Effect of refermentation conditions and micro-oxygenation on the reduction of volatile acidity by commercial S. cerevisiae strains and their impact on the aromatic profile of wines

Herein, we evaluate the applicability of previously characterized commercial and indigenous Saccharomyces cerevisiae strains and non-S. cerevisiae species for the deacidification of white and red wines at a pilot scale. The effect of the refermentation process (mixture of acidic wine with musts from freshly crushed grapes or with residual marc) as well as micro-oxygenation (MO) on acetic acid removal efficiency and wine aromatic composition was also assessed in a red wine. The commercial strains S26 and S29 efficiently reduced both acetic acid (43 and 47%, respectively) and sugar (100%) after 264 h of refermentation of an acidic white wine that was supplemented with grape must. Similar results (60-66% of acetic acid removal) were observed for red wine deacidification using grape must, independently of MO. When residual marc was used for deacidification, strain S26 removed 40% of acetic acid, whereas strain S29 did not initiate refermentation with or without MO. Wines obtained by refermentation with the must had significantly lower acetic acid and a higher total SO₂ concentration in comparison to the wines deacidified by the grape marcs. The volatile aroma compound's composition of deacidified red wines was dependent on the refermentation process used, rather than on MO. The marc-deacidified wine obtained by the use of strain S26 and without MO achieved the best sensory classification. When data from all analytical and sensory evaluation were combined, Principal Component Analysis (PCA) separated the wines into three distinct groups according to the strain and the refermentation process independently of MO. We successfully established an efficient and cheap enological solution for the rectification of volatile acidity of wines.     

Characteristics of wines fermented with different Saccharomyces cerevisiae strains isolated from the La Mancha region

One hundred and seventy-four strains of Saccharomyces cerevisiae from musts in fermentation were characterized using pulsed-field gel electrophoresis. Of these, 13 strains were selected for their good oenological properties and were used as inocula in laboratory-scale fermentation of an Airén must. Volatile compound and amino acid content of the resulting wines was analysed. Factorial principal component analysis of the data revealed differences between wines according to the strain used in the fermentation. Strains that produce more volatile compound and have an adecuated nitrogen assimilation are recommended to obtain quality wines.     

Volatile composition of partially fermented wines elaborated from sun dried Pedro Ximénez grapes

In this work, we used a cell immobilisation system consisting of Penicillium chrysogenum fungi (GRAS) bound to the osmotolerant yeast strains Saccharomyces cerevisiae X4 and X5 for the partial fermentation of raisin musts. The resulting wines were compared with others obtained by partial fermentation of musts with free yeasts and with a traditionally produced sweet wine (i.e. without fermentation of the must). The analysis of volatile compounds grouped by aroma series showed the partially fermented musts had a more complex aroma than the traditional wine. Specially prominent among aroma series was that of ripe fruit, followed by the milky and chemical series. The volatiles with the greatest impact on wine aroma as assessed in terms of odour activity were ethyl hexanoate, ethyl octanoate, butyrolactone, isoamyl alcohols, acetaldehyde, ethyl acetate, 2,3-butanediol, acetoin and 2,3-butanedione. A cluster analysis according to the Ward method was performed to assess the similarity between the traditional sweet wine and those obtained by partial fermentation with free and immobilised yeasts revealed small differences between the wines obtained with free and immobilised yeasts, and marked differences between partially fermented and traditionally obtained sweet wine. The wines provided by immobilised yeasts were the most appreciated in the sensory analysis (especially those obtained with X4 yeasts).     

The influence of yeast on the aroma of Sauvignon Blanc wine

The main objective of this study was to investigate the effect of different Saccharomyces cerevisiae wine yeast strains on the concentration of aroma-enhancing volatile thiols and fermentation metabolites in Sauvignon Blanc wine. Seven commercial wine yeast strains were selected based on their putative ability to modulate the concentrations of the fruity volatile thiols, 4-mercapto-4-methylpentan-2-one (4MMP), 3-mercapto-hexanol (3MH) and 3-mercapto-hexylacetate (3MHA). Each of these yeasts was used to produce Sauvignon Blanc wines under controlled conditions, in triplicate, in 20-L quantities. The levels of 4MMP, 3MH and 3MHA in these wines were quantified using the p-hydroxymercuribenzoate method. In addition, a total of 24 volatile yeast-derived fermentation aroma compounds were also quantified using headspace solid-phase microextraction coupled with gas chromatography mass spectrometry (HS-SPME–GC–MS). Formal sensory analysis was conducted by 12 trained assessors and, additionally, a panel of 24 experienced wine industry professionals assessed the wines and ranked them in order of preference. The results indicated that the yeast strains varied significantly in terms of their capabilities to (i) produce volatile thiols and fermentation metabolites; and (ii) to modulate the varietal characters of Sauvignon Blanc wine. Yeast strains that produced the highest levels of volatile thiols were responsible for wines with the highest perceived intensity of fruitiness, and these wines were preferred by the tasting panels. While the ‘green’ characters in Sauvignon Blanc wines can be manipulated through vineyard management, the ‘tropical fruity’ characters appear to be largely dependent on the wine yeast strain used during fermentation. Therefore, the choice of yeast strain offers great potential to modulate wine aroma profiles to definable styles and predetermined consumer market specifications.     

Influence of autochthonous Saccharomyces cerevisiae strains on volatile profile of Negroamaro wines

Saccharomyces cerevisiae is the yeast species predominating the alcoholic fermentation of grape must. The aim of this research was to evaluate the impact of indigenous S. cerevisiae strains biodiversity on the aroma of wines from Negroamaro grapes. Grapes collected in two different Negroamaro producing micro districts in Salento (Southern Italy), were subjected to natural fermentation and two indigenous S. cerevisiae populations were isolated. Fifteen strains for each of the two populations were selected and tested by micro fermentation assay in order to evaluate their specific contribute to the volatiles composition and sensory impact of the produced wines. The aromatic profile of wines obtained by each selected strain was characterized by different contents of acetates, ethyl esters of fatty acids, higher alcohols, thus showing to be related to the strains geographical origin. The sensorial analysis of wines produced by the six best performing strains confirmed that they are good candidates as industrial starter cultures, This study indicates that the use of a “microarea-specific” starter culture is a powerful tool to enhance the peculiarity of wines deriving from specific areas.     

Increased flavour diversity of Chardonnay wines by spontaneous fermentation and co-fermentation with Hanseniaspora vineae

Discovery, characterisation and use of novel yeast strains for winemaking is increasingly regarded as a way for improving quality and to provide variation, including subtle characteristic differences in fine wines. The objective of this work was to evaluate the use of a native apiculate strain, selected from grapes, Hanseniaspora vineae (H. vineae) 02/5A. Fermentations were done in triplicate, working with 225 L oak barrels, using a Chardonnay grape must. Three yeast fermentation strategies were compared: conventional inoculation with a commercial Saccharomyces cerevisiae strain, ALG 804, sequential inoculation with H. vineae and then strain ALG 804 and spontaneous fermentation. Yeast strain identification was performed during fermentation, in which the apiculate strain was found to be active, until 9% of alcohol in volume, for the co-fermentation and the spontaneous fermentation was completed by three native S. cerevisiae strains. Basic winemaking parameters and some key chemical analysis, such as concentration of glycerol, biogenic amines, organic acids, and aroma compounds were analysed. Sensory analysis was done using a trained panel and further evaluated with professional winemakers. Sequential inoculation with H. vineae followed by S. cerevisiae resulted in relatively dry wines, with increased aroma and flavour diversity compared with wines resulting from inoculation with S. cerevisiae alone. Wines produced from sequential inoculations were considered, by a winemaker’s panel, to have an increased palate length and body. Characteristics of wines derived from sequential inoculation could be explained due to significant increases in glycerol and acetyl and ethyl ester flavour compounds and relative decreases in alcohols and fatty acids. Aroma sensory analysis of wine character and flavour, attributed to winemaking using H. vineae, indicated a significant increase in fruit intensity described as banana, pear, apple, citric fruits and guava. GC analysis of the relative accumulation of 23 compounds to significantly different concentrations for the three fermentation strategies is discussed in relation to aroma compound composition.     

Influence of sequential inoculation of Wickerhamomyces anomalus and Saccharomyces cerevisiae in the quality of red wines

The use of mixed inoculation of non-Saccharomyces yeasts and S. cerevisiae in wine fermentations is of increasing interest for quality enhancement and improved complexity of wines. The effect of sequential inoculation of Wickerhamomyces anomalus (formerly Hansenula anomala) with interesting enological properties in terms of secondary metabolite production and a commercial S. cerevisiae strain in fermentation of non-sterilized red musts from Mazuela variety has been examined. The wines elaborated by sequential inoculation presented higher levels of acetates and ethyl esters, compounds that supply a fruity note, higher levels of lineal alcohols, which are responsible for herbaceous notes and lower concentrations of organic acids, that contribute to increase the aromatic quality, than wines produced by a S. cerevisiae monoculture. Both types of wines were comparable in levels of volatile acidity, glycerol, lactic acid and succinic acid produced. Sensory analysis showed that red wines obtained by mixed fermentations were preferred by 71.5 % of the tasters and were particularly appreciated for its floral and/or fruity notes.     

Application of new fungicides under good agricultural practices and their effects on the volatile profile of white wines

Three new commercial fungicides to control downy mildew (Plasmopara viticola), which contain new generation fungicides (benalaxyl, iprovalicarb and piraclostrobin) were applied under Good Agricultural Practices (GAP) in an experimental vineyard producing white grapes (Vitis vinifera) Godello var. Once white grapes were harvested, single vinifications were performed. To evaluate possible modifications in aroma composition of wines, Odour Activity Values (OAVs) were estimated due to this parameter provides information about sensorial changes. Fungicide residual levels found in treated wines with respect to the control wine reduced the varietal aroma of wines attributed to geraniol. However, treated wines showed an increase in the fruity aroma due to several ethyl esters (ethyl hexanoate, ethyl octanoate, and ethyl decanoate) and acetates (3-methyl-1-butyl acetate and 2-phenylethyl acetate) increased their levels and OAVs in presence of fungicide residues; these secondary products of the fermentation process influence strongly the aromatic profile of young wines.     

Autolytic capacity and foam analysis as additional criteria for the selection of yeast strains for sparkling wine production

This study proposes a selection methodology for secondary fermentation yeast strains for the production of sparkling wines. It began with 34 different yeast strains, mainly of the Saccharomyces cerevisiae species. The selection methodology was divided into four consecutive stages: (1) a study of the fermenting capacity of the strains under secondary fermentation conditions; (2) analysis of the most important enological characteristics of the strains; (3) a study of the autolytic capacity of the yeast; and (4) analysis of the foaming properties of the autolysates obtained. Following this methodology, three strains were selected, with which three sparkling wines were produced by the Champenoise method. Industrial sparkling wines were also produced with the commercial strain EC-1118, used as a control in this study, and with strain J, from the collection of the winery where the sparkling wines were prepared. The wines thus obtained were aged for 12 months in presence of the yeast. The findings of the sensory analysis indicated that all of the sparkling wines were good quality.     

Influence of indigenous yeasts on the fermentation and volatile profile of plum brandies

The aim of this study was to determine the influence of different yeasts isolated from fresh blue plum fruits (Aureobasidium sp.) and spontaneously fermenting plum musts (Kloeckera apiculata and Saccharomyces cerevisiae), as well as commercial wine and distillery strains, on the fermentation and chemical composition of plum brandies. Gas chromatography methods were used to detect major volatile components. The most rapid fermentation occurred in musts inoculated with S. cerevisiae. However, the highest concentration of ethanol was detected in samples after spontaneous fermentation (8.40% v/v). Plum brandies obtained after distillation contained from 66.3 (K. apiculata) up to 74.3% v/v ethanol (spontaneous fermentation). The samples after spontaneous fermentation were distinguished by a high content of acetoin, ethyl acetate and total esters, accompanied by a low level of methanol and fusel alcohols. Non-Saccharomyces yeasts were responsible for higher concentrations of esters and methanol, while S. cerevisiae strains resulted in increased levels of higher alcohols. It was also found that isolated indigenous strains of S. cerevisiae synthesized relatively low amounts of higher alcohols compared to commercial cultures. Samples obtained using the distillery strain of S. cerevisiae received the highest score (18.2) during sensory analysis and were characterized by a well-harmonised taste and aroma.     

Influence of locally-selected yeast on the chemical and sensorial properties of Albariño white wines

The use of selected yeast strains with improved or novel properties may promote wines with special and original quality attributes. In this paper, changes in the chemical composition (aroma compounds and polyphenols) and sensorial properties of Albariño white wines elaborated with the same must and selected yeast (named as 1, 2 and 3) have been studied in comparison with wines subjected to non-inoculated fermentation (control wine). The results indicated that yeast strain can significantly influence the aroma and polyphenol composition of the wines. Wines elaborated with strain 1 had a higher concentration of terpenes and norisoprenoids, which are compounds closely associated with the fruity and fresh character of Albariño white wines. These same wines had a lower concentration of flavan-3-ols, closely associated with the astringency and bitterness of the wine and the lowest browning potential. The formal sensory analysis conducted by 8 trained judges showed that wines elaborated with strain 1 were preferred by the tasting panel. Therefore, the selection of yeast strains could offer the possibility to modulate sensorial attributes related with the aroma and phenol composition in Albariño white wines.     

Discrimination of sweet wines partially fermented by two osmo-ethanol-tolerant yeasts by gas chromatographic analysis and electronic nose

Some special sweet wines are obtained by partial fermentation of musts from off-vine dried grapes containing large amounts of sugars. This process is very slow and subject to serious stop problems that can be avoided by using osmo-ethanol-tolerant yeasts. Musts containing 371 g/l of sugars were partially fermented with selected Saccharomyces cerevisiae strains, X4 and X5, to 12% (v/v) and the wines obtained with X5 exhibited a higher volatile acidity but lower concentrations of higher alcohols, carbonyl compounds and polyols than those obtained with X4. A principal component analysis (PCA) of the data provided by an electronic nose (E-nose) afforded discrimination between fermented and unfermented musts, but not between wines obtained with X4 or X5. The PCA applied to the major volatile compounds and polyols shows similar results, but a clear discrimination between wines is obtained by removing the polyols glycerol and 2,3-butanediol from the PCA.     

Influence of yeast strain on aromatic profile of Gewürztraminer wine

Three selected autochthonous and one commercial Saccharomyces cerevisiae strains used as starters for fermentation of the same Gewürztraminer must were compared in terms of their influence on primary and secondary aroma of wine. At the same testing conditions, each strain S. cerevisiae produced individual metabolites in different concentrations and combinations which significantly influenced resulting wine flavour. Higher concentrations of 2-phenylethanol and cis-rose oxide, associated with S. cerevisiae TC-NAX-A, considerably distinguished this strain from the others. Occurrence of these VOCs has important influence on sweet rose-like flavour typical for Gewürztraminer wine. This paper deals with the characterization of chemical substances that directly affect the primary varietal aroma of Gewürztraminer wine, while looking for a tool to produce an original and attractive product in form of suitable autochthonous strain S. cerevisiae.     

烟台贵人香葡萄自然发酵醪中本土酿酒酵母的选育及酿造特性研究

自葡萄原料生产地选育优良酿造特性的本土酵母是开发地方特色葡萄酒品种的重要措施。本研究以烟台地区贵人香葡萄自然发酵醪为材料,筛选酿酒酵母并对其发酵特点和耐受能力进行测定,进而选育本土酿酒酵母用于霞多丽干白和赤霞珠干红葡萄酒的酿造试验。采用孟加拉红选择性培养基筛选本土酵母菌,并经WL鉴定培养基和5.8S ITS序列鉴定获得12株酿酒酵母。通过测定发酵后残糖量和酒精度及耐受能力(酒精度、SO2、酸、高糖),选育4株酵母用于酿造霞多丽干白葡萄酒,对酒样指标、主要挥发物和香气组分分析,显示菌株YGF2、YGF5和YGF10的酿造特性和发酵指标较好,并用于酿造赤霞珠干红葡萄酒。结果表明菌株YGF2酿造的葡萄酒质量较好,香气浓郁,部分指标优于商品酿酒酵母,具备生产区域特色葡萄酒的潜力。     

Determination of flavan-3-ols and trans-resveratrol in grapes and wine using HPLC with fluorescence detection

Concentrations of trans-resveratrol, catechin and epicatechin were analyzed in musts and wines produced from seven red and four white grape cultivars from various wine growing regions of Turkey. Phenolics were quantified using an HPLC method optimized for the separation of wine phenolics. Wine samples contained higher phenolics levels than the corresponding musts. With the exception of Semillion, white wines and musts contained lower concentrations of phenolics than red wines and musts. However, the white cultivar Semillion had the highest concentrations of catechin and epicatechin among all wine and must samples. Semillion wine catechin and epicatechin were 13.7 and 11.8 mg/L, respectively. The highest level of trans-resveratrol among the white cultivars was found in Narince wine (1.93 mg/L). Within the red wine and must cultivars, Bo?azkere, Öküzgozü, and Cabernet contained the highest concentrations of flavan-3-ols and trans-resveratrol. Catechin was the major phenolic in all wines and most musts. Epicatechin was the major phenolic in 6 of the 11 must samples, but none of the wine samples. trans-Resveratrol was generally found in lowest concentrations in both wines and musts.     

Evaluation of different Saccharomyces cerevisiae strains for red winemaking. Influence on the anthocyanin,pyranoanthocyanin and non-anthocyanin phenolic content and colour characteristics of wines

The possible industrial use of three previously-selected Saccharomyces cerevisiae strains (1EV, 2EV and 7EV) has been studied in musts derived from Tempranillo and Cabernet Sauvignon. The anthocyanin, pyranoanthocyanin and non-anthocyanin phenolic content, and colour characteristics of the resulting wines have been compared to those of a commercial strain. Anthocyanins were the compounds most influenced by the yeast strain. Independently of the grape variety, wines derived from 2EV presented significantly higher anthocyanin concentrations than those derived from 1EV and 7EV, which presented similar contents. With the exception of hydroxycinnamic acids and derivatives, no particular influence of the yeast strain was observed on the remaining non-anthocyanin phenolic compounds (i.e, hydroxybenzoic acids and flavanols). Pyranoanthocyanins and metabolites resulting from the alcoholic fermentation such as tyrosol and tryptophol, seemed to be more influenced by the must composition and pH, and thus, by the grape variety, than by the yeast strain.     

Resveratrol content in wines and musts from the south of Spain

Trans- and cis-resveratrol and their glycosides have been determined in eighty-one samples including musts, substrate wines and commercial wines (red, white and Sherry-type wines) from the south of Spain. Sample analysis was performed using a direct injection technique by HPLC with photodiode array detector. Prior to the injection, the sample was filtered using a filter selected through a complete filtration study. Climatological data can affect total resveratrol levels. Values obtained for total resveratrol content in red wines ranged from 0.038 mg/l in a dry year to 1.164 mg/l for a normal year. The pressure applied to the berries to obtain must, has been object of study in order to ascertain its influence in final resveratrol content. For the same vintage, the total resveratrol content ranged from 0.032 mg/l in a wine, obtained from the lighest pressure musts, to 0.873 mg/l for those obtained from the highest pressure musts. No resveratrol has been found in Sherry wines, being present in the substrate wines in all cases.     

Fermentation kinetics and chemical characterisation of vino tostado,a traditional sweet wine from Galicia (NW Spain)

BACKGROUND: Grapes after harvesting are air dried and pressed in order to concentrate sugars, acids and flavour compounds to produce vino tostado (toasted wine), a wine with intense aroma and flavour notes and high residual sugar concentration. In order to get a better knowledge of the difficulties involved, several fermentations were conducted at 12 and 28 °C using 0, 15 and 30 g hL^?1 ammonium sulfate and 0, 25 and 50 g hL^?1 exogenous commercial yeast (Saccharomyces cerevisiae var. bayanus) to study the kinetics of sugar consumption and ethanol, acetic acid and glycerol production. RESULTS: Fermentation kinetic parameters were calculated and metal concentrations and antioxidant activity were analysed. CONCLUSION: The spontaneous fermentation at 12 °C and all fermentations conducted with the commercial yeast gave vino tostado of adequate quality, while the spontaneous fermentation at 28 °C was sluggish. High‐temperature fermentations led to sweeter wines with higher volumetric productivities, although low‐temperature fermentations produced better wines in terms of higher glycerol and lower acetic acid levels. Fructose was the only sugar to be consumed during spontaneous fermentations, while both glucose and fructose were consumed during fermentations of the inoculated musts, with preference for each monosaccharide depending on temperature. Copyright © 2009 Society of Chemical Industry