共查询到18条相似文献,搜索用时 78 毫秒
1.
2.
In gas-liquid mass transfer processes,interfacial turbulence may occur due to the surface tension gradient and the density gradient produced by mass transfer near the interface.The interfacial turbulence can enhance the mass transfer since it intensifies the movement of interfacial fluid.By means of the shadowgraph optical method,the interfacial turbulence patterns vertical to the interface were observed directly in the volatilization process of binary systems.The images of the amplified interfacial turbulence showed the variation of concentration and the fluid movement under the interface.Two patterns of interfacial turbulence were observed in the experiments:plume and vortex.With the plume,the interfacial fluid moved slowly and penetrated the liquid deeply.With the vortex,the interfacial turbulence occurred in the vicinity of the liquid interface and the fluid moves quite fast.A qualitative analysis was carried out based on the mechanism of Rayleigh-Bénard convection induced by density gradient and Marangoni convection induced by surface tension gradient. 相似文献
3.
通过氮气吹扫双组分液滴,用激光投影法定性观察由于轻组分向气相扩散导致的Marangoni对流结构,结果表明Marangoni对流以小尺度涡流结构和大尺度对称循环流动的形式出现,其中乙醇-水体系首先出现小尺度涡流结构,涡流不断长大合并;丙酮-水体系则以大尺度对称循环对流结构为主,随后在近界面处形成小尺度涡流结构。采用氮气吹扫乙醇-水及丙酮-水静止悬垂单液滴的方法,通过比较实验测量传质系数与理论预测值,表明液滴近界面处Marangoni对流小尺度涡结构对传质促进作用较小,而液滴内大尺度循环对流结构对传质促进作用大。 相似文献
4.
5.
6.
气液界面Marangoni效应对传质系数的影响 总被引:1,自引:0,他引:1
在气液相际传质过程中,界面Marangoni湍动会对传质过程产生重要的影响,为此,建立了一套气液接触传质设备,以使得通过N2与异丙醇稀溶液逆流接触将液体中使表面张力降低的溶质解吸出来,从而引发Marangoni湍动,提高传质速率。发生Marangoni对流时,液相的传质系数比只依靠扩散传质而不考虑Marangoni效应时大,因此引出增强因子F这一概念,通过计算F的值即可判断Marangoni效应对传质速率影响的程度。提出了一个包括Marangoni准数的计算传质系数关联式,其计算结果与实验结果相符. 相似文献
7.
8.
双光路纹影仪观察气液传质界面湍动现象 总被引:2,自引:1,他引:1
建立了双光路纹影仪实验系统,并利用双光路纹影仪,同时从垂直和平行于界面两个方向对氯苯吸收、解吸CO2的传质对流结构进行了观察,发现在氯苯吸收CO2时,没有明显的对流结构,只是在垂直界面的纹影图像中观察到逐渐变粗的暗条纹。在氯苯解吸CO2时,在垂直和平行于界面两个方向都观察到了明显的对流结构,在垂直界面的纹影图像中开始时出现分层现象,随着解吸的进行,对流加剧,分层现象被破坏;平行界面方向的对流结构发展较快,优先在平行界面的纹影图像中观察到明显的对流结构。由于传质的热效应,两个方向的对流结构都有向中心运动的趋势。实验表明,双光路纹影仪实验系统能观察界面传质对流过程的三维变化,可深化对界面传质对流过程的认识。 相似文献
9.
10.
11.
以分子热力学为基础 ,对气体吸收过程进行了理论分析 ,导出了传质通量的数学表达式。根据该文分析 ,气液界面传质的源动力来自界面处气液两相的不平衡 ,即只要有传质发生 ,液相界面处的浓度就不会达到与气相呈平衡的浓度。对于气相阻力可以忽略的吸收过程 ,两相传质速率的大小主要取决于液相的溶质界面浓度和液膜厚度 ,影响溶质界面浓度和液膜厚度的主要因素是近界面液相侧的流场分布。利用近界面浓度与液膜厚度的激光测定结果 ,计算了甲醇、乙醇及正丙醇吸收CO2 气泡的传质通量 ,计算结果与实验值吻合良好 相似文献
12.
Based on the method of molecular thermodynamics ,the mass transfer mechanism at gas-liquid interface is studied theoretically,and a nowe mathematical model is proposed,Using laser holographic interference technique,the hydrodynamics and mass transfer characteristics of CO2 absorption are measured,It is shown that the calculated results are in good agreement with the experimental data. 相似文献
13.
设计了一套双气泡聚并实验系统,考察了相间传质对气泡聚并过程的影响,气相采用非相变的N2,液相为挥发性的丙酮和乙醇水溶液. 利用该系统测定了25~50℃温度下,不同组分浓度、鼓泡频率和气泡直径时气泡的聚并特性. 结果表明,相间传质诱导的Marangoni效应使聚并时间随温度升高呈先减小后增大的趋势,聚并时间的分散性在较高温度下显著增大,采用聚并效率描述气泡聚并特性更合适;聚并效率在温度升高到一定程度后开始降低并趋于最小值,该值随溶液浓度增加而减小,稳定因子可定量描述Marangoni效应;鼓泡速率和气泡直径增加1倍,最小聚并效率分别减小50%和67%. 相似文献
14.
单组分扩散过程中界面湍动对流结构的观察 总被引:1,自引:0,他引:1
利用激光纹影仪从垂直和平行于界面两个方向对静止和流动乙醇吸收、解吸C02的传质对流结构进行了观察,发现在液相主体中明显存在传质导致的液体对流现象,同时发现对流结构在液相流动方向取向具有优先性。研究界面对流对增大传质速率,探索微观传质机理和寻求强化传质途径具有理论和实际意义。 相似文献
15.
This paper focuses on the mechanism of interfacial mass transfer of a single bubble, based on the chemical potential driving force, an approach for calculating interfacial concentration in practical process is proposed. The absorption processes of bubble under both quiescent and mobile conditions are analyzed and discussed respectively. For a stationary absorption, only in the case of liquid bulk concentration near saturated value, the interfacial concentration could close to the equilibrium value ; For a moving bubble, under ordinary operating condition (Yo〉l), the interfacial concentration is far from its equilibrium. Only under bulk concentration near saturated value or a smaller Yo(Yo〈0.1) which may involve the complication of additional resistance at interface induced by surface contamination or surfactant added, the interfacial concentration could be approximate to equilibrium value. The interfacial concentration close to the interface on liquid side for a single CO2 bubble absorbed by methanol is measured using a modern optical instrumentation in which the laser holographic interference method is adopted with a real-time and amplification technique. Experimental results show that the interfacial concentration decreases significantly with increasing Re and is far from the equilibrium one in a larger Re range. Experiments validate the proposed model. 相似文献
16.
乳状液膜分离Zn^2+的界面传质阻力及传质模型 总被引:7,自引:3,他引:7
用Lweis恒界面传质池对乳状液膜分离Zn^2+的传质阻力进行实验研究,结果表明由于表面活性剂单分子层的形成,使界面传质阻力占整个传质阻力的85%。在此基础上所建立的既考虑界面传质阻力又考虑膜破碎的液膜传质模型能使用理论计算值与实验测定值符合较好。 相似文献
17.
18.
一种用于气液间传质的新型轴流式叶轮黄庆民林齐浩李启恩(华南理工大学化学工程研究所,广州510641)关键词气液传质轴流式叶轮1前言在液体搅拌器中,轴流式叶轮由于功耗较小且泵吸量较大而被广泛采用。在气液两相搅拌器中,由于轴流式叶轮有气泛问题,一般均采... 相似文献