首页 | 本学科首页   官方微博 | 高级检索  
     

空气弹簧在100%低地板轻轨车上应用可行性分析*
引用本文:范韶轩,戚壮,莫荣利,叶特.空气弹簧在100%低地板轻轨车上应用可行性分析*[J].动力学与控制学报,2020,18(3):22-30.
作者姓名:范韶轩  戚壮  莫荣利  叶特
作者单位:石家庄铁道大学 机械工程学院,石家庄 050043,石家庄铁道大学 机械工程学院,石家庄 050043,中国中车株洲时代新材料科技股份有限公司,株洲 412000,中国中车株洲时代新材料科技股份有限公司,株洲 412000
基金项目:(A2018210064)
摘    要:基于多体动力学仿真软件SIMPACK,对某型采用纵向耦合边驱电机转向架的100%低地板轻轨车三模块编组建模,在MATLAB/Simulink中对其中央悬挂部件空气弹簧的主气室、节流孔、附加气室建模.对100%低地板轻轨车运行工况进行设定,通过联合仿真的方式对空气弹簧在100%低地板轻轨车上应用可行性进行分析,得到:1)空气弹簧应用到100%低地板车上后,车辆蛇行失稳临界速度为149km/h,大于设计时速,车辆有较好的运行稳定性.2)车辆运行时,平稳性及最大加速度指标均小于2.5,车辆有较好的运行平稳性.3)车辆通过小半径曲线时,轮重减载率、脱轨系数、轮轴横向力、轮轨横向力指标均小于评判标准限值,车辆有较好的曲线通过能力.4)空气弹簧在通过工况设定的小半径曲线时,各项性能指标均符合该型空气弹簧技术标准,空气弹簧在100%低地板轻轨车上应用可行.

关 键 词:100%低地板轻轨车,  空气弹簧,  稳定性,  平稳性,  曲线通过性
收稿时间:2020/5/14 0:00:00
修稿时间:2020/5/14 0:00:00

FEASIBILITY ANALYSIS OF AIR SPRING IN 100% LOW FLOOR LIGHT RAIL VEHICLE*
Fan Shaoxuan,Qi Zhuang,Mo Rongli and Ye Te.FEASIBILITY ANALYSIS OF AIR SPRING IN 100% LOW FLOOR LIGHT RAIL VEHICLE*[J].Journal of Dynamics and Control,2020,18(3):22-30.
Authors:Fan Shaoxuan  Qi Zhuang  Mo Rongli and Ye Te
Abstract:A three-module marshaling model for a 100% low floor light rail vehicle with longitudinal coupled side-motor drive bogies was built by using the multi-body dynamics simulation software SIMPACK. The main plenum, orifice, and additional plenum of the central suspension air spring were modeled by MATLAB/Simulink. The operating conditions of the 100% low-floor light rail vehicles were set, and the feasibility of using air springs in the 100% low-floor light rail vehicle were analyzed by co-simulation combining SIMPACK and MATLAB/Simulink. The results indicated that both the vehicle stability and curve passing ability are improved after using the air spring. Specifically, the critical speed of hunting instability is increased to 149km/h, which is higher than the design speed. Both the stability and the maximum acceleration index are less than 2.5 as the vehicle runs. When the vehicle passes through a small-radius curve, all the wheel load reduction ratio, derailment coefficient, wheel lateral force, and wheel rail lateral force are less than the evaluation standard limit, and all the performance indices meet the technical standards of this type of air spring. Therefore, the application of air spring to the 100% low-floor light rail vehicle is feasible.
Keywords:100% low  floor light  rail car    air  spring    stability    stability    curve  passing
本文献已被 CNKI 等数据库收录!
点击此处可从《动力学与控制学报》浏览原始摘要信息
点击此处可从《动力学与控制学报》下载全文
设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号