| 硅藻精土制备硅酸钠工艺研究 |
| |
| 引用本文： | 胡志波,李佳旺,郑水林,演阳,徐春宏. 硅藻精土制备硅酸钠工艺研究[J]. 无机盐工业, 2014, 46(3): 19 |
| |
| 作者姓名： | 胡志波 李佳旺 郑水林 演阳 徐春宏 |
| |
| 作者单位： | 中国矿业大学（北京）化学与环境工程学院，北京 100083 |
| |
| 基金项目： | 国家“十二五”科技支撑计划项目“低品位硅藻土资源高效利用与深加工关键技术研究(2011BAB03B07)” |
| |
| 摘 要： | 硅藻土的主要化学成分是非晶质二氧化硅。以临江低品位硅藻土矿选矿精土为原料，采用水热碱溶法进行碱溶制备硅酸钠工艺的研究。以硅藻精土中二氧化硅的溶出率以及制得硅酸钠的硅钠比作为评价指标，研究了碱溶时间、碱溶温度、液固质量比以及碱土质量比对二氧化硅溶出率和硅酸钠硅钠比的影响规律。结果表明，在其他条件相同的情况下，碱土比越大，二氧化硅溶出率越高，硅酸钠的硅钠比越小。在碱溶时间为90 min、碱溶温度为 96 ℃、液固质量比为2.5、碱土质量比为1.24条件下，二氧化硅的溶出率为93.22%，硅酸钠的硅钠比为0.96，硅酸钠的产出率为100 g硅藻精土可制得硅酸钠169.35 g。
|
| 关 键 词： | 硅藻精土 水热碱溶 硅酸钠 |
Process research on preparation of sodium silicate by purified diatomite |
| |
| HU Zhi-Bo,LI Jia-Wang,ZHENG Shui-Lin,YAN Yang,XU Chun-Hong. Process research on preparation of sodium silicate by purified diatomite[J]. Inorganic Chemicals Industry, 2014, 46(3): 19 |
| |
| Authors: | HU Zhi-Bo LI Jia-Wang ZHENG Shui-Lin YAN Yang XU Chun-Hong |
| |
| Affiliation: | School of Chemical & Environmental Engineering，China University of Mining and Technology，Beijing 100083，China |
| |
| Abstract: | The main chemical component of diatomite is amorphous silica.Preparation technology of sodium silicate by water-heated alkali reaction and with Linjiang low-grade diatomite after mineral processing was studied.The influences of the time and temperature of alkali-dissolved reaction，mass ratio of liquid to solid and mass ratio of sodium hydroxide to diatomite on the dissolution rate of silica as well as on Si/Na ratio of sodium silicate were investigated.Results showed that dissolution rate of SiO2 improved and the Si/Na ratio decreased obviously as the mass ratio of sodium hydroxide /diatomite increased under the same conditions.It was verified that the optimal experiment results：dissolution rate of SiO2 was 93.22%，Si/Na ratio of sodium silicate was 0.96，and the output ratio of sodium silicate was 169.35 g when diatomite was 100 g under the conditions as following: time of alkali-dissolved reaction was 90 min，the temperature of alkali-dissolved reaction was 96 ℃，mass ratio of liquid to solid was 2.5，and mass ratio of sodium hydroxide /diatomite was 1.24. |
| |
| Keywords: | purified diatomite water-heated alkaline reaction sodium silicate |
| 本文献已被 CNKI 等数据库收录！ |
| 点击此处可从《无机盐工业》浏览原始摘要信息 |
|
点击此处可从《无机盐工业》下载全文 |
