Sodium Tripolyphosphate Stability and Effect in Ground Turkey Meat

Ground turkey meat, cooked and uncooked, was prepared with and without 0.5% sodium tripolyphosphate (SIP) and stored at 5°C for different periods of time. STP stability was evaluated by determining soluble orthophosphate. Water-holding capacity (WHC), pH, and mi-crobial count were also measured. STP hydrolyzed rapidly in uncooked samples. Refrigerated storage time (up to 6 days) did not affect STP hydrolysis in cooked turkey meat. Heating accelerated the rate of STP hydrolysis. End point temperatures (65, 75, and 85 °C) did not affect the extent of STP hydrolysis. STP increased WHC in both cooked and uncooked samples. STP did not inhibit total microbial growth in cooked or uncooked ground turkey meat.     

Combined effects of NaCl and raw meat pH on water-holding in cooked sausage with and without added phosphate

The intake of sodium in diets is of concern in many industrialized countries. Attempts have been made to lower sodium intake via meat products. The keeping quality, taste and water-holding/firmness of meat products have usually been impaired. The water-holding in cooked sausage was determined by a laboratory sausage method. Beef and pork with varying natural post-rigor pH-values (range: pork 5.50-6.12 and beef 5.60-6.48) were used as mixtures, and 0.5-2.5 % NaCl was used with or without added commercial sausage phosphate (2,5 g/kg determined as P(2)O(5)). The pH-values of raw batter increased to a level 0.0-0.7 units higher than the pH-values of the respective meat mixtures. The increase was higher in lower pH-values, with higher salt levels and with added phosphate. The cooking caused an additional increase of about 0.0-0.2 units, and the increase was again higher at lower pH-values. Maximum in water-holding was reached in 2.5% NaCl in all pH-values, both with and without added phosphate. The pH-value of meat raw materials for the maximum water-holding was ca. 6.3. The combined effect of salt and pH is important in high salt contents and low pH-values. By 2.5% NaCl , where the maximum in water-holding was obtained, raw meat pH has the largest effect, but in low NaCl contents, below 1.0%, only a minor effect in pH-values below 5.9, and above that, almost no effect. Approximately the same water-holding as with 2.5% NaCl in pH 5.7 can be reached with 1.5% NaCl in pH 6.1 and above. The effects of the variables were similar with pork and beef. It was concluded that when lowering the salt content in cooked sausages, the pH of the batter should be increased by using high-pH meat mixtures and/or pH-raising phosphates in order to reach a high enough level of water-holding.     

Development of a Test to Predict Gelation Properties of Raw Turkey Muscle Proteins

A method for extraction and fractionation of muscle proteins into five fractions based on salt (NaCl) solubility was developed. The influence of protein extractability, solubility, muscle pH and total protein on gelation was investigated. Shear stress (gel strength) and shear strain (gel deformability) at failure of cooked (70°C) comminuted turkey breast gels were correlated with the 10 min protein extract and proteins soluble in 0.30–0.35M NaCl. Shear strain was correlated with muscle pH and shear stress was sensitive to total protein. Meat pH and the extraction/fraction method can be used on raw meat to indicate functional properties related to texture of cooked meat.     

Effect of α-Tocopherol, β-Carotene, and Sodium Tripolyphosphate on Lipid Oxidation of Refrigerated, Cooked Ground Turkey and Ground Pork

ABSTRACT α-Tocopherol and β-carotene at 0.03% levels and sodium tripolyphosphate (STP) at 0.2% and 0.3% levels, alone and in combination, were added to ground turkey and ground pork. Hexanal was measured after cooking and storage at 4 °C for 2, 4, or 6 d. α-Tocopherol alone significantly reduced hexanal of stored, cooked, turkey but had no effect in pork. STP was more effective than α-tocopherol and a combination of α-tocopherol with STP resulted in enhanced antioxidant activity. Hexanal of pork with 0.03%α-tocopherol plus 0.3% STP did not increase significantly during storage, and that of turkey increased only slightly. β-Carotene and salt (1% NaCl) had no effect on hexanal.     

Gelation properties of previously cooked minced meat from Jonah crab (Cancer borealis) as affected by washing treatment and salt concentration

The influence of washing treatment (dewatered only, one wash, and three washes) and sodium chloride (NaCl) concentration (0%, 2%, and 4%) on the gelation properties of crab mince was investigated. This previously cooked muscle mince is a low-value by-product of the crab processing industry, considered to have little or no functional properties. Crab mince gels were produced and tested for water-holding capacity (WHC), gel strength, colour, and electrophoretic profile. Wash treatment and NaCl concentration significantly affected gelation. Washed samples exhibited significantly higher WHC than dewatered samples. The 4% NaCl treatment decreased WHC compared to lower NaCl levels. Multiple washing steps increased the force to gel deformation. Wash treatment and NaCl concentration also affected the colour of gels. Based on these results, cooked crab meat mince treated with three washes and 0% NaCl resulted in the strongest gels with the best water-holding capacity, which can be used in the development of value-added products.     

Effect of sodium chloride and pH on the rennet coagulation and gel firmness

The effect of sodium chloride concentration and pH of milk at renneting on the rennet clotting time (RCT) and gel firmness was studied. The results showed that rennet clotting activity and gel firmness decreased with increasing NaCl concentration in milk. The RCT increased as the pH of the salted milk decreased below 6.4. Milk containing 5 and 10 g NaCl/100 g did not coagulate at pH 5.0. The gel firmness increased with decreasing milk pH to 6.2 for unsalted milk. However, the firmness decreased as the pH of milk decreased below 6.2. In case of using salted milk, the firmness decreased as the pH at renneting dropped below 6.4.     

Improved Cooking Yields of Meat Batters Formulated with Potassium Sorbate and Reduced Levels of NaCl

The influence of varying NaCl levels (0.8, 1.2, 1.6, 2.0, and 2.4%) on the cooking yield and composition of comminuted meat (beef-pork) products (frankfurters and cans) was tested in the absence and presence of 0.26% potassium sorbate. Parameters measured included frankfurter smokehouse yields and consumer cook losses; product losses in cans; and, moisture and fat contents of the cooked products. Reducing the NaCl level resulted in increased product losses during cooking. Potassium sorbate decreased these losses. Cooking yields at most NaCl levels (≦ 1.6%) tested were improved (P<0.01) with the addition of potassium sorbate. The positive influence of sorbate on product binding could not be attributed to pH or ionic strength changes, but potential mechanisms of sorbate action are discussed.     

Effect of Sodium Salts and Added Water on Physical, Chemical and Sensory Properties of Dark Turkey Meat Subjected to Long-term Frozen Storage

Patties from a Control (100% meat), Treatment I (meat, 1.1% water, 1.0% NaCl and 0.5% STP) and Treatment II (meat, 11.1% water, 1.0% NaCl and 0.5% STP) were frozen for 0 to 52 wk, broiled, and analyzed. Yield, moisture, expressible moisture, tenderness, and juiciness of both Treatments were improved compared to the Control. TBA values of Treatment II were greater than that of the Control. The force needed to penetrate top surface of patties (FI) from Control and Treatment I was similar and greater than that of patties from Treatment II. The force needed to penetrate bottom surfaces of patties (F2) differed across formulation. Storage adversely affected moisture content of Control along with F2 and TBA values of all formulations. Juiciness was negatively correlated with moisture.     

Effect of Sodium Salts and Added Water on Color of Dark Meat Turkey Patties Subjected to Long-term Storage

Patties from a Control (all meat), Treatment I (meat, 1.1% water, 1.0% NaCl and 0.5% STP) and Treatment II (meat, 11.1% water, 1.0% NaCl and 0.5% STP) were frozen for 0 to 24 wk, broiled, and analyzed for color attributes. Treated patties had lighter exterior surfaces with reduced redness and increased yellowness. The opposite effects were observed for the interior of patties. Treatment II had elevated values for internal yellowness as compared to Treatment I. Storage caused an increase in both external and internal color values. Sensory scores indicated that internal redness of treated patties was greater than that of the Control but gradually decreased during storage.     

OXIDATIVE STABILITY, COOKING YIELD AND TEXTURE OF PORK TREATED WITH A LOW-SODIUM SALT

The effect of a low-sodium salt mixture (LSSM) on the characteristics of cooked ground pork was investigated. LSSM, similar to NaCl, exhibited a minor but definite prooxidative effect in the system examined. The cooking yield of meat containing 1% LSSM was 69.8% compared to 74.3% for 1% NaCl. The cooking yields of samples with 2 and 3% LSSM were similar to those containing 2 and 3% of NaCl, respectively (p > 0.05). Maximum shear force values of samples containing 1% LSSM and 1% NaCl were similar. However, the maximum shear force values of meats treated with LSSM at 2 and 3% LSSM (19.1 and 24.8 kg) were lower (P < 0.05) than those containing 2 and 3% NaCl (21.9 and 27.0 kg). Addition of LSSM or NaCl to ground pork also enhanced the cooking yield and firmness over those containing no salt. The color characteristics of cooked pork remained generally unaffected by LSSM.     

Stability and Gel Strength of Frankfurter Batters Made with Reduced NaCl

A detailed examination of fat emulsification and water-binding capacities in frankfurter batters and the cooked batters' textural responses to lowered levels of added sodium chloride was conducted. In response surface analyses of water and fat exudations and gel strength with varying compositions of fat, water, meat, and salt, the area of maximum stability decreased and moved toward a higher fat content when the salt was reduced from 2.5 to 1.5%. Gel strength increased with increasing content of lean meat and decreased with lowered salt levels. When salt, pH, chopping temperature, and cooking temperature were varied from the standard conditions, water exudate was generally affected first and most intensely while the gel strength was second. Fat release did not occur until more extreme conditions were encountered.     

Quality of Whole Lobster (Homarus americanus) Treated with Sodium Tripolyphosphate Before Cooking and Frozen Storage

ABSTRACT: The objective of this study was to determine the effects of pre-rigor treatment of lobster muscle with sodium tripolyphosphate (STP) before cooking, cryogenic freezing, and frozen storage. STP concentrations of 0.1% and 0.3% were prepared in 0.9% saline solution and injected into lobster before processing. Controls were injected with 0.9% saline solution. Lobsters were then steam-cooked, cryogenically frozen, and stored at −15 °C. Chemical and textural analyses were conducted on reheated samples at storage months 0, 2, 4, and 6, and sensory analyses were conducted at months 2 and 6. Cook loss results showed the 0.3% STP-treated lobsters had a 5% significantly ( P 0.05) lower cook loss than the 0.1% STP and control samples. Yield results revealed that STP-treated tails had a 0.7% to 0.8% significantly ( P 0.05) higher meat yield than control samples. Total moisture results showed that STP-treated lobster tail and claw meat had higher total moisture levels compared with control samples at month 6. Sensory results revealed that panelists rated both 0.1% and 0.3% STP-treated lobster tails significantly ( P 0.01) higher for flavor and texture, and significantly ( P 0.001) higher for overall acceptability than control samples at month 6. The results indicated that STP added at low concentrations may extend the shelf life of whole cooked cryogenically frozen lobster, decrease lipid oxidation over frozen storage time, maintain texture, color, and flavor attributes, increase yield, and decrease drip loss.     

Effect of laccase and transglutaminase on the textural and water-binding properties of cooked chicken breast meat gels

The effects of laccase and transglutaminase (TG) on the firmness and weight loss of cooked chicken meat homogenate gels were investigated at laboratory scale. The salt, trisodium pyrophosphate and meat contents were also used as variables. Laccase decreased firmness and increased weight loss of phosphate-free, low-meat (65%) and low-salt (1%) gels, although it modified myosin and troponin T and reacted with isolated myofibrils. By applying both low-salt (1%) and low-phosphate (0.17%) amounts, gel firmness decreased and weight loss increased (p<0.05) greatly. A high dosage of TG significantly improved (p<0.05) the strength of phosphate-free, low-meat and low-salt homogenate gels compared to the corresponding no-enzyme controls. TG improved gel firmness of the low-meat homogenate to the level of the homogenate containing 75% meat. Weight loss was increased significantly (p<0.05) in all cases when the high-TG dosage was used. Enzymes were not capable of improving either texture or water-holding capacity in the low-salt–low-phosphate system. The firmness and cooking loss of the chicken meat products containing different amounts of meat, salt and TG were investigated at pilot scale. Under the conditions and dosages used, TG was capable of improving (p<0.05) firmness of the products without a significant reduction in water-holding capacity.     

Effect of grape seed extract on physicochemical properties of ground, salted, chicken thigh meat during refrigerated storage at different relative humidity levels

ABSTRACT:  The effect of grape seed extract (GSE, 0.1%) ± NaCl (1%) in ground chicken thigh meat during refrigerated storage at 59%, 76%, 88%, and 99% relative humidity (RH) was examined. Compared to the untreated control, GSE (0.1%) delayed the reduction of water activity (a_w) that occurred during refrigerated storage at different relative humidity levels but had no effect on moisture content or pH compared to the untreated control. GSE inhibited the formation of a secondary marker of lipid oxidation (TBARS) compared to the untreated control and altered the effect of NaCl on TBARS formation. The formation of TBARS was affected by RH level across all treatment groups in the order of 99% > 88% > 76% > 59%. Further analysis revealed that this effect likely is due to the presence of NaCl, which suggests that RH storage does not affect the formation of TBARS except in salted patties, the effect of which is mitigated by the addition of GSE. NaCl, but not GSE, increased both sarcoplasmic and myofibrillar protein solubility after 12 d of refrigerated storage, suggesting increased protein denaturation. This study shows that GSE is an effective antioxidant in ground chicken thigh meat that does not affect moisture content or pH during storage, inhibits TBARS formation, helps to mitigate the prooxidative effects of NaCl, and may alter the effect of NaCl on protein solubility in salted chicken patties. Future work is needed to determine how the physicochemical interactions of GSE affect important cooked meat quality attributes.     

Effect of dietary vitamin e on the oxidative stability of raw and cooked rabbit meat

The effect of dietary α-tocopheryl acetate supplementation (200mg/kg diet) on plasma and muscle levels of α-tocopherol and the oxidative stability of raw and cooked rabbit meat was determined. Two groups of 20 male hybrid rabbits were fed the experimental diets from 35 to 80 days of age. Feed intake, live weight, feed efficiency and qualitative traits of the carcass and meat were recorded. The α-tocopherol levels in plasma and muscle were significantly higher (p≤0·01) in the supplemented group, which also showed an increase in oxidative stability in both raw and cooked meat. The higher α-tocopherol level improved the physical traits of the meat, significantly reducing shear value and increasing water-holding capacity; n-3 fatty acids in raw and cooked meat increased (p≤0·05) and the thrombogenic index decreased (p≤0·05). Dietary vitamin E did not influence weight gain, feed intake and dressing yield.     

Kappa-Carrageenan, Sodium Chloride and Temperature Affect Yield and Texture of Structured Beef Rolls

Structured lean beef rolls (4–5% fat), formulated with 33% added water, 1% sodium chloride and 0.35% sodium tripolyphosphate and cooked to 63°, 73° and 83°, had low cook yields and poor texture and bind. Kappa-carrageen an (KC) added at 0.5–1% and NaCl at 2–3% increased cook yield and improved textural properties (bind, force to fracture, hardness). Rolls with 1.0% KC and 3% NaCl had the highest cook yield (154% meat weight basis) and the highest values for force to fracture and hardness. Cook yield decreased and hardness increased with increased cooking temperature. Effects of KC on yield and texture were most pronounced at the lowest NaCl level (1%) and the highest temperature (83°). KC also reduced purge of vacuum-packaged slices during refrigerated storage.     

Sodium Retention in Prerigor and Postrigor Ground Pork

Sodium retention in pre- and postrigor ground pork was studied. Pork of different ionic strengths was prepared by mixing meat with various amounts of water and NaCl, and was separated into two fractions: supernatants and pellets. Na⁺ retention in supernatants increased with increasing percent NaCl (0–5%). Supernatants of prerigor ground pork contained less Na⁺ than those of postrigor ground meat. Na⁺ retention in pellets also increased with increasing percent NaCl (0–5%). Na⁺ retention was higher in pellets of prerigor ground pork than in those of postrigor ground meat. Muscle proteins were not able to bind added Na⁺, as demonstrated by a dialysis method, regardless of rigor state and fraction.     

Textural and Physical Properties of Acid–Induced and Potassium–Substituted Low–Sodium Surimi Gels

ABSTRACT: Textural and physical properties of acetic acid-induced and salt-induced surimi gels were evaluated. The addition of 2 to 3% acetic acid significantly decreased the shrinkage and total expressible fluid and increased firmness compared to 0.5% acetic acid added. Acid-induced gels without starch were significantly firmer than those with starch and salts. There was no peak in storage modulus with the addition of acid in the temperature range of 32 to 43 °C, suggesting that the acid-induced gelation did not require setting as the salt-induced one. Partial substitution (1%) of KCl for NaCl did not change the storage modulus of the sol during heating and gel firmness. However, KCl and NaCl weakened the firmness of the acid-induced gel.     

Tenderness and Sodium Content of Pectoralis superficialis from Broilers Chilled in Potassium or Sodium Chloride Ice Slush

Cooked light meat (Pectoralis superficialis) from broiler carcasses chilled (4 hr, with agitation) in 5% (w/w) sodium chloride (NaCl), 5% (w/w) potassium chloride (KCl), or ice slush was evaluated for moisture content, tenderness (shear force), chloride ion (Cl) concentration, and sodium ion (Na) concentration. Water uptake of the carcasses during chilling was determined. Chilling in either salt solution increased cooked meat moisture, increased chloride ion concentration, and decreased shear force values. Sodium level and water uptake were increased by NaCl brine ice-slush chilling. Samples chilled in NaCl had higher chloride concentrations and lower shear force than samples chilled in KCl.     

Sodium hydroxide and sodium tripolyphosphate effects on bind strength and sensory characteristics of restructured beef rolls

Restructured beef rolls formulated with 1% NaCl (controls) or with 1% NaCl plus 0.07% NaOH or 0.375% sodium tripolyphosphate (STPP) had different (p < 0.05) relative bind strength and cooked yield, as follows: STPP > NaOH > controls. Percent cooked yield was inversely affected (p < 0.05) by added water level (5 > 10 > 20%). Bind values were lower (p < 0.05) in rolls with 20% added water. NaOH and STPP rolls had higher pH (p < 0.05) than controls (6.28, 6.22, and 6.07, respectively). Panel cohesiveness, juiciness, and acceptability scores were also generally higher (p < 0.05) for NaOH and STPP rolls, compared to controls. There was a high correlation (0.93) between panel cohesiveness scores and instrumental bind values. At 20% added water, STPP rolls were preferred, but at 10% added water, STPP and NaOH rolls were similar in overall acceptability. Thus, if added water level is not too high, NaOH alone or perhaps with other binding agents may be an alternative to phosphates in cooked beef rolls.