Deoxynivalenol in wheat,maize, wheat flour and pasta: surveys in Hungary in 2008–2015

Among Fusarium mycotoxins, deoxynivalenol (DON) is the most common contaminant in case of cereals and cereal-based foods in Hungary. In this study, Hungarian wheat (n = 305), maize (n = 108), wheat flour (n = 179) and pasta (n = 226) samples were analysed (N = 818). The samples were collected during 2008–2015 in Hungary. Applied methods of analysis were enzyme-linked immunosorbent assay and liquid-chromatography coupled with a mass spectrometer. Results were compared and evaluated with Hungarian weather data. Among cereal samples, in 2011, wheat was contaminated with DON (overall average ± standard deviation was 2159 ± 2818 µg kg^?1), which was above the maximum limit (ML). In case of wheat flour and pasta, no average values above ML were found during 2008–2015, but higher DON contamination could be observed in 2011 as well (wheat flour: 537 ± 573 µg kg^?1; pasta: 511 ± 175 µg kg^?1).     

Deoxynivalenol,zearalenone and T-2 in grain based swine feed in Hungary

Fusarium genera can produce trichothecenes like deoxynivalenol (DON), zearalenone (ZEN) and T-2 toxin, which can occur in feed cereal grains. Enzyme-linked immunosorbent assays (ELISA) tests of different Hungarian swine feedstuff proved that these mycotoxins were present. In this survey, 45 feed samples from 3 significant Hungarian swine feedstuff manufacturers were tested. ELISA methodology validation showed mean recovery rates in ranges from 85.3% to 98.1%, with intermediate precision of 86.9-96.9% and variation coefficients of 3.4–5.7% and 5.9–7.1%, respectively. The results showed that among Fusarium toxins, generally DON was present in the highest concentration, followed by T-2 and finally ZEN in all tested swine feeds. Each of the mycotoxins was found above the limit of detection in all swine feedstuffs. Boars feed’s DON (average ± standard deviation was 872 ± 139 µg kg^?1) and ZEN (172 ± 18 µg kg^?1) results of one of the manufacturers were above the guidance values. It indicates the necessity for efficient monitoring of DON, ZEN and T-2 mycotoxins in swine feeds.     

Aflatoxins in animal feed in Iran

One hundred and forty-six samples of animal feed (barley, n = 60; wheat bran, n = 22; wheat dry pulp, n = 29; and canola meal, n = 35) were collected in 2011 from Mashhad (Khorasan, Iran). Aflatoxins (AFs) were determined in these samples after immunoaffinity column clean-up by high-performance liquid chromatography (HPLC) with fluorescence detection. Aflatoxin B₁ (AFB₁) contamination was found in 28 samples: in five of the barley samples (8.3%) at a mean level of 0.48 µg·kg^?1, in two wheat bran samples (9.0%) at a mean level of 0.88 µg·kg^?1, in 10 wheat dry pulp samples (34.5%) at a mean level of 0.30 µg·kg^?1 and in 11 canola meal samples (31.4%) at a mean level of 0.92 µg·kg^?1. AFB₁ levels were below the maximum levels of Iran regulations (5 µg·kg^?1) and the EU maximum limit (5 µg·kg^?1).     

Mycotoxins in wheat flour and intake assessment in Shandong province of China

In the present study, the occurrence and contamination levels of eight mycotoxins were investigated in wheat flour samples (n = 359) from Shandong Province of China. Samples were determined using a multi-mycotoxin method based on isotope dilution ultrahigh performance liquid chromatography–tandem mass spectrometry. The results indicated that the most frequently found mycotoxins were deoxynivalenol (DON) (97.2%), nivalenol (40.4%) and deoxynivalenol-3-glucoside (33.4%), and mean contamination levels in positive samples were 86.7, 3.55 and 3.34 µg kg^?1, respectively. The obtained data were further used to estimate the daily intake of the local population, and indicated that wheat flour consumption contributes little to DON exposure. However, with the aim to keep the contamination levels under control and to establish a more precise evaluation of the mycotoxin burden in Shandong Province, more sample data from different harvest years and seasons are needed in the future.     

Occurrence of deoxynivalenol in wheat flour,instant noodle and biscuits commercialised in Brazil

A total of 134 samples, consisting of 58 wheat flour, 40 instant noodle and 36 biscuits, were analysed for the presence of deoxynivalenol (DON). The samples were obtained from retail markets of the city of São Paulo during the period 2010–2014. DON was determined by high performance liquid chromatography with ultraviolet detection and immunoaffinity sample clean-up. Method validation followed international guidelines. The LOD and LOQ were 60 and 200 µg kg^?1, respectively, considering the three different types of samples analysed. The lowest recovery found in this study was 91.8% with RSD 4.5% for instant noodles. DON was detected in 91.4%, 97.5% and 97.2% of samples wheat flour, instant noodles and biscuits, respectively, resulting in a total of 94.8% with levels ranging from LOD to 1720.0 µg kg^?1.     

Survey of 11 mycotoxins in wheat flour in Hebei province,China

A survey of 11 mycotoxins in 348 wheat flour samples marketed in Hebei province of China were analysed by liquid chromatography-tandem mass spectrometry, was carried out. The selected mycotoxins consisted of four aflatoxins (AFs: AFB₁, AFB₂, AFG₁ and AFG₂) and seven Fusarium toxins, i.e. deoxynivalenol (DON), nivalenol, 3-acetyldeoxynivalenol and 15-acetyldeoxynivalenol, zearalenone, Fusarenon-X and deoxynivalenol-3-glucoside. Results indicated that most of the wheat samples analysed were contaminated with mycotoxins. Wheat was most susceptible to DON (91.4% contamination), with a mean level of 240 μg kg^?1. On average the probable daily intake (PDI, expressed as µg kg^?1 body weight day^?1) of mycotoxins was within the provisional maximum tolerable daily intake (PMTDI, 2.0 µg kg^?1 of body weight day^?1) as set by the Joint FAO/WHO Expert Committee on Food Additives. Nevertheless, exposure assessment revealed that the maximum PDI of mycotoxins was 4.06 µg kg^?1 body weight day^?1, which was twice the PMTDI value. Thus, consistent monitoring is recommended, as to keep the contamination level under control.     

Aflatoxin B1 in betel nuts (Areca catechu L.) imported to Pakistan from different regions of South Asia

Aflatoxin B₁ (AFB₁) levels were evaluated in betel nuts (Areca catechu L.) being imported to Pakistan during 2010–2011. In total, 278 betel nut samples (India = 21, Indonesia = 51, Sri-Lanka = 34 and Thailand = 172) were received from the Department of Customs and were analysed by thin layer chromatography (TLC). All Indian origin betel nuts showed AFB₁ contamination ranging from 11.7–262.0 µg kg^?1 with a mean of 92.5 µg kg^?1. Among Indonesian and Sri Lankan shipments, 80.4% and 73.5% betel nuts were contaminated with AFB₁ ranging between 3.3–39.2 and 6.5–103.4 µg kg^?1 with a mean of 11.6 and 35.0 µg kg^?1, respectively. However, only 30.2% of Thailand origin samples showed AFB₁ contamination ranging 3.3–77.0 µg kg^?1 with a mean of 6.6 µg kg^?1. The widespread occurrence of AFB₁ increases the hazard associated with betel nuts. Thus, strict control is a pre-requisite for the production and import/export of psychoactive substances as betel nuts.     

Analysis of trichothecenes in laboratory rat feed by gas chromatography-tandem mass spectrometry

A method for the determination of seven trichothecenes, neosolaniol (NEO), diacetoxyscirpenol (DAS), deoxynivalenol (DON), nivalenol (NIV), fusarenon-X (FUS-X), 3-acetyldeoxynivalenol (3-ADON) and 15-acetyldeoxynivalenol (15-ADON), in laboratory rat feed by GC-MS/MS was developed. Sample extraction and purification was performed by an acidified mixture of acetonitrile/water (80–20% v/v). Limits of quantitation (LOQs) were between 1 and 10 μg kg^–1 for all studied trichothecenes. Eight concentration levels between the LOQ and 100 × LOQ were used for the calibration curves. Matrix-matched calibration was used for quantitation purposes to compensate the detector signal enhancement obtained for all the analytes. The method accuracy was evaluated by recovery assays at three concentration levels, 25, 50 and 100 μg kg^–1 (n = 9). Recoveries ranged from 62% to 97% and precision, expressed as intra- and inter-day relative standard deviations, was evaluated for all compounds. The validated method was successfully applied to the analysis of 35 laboratory rat feed samples showing mycotoxin contamination in 66% of the samples. DON was the most prevalent trichothecene followed by 15-ADON, NIV and 3-ADON. The maximum DON concentration reached in real samples was 2156 ± 4.3 μg kg^–1, while NEO, DAS and FUS-X were not detected in any sample. Multi-contamination by at least two mycotoxins was observed in 17% of the analysed feed samples.     

Mycoflora and deoxynivalenol in whole wheat grains (Triticum aestivum L.) from Southern Brazil

The fungal species Fusarium graminearum is related to deoxynivalenol (DON) formation. The aim of this study was to evaluate mycoflora and DON occurrence in 53 whole wheat grain samples collected in Southern Brazil during the 2012 crop. Wheat grains showed adequate values of water activity ranging from 0.48 to 0.72, within the required limits of moisture content, ranging from 9.1% to 13.9%. In addition, low counts of fungal colonies, ranging from 10 to 8.2 × 10², were found. For Fusarium genera, there was predominance of Fusarium verticillioides (34%) and F graminearum (30.2%). For Aspergillus species, 37.7% of Aspergillus flavus was determined. Regarding the Penicillium species, Penicillium digitatum (49%) was the most found species. DON was detected in 47.2% (25 out of 53) of the samples analysed, with levels ranging from 243.7 to 2281.3 µg kg^?1 (mean: 641.9 µg kg^?1).     

Immunoassay based on monoclonal antibodies versus LC-MS: deoxynivalenol in wheat and flour in Southern Brazil

An indirect competitive enzyme-linked immunosorbent assay (ELISA) method using a monoclonal antibody for deoxynivalenol (DON) detection in wheat and flour was standardised and validated (detection limit?=?177.1?µg?kg^?1) and its performance was compared with LC-MS, quantification limit?=140?µg?kg^?1). DON recovery ranged from 88.7% to 122.6% for wheat grain and from 70.6% to 139.3% for flour. Among the 38 wheat samples evaluated, DON was detected in 29 samples (76.3%) by ic-ELISA (281.6–12?291.4?µg?kg^?1) and in 22 samples (57.9%) by LC-MS (155.3–9906.9?µg?kg^?1). The 0.93 correlation coefficient between ic-ELISA and LC-MS data in 19 positive DON wheat samples demonstrated the reliability and efficiency of ic-ELISA. Results indicated that standardised ic-ELISA was suitable for DON screening in wheat samples and the need for continuous monitoring of mycotoxin levels in foodstuffs.     

Determination of moulds and mycotoxins in dry dog and cat food using liquid chromatography with mass spectrometry and fluorescence detection

In this study moulds and 12 mycotoxins in dry pet food samples (25 for dogs and 24 for cats) were determined. Primary moulds identified were Aspergillus, Mucor and Penicillium, found in 55% of the samples. Deoxynivalenol and zearalenone (ZEN) were detected in all samples with mean respective concentrations being 97.3 and 38.3 µg kg^?1 in cat food and 114 and 20.1 µg kg^?1 in dog food. T-2 and HT-2 toxins were present in 88% and 84% of the samples, respectively. Two samples contained fumonisins, with a maximum concentration of 108 µg kg^?1. Aflatoxin B₁ and ochratoxin A were detected in 8% and 45% of the samples, respectively. The measured mould and mycotoxin levels were consistent with results obtained by other studies. However, potential exposure to relatively high concentrations of an oestrogen mycotoxin as is ZEN, especially when in combination with other mycotoxins, needs attention.     

Determination of Deoxynivalenol and Nivalenol in Wheat by Ultra-Performance Liquid Chromatography/Photodiode-Array Detector and Immunoaffinity Column Cleanup

An ultra-performance liquid chromatography (UPLC®) method has been developed for the simultaneous determination of deoxynivalenol (DON) and nivalenol (NIV) in wheat. Ground sample was extracted with water and the filtered extract was cleaned up through an immunoaffinity column containing a monoclonal antibody specific for DON and NIV. Toxins were separated and quantified by UPLC® with photodiode-array detector (λ?=?220 nm) in less than 3 min. Mean recoveries from blank wheat samples spiked with DON and NIV at levels of 100–2,000 μg/kg (each toxin) ranged from 85 to 95 % for DON and from 81 to 88 % for NIV, with relative standard deviations less than 7 %. Similar recoveries were observed from spiked samples when methanol/water (80:20, v/v) was used as extraction solvent. However, by using a wheat sample naturally contaminated with DON and NIV, the one-way analysis of variance (Student–Newman–Keuls test) between different extraction solvents and modes showed that water extraction provided a significant increase (P?<?0.001) in toxin concentrations (mean values of six replicate analyses) with respect to methanol/water (80:20, v/v). No significant difference was observed between shaking (60 min) and blending (3 min). The limit of detection (LOD) of the method was 30 μg/kg for DON and 20 μg/kg for NIV (signal-to-noise ratio 3:1). The immunoaffinity columns showed saturation of DON/NIV binding sites at levels higher than 2,000 ng in blank wheat extracts spiked with the corresponding amount of mycotoxin, as single mycotoxin or sum of DON and NIV. The range of applicability of the method was from LOD to 4,000 μg/kg, as single mycotoxin or sum of DON and NIV in wheat. The analyses of 20 naturally contaminated wheat samples showed DON contamination in all analyzed samples at level ranging from 30 to 2,700 μg/kg. NIV was detected in two samples at negligible toxin levels (up to 46 μg/kg). This is the first UPLC® method using immunoaffinity column cleanup for the simultaneous and sensitive determination of DON and NIV in wheat.     

Aflatoxins in composite spices collected from local markets of Karachi,Pakistan

This survey was carried out to evaluate the occurrence of total aflatoxins (AFs; B₁+B₂+G₁+G₂) in unpacked composite spices. A total of 75 samples of composite spices such as biryani, karhai, tikka, nihari and korma masalas were collected from local markets of Karachi, Pakistan, and analysed using HPLC technique. The results indicated that AFs were detected in 77% (n = 58) samples ranging from 0.68 to 25.74 µg kg^?1 with a mean of 4.63 ± 0.95 µg kg^?1. In 88% (n = 66) samples, AFs level was below the maximum limits (ML = 10 µg kg^?1) as imposed by EU. Furthermore, 61% (n = 46) tested samples contained AFs level between 1 and 10 µg kg^?1, 9% (n = 7) exhibited AFs contamination ranged 10?20 µg kg^?1 and only 3% (n = 2) of the investigated samples contained AFs levels higher than the ML of 20 µg kg^?1 for total aflatoxins as set by the USA. It was concluded that there is need to establish a strict and continuous national monitoring plan to improve safety and quality of spices in Pakistan.     

Occurrence and risk assessment of population exposed to deoxynivalenol in foods derived from wheat flour in Brazil

Deoxynivalenol (DON) is the most important of the trichothecenes in terms of amounts and occurrence in wheat. This compound was shown to be associated with a glomerulonephropathy involving an increase of immunoglobulin A in humans. This study assessed the occurrence of DON in wheat flour and the exposure of Brazilian teenagers, adults and elderly to this mycotoxin due to intake of wheat flour-based products. DON extraction in wheat flour was carried out by solid phase extraction and the quantification was performed by ultra-high proficiency liquid chromatography with diode-array detection. A total of 77.9% of all samples were positive for DON, with concentrations ranging from 73.50 to 2794.63 µg kg^?1. The intake was calculated for the average and 90th percentile of the contamination levels of DON in foods based-wheat for teenagers, adults and elderly in Brazil, and compared with the provisional maximum tolerable daily intakes (PMTDI). Females of all age groups were exposed to DON at higher levels when compared to males in regard of consumption of breads and pastas. Teenagers were the main consumers of foods derived from wheat flour, with maximum probable daily intakes of 1.28 and 1.20 µg kg^?1 b.w. day^?1 for females and males, respectively. This population is at an increased risk of exposure to DON due to consumption of wheat flour-based foods in Brazil.     

Analysis of sterigmatocystin in cereals,animal feed,seeds, beer and cheese by immunoaffinity column clean-up and HPLC and LC-MS/MS quantification

A method is reported for the analysis of sterigmatocystin in various food and feed matrices using a commercial sterigmatocystin immunoaffinity column (IAC) for sample clean-up prior to HPLC analysis by UV with mass spectrometric detection (LC-MS/MS). Cereals (wheat, oats, rye, maize and rice), sunflower seeds and animal feed were spiked with sterigmatocystin at levels from 0.75 to 50 µg kg^?1 to establish method performance. Using acetonitrile/water extraction followed by IAC clean-up, and analysis by HPLC with detection at 325 nm, recoveries ranged from 68% to 106%, with repeatability from 4.2% to 17.5%. The limit of quantification with UV detection in these matrices was 1.5 µg kg^?1. For the analysis of beer and cheese the sample preparation prior to IAC clean-up was changed to accommodate the different properties of the matrix, prior to analysis by LC-MS/MS. For beer and cheese spiked at 5.0 µg kg^?1 the recoveries were 94% and 104%, and precision (RSDs) were 1.9% and 2.9% respectively. The limits of quantification by LC-MS/MS in beer and cheese were 0.02 and 0.6 µg kg^?1 respectively. The sterigmatocystin IAC was demonstrated to provide an efficient clean-up of various matrices to enable this mycotoxin to be determined by either HPLC with UV detection or LC-MS/MS.     

Mycotoxin contamination of home-grown maize in rural northern South Africa (Limpopo and Mpumalanga Provinces)

The aim of this study was to assess mycotoxin contamination of crops grown by rural subsistence farmers over two seasons (2011 and 2012) in two districts, Vhembe District Municipality (VDM, Limpopo Province) and Gert Sibande District Municiality (GSDM, Mpumalanga Province), in northern South Africa and to evaluate its impact on farmers’ productivity and human and animal health. A total of 114 maize samples were collected from 39 households over the two seasons and were analysed using a validated liquid chromatography-tandem mass spectrometry mycotoxins method. Aflatoxin B₁ (AFB₁) occurrence ranged from 1 to 133 µg kg^?1 in VDM while AFB₁ levels in GSDM were less than 1.0 µg kg^?1 in all maize samples. Fumonisin B₁ levels ranged from 12 to 8514 µg kg^?1 (VDM) and 11–18924 µg kg^?1 (GSDM) in 92% and 47% positive samples, respectively, over both seasons. Natural occurrence and contamination with both fumonisins and aflatoxins in stored home-grown maize from VDM was significantly (p < 0.0001) higher than from GSDM over both seasons.     

Determination of trichothecenes in cereals and cereal-based products by liquid chromatography–tandem mass spectrometry

A sensitive, accurate and precise method for the simultaneous determination of nivalenol (NIV), deoxynivalenol (DON), T-2 toxin (T-2) and HT-2 toxin (HT-2) in different food matrices, including wheat, maize, barley, cereal-based infant foods, snacks, biscuits and wafers, has been developed. The method, using liquid chromatography coupled with atmospheric pressure chemical ionization triple quadrupole mass spectrometry (LC–APCI–MS/MS), allowed unambiguous identification of the selected trichothecenes at low µg per kg levels in such complex food matrices. A clean-up procedure, based on reversed phase SPE Oasis® HLB columns, was used, allowing good recoveries for all studied trichothecenes. In particular, NIV recoveries significantly improved compared to those obtained by using Mycosep® #227 columns for clean-up of the extracts. Limits of detection in the various investigated matrices ranged 2.5–4.0 µg kg^?1 for NIV, 2.8–5.3 µg kg^?1 for DON, 0.4–1.7 µg kg^?1 for HT-2 and 0.4–1.0 µg kg^?1 for T-2. Mean recovery values, obtained from cereals and cereal products spiked with NIV, DON, HT-2 and T-2 toxins at levels from 10 to 1000 µg kg^?1, ranged from 72 to 110% with mean relative standard deviation lower than 10%. A systematic investigation of matrix effects in different cereals and cereal products was also carried out by statistically comparing the slopes of standard calibration curve with matrix-matched calibration curve for each of the four toxins and the eight matrices tested. For seven of the eight matrices tested, statistically significant matrix effects were observed, indicating that, for accurate quantitative analysis, matrix-matched calibration was necessary. The method was applied to the analysis of 57 samples of ground wheat originated from South Italy and nine cereal food samples collected from retail markets.     

Occurrence of Fusarium mycotoxins in maize imported into the UK, 2004–2007

This study examined a total of 82 consignments of French and Argentinean raw maize as received at maize mills in the UK between 2004 and 2007. Samples were analysed for deoxynivalenol (DON), nivalenol (NIV), other trichothecenes, zearalenone (ZON), and fumonisins B₁, B₂, and B₃ (FB₁, FB₂, and FB₃) using fully validated analytical methods with limits of quantification of 10 µg kg^?1 for DON, NIV, and each fumonisin mycotoxin and 3 µg kg^?1 for ZON. All samples except two containing fumonisins met the European Commission statutory maximum permissible levels for DON, ZON, and FB₁ + FB₂ as operating in 2007. The maximum concentrations found for DON, NIV, ZON, and FB₁ + FB₂ were 444, 496, 165 and 5002 µg kg^?1, respectively. Fumonisins were detected in almost every sample with 65% of Argentinean maize containing more than 1000 µg kg^?1 of FB₁ + FB₂. In contrast, ZON was not detectable in almost 50% of consignments. During this period there was a distinct difference in mycotoxin concentrations between harvests and geographic origin. Flint maize from Argentina usually contained lower concentrations of DON and related trichothecenes and higher levels of fumonisins than maize from France, although concentrations of fumonisins up to 2000 µg kg^?1 or greater occurred in samples from both regions. The incidence and concentrations of fumonisins were similar to those in a similar previous survey, while zearalenone concentrations were lower. The distribution of mycotoxins in multi-hold ships was also investigated showing that fumonisins were much more evenly distributed than DON, thus indicating their general level in the ship as a whole. The effect of cleaning regimes was found to be very variable, especially for DON, ranging from no removal of mycotoxins to greater than 50% in some instances, but was not related to concentration. Evidence here suggests that while cleaning is essential for removing foreign bodies before milling, it cannot be used as a reliable tool for reducing mycotoxins.     

Alternaria toxins in Argentinean wheat,bran, and flour

Alternaria species have been reported to infect a wide variety of vegetables, fruits, and cereal crops. Wheat is one of the most consumed cereal worldwide. A sensitive HPLC-DAD methodology was applied to quantify alternariol (AOH), alternariol methyl ether (AME) and tenuazonic acid (TeA) in 65 samples of whole wheat, bran, and flour. The extraction methodology allowed extracting the three toxins simultaneously. Limits of detection in wheat were 3.4, 4.5, and 0.5 µg kg^?1 for AOH, AME and TeA, respectively. For bran, these data were 3.1, 4.5, and 12 µg kg^?1 and for flour 50, 70, and 14 µg kg^?1, respectively. The studied recoveries were higher than 70% and RSD was below 10%. Wheat and bran samples showed low AOH and AME contamination compared to TeA. The averages levels found for TeA in wheat, bran and flour were 19,190, 16,760, and 7360 µg kg^?1, respectively.     

Assessment of mercury and cadmium via seafood consumption in Italy: estimated dietary intake (EWI) and target hazard quotient (THQ)

Mercury (Hg) and cadmium (Cd) were quantified in fish, cephalopods and crustaceans from Italian supermarkets. Sample compliance with European dietary standards as well as human health risks according to provisional tolerable weekly intake (PTWI) and the methodology of target hazard quotient (THQ) were evaluated. Both element levels were under European legal limits, except for some fish having Hg and Cd contents exceeding or equal to critical values. Estimated weekly intakes (Hg: fish = 0.07–1.44 µg kg^?1 bw week^–1; cephalopods = 0.05–0.15 µg kg^?1 bw week^–1; crustaceans = 0.04–0.08 µg kg^?1 bw week^–1; and Cd: fish = 0.04–0.32 µg kg^?1 bw week^–1; cephalopods = 0.07–0.27 µg kg^?1 bw week^–1; crustaceans = 0.05–0.11 µg kg^?1 bw week^–1) as well as THQ < 1 were within safe limits. Although there seems to be no important risks associated with seafood consumption, Hg exposure was in some cases close to safety margins and thus levels of this metal should be under frequent surveillance.