Heat resistance of Listeria species to liquid whole egg ultrapasteurization treatment

The lethality of ultrapasteurization treatments (70 °C/1.5 min.) applied at constant temperature (isothermal condition) and at a constantly raising temperature of 2 °C/min (non-isothermal condition) in liquid whole egg (LWE) against two strains of Listeria monocytogenes (STCC 5672 and 4032) and one of Listeria innocua has been investigated. Isothermal survival curves up to 71 °C were obtained, which followed first-order inactivation kinetics. The obtained D_t values indicated that L. innocua was significantly (p < 0.05) more heat resistant than L. monocytogenes strains. Non-significant (p > 0.05) differences were observed among z values (12.4 ± 0.4 °C, 13.1 ± 0.4 °C and 12.2 ± 0.7 °C for L. innocua and L. monocytogenes 5672 and 4032, respectively). Based on obtained D_t and z values, isothermal ultrapasteurization treatment (70 °C/1.5 min.) would provide 3.5-, 5.0-, and 6.5-Log₁₀ cycles of L. innocua and L. monocytogenes 5672 and 4032, respectively. Non-isothermal heating lag phase increased the thermotolerance of Listeria species in LWE. The simulated industrial pasteurization treatment for LWE (heating-up phase from 25 to 70 °C followed by 1.5 min. at 70 °C) would attain 5-Log₁₀ reductions of L. monocytogenes 5672 and 4032, and 3.7-Log₁₀ reductions of L. innocua. Therefore, the safety level of industrial ultrapasteurization concerning L. monocytogenes could be lower than that estimated with data obtained under isothermal conditions.     

A comparison between E-beam irradiation and high pressure treatment for cold-smoked salmon sanitation: microbiological aspects

The effectiveness of electron beam irradiation and high pressure treatment for the sanitation of cold-smoked salmon from two points of view, microbial safety and shelf-life extension, was compared. From the response of L. monocytogenes INIA H66a to irradiation, a D value of 0.51 kGy was calculated. For samples stored at 5 °C, 1.5 kGy would be sufficient to attain a Food Safety Objective (FSO) of 2 log₁₀cfu/g L. monocytogenes for a 35-day shelf-life, whereas 3 kGy would be needed in the case of a temperature abuse (5 °C + 8 °C). Pressurization at 450 MPa for 5 min was considered to be an insufficient treatment, since the FSO of 2 log₁₀cfu/g L. monocytogenes was only attained for a shelf-life of 21 days at 5 °C. However, treatment at 450 MPa for 10 min achieved this FSO for samples held during 35 days at 5 °C, or during 21 days under temperature abuse (5 °C + 8 °C) conditions. Irradiation at 2 kGy kept the microbial population of smoked salmon below 6 log₁₀cfu/g after 35 days at 5 °C, with negligible or very light changes in its odor. Pressurization at 450 MPa for 5 min also kept the microbial population below 6 log₁₀cfu/g after 35 days at 5 °C and did not alter odor, but affected negatively the visual aspect of smoked salmon.     

Thermal inactivation of Salmonella spp. during conching

Although chocolate is a microbiologically stable product it has been described as a vehicle for Salmonella spp. Because of the low water activity (a_w) and the high fat content of chocolate Salmonella spp. shows an increased heat resistance, even during the thermal process of chocolate making. The aim of this study was to evaluate the thermal inactivation of Salmonella spp. during conching in various masses of chocolate and cocoa butter at different temperatures (50-90 °C). The effect of thermal treatment on Salmonella spp. was determined with the MPN (Most-Probable-Number) method. Results of thermal treatment showed approximate D-values for cocoa butter from D_50°C = 245 min to D_60°C = 306 min, for cocoa liquor from D_50°C = 999 min to D_90°C = 26 min and for dark chocolate of D_50°C = 1574 min. z-values were found to be z = 20 °C in cocoa liquor and z = 14 °C in dark chocolate. This study demonstrates that the conching process alone does not ensure the inactivation of Salmonella spp. in different chocolate masses and that an additional decontamination step at the beginning of the process as well as an HACCP concept is necessary during chocolate production to guarantee the absence of Salmonella spp. in chocolates and related products.     

Extraction, thermal stability and kinetic behavior of pectinmethylesterase from hawthorn (Crataegus pubescens) fruit

Pectinmethylesterase (PME) extracted from hawthorn (Crataegus pubescens) fruit was evaluated for its thermal stability and kinetic behavior. The enzyme extraction process was established after studying different NaCl concentrations (0.5-3.0 moles/L). A maximum PME extraction of 51.61 units/mg protein was obtained using 2 moles/L NaCl. Kinetic parameters (K_m and V_max) were determined using a commercial citrus pectin and C. pubescens pectin as substrates. The effects of NaCl concentration, pH and temperature on PME activity were investigated. PME showed higher affinity for C. pubescens pectin (K_m and V_max of 2.84 mg/mL protein, and 64.10 units/mg protein, respectively) than for citrus pectin. C. pubescens PME extract showed maximum activity at 0.4 moles/L NaCl, pH 7.5, and 55 °C. The E_a and Q₁₀ for thermal activation were 36.27 kJ/mol and 2.01 (20-30 °C), respectively. About 50% of the activity still remained after heating for 25 min at 60 °C, and it was completely inactivated by incubation at 80 °C for 10 min. The Q₁₀ and E_a values for thermal inactivation reaction were 20.06 (70-80 °C) and 146.16 kJ/mol, respectively. These results provide useful information about the factors that affect the activity of C. pubescens PME, and might be used as a starting point for texture control during post-harvest handling and processing of this fruit.     

Spoilage characteristics of Brochothrix thermosphacta and campestris in chilled vacuum packaged lamb,and their detection and identification by real time PCR

The spoilage potential of Brochothrix campestris and Brochothrix thermosphacta was investigated in vacuum-packed lamb. Striploins (n = 338) were inoculated and stored for twelve weeks at temperatures − 1.5, 0, 2 and 7 °C. Growth around 5–6 log₁₀ CFU/cm² was recorded after six weeks at 0, 2 and 7 °C, and ~ 3 log₁₀ CFU/cm² after nine weeks at − 1.5 °C. B. campestris was shown to cause spoilage by nine weeks at temperatures above 0 °C by the presence of green drip and unacceptable odours. Molecular based assays for the detection and differentiation of B. thermosphacta and B. campestris were developed and validated. A TaqMan assay was designed to target a unique single-nucleotide polymorphism in the Brochothrix 16 s rRNA gene with a sensitivity of < 7 CFU per reaction. Secondly a specific PCR was designed for B. campestris targeting the structural genes, brcA and brcB. These testing regimes offer a rapid and cost effective method for the detection and screening of Brochothrix species in meat products and processing environments.     

Greek dry-salted olives: Monitoring the dry-salting process and subsequent physico-chemical and microbiological profile during storage under different packing conditions at 4 and 20 °C

Naturally black olives cv. Thassos were processed in dry salt according to industrial procedure by uniformly dispersing 40 kg of coarse salt in 100 kg freshly harvested olives. Dry-salting process was monitored by measuring selected physico-chemical (weight loss, NaCl content, pH, a_w, reducing sugars) and microbiological parameters (total viable counts, lactic acid bacteria, enterobacteria, yeasts, pseudomonads). Total weight loss amounted to 21 g/100 g after 80 days of dry-salting. Salt content in the fruits increased to 7.4 g/100 g followed by a decrease in water activity from 0.98 to 0.76. The pH did not change significantly presenting a slight decrease from 5.25 to 4.92. The initial microflora of the fruits comprised of lactic acid bacteria (4.1 log₁₀ cfu/g), yeasts (5.7 log₁₀ cfu/g), enterobacteria (3.7 log₁₀ cfu/g ) and pseudomonads (4.0 log₁₀ cfu/g). In the end of dry-salting, no microbial groups were enumerated apart from yeasts, due to the low water activity of the product. After dry-salting, olives were packed in HDPE bags under air (control samples) and 100 ml/100 ml CO₂. Another lot of fruits was dipped in 1 g/100 ml solution of potassium sorbate for 10 min prior to packing in the same bags under aerobic conditions. All packages were stored at 4 and 20 °C for a period of 180 days. During storage, the microbial flora comprised of yeasts, while no lactic acid bacteria, enterobacteria, pseudomonads or Staphylococcus aureus were detected as the low water activity/high salt content does not favour their growth. At 4 °C, the population of yeasts declined steadily throughout storage, but to a different extend depending on the packing treatment. At 20 °C, only potassium sorbate was effective in suppressing yeast growth. All packing treatments prevented fungal growth at both storage temperatures, apart from the samples stored in air. The pH, a_w and salt content did not change significantly throughout storage.     

Predictive model for growth of Clostridium perfringens during cooling of cooked uncured meat and poultry

Comparison of Clostridium perfringens spore germination and outgrowth in cooked uncured products during cooling for different meat species is presented. Cooked, uncured product was inoculated with C. perfringens spores and vacuum packaged. For the isothermal experiments, all samples were incubated in a water bath stabilized at selected temperatures between 10 and 51 °C and sampled periodically. For dynamic experiments, the samples were cooled from 54.4 to 27 °C and subsequently from 27 to 4 °C for different time periods, designated as x and y hours, respectively. The growth models used were based on a model developed by Baranyi and Roberts (1994. A dynamic approach to predicting bacterial growth in food. Int. J. Food Micro. 23, 277-294), which incorporates a constant, referred to as the physiological state constant, q₀. The value of this constant captures the cells’ history before the cooling begins. To estimate specific growth rates, data from isothermal experiments were used, from which a secondary model was developed, based on a form of Ratkowsky’s 4-parameter equation. The estimated growth kinetics associated with pork and chicken were similar, but growth appeared to be slightly greater in beef; for beef, the maximum specific growth rates estimated from the Ratkowsky curve was about 2.7 log₁₀ cfu/h, while for the other two species, chicken and pork, the estimate was about 2.2 log₁₀ cfu/h. Physiological state constants were estimated by minimizing the mean square error of predictions of the log₁₀ of the relative increase versus the corresponding observed quantities for the dynamic experiments: for beef the estimate was 0.007, while those for pork and chicken the estimates were about 0.014 and 0.011, respectively. For a hypothetical 1.5 h cooling from 54 °C to 27° and 5 h to 4 °C, corresponding to USDA-FSIS cooling compliance guidelines, the predicted growth (log₁₀ of the relative increase) for each species was: 1.29 for beef; 1.07 for chicken and 0.95 log₁₀ for pork. However, it was noticed that for pork in particular, the model using the derived q₀ had a tendency to over-predict relative growth when the observed amount of relative growth was small, and under-predict the relative growth when the observed amount of relative growth was large. To provide more fail-safe estimate, rather than using the derived value of q₀, a value of 0.04 is recommended for pork.     

Effect of water activity, temperature and incubation time on growth and ochratoxin A production by Aspergillus niger and Aspergillus carbonarius on maize kernels

The aim of this study was to determine the effects of water activity (a_w) (0.92-0.98), temperature (5-45 °C) and incubation time (5-60 days) on growth and ochratoxin A (OTA) production by Aspergillus niger and Aspergillus carbonarius on maize kernels using a simple method. Colony diameters of both strains at 0.92 a_w were significantly lower than those at 0.96 and 0.98 a_w levels. The optimum growth temperature range for A. niger was 25-40 °C and for A. carbonarius 20-35 °C. A. niger produced OTA from 15 to 40 °C, and the highest OTA level was recorded at 15 °C. The concentration of OTA produced at 0.92 a_w was significantly lower than those at 0.96 and 0.98 a_w. A. carbonarius produced OTA from 15 to 35 °C and the maximum concentration was achieved at 15 °C, although not differing statistically from the concentration detected at 20 °C. At 0.98 a_w the OTA concentration was significantly higher than at 0.96 and 0.92 a_w. Our results show that maize supports both growth and OTA production by A. niger and A. carbonarius. The studied strains were able to produce OTA in maize kernels from the fifth day of incubation over a wide range of temperatures and water availabilities. Although the limit of quantification of our method was higher than that required for the analysis of OTA in food commodities, it has proved to be a useful and rapid way to detect OTA production by fungi inoculated onto natural substrates, in a similar way as for pure culture. Both species could be a source of OTA in this cereal in temperate and tropical zones of the world.     

Pasteurization of grapefruit juice using a centrifugal ultraviolet light irradiator

Studies are lacking on the nonthermal pasteurization of liquid foods using UV irradiators that centrifugally form very thin films to overcome the problem of limited penetration depth of UV. Grapefruit juice inoculated with Escherichia coli or Saccharomyces cerevisiae was processed at the following conditions: UV dose 4.8–24 mJ/cm²; treatment time 3.2 s, cylinder rotational speed 450–750 rpm, cylinder inclination angle 15–45°, outlet temperature 11 °C, and flow rate 300 ml/min, and was stored for 35 days. Appropriate dilutions of the samples were pour plated with TSA and TSA + 3% NaCl for E. coli and Sabouraud dextrose agar (SDA) and SDA + 5% NaCl for S. cerevisiae. Nonthermal UV processing at 19 mJ/cm², 450 rpm and 15° reduced E. coli in grapefruit juice by 5.1 log₁₀. A dose of 14 mJ/cm² reduced S. cerevisiae by 6.0 log₁₀. Inactivation increased linearly with increasing UV dose. The inactivations at 600 and 750 rpm were similar, and were better than at 450 rpm. The results at 30° and 45° were similar, and were better than at 15°. The occurrence of sublethal injury in either microorganism was not detected. Storing UV processed grapefruit juice at 4 and 10 °C reduced the surviving E. coli to below 1 log₁₀ cfu/ml in 14 days. Processing UV juice reduced the population of S. cerevisiae to less than 1 log₁₀ cfu/ml where it remained for 35 days during refrigerated storage. These results suggest that grapefruit juice may be pasteurized using a nonthermal UV irradiator that centrifugally forms a thin film.     

Characterization of polyphenol oxidase from butter lettuce (Lactuca sativa var. capitata L.)

Polyphenol oxidase (PPO) was isolated from butter lettuce (Lactuca sativa var. capitata L.) grown in Poland and its biochemical characteristic were studied. PPO from butter lettuce showed a higher affinity to 4-methylcatechol than to catechol. The K_M and V_max values were: 3.20 ± 0.01 mM and 4081 ± 8 U/ml min⁻¹ for catechol and 1.00 ± 0.09 mM and 5405 ± 3 U/ml min⁻¹ for 4-methylcatechol. The optimum pHs of the enzyme were found to be 5.5 using catechol and 6.8 using 4-methylcatechol as substrate. The enzyme had a temperature optimum of 35 °C. The enzyme was relatively stable at 30 °C and 40 °C. The times required for 50% inactivation of activity at 50 °C, 60 °C and 70 °C were found to be about 30, 20 and 5 min, respectively. Inhibitors used for investigation in this study were placed in relative order of inhibition: p-hydroxybenzoic acid > glutathione ≈ ascorbic acid > l-cysteine > EDTA > citric acid. The enzyme eluted in the chromatographic separations was analyzed electrophoretically under denaturating conditions. The analysis revealed a single band on the SDS–PAGE which corresponded to a molecular weight of 60 kDa.     

Thermal inactivation of Yersinia enterocolitica in pork slaughter plant scald tank water

The objective of this study was to establish the time–temperature combinations required to ensure the thermal inactivation of Yersinia enterocolitica during scalding of pork carcasses. A 2 strain cocktail of Y. enterocolitica (bioserotypes 2/O:5,27 and 1A/O:6,30) was heat treated at 50, 55 and 60 °C in samples of scald tank water obtained from a commercial pork slaughter plant. Samples were removed at regular intervals and surviving cells enumerated using (i) Cefsulodin–Irgasan–Novobiocin Agar (CIN) supplemented with ampicillin and arabinose and (ii) Tryptone Soya Agar (TSA), overlaid with CIN agar with ampicillin and arabinose. The data generated was used to estimate D- and z-values and the formula D_x = log^− 1(log D₆₀ − ((t₂ − t₁)/z)) was applied to calculate thermal death time–temperature combinations from 55 to 65 °C. D₅₀, D₅₅ and D₆₀-values of 45.9, 10.6 and 2.7 min were calculated from the cell counts obtained on CIN agar, respectively. The corresponding D-values calculated from the TSA/CIN counts were 45.1, 11 and 2.5 min, respectively. The z-value was 7.8. It was concluded that a time–temperature combination of 2.7 min at 60 °C is required to achieve a 1 log reduction in Y. enterocolitica in pork scald tank water. The predicted equivalent at 65 °C was 0.6 min. This study provides data and a model to enable pork processors to identify and apply parameters to limit the risk of carcass cross-contamination with Y. enterocolitica in pork carcass scald tanks.     

The effects of packaging method (vacuum pouch vs. plastic tray) on spoilage in a cook-chill pork-based dish kept under refrigeration

The effects of two packaging methods on the spoilage of a cook-chill pork-based dish kept under refrigeration were studied. Raw pork cuts and pre-cooked tomato sauce were packed under vacuum “sous vide” in polyamide–polypropylene pouches (SV) or into translucent polypropylene trays under modified atmosphere (80% N₂ + 20% CO₂) and sealed with a top film (PT). Samples were cooked inside the pack at an oven temperature/time of 70 °C/7 h, chilled at 3 °C and stored at 2 °C for up to 90 days. Microbial (psychrotrophs, lactic-acid bacteria, Enterobacteriaceae, moulds and yeasts), physical–chemical (pH, water activity and total acidity) and sensory (colour, odour, flavour, texture and acceptance) parameters were determined. Heat penetration was faster in SV (2 °C/min) than in PT (1 °C/min) (core temperature). Both packaging methods were equally effective in protecting against microbial spoilage for 90 day at 2 °C. Minor counts were only detected for lactic-acid bacteria and anaerobic psychrotrophs in SV. No Enterobacteriaceae growth was found. Slight differences between SV and PT in pH and total acidity were observed. SV and PT had similar effects on the sensory preservation of the dishes. A gradual loss of acceptance of the cooked pork and tomato sauce was observed. Rancid flavour in PT and warmed-over-flavour in SV were noted in the final stages of storage. According to acceptance scores, the shelf-life of both SV and PT was 56 days at 2 °C. Both packaging methods can be used to manufacture sous vide meat-based dishes subsequently stored under refrigeration for catering use.     

Characterization of the Enterobacteriaceae community that developed during storage of minced beef under aerobic or modified atmosphere packaging conditions

The whole cell protein and macrorestriction analysis of DNA of Enterobacteriaceae isolates recovered from minced beef stored at 0, 5, 10 and 15 °C aerobically and under modified atmosphere packaging consisting of 40% CO₂-30% O₂-30% N₂ in the presence (MAP+) and absence (MAP−) of oregano essential oil were studied. Sodium dodecyl sulphate polyacrylamide gel electrophoresis (SDS-PAGE) profiles obtained from whole cell protein analysis of the Enterobacteriaceae isolates revealed seven groups. Moreover, application of a modified PFGE protocol with XbaI restriction, resulted into 19 different fingerprints. The Enterobacteriaceae community of fresh meat consisted of Serratia liquefaciens and Serratia proteamaculans. S. liquefaciens strain VK23 was the dominant isolate of Enterobacteriaceae for the most conditions adopted, except 10 °C and 15 °C under MAP + and 10 °C under MAP−. In the latter cases, Hafnia alvei represented the dominant fingerprint. Citrobacter freundii was recovered from minced beef stored aerobically, while H. alvei and Proteus vulgaris were recovered under MAP. Storage conditions affected the Enterobacteriaceae community; modified atmosphere packaging increased both species and strain diversity.     

Nonthermal inactivation and sublethal injury of Lactobacillus plantarum in apple cider by a pilot plant scale continuous supercritical carbon dioxide system

The objective of this study was to evaluate the efficacy of supercritical carbon dioxide (SCCO₂) for inactivating Lactobacillus plantarum in apple cider using a continuous system with a gas-liquid metal contactor. Pasteurized apple cider without preservatives was inoculated with L. plantarum and processed using a SCCO₂ system at a CO₂ concentration range of 0-12% (g CO₂/100 g product), outlet temperatures of 34, 38, and 42 °C, a system pressure of 7.6 MPa, and a flow rate of 1 L/min. Processing with SCCO₂ significantly (P < 0.05) enhanced inactivation of L. plantarum in apple cider, resulting in a 5 log reduction with 8% CO₂ at 42 °C. The response surface model indicated that both CO₂ concentration and temperature contributed to the microbial inactivation. The extent of sublethal injury in surviving cells in processed apple cider increased as CO₂ concentration and processing temperature increased, however the percent injury dramatically decreased during SCCO₂ processing at 42 °C. Structural damage in cell membranes after SCCO₂ processing was observed by SEM. Refrigeration (4 °C) after SCCO₂ processing effectively inhibited the re-growth of surviving L. plantarum during storage for 28 days. Thus this study suggests that SCCO₂ processing is effective in eliminating L. plantarum and could be applicable for nonthermal pasteurization of apple cider.     

Partial purification and characterisation of endoglucanase from an edible mushroom, Lepista flaccida

A crude extract was prepared from the fruiting body of Lepista flaccida, an edible mushroom and endoglucanase activity of the extract was increased 14-fold with ammonium sulphate precipitation. Maximum enzyme activity was seen at pH 4.0 and 50 °C when carboxymethylcellulose was used as a substrate. K_0.5 and V_max values of the partially purified endoglucanase were 7.7 mg/ml and 25 ± 0.9 U/mg protein, respectively. The enzyme was quite stable over a broad range of pH (2.0–9.0) at 4 °C. When it was incubated at temperatures between 20 °C and 60 °C for 12 h, it conserved much of its original activity (over 40%). The activity of the enzyme increased by 234 ± 3.6% in the presence of 1 mM Mn²⁺. The endoglucanase was inhibited by EDTA, PMSF, β-ME and DDT. In conclusion, pH and thermal stability of the L. flaccida endoglucanase could make it useful for industrial purposes.     

High-pressure destruction kinetics of Clostridium sporogenes ATCC 11437 spores in milk at elevated quasi-isothermal conditions

The high-pressure sterilization establishment requires data on isobaric and isothermal destruction kinetics of baro-resistant pathogenic and spoilage bacterial spores. In this study, Clostridium sporogenes 11437 spores (10⁷ CFU/ml) inoculated in milk were subjected to different pressure, temperature and time (P, T, t) combination treatments (700–900 MPa; 80–100 °C; 0–32 min). An insulated chamber was used to enclose the test samples during the treatment for maintaining isobaric and quasi-isothermal processing conditions. Decimal reduction times (D values) and pressure and temperature sensitivity parameters, Z_T (pressure constant) and Z_P (temperature constant) were evaluated using a 3 × 3 full factorial experimental design. HP treatments generally demonstrated a minor pressure pulse effect (PE) (no holding time) and the pressure hold time effect was well described by the first order model (R² > 0.90). Higher pressures and higher temperatures resulted in a higher destruction rate and a higher microbial count reduction. At 900 MPa, the temperature corrected D values were 9.1, 3.8, 0.73 min at 80, 90, 100 °C, respectively. The thermal treatment at 0.1 MPa resulted in D values 833, 65.8, 26.3, 6.0 min at 80, 90, 95, 100 °C respectively. By comparison, HP processing resulted in a strong enhancement of spore destruction at all temperatures. Temperature corrected Z_T values were 16.5, 16.9, 18.2 °C at 700, 800, 900 MPa, respectively, which were higher than the thermal z value 9.6 °C. Hence, the spores had lower temperature sensitivity at elevated pressures. Similarly, corrected Z_P values were 714, 588, 1250 MPa at 80, 90, 100 °C, respectively, which illustrated lower pressure sensitivity at higher temperatures. By general comparison, it was concluded that within the range operating conditions employed, the spores were relatively more sensitive to temperature than to pressure.     

Extraction of α-tocopherol and γ-oryzanol from rice bran

The aim of this research was to study the effect of operating mode (continuous versus batch+continuous), temperature, pressure and solvent on α-tocopherol and γ-oryzanol extraction from rice bran (Oryza sativa Linn.) and compare the efficiency of three extraction methods: SC-CO₂ extraction, solvent extraction and soxhlet extraction. Three sets of experiments were performed. First, extraction using SC-CO₂ was performed over a range of temperatures and pressures (45-65 °C and at 38 and 48 MPa), and at a CO₂ flow rate of 0.45 mL/min. The results showed that the best conditions for α-tocopherol extraction were 55 °C, 48 MPa in the batch+continuous mode. For γ-oryzanol, the best conditions were 65 °C, 48 MPa and in the continuous mode. In the second set of experiments, solvent extraction using hexane and ethanol at 32 and 55-60 °C was studied. The results showed that none of the solvents could extract α-tocopherol; however, ethanol at 55-60 °C was suitable for γ-oryzanol extraction. Finally, soxhlet extraction experiments using hexane for α-tocopherol and ethanol for γ-oryzanol were also performed. In summary, SC-CO₂ was found to be the best solvent for extracting both α-tocopherol and γ-oryzanol from rice bran, because of its higher yields and extraction rate.     

Insecticidal efficacy of diatomaceous earth against Sitophilus oryzae (L.) (Coleoptera: Curculionidae) and Tribolium confusum du Val (Coleoptera: Tenebrionidae) on stored wheat: influence of dose rate, temperature and exposure interval

Laboratory experiments were conducted in order to assess the insecticidal effect of a diatomaceous earth formulation (Silicosec^®, Biofa GmbH, Germany) against Sitophilus oryzae and Tribolium confusum on stored wheat. Adults of the two species were exposed on wheat treated with diatomaceous earth at four dose rates: 0.25, 0.5, 1 and 1.5 g/kg of wheat, respectively. For each dose rate, the treated wheat was placed at 22°C, 25°C, 27°C, 30°C and 32°C. Dead adults were counted after 24 and 48 h, 7 and 14 d of exposure. After the 14-d interval, the live adults were removed and placed for 7 d in untreated wheat (in the case of S. oryzae) or untreated flour (in the case of T. confusum), and the production of F₁ was recorded. For both species, dose rate, temperature and exposure interval significantly affected mortality (P<0.001). Mortality was higher at longer exposure intervals. The efficacy of SilicoSec against S. oryzae increased with temperature, but for T. confusum mortality was lower at 32°C, compared to 30°C, for 24 and 48 h exposure intervals. Tribolium confusum proved less susceptible to SilicoSec than S. oryzae. In general, the rates of 1 and 1.5 g/kg of wheat provided a satisfactory level of protection against the two species examined. For S. oryzae, F₁ emerged only at 22°C, in wheat treated with 0.25 or 0.5 g/kg. However, for T. confusum, F₁ were recorded at 22°C for 0.5 g/kg and at 22°C, 25°C, 27°C and 30°C for 0.25 g/kg.     

Effect of high-pressure processing on reduction of Listeria monocytogenes in packaged Queso Fresco

The effect of high-hydrostatic-pressure processing (HPP) on the survival of a 5-strain rifampicin-resistant cocktail of Listeria monocytogenes in Queso Fresco (QF) was evaluated as a postpackaging intervention. Queso Fresco was made using pasteurized, homogenized milk, and was starter-free and not pressed. In phase 1, QF slices (12.7 × 7.6 × 1 cm), weighing from 52 to 66 g, were surface inoculated with L. monocytogenes (ca. 5.0 log₁₀ cfu/g) and individually double vacuum packaged. The slices were then warmed to either 20 or 40°C and HPP treated at 200, 400, and 600 MPa for hold times of 5, 10, 15, or 20 min. Treatment at 600 MPa was most effective in reducing L. monocytogenes to below the detection level of 0.91 log₁₀ cfu/g at all hold times and temperatures. High-hydrostatic-pressure processing at 40°C, 400 MPa, and hold time ≥15 min was effective but resulted in wheying-off and textural changes. In phase 2, L. monocytogenes was inoculated either on the slices (ca. 5.0 log₁₀ cfu/g; ON) or in the curds (ca. 7.0 log₁₀ cfu/g; IN) before the cheese block was formed and sliced. The slices were treated at 20°C and 600 MPa at hold times of 3, 10, and 20 min, and then stored at 4 and 10°C for 60 d. For both treatments, L. monocytogenes became less resistant to pressure as hold time increased, with greater percentages of injured cells at 3 and 10 min than at 20 min, at which the lethality of the process increased. For the IN treatment, with hold times of 3 and 10 min, growth of L. monocytogenes increased the first week of storage, but was delayed for 1 wk, with a hold time of 20 min. Longer lag times in growth of L. monocytogenes during storage at 4°C were observed for the ON treatment at hold times of 10 and 20 min, indicating that the IN treatment may have provided a more protective environment with less injury to the cells than the ON treatment. Similarly, HPP treatment for 10 min followed by storage at 4°C was the best method for suppressing the growth of the endogenous microflora with bacterial counts remaining below the level of detection for 2 out of the 3 QF samples for up to 84 d. Lag times in growth were not observed during storage of QF at 10°C. Although HPP reduced L. monocytogenes immediately after processing, a second preservation technique is necessary to control growth of L. monocytogenes during cold storage. However, the results also showed that HPP would be effective for slowing the growth of microorganisms that can shorten the shelf life of QF.     

Development and survival of the cheese mites, Acarus farris and Tyrophagus neiswanderi (Acari: Acaridae), at constant temperatures and 90% relative humidity

Two species of acarid mites, Acarus farris and Tyrophagus neiswanderi, have been identified infesting Cabrales cheese in an Asturian maturing cave, the former being the prevalent species. The developmental rate and survival of immature stages of these mites were examined at constant temperatures, ranging from 7 to 29.7 °C for A. farris, and 10 to 31 °C for T. neiswanderi, and a relative humidity (r.h.) of 90±5%. The larval stage of A. farris was particularly susceptible to low and high temperatures with 81.7% and 95.2% mortality at 7 and 29.7 °C, respectively. Tyrophagus neiswanderi larvae also showed the greatest mortality at extreme temperatures among immature stages, though at a lower level than for A. farris (8.6% and 25.6% at 10 and 31 °C, respectively). The optimal temperature for development appeared to be 27-28 °C for both species and the developmental rates were higher for A. farris than T. neiswanderi within the range of the cooler temperatures prevalent in the cheese-maturing caves. The nonlinear Logan type-III model provided the best fit for the relationship between developmental rates and temperature (R_a²>0.99) for all immature stages of A. farris, whereas the development of T. neiswanderi was better described by the Lactin model (R_a²>0.97). The lower and upper developmental threshold temperatures predicted for each stage of A. farris were 3-4 °C lower than those predicted for T. neiswanderi. The differential temperature-development rate for each species might explain the greater abundance of A. farris compared to T. neiswanderi. Furthermore, manipulation of temperature based on modeling predictions may well be used to control mite populations during the cheese maturing process.