共查询到17条相似文献,搜索用时 109 毫秒
1.
脱臭工艺条件对大豆油中反式脂肪酸含量的影响 总被引:1,自引:0,他引:1
研究了脱臭温度和脱臭时间对大豆油中反式脂肪酸含量的影响。结果表明:脱臭温度和脱臭时间对大豆油中反式油酸含量的影响很小;脱臭温度对大豆油中反式亚油酸含量影响显著,脱臭时间对其影响的显著性次之;脱臭温度对每一指定的脱臭时间条件下,大豆油中总反式脂肪酸含量最多约为最少的90~100倍,在250℃以下大豆油中总反式脂肪酸的形成速度缓慢、相对含量低;脱臭时间对每一指定脱臭温度条件下,大豆油中总反式脂肪酸含量最多约为最少的2.8~4倍,且脱臭时间对指定脱臭温度250℃和270℃条件下,在40min以下大豆油中总反式脂肪酸的形成速度缓慢、相对含量低。 相似文献
2.
脱臭工艺条件对棉籽油中反式脂肪酸含量的影响 总被引:2,自引:1,他引:1
研究了脱臭温度和脱臭时间对棉籽油中反式脂肪酸含量的影响。结果表明:脱臭温度和脱臭时间对棉籽油中反式油酸含量的影响很小;脱臭温度对棉籽油中反式亚油酸含量影响显著,脱臭时间对其影响的显著性次之;在一定的脱臭时间,不同脱臭温度下,棉籽油中总反式脂肪酸最多含量为最少含量的100倍以上;在一定的脱臭温度,不同脱臭时间下,棉籽油中总反式脂肪酸最多含量约为最少含量的1.7~5.5倍,且在255℃以下随脱臭时间延长,棉籽油中总反式脂肪酸的形成速度缓慢、相对含量低。 相似文献
3.
4.
5.
6.
研究精炼加工过程玉米油中反式脂肪酸含量的变化趋势,考察精炼工艺对玉米油中反式脂肪酸的影响。结果表明:反式脂肪酸主要在精炼的脱臭工段产生;脱臭温度在210~230 ℃,脱臭时间60 min时,生成的反式脂肪酸主要为C18∶ 2t,脱臭温度升高到250 ℃时,有C18∶ 3t生成;脱臭温度越高,脱臭时间越长,反式脂肪酸含量越高;在脱臭温度210~230 ℃、脱臭时间100 min条件下得到的成品玉米油反式脂肪酸含量小于0.3%,且质量指标满足国标一级玉米油要求。 相似文献
7.
以牡丹籽毛油为原料,经过水化脱胶、碱炼脱酸和吸附脱色后,于160、190、250℃和270℃下脱臭处理,气相色谱法分析不同脱臭时间下牡丹籽油反式脂肪酸含量变化,考察各脂肪酸的反化率,同时检测其酸值、过氧化值、色泽和气味指标变化。结果表明:脱臭温度对牡丹籽油反式脂肪酸含量影响最显著,脱臭时间次之,即脱臭温度越高、脱臭时间越长反式脂肪酸含量越多;就脂肪酸反化率而言,亚麻酸亚油酸油酸;且反式脂肪酸的形成没有位置选择性,即Sn-1,3与Sn-2位的不饱和脂肪酸的反化率相似;牡丹籽油适合的脱臭温度为190℃、脱臭时间为60 min,在此条件下得到的脱臭牡丹籽油总反式脂肪酸含量小于1%,所测定品质指标均符合二级大豆油国家标准。 相似文献
8.
降低大豆油精炼过程反式脂肪酸含量研究 总被引:1,自引:1,他引:0
研究精炼过程对大豆油反式脂肪酸含量变化,发现在碱炼、脱色工段反式脂肪酸含量没明显变化,而在脱臭工段反式脂肪酸含量发生显著变化,表明精炼时脱臭是产生反式脂肪酸主要阶段;同时比较脱臭温度,脱臭塔结构,脱臭时间对大豆油反式脂肪酸形成影响,并根据研究结果,提出工业化降低大豆油反式脂肪酸可行性工艺。 相似文献
9.
研究了脱臭过程中脱臭温度、脱臭时间和脱臭塔残压对玉米油中反式脂肪酸含量的影响,从而确定最佳脱臭工艺条件,尽量减少玉米油精炼过程中反式脂肪酸的生成。 相似文献
10.
米糠油物理精炼过程中脱臭对其谷维素含量的影响 总被引:1,自引:1,他引:0
研究了脱臭温度和脱臭时间对米糠油中谷维素含量的影响.结果表明脱臭温度和脱臭时间对米糠油中谷维素的裂解、汽流夹带损失有不同程度的影响,随着脱臭温度升高和脱臭时间的延长,米糠油中谷维素的裂解、汽流夹带损失量呈增大趋势;在米糠油脱臭的实验条件范围内,脱臭温度为210 ℃,脱臭时间为20 min时,米糠油中谷维素留存量最多,其含量为1.73%;脱臭温度为270℃,脱臭时间为120 min时,米糠油中谷维素留存量最少,其含量为1.28%. 相似文献
11.
分析对比了在220~270℃、100 min及40~120 min、260℃脱臭条件下,葵花籽油中邻苯二甲酸酯类塑化剂(PAEs)、多环芳烃(PAHs)、维生素E(V_E)、甾醇、脂肪酸组成及酸值、过氧化值、烟点、色泽的变化,考察脱臭工艺条件对葵花籽油综合品质的影响。结果表明:随着脱臭温度升高、脱臭时间延长,葵花籽油中PAEs、PAHs各组分脱除率均逐渐升高;V_E、甾醇含量逐渐降低,保留率分别由94.6%降至63.2%及94.4%降至81.6%;反式脂肪酸含量逐渐升高,由0.17%升至1.16%。综合不同脱臭条件对PAEs、PAHs、V_E、甾醇、反式脂肪酸及其他质量指标的影响,基于塑化剂和多环芳烃深度脱除的脱臭条件为260℃、80~100 min,此条件下V_E保留率为73%~75%,甾醇保留率82%~85%,反式脂肪酸含量0.88%~0.90%;保证BaP达标的适度脱臭条件为260℃、60 min或220℃、100 min。260℃、60 min条件下,V_E和甾醇保留率分别为79.3%和85.4%,反式脂肪酸含量0.69%;220℃、100 min条件下,V_E和甾醇保留率均在94%以上,反式脂肪酸含量0.17%。可根据待脱臭油风险成分的含量不同以及对脱臭成品油的限量要求不同选择相应的优化脱臭条件,采用精准的脱臭技术提升葵花籽油综合品质。 相似文献
12.
13.
14.
C. Boeckaert B. Vlaeminck J. Dijkstra T. Van Nespen V. Fievez 《Journal of dairy science》2008,91(12):4714-4727
Two experiments with rumen-fistulated dairy cows were conducted to evaluate the effects of feeding docosahexaenoic acid (DHA; C22:6 n-3)-enriched diets or diets provoking a decreased rumen pH on milk fatty acid composition. In the first experiment, dietary treatments were tested during 21-d experimental periods in a 4 × 4 Latin square design. Diets included a control diet, a starch-rich diet, a bicarbonate-buffered starch-rich diet, and a diet supplemented with DHA-enriched micro algae [Schizochytrium sp., 43.0 g/kg of dry matter intake (DMI)]. Algae were supplemented directly through the rumen fistula. The total mixed ration consisted of grass silage, corn silage, soybean meal, and a standard or glucogenic concentrate. The glucogenic and buffered glucogenic diet had no effect on rumen fermentation and milk fatty acid composition because, unexpectedly, no reduced rumen pH was detected. The algae diet had no effect on rumen pH but provoked decreased butyrate and increased isovalerate molar proportions in the rumen. In addition, algae supplementation affected rumen biohydrogenation of linoleic and linolenic acid as reflected in the modified milk fatty acid composition toward increased conjugated linoleic acid (CLA) cis-9 trans-11, CLA trans-9 cis-11, C18:1 trans-10, C18:1 trans-11, and C22:6 n-3 concentrations. Concomitantly, on average, a 45% decrease in DMI and milk yield was observed. Based on these drastic and impractical results, a second animal experiment was performed for 20 d in which 9.35 g/kg of total DMI of algae were incorporated in the concentrate and supplemented to 3 rumen-fistulated cows. Algae concentrate feeding increased rumen pH, which was associated with decreased rumen short-chain fatty acid concentrations. Moreover, a different shift in rumen short-chain fatty acid proportions was observed compared with the first experiment because molar proportions of butyrate, isobutyrate, and isovalerate increased, whereas acetate molar proportion decreased. The milk fatty acid profile changed as in experiment 1. However, the decrease in DMI and milk yield was less pronounced (on average 10%) at this algae supplementation level, whereas milk fat percentage decreased from 47.9 to 22.0 g/kg of milk after algae treatment. In conclusion, an algae supplementation level of about 10 g/kg of DMI proved effective to reduce the milk fat content and to modify the milk fatty acid composition toward increased CLA cis-9 trans-11, C18:1 trans, and DHA concentrations. 相似文献
15.
16.
研究显示膳食中过高的反式脂肪酸会增加血液中低密度脂蛋白胆固醇与总胆固醇的含量,引起各种慢性疾病,特别是心血管疾病,严重危害人体健康。膳食中的反式脂肪酸主要来自氢化油脂。为消除或减少食品中的反式脂肪酸,通过工艺的改进,特别是改进氢化技术以及使用酯交换技术,是目前的主要方法。本文总结了加工零/低反式脂肪酸人造塑性油脂技术的研究进展情况,以期为业界提供参考。 相似文献