枯草芽孢杆菌对奶牛生产及乳脂脂肪酸组成的影响

研究不同枯草芽孢杆菌对奶牛生产性能和乳脂脂肪酸成分的影响。与对照组相比,试验组A和B日产奶量呈增加趋势,乳脂产量、乳脂率显著增加(P<0.05);除B组乳中体细胞数显著增加外,各试验组乳蛋白、乳糖、非脂固形物等指标无显著变化。脂肪酸的组成比例与对照组相比无显著差异(P>0.05)。但在A和B组中,对长链及中短链脂肪酸的合成均可起促进作用。     

蜡样芽胞杆菌生长/非生长界面模型的建立和评价

蜡样芽胞杆菌是软烤虾仁产品的主要变质菌,它是一种条件致病菌,通过产生腹泻毒素和呕吐毒素导致食物中毒。该研究旨在建立一种概率模型来预测出蜡样芽胞杆菌的生长/非生长情况或者生长概率。用lo-gistic回归模型建立不同温度、水分活度和pH环境因子作用下蜡样芽胞杆菌的生长/非生长界面模型。实验结果表明蜡样芽胞杆菌在脑心浸液肉汤培养基中生长的最低温度为9.99℃,最低水分活度为0.931,最小pH值为4.5。在此基础上建立的蜡样芽胞杆菌生长/非生长界面模型的χ2=49.73,P<0.000 1。用logistic回归模型建立的生长/非生长模型拟合效果达到极显著水平。模型的预测值同时很好地量化了环境因子对蜡样芽胞杆菌的协同作用,为软烤虾仁产品中蜡样芽胞杆菌的生长/非生长界面模型的建立提供了参考。     

湿粉类制品蜡样芽胞杆菌污染风险及控制研究

目的 以广州市为例分析湿粉类制品蜡样芽胞杆菌污染情况和生产加工过程的风险点,提出相应的控制措施.方法 选择广州市范围生产湿粉类制品的生产单位,采集生产环节和销售环节样品及同批次产品生产使用的原料,对蜡样芽胞杆菌进行定量检测.结果 共采集32份出厂的湿粉类制品、139份市售湿粉类制品、32份原料大米、5份小麦淀粉、3份玉...     

Induction of pitting corrosion on stainless steel (grades 304 and 316) used in dairy industry by biofilms of common sporeformers

This study hypothesised that there may be induction of pitting corrosion or microbially‐induced corrosion on stainless steel (SS) dairy‐processing surfaces by biofilms of common milk sporeformers such as Bacillus sporothermodurans and Geobacillus stearothermophilus. Scanning electron microscopy (SEM) and micrographs generated from energy‐dispersive spectroscopy were used to observe pitting corrosion and to find the elemental composition and distribution on the control and pitted surfaces. From SEM images and energy‐dispersive spectroscopy micrographs, it was observed that pitting corrosion on SS could be induced by biofilms of both B. sporothermodurans and G. stearothermophilus.     

pH值对聚谷氨酸发酵液粘度及聚合物结构的影响

生产中聚谷氨酸的发酵液非常黏稠(粘度达1.71Pa.s),这使除菌体提取聚谷氨酸非常困难。通过加酸或碱调节发酵液pH<5或pH>8可明显降低发酵液的粘度(其中pH3.5时粘度仅为pH6.5时的1/50左右)。将pH3.5的发酵液离心除菌(10 000×g,10 min)后超滤浓缩(滤膜孔径0.45μm,平均压力0.08 Mpa)1倍,再加入95%乙醇提取-γPGA,与pH中性时相比,可减少50%以上的能量消耗及40%的溶剂,但聚谷氨酸损失约10%。加酸或加碱处理可使发酵液中-γPGA的分子结构发生改变,分子质量降低,这对生产高分子质量的聚谷氨酸不利,但对生产低分子质量产物是适宜的。     

Effects of starch acryloylation on the grafting efficiency,adhesion, and film properties of acryloylated starch‐g‐poly(acrylic acid) for warp sizing

In order to enhance the grafting efficiency of graft copolymerization of granular cornstarch with acrylic acid (AA) for improving the adhesion and film properties of starch‐g‐poly(acrylic acid) used as sizing agent, the esterification of hydrolyzed starch with acryloyl chloride was applied before graft copolymerization. The influence of three common initiators on the copolymerization were also studied. The initiators included ceric ammonium nitrate [Ce(NH₄)₂(NO₃)₆], hydrogen peroxide/ferrous ammonium sulfate [H₂O₂/FeSO₄ · (NH₄)₂SO₄], and potassium persulfate/sodium bisulfite [K₂S₂O₈/NaHSO₃]. It was found that acryloylation of starch before the copolymerization was an effective method for substantially enhancing the grafting efficiency and improving the performances such as adhesion‐to‐fibers and mechanical properties of grafted starch film. The acryloylation could increase the efficiency to 67–81% when the degree of substitution (DS) of acryloylated starch ranged from 0.010 to 0.036. The adhesion to polyester and cotton fibers reached their maximum at DS = 0.010 and 0.022, respectively. Strong and tough film was obtained when the DS value was in a range of 0.010–0.022. H₂O₂/FeSO₄ · (NH₄)₂SO₄ redox system was more appropriate for initiating the copolymerization of acryloylated starch with AA.     

Effect of feeding extruded flaxseed with different grains on the performance of dairy cows and milk fatty acid profile

Sixteen Holsteins cows were used in a Latin square design experiment to determine the effects of extruded flaxseed (EF) supplementation and grain source (i.e., corn vs. barley) on performance of dairy cows. Extruded flaxseed diets contained 10% [dry matter (DM) basis] of an EF product that consisted of 75% flaxseed and 25% ground alfalfa meal. Four lactating Holsteins cows fitted with rumen fistulas were used to determine the effects of dietary treatments on ruminal fermentation. Intakes of DM (23.2 vs. 22.2 kg/d), crude protein (4.2 vs. 4.0 kg/d), and neutral detergent fiber (8.3 vs. 7.9 kg/d) were greater for cows fed EF diets than for cows fed diets without EF. Milk yield and composition were not affected by dietary treatments. However, 4% fat-corrected milk (30.5% vs. 29.6 kg/d) and solids-corrected milk (30.7 vs. 29.9 kg/d) were increased by EF supplementation. Ruminal pH and total volatile fatty acid concentration were not influenced by EF supplementation. However, feeding barley relative to corn increased molar proportions of acetate and butyrate and decreased that of propionate. Ruminal NH₃-N was lower for cows fed barley than for cows fed corn. Milk fatty acid composition was altered by both grain source and EF supplementation. Cows fed EF produced milk with higher polyunsaturated and lower saturated fatty acid concentrations than cows fed diets without EF. Feeding EF or corn increased the milk concentration of C18:0, whereas that of C16:0 was decreased by EF supplementation only. Extruded flaxseed supplementation increased milk fat α-linolenic acid content by 60% and conjugated linoleic acid content by 29%. Feeding corn relative to barley increased milk conjugated linoleic acid by 29% but had no effect on milk α-linolenic concentration. Differences in animal performance and milk fatty acid composition were mainly due to EF supplementation, whereas differences in ruminal fermentation were mostly due to grain source.     

Effect of whey protein concentrate,pH and salt on colloidal stability of acid dairy drink (Doogh)

Serum separation of Doogh, an Iranian yoghurt drink, is a major problem. In this study, the effects of whey protein concentrate (WPC) addition, pH of the product and dissolved salt (sodium chloride) in milk on the colloidal stability of Doogh were investigated. By increasing the amount of WPC (from 0.5 to 3%) and salt in milk (from 0 to 1.6%), the serum separation decreased. Increasing pH values of sample (from 3.5 to 4.5), WPC (from 0.5 to 4%) and salt concentration in milk (from 0 to 2%) also increased the samples’ viscosity. All samples showed Newtonian behaviour except samples at pH 4.5, containing 4% WPC and 2% dissolved salt in milk.     

Laboratory studies on parasitism of Plodia interpunctella (Hübner) (Lepidoptera: Pyralidae) by two species of Trichogramma Westwood (Hymenoptera: Trichogrammatidae) in different grains,and evaluation of traps for their monitoring

The aim of the present study was to evaluate two species of egg parasitoids under laboratory conditions for biological control of the Indian meal moth Plodia interpunctella, an emerging stored product pest in bulk grain. Trichogramma evanescens proved to be a better candidate for biological control compared to T. cacoeciae as it accepted and parasitised a higher percentage of Indian meal moth eggs. Consequently the foraging of T. evanescens was studied in detail. Preferred oviposition sites on individual seeds by P. interpunctella are the germ region and the raphe. Moth eggs were parasitised at both regions. P. interpunctella eggs received higher parasitism at the germ region compared to the raphe. In stored grain and rice, P. interpunctella eggs can be found in the upper 8 cm of the bulk. Foraging parasitoids were shown to enter up to this depth into wheat, oats, and paella and Basmati rice. Wheat and oats were found most suitable for foraging, as larger numbers of T. evanescens were able to reach this depth as compared to the rice varieties. Among different traps, i.e. probe traps, cone traps and wiregauze tubes with adhesive cardboard, cone traps proved best for monitoring T. evanescens. These cone traps as well as the wiregauze tubes were used for the first time to monitor Trichogramma spp. in bulk grain. Cone traps recorded T. evanescens both when placed on the grain surface and in 5 cm depth within the grain irrespective of the release technique of Trichogramma, i.e. release from cardboard cards or sprinkling loose parasitised eggs. The potential for release of Trichogramma spp. within an integrated control strategy for the Indian meal moth in bulk stored grain and rice is discussed.     

改性活性硅酸（PSA）的制备及其对印染废水处理性能的研究

以硅酸钠为原料制备活性硅酸[w(SiO2)为3%,pH=3,活化时间30～40 min],再加入n(Fe3 )/n(SiO2)为1.0的硫酸铁,陈化后即得改性活性硅酸.以弱酸性染料为模拟印染废水进行絮凝沉淀实验,在该絮凝剂用量8mg/100 mL,染液pH=7.5日寸静置1 h条件下,脱色率和COD.去除率可分别达到97.87%和98.28%.同样条件下,可测得此法对直接染料和活性染料也有很好的效果.     

碳氮源对Bacillus sp.B_(53)发酵产聚谷氨酸的影响

考察了 8种不同碳源和 7种不同氮源对Bacillussp B53 发酵产聚谷氨酸的影响。结果表明 ,柠檬酸、甘油和硫酸铵是合成聚γ 谷氨酸比较适宜的碳源和氮源 ,前体物质L 谷氨酸的存在是聚谷氨酸高产所必需的。经过正交试验和回归分析 ,确定最佳碳氮源配比为 :L Glu 2 0 g/L ,CTA 9 86 4g/L ,Glycerol 80 36 g/L ,(NH4) 2 SO47g/L ,其他培养基成分有MgSO4·7H2 O 0 5 g/L ,FeCl3 ·6H2 O 0 0 2 g/L ,K2 HPO41g/L ,CaCl2 ·2H2 O0 2 g/L ,MnSO4·H2 O 0 0 5 g/L。在既定发酵条件下 ,Bacillussp B53 在优化培养基上产生γ PGA 19 12 g/L比基础发酵培养上的 8 87g/L提高了 115 5 6 %。     

Short communication: Presence of neutral metallopeptidase (npr) gene and proteolytic activity of Bacillus cereus isolated from dairy products

The control of proteolytic microorganisms is one of the main challenges of the dairy industry, due to their spoilage activity that jeopardizes the quality of their products. Seventy-four Bacillus cereus strains isolated from powdered, UHT, and pasteurized milks were tested for the presence of the neutral metallopeptidase (npr) gene and proteolytic activity at 7, 10, 25, 30, and 37°C. All strains had the npr gene, and proteolytic activity increased with the incubation temperature. The obtained results highlight the relevance of B. cereus as a spoiling agent in the dairy industry in terms of its genetic predisposition for proteolytic capacity, especially at room temperature.     

Effect of different levels of propionic acid on the growth of Micropolyspora faeni (A.94) and Thermoactinomyces vulgaris (A.64)

The effects of propionic acid incorporated in agar and on filter paper discs on the growth of Micropolyspora faeni (A.94) and Thermoactinomyces vulgaris (A.64) showed different results between the two methods of testing, with agar showing total inhibition of both micro-organisms even at the lowest level of acid (0.1%). The extent of diffusion of propionic acid from filter paper discs was significant up to 2.5% acid level beyond which there was no significant effect on pH changes in the surrounding medium. Both organisms varied in their degree of sensitivity to propionic acid and to pH. Both organisms grew at a pH of 6.5 and at all acid levels between 0.01 and 0.5%.     

Hot topic: Fatty acid and conjugated linoleic acid (CLA) isomer composition of commercial CLA-fortified dairy products: evaluation after processing and storage

Conjugated linoleic acid (CLA) exerts a strong positive influence on human health but intake of these fatty acids is typically too low, and increased consumption of CLA is recommended. A good way to raise the CLA content in the diet without a radical change in eating habits seems to be the enrichment of commonly consumed food products with CLA supplements. This study analyzed the total fatty acid content and the CLA isomer composition of 6 commercially available CLA-fortified dairy products during processing and 10 wk of refrigerated storage. Research was carried out by combining gas chromatography and silver-ion HPLC. The tested samples were a CLA oil supplement, and several skim milk dairy products fortified with the supplement (milk, milk powder, fermented milk, yogurt, fresh cheese, and milk-juice blend). The CLA oil supplement was added such that the consumer received 2.4 g/d of CLA by consuming 2 servings. The predominant isomers present, C18:2 cis-9, trans-11 CLA and C18:2 cis-10, trans-12 CLA, were in at a similar ratio, which ranged from 0.97 to 1.05. These major isomers were not significantly affected by processing but a decrease in total CLA in fresh cheese samples was detected after 10 wk of refrigerated storage. Refrigerated storage and thermal treatment resulted in significant decreases or disappearance of some of the minor CLA isomers and a significant increase of trans, trans isomers from both cis, trans, trans, cis, and cis, cis isomers especially in CLA-fortified milk powder but also in fermented milk, yogurt, and milk-juice blend.     

Production responses of dairy cows to dietary supplementation with conjugated linoleic acid (CLA) during the transition period and early lactation

Holstein cows (n = 30) entering second or greater lactation were fed fat supplements (90 g/d of fatty acids) consisting of Ca salts of either palm fatty acid distillate (control) or a mixture of palm fatty acid distillate and mixed isomers of conjugated linoleic acid (CLA, 30.4 g/ d) from 2 wk prepartum through 20 wk postpartum to determine whether CLA would inhibit milk fat synthesis during early lactation and, in turn, affect energy metabolism of dairy cows during the transition period and early lactation. Feeding CLA did not affect DMI or plasma concentrations of glucose, nonesterfied fatty acids, or beta-hydroxbutyrate during the prepartum period and did not affect postpartum DMI. Feeding CLA reduced milk fat content by 12.5% during early lactation; however, cows fed CLA tended to produce approximately 3 kg/d more milk during the first 20 wk of lactation. Feeding CLA tended to decrease the contribution of short- and medium-chain (C < or = 16) fatty acids to milk fat. Changes in milk yield, milk fat content, and milk fatty acid composition were not apparent until after the second week of lactation. Yield of 3.5% fat-corrected milk, milk protein content, milk protein composition, and calculated energy balance were not affected by treatment. Postpartum concentrations of glucose, nonesterfied fatty acids, and beta-hydroxbutyrate in plasma and hepatic content of glycogen and triglycerides were similar between treatments. These data imply that with CLA treatment in early lactation, dairy cows decreased milk fat synthesis and appeared to respond by partitioning more nutrients toward milk synthesis rather than improving net energy balance.     

亚损伤状态下枯草芽孢杆菌芽胞萌芽影响因素的研究

为了研究食品中营养要素对处于亚损伤状态枯草芽孢杆菌芽胞的影响,采用分批培养法,利用食品中存在的碳源、氮源、无机盐离子等分别诱导芽胞萌芽,采用正交实验研究了温度、p H、接种量、溶氧量对芽胞萌芽率的影响,分别在OD580下测定其光密度值,得到芽胞萌芽率。结果显示,麦芽糖、乳清蛋白是芽胞萌芽的最佳碳源、氮源;无机盐Mg SO4对芽胞萌芽产生显著的诱导作用。以麦芽糖（5 mg/m L）,Mg SO₄（5 mg/m L）,乳清蛋白（5 mg/m L）为基础培养基,芽胞的最佳生长条件为:接种量4%、p H7.0、溶氧量70 m L,37℃恒温振荡培养60 min,得芽胞萌芽率最大为15.27%。      

Effects of rumen-undegradable protein sources and supplemental 2-hydroxy-4-(methylthio)-butanoic acid and lysine-HCl on lactation performance in dairy cows

One hundred primiparous and multiparous Holstein cows were used in an experiment to evaluate the effect of supplementing diets with either a plant- or an animal-based source of rumen-undegradable protein (RUP), with or without AA supplementation, during the transition period and early lactation on milk production response. The experimental design was a randomized block design with approximately one-third of the cows being primiparous. Cows were assigned to 1 of 4 prepartum diets introduced 3 wk before the expected calving date and switched to the corresponding postpartum diet at calving. Diets 1 (AMI) and 2 (AMI+) included a vegetable RUP source (heat- and lignosulfonate-treated canola meal), with diet 2 containing supplemental Lys·HCl and Met hydroxy analog sources [d,l-2 hydroxy-4-(methylthio)-butanoic acid; Alimet feed supplement]. Diets 3 (PRO) and 4 (PRO+) consisted of a blend of animal RUP sources (blood meal, fish meal, feather meal, and porcine meat and bone meal), with diet 4 containing supplemental Lys·HCl and Met hydroxy analog sources [d,l-2 hydroxy-4-(methylthio)-butanoic acid; Alimet]. During the first 4 wk of lactation, dry matter intake was less when synthetic Lys·HCl and Alimet were supplemented, but this effect was no longer evident in wk 5 to 9 of the experiment. Interestingly, despite the initial decrease in dry matter intake in the cows fed AA-supplemented diets, there was no effect of treatment on milk production or the ratio of fat-corrected milk to dry matter intake throughout the 17 wk of the study. Undegradable protein source (vegetable vs. animal) did not affect dry matter intake, milk production, or 3.5% fat-corrected milk production for the first 17 wk of lactation. The results of this study indicate that heat- and lignosulfonate-treated canola meal can be used as a source of undegradable protein in place of high-quality rumen-undegradable animal protein sources without negative effects on milk production when diets are equivalent in rumen degradable protein, RUP, and metabolizable Met and Lys. Despite other reports citing clear benefits to feeding supplemental synthetic Lys or Met in diets fed to high-producing lactating dairy cows, we were unable to provide additional evidence to support these findings. Additionally, there was a trend for whole-blood Lys concentrations to be greater for diets supplemented with Lys·HCl.     

A comparison between feeding systems (pasture and TMR) and the effect of vitamin E supplementation on plasma and milk fatty acid profiles in dairy cows

Unidentified constituents in fresh pasture increase milk fat cis-9, trans-11 conjugated linoleic acid (CLA) concentration, and prevent milk fat depression, even though ruminal conditions conducive to reducing milk fat synthesis exist. One possible explanation is vitamin E (kappa-tocopherol), a constituent high in fresh pasture, but naturally low in conserved/dried forages and cereal grains. Twenty late-lactating dairy cows previously consuming a total mixed ration (TMR) were randomly allocated to one of two dietary treatments for 21 d: TMR (control; n=10); and TMR plus an additional 10,000 i.u. alpha-tocopherol/d (VIT E; n = 10). These cows were simultaneously compared with 13 late-lactation dairy cows previously grazing fresh pasture (PAS) balanced for age, parity and genetic merit. Average daily alpha-tocopherol intakes were approximately 468, 10,520 and 1,590 i.u./cow for the control, VIT E and PAS treatments, respectively. Dietary alpha-tocopherol supplementation (VIT E v. control) slightly increased milk fat content by 0.23 percentage units, but did not significantly alter milk fatty acid composition. Plasma trans-11 18:1 (VA) content tended to increase and trans-10 18:1 levels numerically declined following alpha-tocopherol supplementation suggesting possible changes in rumen biohydrogenation products. In addition, increased alpha-tocopherol intake in TMR-fed cows decreased serum urea levels and tended to alter milk fat 15:0 suggesting changes in rumen microbial populations. However, when compared with cows grazing pasture, TMR-fed cows supplemented with alpha-tocopherol, still produced milk with lower cis-9, trans-11 CLA and VA, and higher trans-10 18:1 concentrations suggesting alpha-tocopherol is not a primary reason for milk fatty acid profile differences between pasture and TMR-fed cows. Therefore, additional unknown pasture constituents favour production of fatty acids originating from the cis-9, trans-11 instead of the trans-10, cis-12 CLA biohydrogenation pathways.