共查询到17条相似文献,搜索用时 93 毫秒
1.
目前关于有氧或微氧的乙醇发酵的尾气检测系统已经建立,但是对于丙酮丁醇梭菌等严格厌氧菌发酵尾气的在线监测鲜见文献报道。因此,本研究以丙酮丁醇梭菌生产丁醇的严格厌氧发酵体系为研究对象,研究了传统有氧或微氧尾气检测方法在丙酮丁醇梭菌厌氧发酵体系中的检测结果,设计并建立了适合厌氧菌发酵的尾气在线监测系统,对丙酮丁醇梭菌的发酵过程实时监测。在建立有效的厌氧发酵尾气分析系统的条件下,比较了丙酮丁醇梭菌在游离细胞条件下和高细胞密度条件下的发酵性能。相比较于游离发酵,高细胞密度发酵的发酵周期明显缩短,丁醇生产强度显著提高。丁醇最高产量为15.4g/L,生产强度0.64g/(L·h),分别比对照组提高了12.4%和106%,CO2和H2最高产气速率分别提高60%和9%,产气量分别提高了20.7%和41.3%。尾气分析系统采集的气体数据为丙酮丁醇梭菌的代谢分析提供了重要依据。 相似文献
2.
3.
丙酮-丁醇发酵生产菌的快速筛选方法 总被引:8,自引:0,他引:8
建立了高效丙酮-丁醇生产菌的快速筛选方法,采用氮离子注入诱变技术选育丙酮-丁醇发酵生产菌,以2-脱氧-D-葡萄糖作为抗代谢阻遏物,筛选高淀粉酶活性的突变株. 首次根据丙酮-丁醇发酵代谢途径中先产酸后产溶剂及高活力厌氧发酵细胞具有较强还原力的特点,设计了溴甲酚绿和刃天青2种筛选平板,所筛突变株经发酵验证丁醇和总溶剂产生能力均有显著提高,I4-28突变菌株总溶剂产量和丁醇产量分别较出发菌株提高了27.96%和40.66%,丁醇/总溶剂比由63.39%提高到71.94%,突变菌株具有较好的传代稳定性. 相似文献
4.
5.
汽爆秸秆膜循环酶解耦合丙酮丁醇发酵 总被引:8,自引:0,他引:8
利用新型的汽爆玉米秸秆膜循环酶解耦合发酵系统进行了丙酮丁醇发酵的研究,并对使用该系统所导致的丙酮丁醇梭菌(Clostridium acetobutylicum AS1.132)代谢的变化进行了讨论. 在稀释率为0.075 h-1的条件下,丁醇的产量为0.14 g/g (纤维素+半纤维素),最大丁醇产率达到0.31 g/(L×h),溶剂组成为丁醇:丙酮:乙醇65.3:24.3:10.4(体积比),纤维素和半纤维素的转化率分别为72%和80%,使用单位纤维素酶所产生的丁醇量为3.9 mg/IU,是分步水解批次发酵的1.5倍. 利用该系统使酶解和发酵分别在各自最适的条件下同时连续进行,减少了纤维素酶的用量,有效地解除了酶解产物对纤维素酶的抑制作用,并减轻了溶剂产物尤其是丁醇对微生物活性的影响,延长了发酵周期. 相似文献
6.
基于微生物发酵动力学模型和丙酮丁醇发酵工艺的特点,由5组控制pH下的实验数据建立该发酵过程的动力学模型,采用改进的自适应遗传算法对模型的12个参数进行优化,并采用一组控制pH数据对模型进行了外推验证,结果表明,该模型能够较好地描述pH的丙酮丁醇间歇发酵过程. 相似文献
7.
8.
9.
10.
青霉素发酵过程是一个严重非线性、时变、复杂的动态过程,发酵过程中一些关键参数(如菌体质量浓度ρX、基质质量浓度ρS和产物质量浓度(ρP)难以通过常规仪表在线测量,这些参数的获取非常耗时和困难。提出一种基于粒子群模糊神经网络逆(PSO-FNN逆)的软测量方法。首先给出青霉素发酵过程数学模型,然后根据逆系统理论证明其可逆性,在此基础上构建基于PSO-FNN逆的青霉素发酵软测量模型,最后通过仿真验证该方法性能。仿真结果表明:PSO-FNN逆的青霉素发酵软测量方法能够结合基于发酵机制和纯数据驱动2种软测量方法的优点,对不直接可测的关键参数实现在线软测量,较PSO-BPNN逆和PSO-BPNN软测量方法具有更高的预测精度和更强的预测能力。 相似文献
11.
12.
13.
The existing process kinetics model of the acetone-butanol fermentation was adjusted and adapted for the fed-batch mode of operation. The optimal sugar feeding strategy for maximum solvent production was determined from the model and implemented in an experiment where the fluorescent features of the culture were also determined. While the model predictions agreed with experimentally observed trends, the actual data did not compare well. The characterisation of the culture physiological state under dynamic growth conditions was attempted by utilizing on-line fluorescence measurements and the concept of stoichiometric metabolic pathway rates. This methodology served well in assessing the NADH related culture metabolic activity and the substrate consumption rate in the solventogenic phase. 相似文献
14.
Acetone-butanol fermentation: basis of a modern biotechnological process? Acetone-butanol fermentation was performed on a large industrial scale for about forty years. After the Second World War it was unable to compete with petrochemical processes and renewed interest in this fermentation has developed only during the last decade. It has led to a vast increase of our knowledge of the biochemistry of acetone-butanol formation and of the genetics of the producing organism, Clostridium acetobutylicum. Considerable progress was also made in defining optimal fermentation conditions. However, the biotechnological process is not yet economically feasible, primarily because low final product concentrations engender high product recovery costs. 相似文献
15.
光合细菌法综合处理丙酮——丁醇发酵废水 总被引:6,自引:0,他引:6
利用光合细菌生物氧化及物化法综合处理丙酮-丁醇发酵废水,CODCr去除率达99%,光合细菌处理段CODCr容积负荷达6.5kgCODCr/m^3.d,饲料蛋白回收率为10kg/t。该工艺使污染严重的丙酮-丁醇废水得以彻底处理,同时可获得一定的经济效益。 相似文献
16.
A mathematical model for the kinetics of the acetone-butanol fermentation by Clostridium acetobutylicum was developed reflecting the biochemical pathway and culture behavior. Steady-state concentration of the process parameters in a cell-retention (CR) fermentation were predicted by computer process simulation. It was established that the product concentrations are independent of the dilution rate ((DF), whereas the accumulated biomass concentration increased linearly with respect to the dilution rate. The predicted effect of the glucose feed concentration (So) on steady-state concentrations of the process parameters showed that for values of So greater than 52.0 g/L the CR fermentor cannot attain a steady-state. 相似文献
17.
影响丙酮丁醇发酵的主要因素及 解决方案的研究进展 总被引:3,自引:0,他引:3
制约丙酮丁醇发酵工业化生产的主要问题是丙酮丁醇梭菌在发酵过程中孢子的形成、溶剂产量低、副产物的生成以及丁醇对菌株的毒性等因素。此外,使用木质纤维素等廉价、环保的原料作为发酵底物生产生物丁醇也是目前研究的热点之一。本文就以上问题综述了近年来的研究进展,如孢子形成的分子机制及解除孢子形成与溶剂生成之间联系的途径,丁醇抑制梭菌细胞生长的机制及降低丁醇毒性的方法,通过基因工程改造减少副产物的生成,增加丁醇产量等,并讨论了进一步改造菌种及降低生物丁醇成本的策略。 相似文献