共查询到20条相似文献,搜索用时 15 毫秒
1.
2.
铁在二氧化碳溶液中的腐蚀电化学行为研究 总被引:8,自引:0,他引:8
用电化学极化曲线和交流阻抗研究了铁在二氧化碳溶液中的腐蚀电化学行为,得出了在二氧化碳溶液中的电化学反应机理,在所研究的CO2分压范围内,CO2促进了阴极反应,抑制了阳极溶解反应,利用弱极化曲线拟合法得出了铁的腐蚀速度,腐蚀电位与二氧化碳分压的关系,试验和的推导结果相吻合。 相似文献
3.
This paper studied the changing principles of carbon content in direct reduction iron (DRI) and liquid iron in the COREX melting gasifier. Under the normal working conditions of experimental equipment, liquid nitrogen was poured into the melting gasifier from its tuyere to cool down quickly. And then seven cross sections were made to study the carburization reaction and its characteristics of the solid iron and the liquid iron, and also the reaction of carbon between the slag and the metal. According to the results, the influences of the thickness of the semi-coke layer and the temperature on the carbon content of liquid iron in the COREX melting gasifier were confirmed. 相似文献
4.
5.
研究了纯Fe在含有KCl蒸汽的O2中于650℃~850℃的腐蚀行为,结果表明,纯Fe在试验条件下发生了加速腐蚀,并且随温度的提高和KCl蒸气浓度的增大,腐蚀速率均增高.微量的KCl蒸气起加速腐蚀作用,主要是通过与试样表面的氧化膜反应生成Cl2, 而Cl2能渗透到基体界面处与基体生成挥发性的Fe的氯化物实现的.
〖HT5”H〗中图分类号:〖HT5”SS〗〓〓
〖 相似文献
6.
用直接合成法制备了Laβ-Al2O3,固体电解质,用阻抗谱技术在800-1500℃测得其电导率为10-6-10-3S·m-1不同组成样品的电导激活能在1.95-2.07eV之间。用Coulomb滴定抽La法验证Laβ-Al2O3的La3+的导电性;在500-1600℃下示差热分析的结果表明,Laβ-Al2O3未发现相变和分解制得Laβ-Al2O3固体电解质管,以纯La作为参比电极,组成La传感探头,在1450℃测得碳饱和铁液中、不同La浓度下溶解态La的活度具有规律性;与同时用氧传感探头测得氧的变化规律相符合.在实验条件下,La传感探头经过连续多次使用,未见有开裂或渗漏现象,La与Laβ-Al2O3管不发生作用. 相似文献
7.
8.
J.H.Liu ) S.H.Jiang ) M.Yao ) ) Department of mechanical Engineering Engineering college Yangzhou University Yangzhou China ) Department of Material Science Yanshan University Qinhuangdao China 《金属学报(英文版)》1999,12(5):852-855
1.IntroductionFig.1 ThermalfatiguetestmachinewithOutercinstraintThedamagecausedbythermalfatigueisoneofthemainfailureformsofmetalworkingpiecesunderthetemperaturevariationconditions.Alotofthermalfatiguetestsconcerningthefailurewereconductedonthevariou… 相似文献
9.
LIU Yumen HE Zhirong Xi''''an Jiaotong University Xi''''an China Professor Dept.of Materials Science Engineering Xi''''an Jiaotong University Xi''''an China 《金属学报(英文版)》1989,2(5):364-367
The morphologic,substructural and crystallographic characteristics of martensite in steels 60and 60Si2Mn have been investigated by means of optical and transmission electronmicroscopy combined with B-M phenomenological crystallographic theory.The average hab-it plane of martensite in medium carbon iron alloys is{225}_f.Experimental data on the habitplane and the orientation relationship between the austenite and martensite are in agreementwith the B-M theoretical calculation of using the Bain strain and lattice invariant shear on(100)[011]_f. 相似文献
10.
本文利用S4-10型Stereoscan扫描电镜拉伸试验装置,对阴极充氢的Johnson-Matthey纯铁的形变和断裂微观过程进行了动态观察。主要结果如下: 1.随着氢含量的增加(从5.4cm~3/100g增到31.0cm~3/100g),屈服应力略有增加,流变应力和断裂强度显著增加,而断裂应变明显降低。在氢含量高于18.7cm~3/100g以上时,下屈服点和Lüders带消失。 2.氢含量低于10cm~3/100g的试样,裂纹优先在晶内滑移面上萌生形核,沿着亚晶界向前扩展,断裂途径大都是与拉伸轴呈45°方向断开。而氢含量大于16cm~3/100g的试样,裂纹易在晶界上开裂,在晶内呈锯齿形向前扩展,与拉伸轴正交方向断开。 3.纯铁氢脆的主要特征是:(1)试样表面上滑移线的明显减少,(2)脆性微观断裂形态的形成和增多。这是由于固溶的氢原子降低塑性形变所致。 相似文献
11.
用容量为10公斤的真空感应炉研究了在电熔氧化鎂坩堝中熔炼純鉄时熔池中碳和氧的反应,以及坩堝在这个反应中所起的作用。証实在熔炼过程中坩堝不断向熔池供氧,因此熔池的含氧量在降低到最低值后重新回升。 在10~(-4)(及10~(-1))毫米汞柱的炉压下,发現熔池中的[%C]·[%O]乘积都达到6×10~(-6)至3.5×10~(-5)之間的数值。当配料含碳0.03—0.05%而含氧为其一半时,可以得到含碳0.006%以下、含氧0.003%以下的高純度铁。 坩堝对熔池的影响随着使用次数的增长而減弱。 熔池的氧浓度对最終含氮量有显著影响。含氧量越高,脫氮就越慢。 相似文献
12.
将Cr~(2+)、Dy~(2+)离子注入到DT-4纯铁和45号钢,Yb~(2+)注入到DT-4纯铁,Dy~(2+)注入到1Cr18Ni9Ti表层。用俄歇谱仪测量了注入元素的深度分布。用动电位三向扫描法研究了注有Cr~(2+)和Dy~(2+)的试样在NaAc/HAc溶液中的阳极极化行为。结果表明,离子注入显著提高了材料的耐蚀性。 相似文献
13.
The reduction behavior of iron ore pellets containing carbon under non-isothermal condition in the temperature range from 573 to 1373K has been investigated in a laboratory scale setup. The test results show that carbon content has no obvious effect on reduction degree of composite pellets (C/O mole ratio=1.0) by CO in the temperature range from 575 to 1373K under linear temperature-rising program; reduction degree of iron ore pellets containing carbon is larger in 90%CO-10%CO2 mixture than that of in 100%CO atmosphere or in 80%CO-20%CO2 mixture; the s type temperature-rising program has a better effect than that of linear one to increase the reduction degree; and reduction degree of slower linear temperature-rising program is greater than that of faster one, but the final reduction degrees, i.e., those at the highest temperature are about same for various CO partial pressures or temperature-rising programs. The kinetic analysis also shows that the reduction of iron ore-carbon composite pellets by CO or CO-CO2 mixture under non-isothermal condition should be controlled 6y surface reaction, and the apparent reduction activation energy changes with the reduction progress under various test conditions. 相似文献
14.
对TU48碳钢在不同溶解氧浓度的水溶液中进行了低周腐蚀疲劳,结合俄歇电子能谱(AES)和Mossbauer谱分析其表面的腐蚀产物.结果表明,随着水中溶解氧含量的增加,碳钢的腐蚀疲劳断裂时间变短,碳钢表面形成的腐蚀产物的成分也有很大的变化,Fe3O4减少,而γ—Fe2O3含量增多;在含氧量很低的条件下,腐蚀还生成α—Fe2O3和铁的氢氧化物. 相似文献
15.
THEALLOYINGBEHAVIOROFBORONANDCARBONINNi3Al①ZhangYun,HuangJin,LinDongliangShanghaiJiaotongUniversity,Shanghai200030ABSTRACTTof... 相似文献
16.
17.
碳钢在海泥中的电化学行为 总被引:2,自引:0,他引:2
研究了厦门海域海泥的腐蚀性以及碳钢在海泥中的极化曲线,电化学交流阻抗频,结果表明,所研究的海泥为强腐蚀性介质,碳钢在海泥中的腐蚀电位为-0.75V,腐蚀速度受氧扩散控制。为2.3μA/cm^2,析氢电位为-0.87V(SCE)。碳钢在海泥和海水中的极化行为相似。在海泥中放置两个月后,碳钢的电交流阻频谱图上出现感抗弧,估计由锈层引起。 相似文献
18.
碳钢在煤水两相介质中的腐蚀行为 总被引:2,自引:0,他引:2
采用失重及电化学方法研究了碳钢在煤水两相介质中 的腐蚀行为.结果表明,在煤水两相介质中,钢的腐蚀既不同于钢在均相水中的腐蚀,也不 同于与煤整体接触形成的腐蚀,腐蚀的初始形态为坑状,表象为均匀腐蚀.具有一定腐蚀性 的固相(高煤化度的煤)明显加速钢的腐蚀. 相似文献
19.