Performance of BaZrO3/Y2O3 dual-phase refractory applied to TiAl alloy melting

Vacuum induction melting is a potential process for the preparation of TiAl alloys with good homogeneity and low cost. But the crucial problem is a selection of high stability refractory. In this study, a BaZrO₃/Y₂O₃ dual-phase refractory was prepared and its performance for melting TiAl alloys was studied and compared with that of a Y₂O₃ refractory. The results showed the dual-phase refractory consisted of BaZr_1-xY_xO_3-δ and Y₂O₃(ZrO₂), exhibited a thinner interaction layer (30 μm) than the Y₂O₃ refractory (90 μm) after melting the TiAl alloy. Although the TiAl alloys melted in the dual-phase and Y₂O₃ refractory exhibited similar oxygen contamination (<0.1 wt%), the alloy melted in the dual-phase refractory had smaller Y₂O₃ inclusion content and size than that in the Y₂O₃ refractory, indicating that the dual-phase refractory exhibited a better melting performance than the Y₂O₃ refractory. This study provides insights into the process of designing highly stable refractory for melting TiAl alloys.     

Al2O3对镁铬耐火材料致密化的影响

为了提高镁铬耐火材料的烧结性能,通过考察气孔率、体积密度和常温耐压强度与Al2O3加入量之间的关系,讨论了Al2O3添加剂对两种不同镁铬耐火材料致密化的影响.结果表明,镁铬耐火材料的骨料不同,Al2O3对其烧结性能和致密化的影响也不一样.     

难洗选铁矿工艺流程改造

介绍了他达铁矿高平洗选厂由于矿石原矿性质变化，原工艺流程已不能满足生产要求，进行技改的措施、工艺设计。     

臭氧氧化法在深度处理难降解有机废水中的应用

臭氧氧化作为一种有效的深度处理技术,对难降解有机废水具有良好的降解功效.介绍了臭氧的性质及氧化机理,分析了臭氧氧化法在处理纺织印染废水、造纸废水、垃圾渗滤液、炼油废水、焦化废水等难降解有机废水中的应用,指出了臭氧氧化存在的问题.     

蛇纹石矿的开发利用现状及发展趋势

我国拥有丰富的蛇纹石矿资源，其中有许多在近些年已得到较好的开发利用。综述了蛇纹石矿的开发研究现状，指出蛇纹石矿作为耐火材料及Mg、Ni及Pd等有价金属的重要矿物来源，应加强选矿及综合利用方面的研究。     

电炉钢外来夹杂控制的研究

介绍了夹杂物的来源,包括内生夹杂和外来夹杂,着重于二次氧化产物、卷渣、内衬侵蚀.同时介绍了鄂钢电炉厂在冶炼和连铸过程中控制夹杂物的操作实践.     

The Locus of Redundant-Targets and Nontargets Effects: Evidence From the Psychological Refractory Period Paradigm.

In target detection tasks, responses are faster when displays have 2 targets (redundant-targets effect; RTE) and slower when they have no targets (nontargets effect; NTE) relative to displays with a single target. The psychological refractory period paradigm was used to localize these effects. In Experiment 1, participants classified tones as high or low and then classified letters as targets or nontargets after a short or long stimulus onset asynchrony (SOA). The magnitudes of the RTE and NTE did not depend on SOA. In Experiment 2, the order of the tasks was reversed, and at short SOAs the RTE and NTE had similar magnitudes for both tone discrimination and target detection responses. These findings suggest that the RTE and NTE arise during response selection. Interactive effects of tone pitch with the number and type of target features were also observed, and these were tentatively interpreted as synesthetic effects. (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

含砷、锑、碳难处理金精矿焙烧氰化提金工艺研究

镇沅含砷、锑、碳难处理金精矿直接氰化金浸出率小于 10 % ,采用常规焙烧 -焙砂氰化提金工艺金浸出率仅达到 73 2 % ,而采用先行除锑 ,再焙烧脱除硫、碳、砷的提金工艺方案 ,金氰化浸出率达到90 4 % ,同时锑可作为锑精矿外售 ,经济效益明显。     

稀土锆莫来石耐火材料的显微结构研究

本文运用ＸＲＤ、ＳＥＭ等方法对稀土锆莫来石耐火材料的显微结构，物相变化，以及稀土的作用机制进行了研究。     

攀钢高炉焖砂口试验

分析了高炉冶练钒钛磁铁矿炉前砂口损坏的原因。对新型砂口泥进研制，同时改进了套砂口工艺，满足了攀钢高炉焖砂口的需要。攀钢高炉采用闷砂口工艺后，从根本上解决了铁水带渣问题，提高了铁水的洁净度。