Storage studies of tomato and bell pepper using eco‐friendly films

Tomato (Lycopersicon esculentum) and bell pepper (Capsicum annuum), packaged in cartons (approximately 0.35 kg per box) covered with either eco‐friendly chitosan film or synthetic petroleum‐based low‐density polyethylene (LDPE) film, were stored at room temperature (27 ± 1 °C) and 65 ± 3% relative humidity (RH). Fruits were withdrawn periodically and changes in physico‐chemical, instrumental and sensory characteristics were analysed. During storage, oxygen levels showed only marginal changes, while CO₂ levels showed a gradual increase, especially so in LDPE film‐covered cartons. The fresh weight loss, colour, firmness, formation of defective spots and shrivelling showed greater changes for unpackaged fruits as well as for those in LDPE film‐covered cartons, in comparison with fruits stored in chitosan film‐covered cartons, which retained many of the desirable attributes. Principle component analysis of data from sensory or instrumental sensory analyses indicated segregation of samples stored under different conditions with respect to both desirable and undesirable attributes. The fruits showed greater deterioration, including the loss of characteristic bell pepper odour, when packaged in cartons covered with LDPE films, while those packaged in chitosan film retained more of the desirable quality attributes for a longer period. Copyright © 2006 Society of Chemical Industry     

典型电商运输包装对猕猴桃运输微环境及贮藏品质的影响

为了探索3 种典型电商运输包装猕猴桃所处运输微环境变化特点及其对后续贮藏品质的影响,分别采用单纯纸箱、纸箱内衬聚苯乙烯泡沫箱和纸箱内衬聚乙烯发泡棉材料（果实单格放置）3 种形式包装对预冷猕猴桃进行运输,记录运输期间包装箱内的温湿度和振动强度变化,运输结束后分装入打孔塑料盒,贮藏于（4.0±0.5）℃的环境中并定期测定其品质变化。结果表明,纸箱内衬聚苯乙烯泡沫箱和内衬聚乙烯发泡棉材料均能够有效延缓包装箱内温度的上升,保持包装内的湿度;猕猴桃运输过程中振动主要来自于车辆的加减速和颠簸,纸箱内衬聚乙烯发泡棉材料的综合减振效果最好。运输过程的颠簸及温度变化是影响猕猴桃品质的主要因素,经过纸箱内衬聚乙烯发泡棉材料包装运输的猕猴桃在贮藏期间质量损失率上升最缓慢,硬度最高,颜色最鲜艳,总可溶性固形物、总酸质量分数较高,综合贮藏品质最好;纸箱内衬聚苯乙烯泡沫箱包装运输的猕猴桃贮藏品质稍次之,单纯纸箱包装运输的猕猴桃贮藏品质最差。综合运输微环境及货架期品质变化,纸箱内衬聚苯乙烯泡沫箱和纸箱内衬聚乙烯发泡棉材料均是适于电商运输猕猴桃的包装方式。     

Combined effects of postharvest heat treatment and chitosan coating on quality of fresh‐cut mangoes (Mangifera indica L.)

The influence of heat treatment combined with coating on sensory quality, physico‐chemicals characteristics (firmness, colour, pH, titratable acidity, total soluble solids and total carotenoids content) and microbiological quality of fresh‐cut mangoes were studied. Whole mangoes (Mangifera indica cv ‘Tommy Atkins’) were subjected to hot water dipping (HWD) at 50 °C for 30 min and cooled for 15 min. Heated and unheated fruits were minimally processed and mango cubes were coated with chitosan solution (0.25% w/v) dissolved in 0.5% (w/v) citric acid, and stored for 9 days at 6 °C under ambient atmosphere. This study showed that both HWD 50 °C for 30 min and chitosan coating, either alone or combined, did not affect the taste and the flavour of mangoes slices. The chitosan coating combined with HWD or not inhibited the microbial growth for 9 days at 6 °C. Indeed chitosan coating was used for his antimicrobial proprieties. HWD 50 °C for 30 min was the beneficial treatment to maintain firmness and colour during 9 days at 6 °C.     

Storage studies of mango packed using biodegradable chitosan film

The effect on the quality of mango fruits (Mangifera indica) during modified atmosphere packaging was investigated. The fruits were kept in carton boxes whose top surface was covered with either chitosan film or with low-density polyethylene (positive control) or kept as such (control) and stored at room temperature (27ǃ °C at 65% RH). The CO₂ and O₂ levels measured on day 3 were 23-26% and 3-6%, and at the end of the storage period they were 19-21% and 5-6%, respectively. Various quality parameters such as colour, chlorophyll, acidity, vitamin C, carotenoid and sugar contents were studied. The fruits stored as such had a shelf-life of 9ǃ days, whereas those stored in low-density polyethylene showed off-flavour due to fermentation and fungal growth on the stalk and around the fruits, and were partially spoiled. On the other hand, fruits stored in chitosan-covered boxes showed an extension of shelf-life of up to 18 days and without any microbial growth and off-flavour. Being biodegradable and ecofriendly, chitosan films are useful as an alternative to synthetic packaging films in the storage of freshly harvested mangoes.     

QUALITY CHANGES IN ORGANIC TOMATOES PACKAGED IN BIODEGRADABLE PLASTIC FILMS

Quality changes in organic tomatoes stored in four biodegradable packages and in LDPE‐bags at 11 ± 1C and 75–85% RH were studied for three weeks. Organic tomatoes were packed in perforated LDPE‐bags and the following biodegradable packages: a perforated Mater‐Bi®‐bag, a Biopol®‐coated paperboard tray overwrapped with a perforated Mater‐Bi®‐bag, a polylactide coated paperboard tray overwrapped with a perforated Mater‐Bi®‐bag, and a perforated cellophane bag. The tomatoes were analyzed for weight loss, moisture content, color, firmness and flavor. Package type had no significant influence on the tomatoes' sensory quality, whereas storage time significantly (p < 0.05) influenced the fruits' color, flavor and firmness. The tomatoes' firmness decreased, their redness (a*value) increased and their flavor diminished during storage. The tomatoes lost more of their weight in biodegradable packages than in LDPE packages.     

The response of unripe Conference pears to modified atmosphere retail packaging

Unripe green Conference pears with initial firmness values of 46–55 N were sealed in modified atmosphere (MA) low density polyethylene (LDPE, 30μ) pillow packs and in perforated control packs on three dates during 1985–1986. Changes in pack atmosphere composition, skin chlorophyll content, flesh firmness and sensory quality were monitored during 14–20 days simulated shelf-life at 20°C. In MA packs, equilibrated atmospheres containing 5–9% CO₂ and < 5% O₂ developed within c. 3 days. Chlorophyll degradation was completely inhibited by MA and resumed when packs were perforated, but MA only partially retarded the rate of flesh softening. Variations in the rate of ripening changes in duplicate MA packs could not be explained simply by differences in pack atmospheres. Furthermore, pears retarded by MA packaging failed to develop the normal sweet, aromatic flavour and succulent, juicy texture of 'eating-ripe' fruit, even when the packs were perforated after 4 days.
The differences in the responses of pears and apples to MA packaging, and the limitations of using this technique for the commercial marketing of English pears are discussed.     

Effectiveness of Hydrothermal‐Calcium Chloride Treatment and Chitosan on Quality Retention and Microbial Growth during Storage of Fresh‐Cut Papaya

Rapid degradation of fresh‐cut papaya limits its marketability. Hydrothermal treatments in combination with a calcium dip, applied to whole fruit before slicing, and also the application of chitosan as a coating film, have been found to have very good results in maintaining the quality of fresh‐cut fruits. Based on these considerations, the aim of this study was to evaluate the effect of hydrothermal treatment (HT; 49 °C, 25 min) containing calcium chloride (Ca; 1%, w/v) followed by dipping in chitosan (Chit; 1%, w/v, 3 min) on the physical, chemical, and microbial qualities of papaya slices stored at 5 °C for 10 d. Pulp color, firmness, ascorbic acid, total phenolics, β‐carotene, and lycopene were evaluated every 2 d while the microbial quality (mesophilics, psychrophilics, molds, and yeasts) was evaluated every 5 d. Fruit treated with HT‐Ca and HT‐Ca + Chit showed better color and firmness retention than Control and Chit. Papaya slices treated with HT‐Ca + Chit had higher nutritional content and lower microbial growth at the end of storage. The application of the HT‐Ca + Chit could be used to reduce deterioration processes, maintaining physical, chemical, and microbial qualities and increasing the shelf life of fresh‐cut papaya stored at 5 °C.     

Active Packaging of Cardboard to Extend the Shelf Life of Tomatoes

In order to extend the shelf life of fresh tomatoes using biodegradable materials, an active microcorrugated cardboard tray package was tested for use with fresh Cherry tomatoes (Lycopersicon esculentum var. cerasiforme). Active packaging characteristics were achieved by coating the interior surface of the cardboard tray with polylactic acid (PLA; 3% w/v) and, after filling with tomatoes, the tray was wrapped with a low-density polyethylene (LDPE) film of 70 or 20 μm thickness and hermetically heat sealed. Uncoated trays were used as control. The trays of tomatoes were stored at 20?±?0.5 °C and 55?±?2% relative humidity, for 30 days, and the ethylene concentration in the package atmosphere was measured periodically as an indicator of ripeness. The following fruit quality parameters were also studied: weight loss, surface colour, microbial count, firmness, soluble solids and pH. It was demonstrated that the capacity of PLA to adsorb ethylene and water vapour and the thickness of the LDPE film were decisive for controlling the ethylene concentration of the package atmosphere and for preventing condensation of water vapour on the fruit and film. The active packaging configuration and storage conditions used preserved fruit quality for a month, thus extending the useful life of the tomatoes and saving refrigeration costs.     

Effects of Modified Atmosphere Packaging on the Physicochemical Characteristics of Ciku ( Achras sapotaL) at Various Storage Temperatures

The physicochemical changes in ciku during storage at various temperatures and the effect of various techniques of modified atmosphere packaging (MAP) at 5, 10, 15°C and ambient were examined by monitoring fruit texture, weight loss, soluble solids content, pH, sucrose, fructose, glucose, pectin, tannin, ascorbic acid and microbial infection. Under MAP, ciku could be stored for 4 weeks at 10°C and 3 weeks at 15°C, while without MAP the storage life was shorter by 1 week. Packaging in low-density polyethylene film (LDPE) was highly effective in maintaining the texture and weight of cold-stored fruits. Fruits stored at 5°C experienced chilling injury, observed as their inability to ripen properly, even after 3 days at room temperature in the presence of 50 g kg⁻¹ calcium carbide. The ascorbic acid content was highest in vacuum-packed fruits followed by the other LDPE packagings. LDPE packaged fruits also received the highest sensory scores for taste, colour, texture and overall acceptability in cold-stored ciku. The unsealed nature and heating involved in shrink wrapping did not favourably affect the storage life of ciku. MAP alleviated the chilling injury which occurred in ciku stored at 10°C but not at 5°C.     

A comparative study on the effect of packaging material and storage environment on shelf life of fresh bell-pepper

The effect of packaging materials [low density polyethylene (LDPE), polypropylene (PP)] and storage environment [modified atmospheric packaging (MAP)] on shelf life enhancement of bell pepper in terms of quality attributes such as physiological weight loss, ascorbic acid, texture, surface colour and subjective quality analysis have been studied at ambient and refrigerated condition. Different packaging techniques used for the experiment were MAP with LDPE, MAP with PP, MAP in perforated LDPE films, MAP in perforated PP films, shrink packaging with bi-axially oriented PP (BOPP) film and vacuum packaging with PP film. The in-pack bell pepper created a suitable headspace environment with low O₂ and high CO₂ concentrations, which resulted in a better retention of freshness of the vegetables and its marketability. Shrink packaging with BOPP film could not yield better result under ambient storage because of high water vapor transmission rate of the film and consequently loss of turgidity of the vegetables. Among different packaging techniques and storage conditions, MAP with PP film in refrigerated condition was found to be the best followed by vacuum pack with PP film in refrigerated condition and could be used to store for 20 days for bell pepper with maintenance of texture, colour, ascorbic acid and marketability. It is also inferred that under ambient conditions, bell pepper could be stored for 4 days using ventilated LDPE and PP as MAP storage. Further studies are needed to evaluate the sensory aspects, as well as to microbiological evaluation to characterize the fresh bell pepper during storage.     

STORAGE OF IMMATURE GREEN MANGO (Mangifera indica, L.) FRUIT FOR PROCESSING

A suitable method of storing, for processing immature green mangoes in a fresh state was sought. Fruits were stored at three temperatures (1OC, 20C and 30C) either in sealed low density polyethylene (LDPE) bags or paper bags or they were waxed before storage. Storage above 20C proved unsuitable for fruits held longer than one week. Sixty percent of fruits stored at 10C in LDPE bags showed no evidence of pathological infection. Development of severe chilling injury limited the use of waxed and control fruits beyond 14 days at 10C. There were no visible symptoms of chilling injury in fruits stored at 10C in LDPE bags. The majority of fruits stored in LDPE bags at 10C maintained good quality characteristics with acceptable flavor and minimal changes in chemical composition up to 21 days.     

Absorption of Aroma Volatiles of Orange Juice into Laminated Carton Packages Did Not Affect Sensory Quality

Orange juice was stored in glass bottles and polyethylene/barrier material laminated cartons at 4°C for 24 wk. Studies were carried out on the absorption of 19 orange juice aroma compounds (e.g ethyl butyr-ate, d-limonene) into low density polyethylene (LDPE). Sensory evaluations were performed on the same orange juice in different packages over the storage period. A reduction of d-limonene of up to 50% by absorption into the LDPE inside coating was observed. However, an experienced sensory panel did not distinguish between orange juice stored in glass bottles and polyethylene laminated cartons.     

Ultrasound-Assisted Chitosan–Surfactant Nanostructure Assemblies: Towards Maintaining Postharvest Quality of Tomatoes

A novel ultrasound-assisted chitosan–surfactant nanostructure assembly was developed to allow better delivery of chitosan particles into intact fruit tissues for extension of postharvest life. Three solutions of 1 % chitosan–surfactant nanostructure assembly with micelle sizes of 400, 600 and 800 nm were prepared and applied as an edible coating on tomatoes. The fruits were stored at 15?±?2 °C and 70–80 % relative humidity for 20 days. The indicators of tomato ripening, which included loss of firmness, decline of titratable acidity, decline of chlorophyll content and increase in soluble solid content, were delayed in the treated fruits in comparison to the control (p?<?0.05). A delay of approximately 5 days in ripening was observed by evaluating the colour evolution from green to red. The treatment significantly (p?<?0.05) enhanced the phenolic content while maintaining a lower level of respiration in comparison to the control, throughout most of the storage duration. However, weight loss was higher in the treated fruits in comparison to the control. No significant difference in the resultant effects was observed by using chitosan–surfactant nanostructure assemblies of different micelle sizes (p?>?0.05).     

Effect of 1-methylcyclopropene on tomato flavour components, shelf life and decay as influenced by harvest maturity and storage temperature

BACKGROUND: In Florida, tomatoes are harvested green (GR), which includes mature green (MG) and immature green (IG) fruits, and stored at low temperature (13 °C), resulting in poor flavour. Flavour improvement might be achieved if fruits were harvested with some colour (to eliminate IG fruits) and/or stored at higher temperature with the ripening inhibitor 1‐methylcyclopropene (1‐MCP). RESULTS: ‘Florida 47’ tomatoes were harvested at GR (MG + IG), breaker (BR), turning (TR) and pink (PK) stages, treated (+) or not (?) with 1‐MCP and stored at 13 and/or 18 °C. 1‐MCP treatment resulted in a gain of up to 6 days of shelf life depending on harvest maturity and storage temperature. Storage at 18 °C rather than 13 °C resulted in an increase in internal red colour, soluble solids (SS)/titratable acidity (TA) ratio and levels of many volatiles studied. The shelf life of BR (+) MCP fruits stored at 13 °C was similar to that of MG fruits. IG fruits exhibited lowest levels of SS, TA and ten volatiles compared with BR fruits. CONCLUSION: Harvesting tomatoes with colour (BR), thereby eliminating IG fruits, and treating with 1‐MCP resulted in better quality with adequate shelf life. Published 2011 by John Wiley & Sons, Ltd.     

Modified atmosphere packaging of common mushroom

Until recently, the films used for packaging fresh fruits and vegetables were not permeable enough to balance the high respiration rate of mushrooms. Consequently, modified atmosphere packaging (MAP) in sealed pouches or punnets was not appropriate for this commodity. Four microporous films in oriented polypropylene (OPP) and one film currently used to overwrap mushroom punnets (stretchable PVC) were tested. Mushroom punnets placed into pouches were stored at 4 and 10°C for 8 days. the influence of the modified atmosphere on the marketing quality of pre-packed mushrooms was assessed by measuring the external and internal colour, development stage, firmness and microbial growth. A mathematical model was used to predict the gas composition within the pouches at steady state as a function of the film properties and the characteristics of the plant tissues. the equation calculated from the simplified model shows a linear relationship between the reciprocal of O₂ concentration at steady state, (1/x) at 10 and 4°C and the reciprocal of the film permeability, (1/PmO₂).     

Use of modified atmospheres to prolong the postharvest life of Burlat cherries at two different degrees of ripeness

The effects of degree of ripeness and packaging atmosphere on the quality of the very early season cherry (Prunus avium) cultivar ‘Burlat’ have been studied. Cherries were classified into two groups depending on their stage of ripening, taking colour as a maturity index (red and purple). After rapid chilling, cherries were sealed in 50 µm low‐density polyethylene (LDPE) bags in four different atmosphere compositions. Packages were stored at 2 °C and cherries were analysed weekly until they were deemed to be commercially unacceptable (after 4 weeks for red cherries and 3 weeks for purple cherries). Changes in atmosphere composition, skin colour, pigment content, titratable acidity, soluble solids, firmness and sensory quality were monitored. Acceptability was higher for the less mature group of cherries. Colour shifted in both groups, initially from red to blue/red and later on back to red. Titratable acidity decreased at the end of the experimental period for all samples. Firmness increased at first, but towards the end of the experiment it was similar to the initial value. The gas composition of the four modified atmosphere conditions approached a final equilibrium consisting of 9–12% CO₂ and 1–3% O₂. For long‐distance transportation of Burlat cherries the following procedure is recommended: harvest at the red colour stage, package in air using LDPE bags and maintain the temperature at 2 °C. Under these conditions, red Burlat cherries can be kept in an excellent commercial state for 3 weeks. © 2000 Society of Chemical Industry     

纳米二氧化硅改性LDPE膜对贡柑贮藏品质的影响

为了探索纳米二氧化硅改性低密度聚乙烯薄膜(LDPE)对贡柑的保鲜效果,分别研究了未包装、常规LDPE膜包装和纳米二氧化硅改性LDPE膜包装三种贮藏方式对贡柑采后贮藏品质的影响。结果表明:两种包装材料均能改善贡柑的贮藏品质,其中纳米二氧化硅改性LDPE膜能够更好地延缓贡柑采后失重率、腐烂率的上升和硬度的下降,更好地抑制丙二醛的积累,贮藏后期保持较高的可溶性固形物和可滴定酸含量,并能较好地维持果实抗氧化性能和感官满意度。     

Changes in selected quality characteristics of minimally processed carambola (Averrhoa carambola L.) when treated with ascorbic acid

‘B 10’ carambola of ripening stage (RS) 3 and 4 were minimally processed (MP) and then dipped in 0, 15 and 30 mg L^?1 ascorbic acid (AA). The 1‐cm‐thick slices were then dried, packed into cling‐wrapped‐foam tray and stored at 7 °C for 0, 3 and 5 days. Skin colour (L*, C* and h°), flesh firmness, soluble solids concentration, vitamin C content, titratable acidity, pH, degree of browning, polyphenoloxidase (PPO) activity and sensory attributes of MP carambola treated with AA were determined. AA treatment had significant effect in decreasing cut surface browning degree but no significant effect on all the selected quality characteristics of the MP carambola. In the sensory evaluation, flesh colour, sweetness, flavour and overall taste were significantly affected by AA treatment especially at 15 mg L^?1. The RS of fruit significantly affected skin colour (C* and h°), pH and sensory attributes of colour and flavour of the MP carambola. As storage day (SD) progressed, skin colour (C* and h°), flesh firmness and vitamin C content, cut surface browning, PPO activity and all the sensory attributes of MP carambola decreased significantly. Flesh firmness of the MP carambola was affected by the interaction between AA × SD. Sensory attributes of MP carambola were affected significantly by AA × RS. All the sensory attributes of MP carambola positively correlated to each other but negatively correlated with browning degree. PPO activity positively correlated with browning degree. Copyright © 2007 Society of Chemical Industry     

Effects of chitosan coating on postharvest life and quality of longan fruit

The effects of chitosan coating in extending postharvest life of longan fruits and maintaining their quality were investigated. The fruits were treated with aqueous solutions of 0.5, 1.0 and 2.0% chitosan, respectively, and then stored at 2°C and 90% relative humidity. Changes in respiration rate, polyphenol oxidase (PPO) activity, colour, eating quality, and weight loss were measured. The effect of chitosan coating on disease incidence was also evaluated. The application of chitosan coating reduced respiration rate and weight loss, delayed the increase in PPO activity and the changes in colour, and eating quality, and partially inhibited decay of fruit during storage. Furthermore, increasing the concentration of chitosan coating enhanced the beneficial effects of chitosan on postharvest life and quality of the fruit.     

Effect of calcium on the storage life of oro (Antiaris africana)

The effects of calcium on the ascorbic acid, chlorophyll, titratable acidity and texture (firmness) of stored oro (Antiaris africana (Mill)) friuits (average weight 100 g ) were studied. Three groups of the fruits were dipped in 20 g litre^?1, 40 g litre^?1 CaCl₂ solutions and deionised water respectively for I0 min. The fourth group, which was untreated, served as the control and was also packaged in heat-sealed cellophane bags. The fruits were displaced and stored at ambient temperature (28 ± 2°C). The calciumtreated fruits which kept better were firmer and had a slight colour change (chlorophyll) which also produced a progressive increase in ascorbic acid level during storage. The titratable acidity of the fruits did not fluctuate as signijcantly as that of the untreated (control) fruits.