter of 7.56 ps, in response to 312-1 pseudorandom bit sequence(PRBS) input. For 1.2 V voltage supply, the CDR circuit consumes 92 m W(excluding output buffers).     

Preparation of Silver Nanowires via a Rapid,Scalable and Green Pathway

Rapid synthesis of silver nanowires(Ag NWs) with high quality and a broad processing window is challenging because of the low selectivity of the formation of multiply twinned particles at the nucleation stage for subsequent Ag NWs growth.Herein we report a systematic study of the water-involved heterogeneous nucleation of Ag NWs with high rate(less than 20 min) in a simple and scalable preparation method.Using glycerol as a reducing agent and a solvent with a high boiling point,the reaction is rapidly heated to 210 ℃ in air to synthesize Ag NWs with a very high yield in gram level.It is noted that the addition of a small dose of water plays a key role for obtaining highly pure Ag NWs in high yield,and the optimal water/glycerol ratio is0.25%.After investigating a series of forming factors including reaction temperature and dose of catalysts,the formation kinetics and mechanism of the Ag NWs are proposed.Compared to other preparation methods,our strategy is simple and reproducible.These Ag NWs show a strong Raman enhancement effect for organic molecules on their surface.     

WIRELESS BODY-AREA NETWORKS

The last decade has witnessed the convergence of three giant worlds:electronics,computer science and telecommunications.The next decade should follow this convergence in most of our activities with the generalization of sensor networks.In particular with the progress in medicine,people live longer and the aging of population will push the development of wireless person-     

FINE:Future Internet iNnovation Environment

This article introduces FINE(Future Internet iNnovation Environment) project,which is supported by National High-tech R&D Program( "863" Program) of China.     

高效固体缓释型阻垢剂的研制及性能分析

针对大庆油田集输管道腐蚀结垢现象,以主剂、分散剂、特殊缓蚀阻垢剂和载体配制固体缓蚀阻垢剂,通过复配试验筛选出适合其采出液水质的药剂,并对其缓蚀和阻垢性能进行分析。结果表明:加注药剂后的管道钢腐蚀速率为0.070mm/a,远低于未加注前的0.310mm/a;阻垢效果15天内稳定,阻垢率约为91%,阻垢性能良好;缓释速率为约每10天溶解8%,加注周期约为3个月。所制备药剂性价比高,缓蚀阻垢综合性能良好,可作为油田水驱采出液专用缓蚀阻垢药剂。     

颗粒在椭圆形回转干馏炉内运动分析

通过实验研究颗粒在不同椭圆滚筒内的运动情况,分析了不同填充率、不同转速和不同颗粒粒径对其的影响。由实验得出:颗粒在椭圆不同位置的运动情况并不一致,随着长短轴之比变大,运动趋于平缓;填充率降低会引起颗粒运动模式过渡区间变大,进入小瀑布模式所需转速增加;颗粒粒径增大,颗粒在筒内受重力、摩擦力的影响变得更加明显,在长轴垂直水平位置,所受惯性影响更加显著,并出现明显的多种模式相结合的运动形式。     

基于Fluent的水击泄压阀阻力系数研究

针对长输油管道广泛应用的水击泄压阀,应用CFD方法对其内部流场进行了分析计算。按照实际泄压阀的结构,建立了简化后的二维流场几何模型,根据模拟的流场压力分布计算不同开度、不同开启压力和不同管径下泄压阀的阻力系数,指出泄压阀的阻力系数与开度、管径有关,开启压力对泄压阀的阻力系数几乎没有影响。