Efficacy of Slightly Acidic Electrolyzed Water and UV‐Ozonated Water Combination for Inactivating Escherichia Coli O157:H7 on Romaine and Iceberg Lettuce during Spray Washing Process

Spray washing is a common sanitizing method for the fresh produce industry. The purpose of this research was to investigate the antimicrobial effect of spraying slightly acidic electrolyzed water (SAEW) and a combination of ozonated water with ultraviolet (UV) in reducing Escherichia coli O157:H7 on romaine and iceberg lettuces. Both romaine and iceberg lettuces were spot inoculated with 100 μL of a 3 strain mixture of E. coli O157:H7 to achieve an inoculum of 6 log CFU/g on lettuce. A strong antimicrobial effect was observed for the UV‐ozonated water combination, which reduced the population of E. coli by 5 log CFU/g of E. coli O157:H7 on both lettuces. SAEW achieved about 5 log CFU/g reductions in the bacterial counts on romaine lettuce. However, less than 2.5 log CFU/g in the population of E. coli O157:H7 was reduced on iceberg lettuce. The difference may be due to bacteria aggregation near and within stomata for iceberg lettuce but not for romaine lettuce. The UV light treatment may stimulate the opening of the stomata for the UV‐ozonated water treatment and hence achieve better bacterial inactivation than the SAEW treatment for iceberg lettuce. Our results demonstrated that the combined treatment of SAEW and UV‐ozonated water in the spray washing process could more effectively reduce E. coli O157:H7 on lettuce, which in turn may help reduce incidences of E. coli O157:H7 outbreaks.     

Switchgrass extractives to mitigate Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium contamination of romaine lettuce at pre- and postharvest

The antimicrobial potential of switchgrass extractives (SE) was evaluated on cut lettuce leaves and romaine lettuce in planta, using rifampicin-resistant Escherichia coli O157:H7 and Salmonella Typhimurium strain LT2 as model pathogens. Cut lettuce leaves were swabbed with E. coli O157:H7 or S. Typhimurium followed by surface treatment with 0.8% SE, 0.6% sodium hypochlorite, or water for 1 to 45 min. For in planta studies, SE was swabbed on demarcated leaf surfaces either prior to or after inoculation of greenhouse-grown lettuce with E. coli O157:H7 or S. Typhimurium; the leaf samples were collected after 0, 24, and 48 h of treatment. Bacteria from inoculated leaves were enumerated on tryptic soy agar plates (and also on MacConkey's and XLT4 agar plates), and the recovered counts were statistically analyzed. Cut lettuce leaves showed E. coli O157:H7 reduction between 3.25 and 6.17 log CFU/leaf, whereas S. Typhimurium reductions were between 2.94 log CFU/leaf and 5.47 log CFU/leaf depending on the SE treatment durations, from initial levels of ∼7 log CFU/leaf. SE treatment of lettuce in planta, before bacterial inoculation, reduced E. coli O157:H7 and S. Typhimurium populations by 1.88 and 2.49 log CFU after 24 h and 3 h, respectively. However, SE treatment after bacterial inoculation of lettuce plants decreased E. coli O157:H7 populations by 3.04 log CFU (after 0 h) with negligible reduction of S. Typhimurium populations. Our findings demonstrate the potential of SE as a plant-based method for decontaminating E. coli O157:H7 on lettuce during pre- and postharvest stages in hurdle approaches.     

Efficacy of slightly acidic electrolyzed water in killing or reducing Escherichia coli O157:H7 on iceberg lettuce and tomatoes under simulated food service operation conditions

Abstract: The objective of this study was to evaluate the efficacy of slightly acidic electrolyzed (SAEO) water in killing or removing Escherichia coli O157:H7 on iceberg lettuce and tomatoes by washing and chilling treatment simulating protocols used in food service kitchens. Whole lettuce leaves and tomatoes were spot‐inoculated with 100 μL of a mixture of 5 strains of E. coli O157:H7. Washing lettuce with SAEO water for 15 s reduced the pathogen by 1.4 to 1.6 log CFU/leaf, but the treatments did not completely inactivate the pathogen in the wash solution. Increasing the washing time to 30 s increased the reductions to 1.7 to 2.3 log CFU/leaf. Sequential washing in SAEO water for 15 s and then chilling in SAEO water for 15 min also increased the reductions to 2.0 to 2.4 log CFU/leaf, and no cell survived in chilling solution after treatment. Washing tomatoes with SAEO water for 8 s reduced E. coli O157:H7 by 5.4 to 6.3 log CFU/tomato. The reductions were increased to 6.6 to 7.6 log CFU/tomato by increasing the washing time to 15 s. Results suggested that application of SAEO water to wash and chill lettuce and tomatoes in food service kitchens could minimize cross‐contamination and reduce the risk of E. coli O157:H7 present on the produce. Practical Application: SAEO water is equally or slightly better than acidic electrolyzed (AEO) water for inactivation of bacteria on lettuce and tomato surfaces. In addition, SAEO water may have the advantages over AEO water on its stability, no chlorine smell, and low corrosiveness. Therefore, SAEO water may have potential for produce wash to enhance food safety.     

Rhizosphere effect on survival of Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium in manure-amended soil during cabbage (Brassica oleracea) cultivation under tropical field conditions in Sub-Saharan Africa

The effect of cabbage (Brassica oleracea) rhizosphere on survival of Escherichia coli O157:H7 and Salmonella Typhimurium in manure-amended soils under tropical field conditions was investigated in the Central Agro-Ecological Zone of Uganda. Three-week old cabbage seedlings were transplanted and cultivated for 120 days on manure-amended soil inoculated with 4 or 7 log CFU/g non-virulent E. coli O157:H7 and S. Typhimurium. Cabbage rhizosphere did not affect survival of the 4 log CFU/g inocula in manure-amended soil and the two enteric bacteria were not detected on/in cabbage leaves at harvest. The 7 log CFU/g E. coli O157:H7 and S. Typhimurium survived in bulk soil for a maximum of 80 and 96 days, respectively, but the organisms remained culturable in cabbage rhizosphere up to the time of harvest. At 7 log CFU/g inoculum, E. coli O157:H7 and S. Typhimurium contamination on cabbage leaves occurred throughout the cultivation period. Leaf surface sterilisation with 1% AgNO₃ indicated that the organisms were present superficially and in protected locations on the leaves. These results demonstrate that under tropical field conditions, cabbage rhizosphere enhances the persistence of E. coli O157:H7 and S. Typhimurium in manure-amended soil at high inoculum density and is associated with long-term contamination of the leaves.     

Antimicrobial Activities of Phenolic Extracts Derived from Seed Coats of Selected Soybean Varieties

Soybean hulls or seed coats consist of complex carbohydrates, proteins, lipids, and polyphenols such as anthocyanidins, proanthocyanidins, and isoflavones. The polyphenolics in the seed coats give them various colors such as black, brown, green, yellow, or even a mottled appearance. In this study, the antimicrobial effects of phenolic extracts from the seed coats of different colored soybeans (yellow, dark brown, brown, and black) were evaluated against foodborne pathogens such as Salmonella Typhimurium, Escherichia coli O157:H7, and Campylobacter jejuni in broth‐cultures as well as on chicken skin. The highest total phenolic content was observed for the phenolic extract from soybean variety (R07‐1927) with black colored seed coat (74.1 ± 2.1 mg chlorogenic acid equivalent [CAE]/g extract) and was significantly different (P <0.0001) from the extract of the conventional soybean variety (R08‐4004) with yellow colored seed coat (7.4 ± 1.2 mg CAE/g extract). The extract from black colored soybean produced reductions of 2.10 ± 0.08 to 2.20 ± 0.08‐log CFU/mL for both E. coli O157:H7 and C. jejuni after 3 d when incubated in broth‐culture having 4‐log CFU/mL of bacteria, whereas a 6 d incubation was found to reduce S. Typhimurium and E. coli O157:H7 at 2.03 ± 0.05 and 3.3 ± 0.08‐log CFU/mL, respectively. The extract also reduced S. Typhimurium and E. coli O157:H7 attached to chicken skin by 1.39 ± 0.03 and 1.24 ± 0.06‐log CFU/g, respectively, upon incubation for 6 d. Soybean seed coat extracts may have a potency as antimicrobial agents to reduce foodborne bacteria contaminating poultry products.     

Transfer and internalisation of Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium in cabbage cultivated on contaminated manure-amended soil under tropical field conditions in Sub-Saharan Africa

Surface contamination and internalisation of Escherichia coli O157:H7 and Salmonella Typhimurium in cabbage leaf tissues at harvest (120 days post-transplantation) following amendment of contaminated bovine manure to soil at different times during crop cultivation were investigated under tropical field conditions in the Central Agro-Ecological Zone of Uganda. Fresh bovine manure inoculated with rifampicin-resistant derivatives of non-virulent strains of E. coli O157:H7 and S. Typhimurium was incorporated into the soil to achieve inoculum concentrations of 4 and 7 log CFU/g at the point of transplantation, 56 or 105 days post-transplantation of cabbage seedlings. Frequent sampling of the soil enabled the accurate identification of the survival kinetics in soil, which could be described by the Double Weibull model in all but one of the cases. The persistence of 4 log CFU/g E. coli O157:H7 and S. Typhimurium in the soil was limited, i.e. only inocula applied 105 days post-transplantation were still present at harvest. Moreover, no internalisation in cabbage leaf tissues was observed. In contrast, at the 7 log CFU/g inoculum level, E. coli O157:H7 and S. Typhimurium survived in the soil throughout the cultivation period. All plants (18/18) examined for leaf contamination were positive for E. coli O157:H7 at harvest irrespective of the time of manure application. A similar incidence of leaf contamination was found for S. Typhimurium. On the other hand, only plants (18/18) cultivated on soil amended with contaminated manure at the point of transplantation showed internalised E. coli O157:H7 and S. Typhimurium at harvest. These results demonstrate that under tropical field conditions, the risk of surface contamination and internalisation of E. coli O157:H7 and S. Typhimurium in cabbage leaf tissues at harvest depend on the inoculum concentration and the time of manure application. Moreover, the internalisation of E. coli O157:H7 and S. Typhimurium in cabbage leaf tissues at harvest seems to be limited to the worst case situation, i.e., when highly contaminated manure is introduced into the soil at the time of transplantation of cabbage seedlings.     

Effects of X-ray radiation on Escherichia coli O157:H7, Listeria monocytogenes, Salmonella enterica and Shigella flexneri inoculated on shredded iceberg lettuce

The main goal of this investigation was to study the efficacy of X-ray doses (0.1, 0.2, 0.3, 0.5, 0.75, 1.0, 1.5 and 2.0 kGy) on inoculated Escherichia coli O157: H7, Listeria monocytogenes, Salmonella enterica and Shigella flexneri on shredded iceberg lettuce. The second goal was to study the effect of X-ray on the inherent microflora counts and visual color of shredded iceberg lettuce during storage at 4 °C for 30 days. Treatment with 1.0 kGy X-ray significantly reduced the population of E. coli O157: H7, L. monocytogenes, Salmonella enterica and S. flexneri on shredded iceberg lettuce by 4.4, 4.1, 4.8 and 4.4-log CFU 5 cm⁻², respectively. Furthermore, more than a 5 log CFU reduction of E. coli O157: H7, L. monocytogenes, S. enterica and S. flexneri was achieved with 2.0 kGy X-ray. Treatment with X-ray reduced the initial microflora on iceberg lettuce and kept them significantly (p < 0.05) lower than the control during storage at 4 °C and 90% RH for 30 days. Treatment with X-ray did not significantly (p > 0.05) change the green color of iceberg lettuce leaves. Treatment with X-ray significantly reduced selected pathogens and inherent microorganisms on shredded iceberg lettuce leaves, which could be a good alternative to other technologies for produce (lettuce) industry.     

Survival and growth of foodborne pathogens in minimally processed vegetables at 4 and 15 °C

Abstract: We conducted this study to investigate the survival and growth of pathogens on fresh vegetables stored at 4 and 15 °C. Vegetables (romaine lettuce, iceberg lettuce, perilla leaves, and sprouts) were inoculated with 4 pathogens (Salmonella enterica serovar Typhimurium, Staphylococcus aureus, Listeria monocytogenes, and Escherichia coli O157:H7) and stored at 2 different temperatures for different periods of time (3, 6, 9, 12, and 15 d at 4 °C and 1, 2, 3, 5, and 7 d at 15 °C). Populations of the 4 pathogens tended to increase on all vegetables stored at 15 °C for 7 d. Populations of E. coli O157:H7 and S. Typhimurium increased significantly, by approximately 2 log₁₀CFU/g, on loose and head lettuce stored at 15 °C for 1 d. No significant differences were observed in the growth of different pathogens on vegetables stored at 4 °C for 15 d. E. coli O157:H7 did not survive on sprouts stored at 15 or 4 °C. The survival and growth of food pathogens on fresh vegetables were very different depending on the pathogen type and storage temperature. Practical Application: Survivals and growth of pathogens on various vegetables at 4 and 15 °C were observed in this study. Survivals and growth of pathogens on vegetables were different depending on the pathogen type and storage temperature. Therefore, vegetables should be stored under refrigerated conditions (below 4 °C) prior to consumption. This recommendation may vary depending on the type of vegetable.     

Inactivation of Salmonella enterica serovar Typhimurium and Escherichia coli O157:H7 in peanut butter cracker sandwiches by radio-frequency heating

A multistate outbreak of Salmonella enterica serovar Typhimurium recently occurred in the USA, which was traced back to various food products made with contaminated peanut butter. This study was conducted to investigate the efficacy of radio-frequency (RF) heating to inactivate S. Typhimurium and Escherichia coli O157:H7 in peanut butter cracker sandwiches using creamy and chunky commercial peanut butter and to determine the effect on quality by measuring color changes and sensory evaluation. Samples were treated for a maximum time of 90 s in a 27.12 MHz RF heating system. Samples were prepared in the form of peanut butter cracker sandwiches and placed in the middle of two parallel-plate electrodes. After 90 s of RF treatment, the log reductions of S. Typhimurium and E. coli O157:H7 were 4.29 and 4.39 log CFU/g, respectively, in creamy peanut butter. RF treatment of chunky peanut butter for 90 s also significantly (P < 0.05) reduced levels of S. Typhimurium and E. coli O157:H7 by 4.55 log CFU/g and 5.32 log CFU/g. Color values and sensory characteristics of the RF treated peanut butter and crackers were not significantly (P > 0.05) different from the control. These results suggest that RF heating can be applied to control pathogens in peanut butter products without affecting quality.     

The Effect of pH on Inactivation of Pathogenic Bacteria on Fresh-cut Lettuce by Dipping Treatment with Electrolyzed Water

Fresh‐cut lettuce samples inoculated with S. Typhimurium, E. coli O157:H7 or L. monocytogenes were dipped into 300 ppm electrolyzed water (EW) at pH 4 to 9 and 30 °C for 5 min. The effects of treatment pH on bacterial reduction and visual quality of the lettuce were determined. The treatments at pH 4 and 8 resulted in the most effective inactivation of E. coli O157:H7, but the effect of pH was not significant (P > 0.05) for S. Typhimurium and L. monocytogenes. The treatment at pH 7 retained the best visual quality of lettuce, and achieved a reduction of approximately 2 log CFU/g for above 3 bacteria.     

Inactivation of Escherichia coli O157:H7, Salmonella typhimurium,and Listeria monocytogenes on Stored Iceberg Lettuce by Aqueous Chlorine Dioxide Treatment

ABSTRACT: Inactivation of Escherichia coli O157:H7, Salmonella typhimurium, and Listeria monocytogenes in iceberg lettuce by aqueous chlorine dioxide (ClO₂) treatment was evaluated. Iceberg lettuce samples were inoculated with approximately 7 log CFU/g of E. coli O157:H7, S. typhimurium, and L. monocytogenes. Iceberg lettuce samples were then treated with 0, 5, 10, or 50 ppm ClO₂ solution and stored at 4 °C. Aqueous ClO₂ treatment significantly decreased the populations of pathogenic bacteria on shredded lettuce (P < 0.05). In particular, 50 ppm ClO₂ treatment reduced E. coli O157:H7, S. typhimurium, and L. monocytogenes by 1.44, 1.95, and 1.20 log CFU/g, respectively. The D₁₀‐values of E. coli O157:H7, S. typhimurium, and L. monocytogenes in shredded lettuce were 11, 26, and 42 ppm, respectively. The effect of aqueous ClO₂ treatment on the growth of pathogenic bacteria during storage was evaluated, and a decrease in the population size of these pathogenic bacteria was observed. Additionally, aqueous ClO₂ treatment did not affect the color of lettuce during storage. These results suggest that aqueous ClO₂ treatment can be used to improve the microbial safety of shredded lettuce during storage.     

Magnetic nano-beads based separation combined with propidium monoazide treatment and multiplex PCR assay for simultaneous detection of viable Salmonella Typhimurium, Escherichia coli O157:H7 and Listeria monocytogenes in food products

We developed a rapid and reliable technique for simultaneous detection of Salmonella Typhimurium, Escherichia coli O157:H7 and Listeria monocytogenes that can be used in food products. Magnetic nano-beads (MNBs) based immunomagnetic separation (IMS) was used to separate the target bacterial cells while multiplex PCR (mPCR) was used to amplify the target genes. To detect only the viable bacteria, propidium monoazide (PMA) was applied to selectively suppress the DNA detection from dead cells. The results showed the detection limit of IMS-PMA-mPCR assay was about 10² CFU/ml (1.2 × 10² CFU/ml for S. Typhimurium, 4.0 × 10² CFU/ml for E. coli O157:H7 and 5.4 × 10² CFU/ml for L. monocytogenes) in pure culture and 10³ CFU/g (5.1 × 10³ CFU/g for S. Typhimurium, 7.5 × 10³ CFU/g for E. coli O157:H7 and 8.4 × 10³ CFU/g for L. monocytogenes) in spiking food products samples (lettuce, tomato and ground beef). This report has demonstrated for the first time, the effective use of rapid and reliable IMS combined with PMA treatment and mPCR assay for simultaneous detection of viable S. Typhimurium, E. coli O157:H7 and L. monocytogenes in spiked food samples. It is anticipated that the present approach will be applicable to simultaneous detection of the three target microorganisms for practical use.     

Fate of Escherichia coli O157:H7 in field-inoculated lettuce

Impact of drip and overhead sprinkler irrigation on the persistence of attenuated Escherichia coli O157:H7 in the lettuce phyllosphere was investigated using a split-plot design in four field trials conducted in the Salinas Valley, California, between summer 2007 and fall 2009. Rifampicin-resistant attenuated E. coli O157:H7 ATCC 700728 (BLS1) was inoculated onto the soil beds after seeding with a backpack sprayer or onto 2- or 4-week-old lettuce plant foliage with a spray bottle at a level of 7 log CFU ml⁻¹. When E. coli O157:H7 was inoculated onto 2-week-old plants, the organism was recovered by enrichment in 1 of 120 or 0 of 240 plants at 21 or 28 days post-inoculation, respectively. For the four trials where inoculum was applied to 4-week-old plants, the population size of E. coli O157:H7 declined rapidly and by day 7, counts were near or below the limit of detection (10 cells per plant) for 82% or more of the samples. However, in 3 out 4 field trials E. coli O157:H7 was still detected in lettuce plants by enrichment 4-weeks post-inoculation. Neither drip nor overhead sprinkler irrigation consistently influenced the survival of E. coli O157:H7 on lettuce.     

Comparison of the Microbiological Quality of Environmentally Friendly and Conventionally Grown Vegetables Sold at Retail Markets in Korea

Fresh produce is usually eaten raw without cooking or heating, which may increase the probability of foodborne infection. The microbiological quality of 11 types of fresh, raw vegetables (romaine lettuce, sesame leaves, crown daisy, garlic chives, iceberg lettuce, cabbage, broccoli, leek, chili pepper, capsicum, and zucchini) purchased at retail markets in Iksan, Korea as affected by cultivation method (environmentally friendly vegetables [organic, pesticide‐free, and low‐pesticide vegetables] and conventionally grown vegetables) and harvest season was determined. Escherichia coli O157:H7 and Salmonella were not detected in all samples of vegetables tested. Aerobic mesophiles (>6 log cfu/g) were detected in environmentally friendly romaine lettuce and crown daisy and environmentally friendly and conventionally grown garlic chives, which also contained coliforms (>3 log cfu/g). Sesame leaf and crown daisy (regardless of cultivation method), as well as conventionally grown romaine lettuce and leek, contained >1 log cfu/g of E. coli. The overall microbiological quality of environmentally friendly and conventionally grown vegetables was not significantly different (P > 0.05). However, there were seasonal effects on populations of coliforms and generic E. coli on vegetables. The greatest numbers of microorganisms were isolated from environmentally friendly or conventionally grown vegetables purchased in winter. The vegetables, regardless of cultivation method or season, should be subjected to appropriate antimicrobial treatment to enhance their microbial safety.     

Detection of 5 CFU/g of Escherichia coli O157:H7 on lettuce using activated charcoal and real-time PCR without enrichment

A sample treatment method which separates Escherichia coli O157:H7 from lettuce and removes PCR inhibitors allowing 5 CFU/g of target cells to be detected using real-time PCR is described. Lettuce leaves inoculated with E. coli O157:H7 were rinsed with 0.025% sodium dodecyl sulfate (SDS). In this study, there were two major factors that strongly affected the recovery of E. coli O157:H7 during sample preparation, the amount of bentonite coated activated charcoal used to remove PCR inhibitors and the agitated contact time of the samples with the coated charcoal. When 3.0 g of activated carbon coated with bentonite were mixed with target cell suspensions (30 ml) derived from 50 g of lettuce, a high recovery of E. coli O157:H7 (93%) was obtained. Sample agitation with bentonite coated activated charcoal for 15 min resulted in 95% recovery of E. coli O157:H7. When a commercial DNA purification resin was used for detection of E. coli O157:H7 without the use of the bentonite treated charcoal, the real-time PCR (Rti-PCR) failed to detect 1 × 10² CFU/g. In contrast, with the use of use of bentonite coated activated charcoal and a commercial DNA purifying resin together, Rti-PCR was able to detect 5 CFU of E. coli O157:H7/g of lettuce which was equivalent to 2.8 CFU/Rti-PCR. Such a successful detection level was the result of the bentonite coated activated charcoal’s ability to absorb the PCR inhibitors released from seeded lettuce during detachment. A standard curve was generated by plotting the Ct values against the log of CFU of target bacterial cells. A linear range of DNA amplification was exhibited from 5.0 × 10⁰ to 1.0 × 10⁴ CFU/g by using Rti-PCR.     

Reduction of Escherichia coli O157:H7 in Biofilms Using Bacteriophage BPECO 19

Biofilm formation is a growing concern in the food industry. Escherichia coli O157:H7 is one of the most important foodborne pathogens that can persists in food and food‐related environments and subsequently produce biofilms. The efficacy of bacteriophage BPECO 19 was evaluated against three E. coli O157:H7 strains in biofilms. Biofilms of the three E. coli O157:H7 strains were grown on abiotic (stainless steel, rubber, and minimum biofilm eradication concentration [MBEC^TM] device) and biotic (lettuce) surfaces at different temperatures. The effectiveness of bacteriophage BPECO 19 in reducing preformed biofilms on these surfaces was further evaluated by treating the surfaces with a phage suspension (10⁸ PFU/mL) for 2 h. The results indicated that the phage treatment significantly reduced (P  < 0.05) the number of adhered cells in all the surfaces. Following phage treatment, the viability of adhered cells was reduced by ≥3 log CFU/cm², 2.4 log CFU/cm², and 3.1 log CFU/peg in biofilms grown on stainless steel, rubber, and the MBEC^TM device, respectively. Likewise, the phage treatment reduced cell viability by ≥2 log CFU/cm² in biofilms grown on lettuce. Overall, these results suggested that bacteriophages such as BPECO 19 could be effective in reducing the viability of biofilm‐adhered cells.     

The efficacy of UVC LEDs and low pressure mercury lamps for the reduction of Escherichia coli O157:H7 and Listeria monocytogenes on produce

The inactivation efficacies of low pressure mercury (LPM) lamps (253.7 nm) and UVC LEDs (277 nm) were compared for Escherichia coli O157:H7 on lettuce leaves and Listeria monocytogenes on apple skin. Reductions ranging from 1.19 ± 0.59 to 1.58 ± 0.27 log CFU per sample at 4 and 25 °C were achieved. At 4 °C, UVC LEDs increased in fluence rate, while achieving log reductions similar to those at 25 °C. The effect of wavelength on lettuce quality was also evaluated. Treatment (500 mJ·cm⁻²) from either light source increased browning of romaine lettuce, while mesophilic counts, chlorophyll content and spoilage enzyme activity were not affected significantly over a storage period of up to 21 days. Finally, the adjusted germicidal power (AGP) as a means of comparing inactivation performance between UV wavelengths was evaluated. It was found that AGPs generated in a water-based model system did not adequately predict efficacy on solid food matrices.Industrial relevanceThe use of ultraviolet-C (UVC) light for disinfection represents a possible dry means to augment or replace existing batch-wash disinfection systems for fresh produce. In this study we have shown that UVC LEDs at 277 nm have comparable germicidal efficacy to LPM lamps against the foodborne pathogens E. coli O157:H7 and Listeria monocytogenes on lettuce leaves and apple skin, respectively, while both light sources achieve log reductions similar to an aqueous sodium hypochlorite wash. Overall these results indicate that UVC LEDs (and UVC light in general) is an alternative effective and sustainable method of disinfecting apples and lettuce in an industrial setting, reducing or eliminating the dependence on aqueous sanitizers.     

Combined effect of ultrasound and organic acids to reduce Escherichia coli O157:H7, Salmonella Typhimurium, and Listeria monocytogenes on organic fresh lettuce

This study was performed to compare the effectiveness of individual treatments (ultrasound and organic acids) and their combination on reducing foodborne pathogens on organic fresh lettuce. Lettuce leaves were inoculated with a cocktail of three strains each of Escherichia coli O157:H7, Salmonella Typhimurium, and Listeria monocytogenes and treated with ultrasound (40 kHz) alone, organic acids (0.3, 0.5, 0.7, 1.0, and 2.0% — malic acid, lactic acid, and citric acid) alone and combined with ultrasound and organic acids for 5 min. For all 3 pathogens, the combined treatment of ultrasound and organic acids resulted in additional 0.8 to 1.0 log reduction compared to individual treatments, without causing significant quality change (color and texture) on lettuce during 7 day storage. The maximum reductions of E. coli O157:H7, S. Typhimurium, and L. monocytogenes were 2.75, 3.18, and 2.87 log CFU/g observed after combined treatment with ultrasound and 2% organic acid for 5 min, respectively. Our results suggest that the combined treatment of ultrasound with organic acids was effective at increasing pathogen reduction compared to individual treatments without significantly affecting quality, and demonstrates its potential as a novel method to increase the microbial safety on organic fresh lettuce.     

Efficacy of Cetylpyridinium Chlorine on Salmonella Typhimurium and Escherichia coli O157:H7 in Immersion Spray Treatment of Fresh-Cut Lettuce

Fresh‐cut lettuce inoculated with Salmonella enterica serovar Typhimurium and Escherichia coli O157:H7 was treated using cetylpyridinium chlorine (CPC) solution in a laboratory‐scale immersion spray system. With 0.7 kg/cm² spray pressure and 1.5‐min spray time (ST), both bacteria were significantly reduced (P < 0.05) in 0.1% to 0.3% CPC spray treatments, compared with water spray controls. At the same ST, increasing spray pressure from 0.7 to 2.1 kg/cm² further reduced bacteria by 0.5 to 1.5 log colony‐forming units (CFU)/g. The 0.2% and 0.3% CPC treatments resulted in the greatest reduction of S. serovar Typhimurium and E. coli O157:H7, respectively. Similar bacterial reduction could be achieved using shorter ST with extended post‐spray exposure time. No color change on the lettuce was observed after CPC treatment.     

Edible films containing carvacrol and cinnamaldehyde inactivate Escherichia coli O157:H7 on organic leafy greens in sealed plastic bags

The antimicrobial effects of apple-, carrot-, and hibiscus-based edible films containing carvacrol and cinnamaldehyde against Escherichia coli O157:H7 on organic leafy greens in sealed plastic bags were investigated. Fresh-cut Romaine and Iceberg lettuce, and mature and baby spinach leaves were inoculated with E. coli O157:H7 and placed into Ziploc® bags. Edible films were then added to the bags, which were stored at 4°C. The evaluation of samples taken at days 0, 3, and 7 showed that on all leafy greens, 3% carvacrol-containing films had the greatest effect against E. coli O157:H7, reducing the bacterial population by about 5 log CFU/g on day 0. All three types of 3% carvacrol-containing films reduced E. coli O157:H7 by about 5 log CFU/g at day 0. The 1.5% carvacrol-containing films reduced E. coli O157:H7 by 1–4 logs CFU/g at day 7. Films with 3% cinnamaldehyde showed reduction of 0.6–3 logs CFU/g on different leafy greens.