Optimization of stepwise blanching of frozen-thawed potato tissues (cv. Monalisa)

 Response surface methodology was used to compare the effect of temperature and time of the first step of blanching on compression, shear, tension and stress-relaxation parameters of frozen-thawed potato tissues. A central, composite rotatable design was used to study the effects of variation in levels of temperature (52.93–67.07  °C) and time (15.86–44.14 min) on rheological parameters. Blanching temperature was the most important factor affecting the mechanical properties tested. The models fitted for the apparent modulus of elasticity in compression, maximum tension force, and relaxed force in the first cycle (F _r1); all had R ²>0.85 (P≤0.01) and were used for doing predictions. Optimum conditions were with in the ranges of temperature (60–65  °C) and time (25–35 min) used for each factor. In the experimental verification of the models at 65  °C during 30 min, the lowest percentage residual between experimental and predicted values was obtained for F _r1 (0.644), which was therefore the most appropiate parameter for detecting the firming effect that the pectinesterase activity produced on frozen potato tissues as a consequence of stepwise blanching under these conditions. Received: 3 February 1999 / Revised version: 12 April 1999     

The effectiveness of ozone and acidulant treatments in extending the refrigerated shelf life of fresh-cut potatoes

Abstract: The objective of the study was to determine the effectiveness of acidulant dip treatments (with or without aqueous ozone) to reduce enzymatic browning and to extend the shelf life of fresh‐cut potato slices during refrigerated storage (4 °C) for 28 d. Potato slices subjected to aqueous ozone (2 ppm) had significantly (P≤ 0.05) higher L‐values and lower a‐values, but ozone did not appear to have any effect on aerobic plate counts (APCs) or polyphenol oxidase (PPO) activity. NatureSeal (NS) and sodium acid sulfate (SAS) were the most effective acidulant treatments in reducing browning (significantly [P≤ 0.05] higher L‐values, lower a‐values, and browning index values) regardless of ozone treatment. NS and SAS also had lower PPO activity compared to other treatments on days 0 and 28, and significantly (P≤ 0.05) lower APCs (≤2.00 log CFU/g) over refrigerated storage. Therefore, the SAS treatment was comparable to NS, a commercially available product, and showed promise as an effective antibrowning dip to reduce browning and spoilage in fresh‐cut potato products. Practical Application: A 1% SAS dip treatment which included 1% citric and 1% ascorbic acid was found to be an effective antibrowning dip for fresh‐cut potatoes along with NatureSeal®'s PS‐10, compared to other treatments. They were both effective in maintaining low microbial counts over refrigerated storage. Additionally, aqueous ozone washes (2 ppm) showed significant benefits to reduce browning; however, ozone did not affect microbial counts or PPO enzyme activity. Therefore, the SAS treatment could have potential use in the fruit and vegetable industry to reduce browning and spoilage in fresh‐cut potato products.     

Storage time effect on the rheology of refrigerated potato tissue (cv. Monalisa)

 Potato tubers were held in refrigerated storage and their firmness periodically sampled over a period of 140 days. At each sampling, the rheological properties uniaxial compression, shear, uniaxial tension, successive cycles of stress relaxation, creep compliance and texture profile analysis were determined, as was moisture content. Compression energy, maximum shear force, longitudinal tension stiffness and maximum tension deformation, stress relaxation parameters and moisture content were all significantly affected by storage time. Relaxed forces decreased consistently and linearly with time over a 140-day storage period, reflecting the decrease in cell turgor pressure resulting from the predominance of water loss through evaporation over water production. Longitudinal tension stiffness and maximum shear force increased linearly in the early stages, reflecting the increase in cell wall stiffness and elastic tissue behavior. Maximum tension deformation increased linearly with time reflecting the plastic deformation of the cell wall caused by growth in cell turgor pressure at early stages. Changes in the trends of rheological parameters over 140, 64 and 28 days evidenced the importance of extending the time period considered for rheological parameters of potato tissue. Received: 28 December 1999     

Use of UV-C treatments to maintain quality and extend the shelf life of green fresh-cut bell pepper (Capsicum annuum L.)

Abstract: The objective of this work was to select a Ultraviolet‐C (UV‐C) treatment for fresh‐cut mature green bell pepper, and to evaluate the effect of its combination with refrigeration on quality maintenance. Bell pepper sticks were treated with 0, 3, 10, or 20 kJ/m² UV‐C in the outer (O), inner (I), or both sides of the pericarp (I/O) and stored for 8 d at 10 °C. During the first 5 d of storage, all UV‐C treatments reduced deterioration as compared to the control. The treatment with 20 kJ/m² I/O was the most effective to reduce deterioration, and was used for further evaluations. In a second group of experiments, mature green bell pepper sticks were treated with 20 kJ/m² I/O, stored at 5 °C for 7 or 12 d and assessed for physical and chemical analysis, and microbiological quality. UV‐C‐treated fruit showed lower exudates and shriveling than the control. UV exposure also reduced decay, tissue damage, and electrolyte leakage. After 12 d at 5 °C, UV‐C irradiated peppers remained firmer and had higher resistance to deformation than the control. The UV‐C treatments also reduced weight loss and pectin solubilization. UV‐C exposure decreased the counts of mesophile bacteria and molds, and did not affect acidity or sugars. UV‐C‐treated fruit stored for 0 or 7 d at 5 °C did not show major differences in antioxidants from the control as measured against DPPH^? or ABTS^?+ radicals. Results suggest that UV‐C exposure is useful to maintain quality of refrigerated fresh‐cut green pepper. Practical Application: Exposure to UV‐C radiation before packing and refrigeration could be a useful nonchemical alternative to maintain quality and reduce postharvest losses in the fresh‐cut industry.     

Optimisation of freezing process with pressure steaming of potato tissues (cv Monalisa)

Response surface methodology (RSM) was used for determining optimum conditions of the freezing process on pectinesterase (PE) activity, rheological parameters and textural properties in potato tissues. In the process of production of frozen potatoes, the second step of the stepwise blanching prior to freezing was considered as a fixed factor and performed at 97 °C for 2 min as well as the freezing rate in the freezing step itself, which was carried out at −2 °C min⁻¹. The effects of variation in levels of temperature (57.93–72.07 °C) and time (15.86–44.14 min) in the first blanching step on the PE activity were studied using a central composite rotatable design. A Box–Behnken factorial design was used to investigate the effects of simultaneous variation of temperature (60–70 °C) and time (20–40 min) in the first blanching step and steaming temperature (112–122 °C) and time (1–3 min) on rheological parameters and textural properties. Blanching temperature was the independent variable that most influenced either enzymatic activity or rheological parameters. Stationary points showing maximum PE activity had critical temperature and time values of 64.22 °C and 29.37 min before freezing and 64.39 °C and 28.02 min after freezing and steaming of the tissues, and these values were very close to those obtained for some creep compliance parameters. Results show a high correlation between increases in PE activity and tissue firmness below optimum experimental freezing conditions, proving the role of the enzyme as one of the main contributors to the firmness which determines the textural quality of frozen potato tissues. © 1999 Society of Chemical Industry     

Kinetics of thermal softening of potato tissue (cv. Monalisa) by water heating

The temperature dependence of rheological parameters as firmness indicators for potato tissue was determined within the temperature range 50-100 °C using four different objective methods. The rate of thermal softening of potato tissue by water treatment at 50 °C, 90 °C, and 100 °C was consistent with one pseudo first-order kinetic mechanism, while at 70 °C and 80 °C the rate of softening was consistent with two simultaneous pseudo first-order kinetic mechanisms. Kinetic theory was suitable to detect an increase of firmness through heating at 60 °C, mainly between 20 min and 40 min, presumably by pectinesterase activation. This study shows that two substrates S_a and S_b may be involved in providing firmness to potato tissue at 70 °C and 80 °C. For these temperatures, mechanism 1 is more probably due to gelatinization and light cooking, whereas mechanism 2 is more likely to represent the changes of the pectic substances in the cell wall and interlamellar region. At 90 °C and 100 °C the gelatinization process was fast and therefore the simple mechanism fitted presumably reflects the degree of solubilization of the pectic substances. At 50 °C and 60 °C there was practically no gelatinization, so that the simple mechanism fitted presumably represented incipient solubilization of pectic material. In water heating, gelatinization contributes less than the cell wall structure to potato tissue firmness on the basis of either kinetic parameters or microscopic observations. Maximum breaking compression force and modulus of rigidity were the most suitable rheological parameters for studying the softening of potato tissue in water heating.     

Fogging with antibrowning agents as an alternative to conventional immersion treatments to extend shelf life of mushrooms

Mushroom (Agaricus bisporus) is a highly perishable product and can be easily damaged when immersion in antibrowning solutions is performed; therefore, fogging application represents a less aggressive technique. The objective of this work was to evaluate the effect of different antibrowning agents (ascorbic acid, sodium metabisulphite and L-cysteine) applied by two methodologies (immersion and fogging) on the quality of mushrooms during storage at 5 °C. Weight losses, microstructural organisation, colour and texture changes were evaluated as quality indicators. Polyphenol oxidase activity, phenolic content and antioxidant activity were also evaluated. Fogging achieved browning inhibition without major changes in firmness, while immersion treatments inhibited browning but significant changes in firmness were found. Browning inhibition achieved by fogging showed similar results when compared to the conventional immersion treatments. Fogging has the advantage of being less aggressive than immersion while requiring a significantly smaller amount of antibrowning solution than traditional immersion.     

Effect of temperature fluctuations during frozen storage on the quality of potato tissue (cv. Monalisa)

 Results are presented on the effect of different ranges of temperature fluctuation (–24 to –18°C, –18 to –12°C, –12 to –6°C, –24 to –12°C and –18 to –6°C) on the compression, shear and tension parameters of packed and unpacked frozen potato tissue. The initial temperature, duration and number (2, 4, 8, 16, 24 and 32) of fluctuations were varied. The highest parameter values occurred in samples subjected to fluctuations between –24°C and –18°C, and the lowest values in the range –18 to –6°C. The mechanical strength of the frozen tissue decreased with an increase in the number of fluctuations and in most cases was lower in the packed samples. Moisture loss was greatest in the –18 to –6°C range for pre-packed samples. Changes in the maximum compression force, as a measure mechanical damage, showed the greatest level of significance. Received: 17 June 1997     

Effect of temperature fluctuations during frozen storage on the quality of potato tissue (cv. Monalisa)

 Results are presented on the effect of different ranges of temperature fluctuation (–24 to –18°C, –18 to –12°C, –12 to –6°C, –24 to –12°C and –18 to –6°C) on the compression, shear and tension parameters of packed and unpacked frozen potato tissue. The initial temperature, duration and number (2, 4, 8, 16, 24 and 32) of fluctuations were varied. The highest parameter values occurred in samples subjected to fluctuations between –24°C and –18°C, and the lowest values in the range –18 to –6°C. The mechanical strength of the frozen tissue decreased with an increase in the number of fluctuations and in most cases was lower in the packed samples. Moisture loss was greatest in the –18 to –6°C range for pre-packed samples. Changes in the maximum compression force, as a measure mechanical damage, showed the greatest level of significance. Received: 17 June 1997     

Effect of preservative agents on the respiration rate of minimally processed potato (Solanum tuberosum cv. Monalisa)

ABSTRACT:  The shelf life of minimally processed potatoes (MPP) is limited by enzyme-catalyzed browning reactions, with the increase in respiration being another factor that affects quality retention of this product. Sulfites are commonly used as effective preservative agents in minimally processing potatoes, but ascorbic acid and citric acid are considered natural sulfite substitutes and more accepted by consumers. The aim of this study was to study the effect of combinations of the preservative agents cited above (sodium metabisulfite 0.1% and 0.5%; citric acid 0.1% and 0.5%; ascorbic acid 0.5%) on the respiration rate of MPP (cv. Monalisa) processed at both ambient and refrigerated temperatures. The results have revealed that there is a significant effect of dipping treatment and temperature on respiration rate of MPP. Sodium metabisulfite (SM) reduces respiratory activity up to 0.8 mL/kg/h. The addition of either citric or ascorbic acid enhanced the effect of SM on the reduction of the respiration rate of MPP. The strongest effect (up to 3.3 mL/kg/h) was observed when a combination of all 3 agents at the higher concentrations was employed at a temperature of 18 °C.     

Combined effect of active coating and MAP to prolong the shelf life of minimally processed kiwifruit (Actinidia deliciosa cv. Hayward)

In this work different strategies aimed to prolong the shelf life of minimally processed kiwifruits are presented. First, the effectiveness of several treatments in delaying the quality loss of the investigated produce packaged under passive MAP was addressed; afterward, the treatments that have shown the best performances were used to assess the effectiveness of active MAP in prolonging the packaged produce shelf life. Different treatments such as coating with sodium alginate in combination with dipping into an hydro-alcoholic solution (Coat-dipp-EtOH), dipping into an hydro-alcoholic solution (Dipp-EtOH) and coating with sodium alginate containing grape fruit seed extract solution (Coat-GFSE) were investigated. The untreated samples were used as control. Headspace gas concentrations, pH, mass loss, sensory quality and viable cell load of main spoilage microorganisms were monitored in both the experimental steps. Results suggested that the best performances under passive MAP were recorded with the coating treatments, justifying the choice of this treatment in the second step. In fact, the coatings were more effective in delaying dehydration and slowing down respiratory activity of minimally processed kiwifruits both in passive and active MAP. The combination of active compounds with alginate-based coating delayed the microbial growth whereas the sole dipping treatment was inefficient. In particular, a viability loss of the mesophilic and psychrotrophic bacteria of about 2 log cycle for the coated samples with respect to control and dipped samples was found. However, as the microbial load was always found below the threshold value imposed by law, the sensorial acceptability limit of the packaged fresh-cut produce coincided with its shelf life. Alginate-based coating reduced respiratory activity, as well as sensory decay, increasing the sensorial acceptability limit of the samples packaged under passive MAP up to 12 days with respect to the control (8 days). For the samples packaged under active MAP, the coating treatments reduced the excessive dehydration of the produce due to the MAP conditions. In fact, when the active MAP was used alone a very short shelf life of the uncoated samples occurred (2.7 days). Whereas, the combined use of active MAP and coating treatments prolonged the produce shelf life up to 13 days.     

Use of dietary vitamin E and selenium (Se) to increase the shelf life of modified atmosphere packaged light lamb meat

The aim of this work was to determine the increase in the shelf life of modified atmosphere packaged fresh lamb meat due to the effect of dietary vitamin E and selenium supplementation on colour and lipid oxidation. 128 lambs were fed on a concentrate with standard levels of vitamin E (C), a concentrate enriched with vitamin E (V), a concentrate with sodium selenite (S) and a concentrate enriched with both vitamin E and sodium selenite (VS). The lambs were slaughtered at 27.3±1.45 kg LW, and chops stored on MAP for 7, 9, 11 and 13 days. CIELab colour and TBARs were studied on these days. Use of dietary vitamin E extended the shelf life a further 4 days from the commercial sell-by date in terms of lightness, hue angle, metmyoglobin formation and lipid oxidation. Selenium could be used to increase the lightness of meat without vitamin E supplementation in lambs' diets.     

Improving the shelf life stability of vacuum-packed fresh-cut peaches (Prunus persica L.) by radio frequency heating in water

The present study aimed to investigate the influence of radio frequency (RF) heating at 70 and 80 °C, in comparison with the traditional conventional heating. The RF heating technology was applied for maintaining the colour and textural quality as well as inactivating the enzymatic activity of polyphenol oxidase (PPO) and reducing the Escherichia coli growth in packaged fresh-cut peach samples. To evaluate this, 120 g of freshly cut peach fruit was placed in heat-resistant plastic bags, and 50 mL of sugar solution (12°Brix) was added to each bag and vacuum-packed for conventional heating and radio frequency (RF) heating. Our results demonstrated that the RF heating process could reduce the heating time by up to 83% at 70 and 80 °C as compared to conventional heating. Moreover, RF heating at 70 and 80 °C reduced the PPO enzymatic activity, which caused enzymatic browning, up to 85.46% and 93.5%, respectively, as compared to 40.86% reduction only for conventional heating. Furthermore, RF heating completely inhibited E. coli growth. Collectively, we demonstrated that RF heating is an emerging and promising technology for improving the quality of fresh-cut fruits such as peach during various storage conditions. The present study provides relatively novel information on the effectiveness of RF heating in maintaining the quality of fresh-cut peaches. In the future, we would like to investigate the effectiveness of RF heating on other agricultural products.     

Effects of chitosan-based coating and modified atmosphere packaging (MAP) on browning and shelf life of fresh-cut lotus root (Nelumbo nucifera Gaerth)

The present study investigated the effect of chitosan coating containing antibrowning agents and modified atmosphere packaging (MAP) on the browning and shelf life of fresh-cut lotus root stored at 4 °C for 10 days. The atmosphere in the packages was evaluated for O₂ and CO₂ concentrations. The browning on the surface of lotus root slices was prevented by chitosan-based coating and MAP treatment. L* values of coated + MAP and control samples were 68.8 and 48.9 after 8 days storage, respectively. For a^? and b^? values, samples of coated + MAP treatment had the slowest increasing trends among all the treatments. At the end of storage, the coated + MAP samples exhibited the lowest polyphenol oxidase (PPO) activity and malondialdehyde (MDA) content. Its highest overall visual quality (OVQ) scores (> 7) demonstrated that chitosan-based coating + MAP treatment could provide a better inhibitory effect on the browning and extend the shelf life of fresh-cut lotus root.Industrial relevance: Fresh-cut vegetables have drawn the attention of industry as a novel lightly processed product. Both edible coating and MAP treatment cause changes in atmosphere composition and respiration rate of lotus root slices. This combined treatment could be used to control the browning and improve the storage life of this fresh-cut vegetable. This information could be useful for the development of novel application to edible coating and MAP design for lightly processed lotus root.     

The use of thyme and laurel essential oil treatments to extend the shelf life of bluefish (Pomatomus saltatrix) during storage in ice

The objective of this investigation was to study the effect of thyme and laurel essential oil treatments on the quality of bluefish during storage in ice for 13?days. The quality of bluefish during storage time was evaluated by sensory, chemical, physical, physicochemical and microbiological analysis. According to the sensory evaluation results, shelf life of control and treated bluefish samples stored in ice were 9 and 11?days, respectively. Total volatile base nitrogen and trimethylamine values gave acceptable results for up to 9?days for the control groups samples and 13?days for treated groups. Free fatty acid, peroxide and thiobarbituric acid values for treated samples were lower than the control. Microbial growth during storage in ice for control samples was higher than treated samples. The results obtained from this study showed that the shelf life of stored bluefish in ice has extended by 3?C4?days compare to the control samples.     

Microencapsulated Lactobacillus reuteri combined with modified atmosphere as a way to improve tuna burger shelf life

In this study, tuna burgers were subjected to a bio‐preservation treatment combined with modified atmosphere packaging (MAP) in order to prolong the shelf life. After L. reuteri production of reuterin, the antimicrobial compound was microencapsulated and then added to tuna burger formulation. Reuterin content was analysed before and after the spray drying treatment, thus assessing its final concentration. Then, the effects of spray‐dried reuterin on tuna burgers quality were investigated with success on samples packaged under both ordinary and MAP conditions. The efficacy of bio‐control was evident in all the samples. For burgers stored in air, a shelf life of about 7.63 days was recorded for the active samples with respect to the 5.78 days of the reuterin‐free samples. Under MAP, a similar reuterin effectiveness was recorded but a general shelf life improvement was reached, accounting for about 13 days in the active samples and 12 days in the reuterin‐free samples.