Adsorption of superplasticizers in fly ash blended cement pastes and its rheological effects

The adsorption of superplasticizers in fly ash blended cement paste and its rheological effects were investigated.It is shown that the absorption of superplasticizer on portland cement particles is very different from that on fly ash particles.The fly ash particles have smooth surfaces and are negatively charged,so its adsorption capacity is weaker than the portland cement particles.The amount of adsorbed SP in the fly ash blended cement paste depends highly on the replacement proportion of portland cement with fly ash,and to a much less extent on the nature of the fly ash.However,the amount of adsorbed superplasticizer does not correspond well the ζ-potential of the solid particles,due the strong adsorbing capacities of the Portland cement particles.When fly ash replaces portland cement in the paste,the rheological behavior is radically changed,which is closely related to the fineness and density of the ash.The packing and agglomeration of the solid particles are the controlling factors on the rheological parameters of the fresh paste,instead of the amount and type of adsorbed superplasticizer.     

Influence of ultra-fine fly ash on hydration shrinkage of cement paste

1INTRODUCTION Hydrationshrinkageisalsoknownaschemicalshrinkage[1].Thesolidvolumeincreasesafterce menthydrating,buttheabsolutevolumeofcementwatersystemreduces.Usuallythetotalamountofvolumeshrinkageofcementwatersystemis7%9%[1,2].Withthedevelopmentofthetechno logyofcementandconcrete,concretewithhighstrengthandhighperformanceisthedevelopingtendencynow.However,nowadays,comparedwithordinaryconcrete,thehydrationshrinkageofhighperformancecementconcreteincreasesobvi ouslybecauseoftheaccelerationof…     

复合浆体中粉煤灰和水泥水化反应程度的测定

采用盐酸选择溶解法测定粉煤灰的水化程度,再结合水化热法计算复合浆体中水泥的水化程度。试样结果表明,在水化早期粉煤灰仅作为惰性材料填充于复合浆体的孔隙中。随着粉煤灰掺量的增大,水泥的水化程度越高,单位体积中水化产物的总体数量仍为减少。     

Effect of MSWI fly ash and incineration residues on cement performances

The activities of municipal solid waste incineration (MSWI) fly ash and incineration residues were studied contrastively, through the component analysis and the activity ratio tests. The mechanical properties, hydration mechanism and leaching toxicity of the hardened cement paste mixing with MSWI fly ash and incineration residues were investigated. The experimental results indicated that the active constituents (CaO+Al₂O₃+Fe₂O₃) in MSWI fly ash were higher than those in incineration residues. Therefore the activity ratio of MSWI fly ash was 43.58%, twice as much as that of incineration residues. Meanwhile, the hydration of cement was delayed by mixing with MSWI fly ash and incineration residues, which also reduced the cement strength markedly. By adding with exceeding 20% MSWI fly ash, the specimens expanded and microcracks appeared. The leaching toxicities of cement pasted mixed with MSWI fly ash and incineration residues were lower than the Chinese national standard. Accordingly the cement mixed by MSWI fly ash and incineration residues can be considered as the environment-friendly materials.     

低水胶比下粉煤灰对水泥早期水化的影响

提出可用等效结合水含量和水化影响因子来定性和定量分析粉煤灰对水泥早期水化作用的大小。若粉煤灰的水化影响因子 >1,则粉煤灰促进水泥水化 ,值越大 ,促进作用越显著 ;若粉煤灰的水化影响因子 <1,则粉煤灰延缓水泥水化 ,值越小 ,延缓作用越显著。同时研究和分析了低水胶比下粉煤灰不同品种和掺量对水泥早期水化的影响     

Effect of MSWI Fly Ash and Incineration Residues on Cement Performances

The activities of municipal solid waste incineration (MSWI) fly ash and incineration residues were studied contrastively, through the component analysis and the activity ratio tests. The mechanical properties, hydration mechanism and leaching toxicity of the hardened cement paste mixing with MSWI fly ash and incineration residues were investigated. The experimental results indicated that the active constituents (CaO+Al2O3+Fe2O3) in MSWI fly ash were higher than those in incineration residues. Therefore the ...     

The Rheological Properties of Ultra-fine High PerformanceGrouting Cement

The material properties of surface and powder, rheological property and mineral composition were investigated by means of SEM, XRD, Malvern laser granulometer and rotary viscometer. The influence of admixture on ultra-fine cement rheological properties and its mechanism were studied in material theories. The results show that the ultra-fine fly ash has a higher zeta potential, and improves flowability of ultra-fine cement paste, decreases Jlowability loss as time prolonging, improves compatibility between superplasticizers and cement because of the electrostatic repulsion, ball bearing effect, filling and dispersing effect of admixtures and delay-releasing effect of superplasticizers.     

外掺材料对多孔水泥混凝土胶浆强度的影响研究

文章采用超细粉煤灰与硅灰的复合技术配制多孔水泥混凝土水泥浆体试件.通过与双掺硅灰和减水剂、双掺粉煤灰和减水剂以及复合掺粉煤灰、硅灰和减水剂的情况对比,系统研究了硅灰粉煤灰作为外掺挤对多孔水泥混凝土水泥浆体的强度的影响.实验结果表明,由于硅灰与超细粉煤灰的复合,在水泥浆体形成过程中,这2种材料充分发挥了各自的功能效应,使得多孔水泥混凝土水泥浆体的强度性能显著提高.文章通过扫描电镜试验,剖析了超细粉煤灰与硅灰复合效应的机理,论证了用超细粉煤灰和硅灰以及减水剂复合配制多孔水泥混凝土水泥浆体的可行性.     

Mineralogical and Active Mechanical Excitation Characteristics of Filled Fly Ash Cementitious Materials

To reveal the influence of mechanical activation on the performance of fly ash, the microanalysis(the energy spectroscopy, XRD and SEM), the distribution size of particle of fly ash and cement paste intensity of various age for different grinding time were studied. The relationships of the activity and the composition of fly ash, microstructure and the distribution of particle size by mechanical activation of fly ash were obtained. The internal glass beads with activity were released by grinding fly ash for a certain time. The particle specific surface area was improved and the hydration reaction of the interface and the surface active center was increased by grinding. The granularity distributing of fly-ash trended towards optimization. The polar molecules or ions were easier to intrude into the internal cavity of the vitreous body. The active silica and alumina of fly ash were rapidly depolymerized. Each performance index of fly ash was increased before grinding for 20 min. Cement paste intensity of various age increased along with the grinding time, and the early strength increase range was big, but the later period intensity increase range hastened slightly. The internal part of vitreous of fly ash was destroyed if the fly ash continued to be ground and the activity of fly ash was reduced. It is suggested that Guozhuang's fly ash should be ground for 20 min.     

矿物掺和料对水泥浆体的流变性和相容性的影响

不同的矿物掺和料及其掺量,对水泥浆体的流变性及与外加剂的相容性有不同的影响.通过水泥浆体的扩展度和黏度2个指标来研究矿物掺和料对水泥浆体的流变性及与外加剂的相容性的影响.试验结果表明：在最佳掺量时,矿物掺和料对改善浆体流变性和相容性效果最好,且不同的矿物掺和料的最佳掺量区别较大.硅灰的最佳掺量为5%～10%;普通矿粉的最佳掺量为10%;2种超细矿粉和粉煤灰的最佳掺量为20%～30%.     

利用高钙粉煤灰生产粉煤灰水泥的试验研究

研究了高钙粉煤灰水泥的细度及活性激发剂对其物理性能的影响。研究结果表明,高钙粉煤灰水泥的安定性和各龄期的抗折、抗压强度均随着水泥的细度的提高和活性激发剂的掺入而提高,活性激发剂具有加速水泥矿物和ｆ Ｃａ Ｏ 水化的作用。采用５２５＃ 熟料,掺加３０％ 的高钙粉煤灰时,水泥的比表面积在３４０～４００ ｍ ２ ／ｋｇ 和掺入１％ 的活性激发剂,能够稳定生产４２５＃ 高钙粉煤灰水泥。     

混合材对MSWI制CSA水泥性能的影响

以城市垃圾焚烧飞灰（MSWI）为主要原料,在实验室成功烧制了硫铝酸钙（CSA）水泥熟料.研究了单掺或复掺不同种类、不同掺量的混合材后,CSA水泥的力学性能和水化性能.结果表明：石灰石粉（LI）/矿渣粉（SL）在CSA水泥中较为适用,而粉煤灰（FA）/MSWI的活性较差;单掺4种混合材均对CSA水泥早期强度产生不利影响;单掺LI/SL对后期强度发展有益;复掺混合材较单掺效果好,尤其是试样10％LI＋10％SL、10％LI＋10％MSWI和5％LI＋15 ％SL.     

粉煤灰-脱硫石膏水泥基材料水化活性及微结构

采用DTA—TG、XRD、SEM以及宏观水化收缩和强度试验等手段研究了粉煤灰一脱硫石膏一水泥三元复合胶凝体系的水化过程、活性效应及微观结构等,根据试验结果总结了复合胶凝材料的水化动力学过程。结果表明,粉煤灰一脱硫石膏水泥石的钙矾石吸热峰强于基准样;在各组分相互活性激发和外掺激发剂作用下,粉煤灰一脱硫石膏水泥石中2次水化效应明显;SEM、XRD表明水泥石早期有明显的钙矾石生成,同时粉煤灰颗粒的表面侵蚀现象明显,进一步说明复合胶凝体系的早期活性得到有效激发,硬化后综合性能得到有效保证。且宏观收缩及强度试验也从侧面印证了微观试验结果。粉煤灰一脱硫石膏水泥基复合胶凝材料体系的研发可大量消耗燃煤电厂的工业废渣,具有显著的“绿色”效应。     

Comparison of hydration properties between cement-GGBS-fly ash blended binder and cement-GGBS-steel slag blended binder

The hydration properties of cement-GGBS-fly ash blended binder and cement-GGBS-steel slag blended binder were compared. The experimental results show that the hydration rate of cement-GGBS- steel slag blended binder is higher than that of cement-GGBS-fly ash blended binder within 28 days, but lower than the latter after 28 days. The hydration of cement-GGBS-steel slag blended binder tends to produce more Ca（OH）2 than the hydration of cement-GGBS-fly ash blended binder, especially at late ages. Cement-GGBS- steel slag mortar exhibits higher strength than cement-GGBS-fly ash mortar within 28 days, but at late ages, it exhibits similar compressive strength with eement-GGBS-fly ash mortar and even slightly lower bending strength than cement-GGBS-fly ash mortar. Cement-GGBS-steel slag paste has finer early pore structure but coarser late pore structure than cement-GGBS-fly ash paste. Cement-GGBS-steel slag paste can get satisfied late pore structure and cement-GGBS-steel slag mortar can get satisfied late strength as compared with pure cement paste and pure cement mortar, respectively.     

粉煤灰硅酸盐水泥的研制

研究在不同掺量、不同水胶比、不同养护龄期下粉煤灰硅酸盐水泥的水化进度、各组分含量以及各项力学性能.明确粉煤灰在水泥基材料中所发挥的作用,了解粉煤灰在水化过程中对各组分产物形成某些特定的影响,作为粉煤灰在水泥基材料中的合理有效应用提供理论依据和实践指导.     

Effect of Fly Ash and Silica Fume on Hydration Rate of Cement Pastes and Strength of Mortars

The effect of fly ash and silica fume on hydration rate and strength of cement in the early stage was studied. Contrast test was applied to the complex cementitious system to investigate the hydration rate. Combined with mechanical strength, the influence of fly ash and silica fume during the hydration process of complex binder was researched. The peak of the rate of hydration heat evolution and the mechanical strength decreased as the ratio of fly ash increased, however, as the ratio of silica fume increased, the peak of the rate of hydration heat evolution and the mechanical strength increased obviously. When the ratios of fly ash and silica fume are 10% and 5%, the peak of the rate of hydration heat evolution is the highest. At the same time 7 days of flexural and compressive strength are the highest as 8.89 MPa and 46.52 MPa, respectively. Fly ash and silica fume are the main factors affecting the hydration rate and the mechanical property.     

搅拌时间对粉煤灰水泥净浆流动性及早期抗压强度的影响

影响粉煤灰水泥净浆的流动性与早期抗压强度等问题一个重要原因就是拌合是否充分,搅拌时间是否合适。现有的相关规范中对于拌合时间的规定大都针对普通混凝土,随着高性能混凝土的发展,尤其是粉煤灰混凝土近几年来的广泛使用,导致现有的拌合时间规定无法满足粉煤灰混凝土均匀性的控制要求。为此,通过初步研究不同拌合时间对不同掺量的粉煤灰水泥净浆流动性及早期抗压强度的影响,最终确定合理的粉煤灰水泥净浆拌合时间,供进一步研究与工程应用参考。     

矿物掺和料-水泥浆体电学特性与其微结构的关系

采用循环伏安法和交流阻抗法系统研究了粉煤灰、矿渣粉和石灰石粉水泥浆体的电学特性,通过等效电路对电学测试结果进行拟合,并将拟合所得浆体电学参数与浆体化学结合水和压汞所测孔结构之间的相关性进行比较。结果表明：浆体的化学结合水与其电阻率具有较好的正相关性,即化学结合水越多,水化程度越大,浆体电阻率越高;粉煤灰和矿渣粉可以提高浆体电阻率,而石灰石粉在5%掺量下对浆体电阻率无影响;随着水化龄期的延长,浆体孔溶液电阻增大,其变化规律与浆体电阻率一致;浆体凝胶电容和凝胶电阻与C-S-H凝胶含量有关,二者有很好的负相关性;随着水化龄期的延长,浆体孔结构曲折程度提高,交流阻抗法所测得常相角指数减小,压汞测得的分形维数增大。     

聚合物-水泥基注浆材料早期流变及水化特性

为制备满足复杂地层加固工程需求的高性能水泥基注浆材料,探究以偏铝酸钠(SA)、聚羧酸(Sp)及高吸水性树脂(SAP)为组分的聚合物体系及其掺量对新拌水泥浆体流变特性与泌水率的影响,并采用水化放热监测与倒置荧光显微技术,对不同体系下水泥浆体早期水化进程及微米级颗粒的悬浮分散形态进行分析.结果表明:新拌水泥浆液流动性和泌水率与SA、SAP掺量呈负相关,随Sp掺量增加而提高. Sp及SAP延缓了水泥早期水化进程,改性样延迟近1 h进入水化诱导期,诱导期内水化放热速率显著降低.在不同掺量SA的促凝效应、Sp的分散效应以及SAP的"水库"作用下,新拌水泥浆液表现为初始及经时流动度大于200 mm的高流态期可分别被控制在10、20、30 min内且析水率小于5%(稳定性浆液),接近临界期时流动度陡降、流变参数突增并迅速凝结的流变特性.结合微观结构观测结果,建立了新拌水泥浆体流变演化模型,揭示多聚合物协调效应下水泥浆体呈现分散-储水-流变-水化的早期流变机制.     

低水胶比下工业废渣与水泥熟料的相互作用

探索了工业废渣与水泥熟料相互作用的定量指标.以掺惰性材料———刚玉粉的水泥水化样作参比样,研究和分析了低水胶比下粉煤灰、煤矸石与水泥熟料的相互作用.实验中粉煤灰掺量为10%~80%,煤矸石掺量为20%~60%,龄期为1~672 h.结果表明,水泥中掺入粉煤灰和煤矸石,由于水泥熟料用量降低而产生的稀释作用促进了水泥熟料的水化,而其他物理化学作用则依工业废渣的掺量、水化样龄期的不同而表现为促进或延缓水泥熟料的水化.