| 空气外掠钢渣颗粒准则关系式及其影响因素 |
| |
| 引用本文： | 米沙, 谢锴, 孙岱, 李启. 空气外掠钢渣颗粒准则关系式及其影响因素[J]. 工程科学学报, 2016, 38(9): 1242-1249. DOI: 10.13374/j.issn2095-9389.2016.09.007 |
| |
| 作者姓名： | 米沙 谢锴 孙岱 李启 |
| |
| 作者单位： | 中南大学能源科学与工程学院,长沙,410083;中南大学信息科学与工程学院,长沙,410083 |
| |
| 基金项目： | 国家高技术研究发展计划资助项目(2009AA064603) |
| |
| 摘 要： | 通过空冷固态高温钢渣颗粒实验,由实验数据拟合平均努塞尔数实验关联式.对空冷高温钢渣颗粒进行三维数值模拟,研究不同绕流雷诺数下的准则关系式,分析空气外掠固态钢渣颗粒影响因素.研究得出空气冷却固态钢渣颗粒的实验关联式与数值计算关联式,实验与数值计算之间误差较小,验证了采用SST k-ω模型计算的可靠性.实验结果表明:钢渣颗粒的平均努塞尔数随着绕流雷诺数、粒径和气体流速的增大而增大.在同等条件下,钢渣粒径对平均努塞尔数的影响作用大于气体流速;模拟空冷高温钢渣颗粒时,直径对钢渣颗粒凝固时间的影响作用最大,导热系数的影响作用次之,来流空气温度影响作用最小.
|
| 关 键 词： | 钢渣 颗粒 气流 影响因素 努塞尔数 凝固时间 |
| 收稿时间： | 2015-06-03 |
Criterion equations and influencing factors of air flow around steel slag particles |
| |
| MI Sha, XIE Kai, SUN Dai, LI Qi. Criterion equations and influencing factors of air flow around steel slag particles[J]. Chinese Journal of Engineering, 2016, 38(9): 1242-1249. DOI: 10.13374/j.issn2095-9389.2016.09.007 |
| |
| Authors: | MI Sha XIE Kai SUN Dai LI Qi |
| |
| Affiliation: | 1. School of Energy Science and Engineering, Central South University, Changsha 410083, China;2. School of Information Science and Engineering, Central South University, Changsha 410083, China |
| |
| Abstract: | The experiment of air flowing high-temperature steel slag particles was done and the experimental correlation of non-di-mensional average Nusselt number was fitted. A three-dimensional numerical simulation of air-cooled high-temperature steel slag parti-cles was performed to study the criterion equations in different conditions and to analyze the influencing factors of air sweeping solid steel slag particles. The experimental correlation and numerical calculation of air-cooled solid steel slag particles were gained, and the error between the experimental and numerical calculation is very small, which verifies the reliability of the SST k-ω model. The results show that the average Nusselt number of slag particles increases with the increase of streaming Reynolds number, particle diameter, and air velocity. The particle diameter effect on the average Nusselt number is larger than the air velocity under the same conditions. The influence of the steel slag particle diameter on the solidification time is the largest, the thermal conductivity is the second, and the air stream temperature is the smallest. |
| |
| Keywords: | steel slag particles air flow influencing factors Nusselt number solidification time |
| 本文献已被 万方数据 等数据库收录！ |
| 点击此处可从《工程科学学报》浏览原始摘要信息 |
|
点击此处可从《工程科学学报》下载免费的PDF全文 |
|
