Bactericidal effects of Lactobacillus reuteri and allyl isothiocyanate on Escherichia coli O157:H7 in refrigerated ground beef

Two naturally occurring antimicrobial agents were tested in packages of refrigerated ground beef for their ability to reduce the viability of Escherichia coli O157:H7 during storage. Allyl isothiocyanate (AITC) and Lactobacillus reuteri were tested separately and together for their action against a cocktail of five strains of E. coli O157:H7 in ground beef held at 4 degrees C for 25 days. Ground beef prepared from whole, raw inside round beef roasts was inoculated with low (3 log CFU/g) or high (6 log CFU/g) levels of the E. coli O157:H7 mixture. The beef was treated with AITC (about 1,300 ppm), L. reuteri, or both, along with 250 mM of glycerol per kg of meat at two levels (3 and 6 log CFU/g) and according to a design that yielded 8 controls plus 10 different treatments. Samples were analyzed for E. coli O157:H7 survivors, numbers of total bacteria, and lactic acid bacteria on days 0 to 25 at 5-day intervals. L. reuteri at both input levels with glycerol killed E. coli O157:H7 at both inoculated levels before day 20. AITC completely eliminated E. coli O157:H7 at the low-inoculum level (3 log CFU/g) and reduced viability >4.5 log CFU/g at the high-inoculum level (6 log CFU/g) by the end of the storage period. The combination of L. reuteri and AITC did not yield an additive effect against E. coli O157:H7 viability. L. reuteri in the presence of glycerol was highly effective against E. coli O157:H7 in ground beef during refrigerated storage (4 degrees C) in modified atmosphere packages. Sensory testing is planned to evaluate effects of treatments.     

Antimicrobial activity of reuterin in combination with nisin against food-borne pathogens

Antimicrobial activity of reuterin individually or in combination with nisin against different food-borne Gram-positive and Gram-negative pathogens in milk was investigated. Reuterin (8 AU/ml) exhibited bacteriostatic activity against Listeria monocytogenes, whereas its activity was slightly bactericidal against Staphylococcus aureus at 37 degrees C. Higher bactericidal activity was detected against Escherichia coli O157:H7, Salmonella choleraesuis subsp. choleraesuis, Yersinia enterocolitica, Aeromonas hydrophila subsp. hydrophila and Campylobacter jejuni. A significant synergistic effect on L. monocytogenes and a slight additive effect on S. aureus after 24 h at 37 degrees C were observed when reuterin was combined with nisin (100 IU/ml). The combination of reuterin with nisin did not enhance the antimicrobial effect of reuterin against Gram-negative pathogens.     

Antimicrobial effect of herb extracts against Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella typhimurium associated with beef

The effects of plant extracts against pathogenic bacteria in vitro are well known, yet few studies have addressed the effects of these compounds against pathogens associated with muscle foods. A series of experiments was conducted to determine the effectiveness of a commercially available, generally recognized as safe, herb extract dispersed in sodium citrate (Protecta One) or sodium chloride (Protecta Two) against Escherichia coli O157:H7, Salmonella typhimurium, and Listeria monocytogenes associated with beef. In the first experiment, E. coli O157:H7, Salmonella typhimurium, and L. monocytogenes inoculated onto beef and subjected to surface spray treatments with 2.5% solutions of Protecta One or Protecta Two were not affected by immediate application (day 0) of the herbal extracts. However, after 7 days of storage at 4 degrees C, E. coli O157:H7 was reduced by >1.3 log10 CFU/cm2 by Protecta Two; L. monocytogenes was reduced by 1.8 and 1.9 log10 CFU/cm2 by Protecta One and Protecta Two, respectively; Salmonella typhimurium was not reduced >0.3 log10 CFU/cm2 by either extract by day 7. In the second experiment, 2.5% Protecta Two (wt/vol or wt/wt) added to inoculated lean and adipose beef trim, processed, and packaged as ground beef chubs (80% lean, 20% adipose), did not reduce pathogen populations >0.5 log10 CFU/g up to 14 days at 4 degrees C. In the third experiment, surface spray treatments of beef with 2.5% lactic acid or 2.5% solutions of Protecta One or Protecta Two, vacuum packaged, and stored up to 35 days at 4 degrees C did reduce E. coli O157:H7, L. monocytogenes, and Salmonella Typhimurium slightly. These studies suggest that the use of herb extracts may afford some reductions of pathogens on beef surfaces; however, the antimicrobial activity may be diminished in ground beef by adipose components.     

Growth and survival of Escherichia coli O157:H7 and Listeria monocytogenes in egg products held at different temperatures

Growth and survival of Escherichia coli O157:H7 and Listeria monocytogenes in steamed eggs and scrambled eggs held at different temperatures (5, 18, 22, 37, 55, and 60 degrees C) were investigated in the present study. Among the holding temperatures tested, both pathogens multiplied best at 37 degrees C followed by 22, 18, and 5 degrees C. In general, E. coli O157:H7 grew better in the egg products than L. monocytogenes did at all the storage temperatures tested except at 5 degrees C. E. coli O157:H7 did not grow in steamed eggs and scrambled eggs held at 5 degrees C. L. monocytogenes showed a slight population increase of approximately 0.6 to 0.9 log CFU/g in these egg products at the end of the 36-h storage period at 5 degrees C. The population of both pathogens detected in the egg products was affected by the initial population, holding temperature, and length of the holding period. It was also noted that L. monocytogenes was more susceptible than E. coli O157:H7 in steamed eggs held at 60 degrees C. After holding at 60 degrees C for 1 h, no detectable viable cells of L. monocytogenes with a population reduction of 5.4 log CFU/g was observed in steamed eggs, whereas a lower population reduction of only approximately 0.5 log CFU/ml was noted for E. coli O157:H7.     

Spread of bacterial pathogens during preparation of freshly squeezed orange juice

To study the potential of three bacterial pathogens to cross-contaminate orange juice during extraction, normal operation conditions during juice preparation at food service establishments were simulated. The spread of Salmonella enterica serovar Typhimurium, Escherichia coli O157:H7, and Listeria monocytogenes from inoculated oranges to work surfaces and to the final product was determined. The transference of these three bacterial pathogens to orange juice made from uninoculated oranges with the use of contaminated utensils was also studied. Fresh oranges were inoculated with a marker strain of rifampicin-resistant Salmonella Typhimurium, E. coli O157:H7, or L. monocytogenes. Final pathogen levels in juice were compared as a function of the use of electric or mechanical juice extractors to squeeze orange juice from inoculated oranges. Pathogen populations on different contact surfaces during orange juice extraction were determined on sulfite-phenol red-rifampicin plates for Salmonella Typhimurium and E. coli O157:H7 and on tryptic soy agar supplemented with 0.1 g of rifampicin per liter for L. monocytogenes. After inoculation, the average pathogen counts for the orange rind surface were 2.3 log10 CFU/cm2 for Salmonella Typhimurium, 3.6 log10 CFU/cm2 for E. coli O157:H7, and 4.4 log10 CFU/cm2 for L. monocytogenes. This contamination was spread over all utensils used in orange juice squeezing. Mean pathogen counts for the cutting board, the knife, and the extractor ranged from -0.3 to 2.1 log10 CFU/cm2, and the juice contained 1.0 log10 CFU of Salmonella Typhimurium per ml, 2.3 log10 CFU of E. coli O157:H7 per ml, and 2.7 log10 CFU of L. monocytogenes per ml. Contact with contaminated surfaces resulted in the presence of all pathogens in orange juice made from uninoculated oranges. These results give emphasis to the importance of fresh oranges as a source of pathogens in orange juice.     

Effects of recovery, plating, and inoculation methods on quantification of Escherichia coli O157:H7 and Listeria monocytogenes from strawberries

Effects of different recovery and inoculation methods on quantification of Escherichia coli O157:H7 and Listeria monocytogenes from strawberries were studied. Strawberries were spot or dip inoculated with 7 to 8 log CFU per strawberry of each pathogen, air dried for 2 h, and stored for 1, 3, and 7 days at 4 degrees C. The inoculated samples were stomached or washed with phosphate-buffered saline (PBS; pH 7.2) or with modified PBS (pH 8.4). Bacterial levels were determined using a direct selective plating, thin agar layer plating, or membrane-transferring plating (MTP) with tryptic soy agar and sorbital MacConkey agar (E. coli O157:H7) or modified Oxford agar (L. monocytogenes). Under most test conditions, washing with PBS followed by MTP had significantly higher (P < 0.05) recovery for both bacteria compared with other tested methods. Within a 7-day storage period for spot-inoculated strawberries, a stomaching step resulted in an injury of 0.9 to 1.4 log CFU for E. coli O157: H7 and 1.4 to 1.7 log CFU for L. monocytogenes. When a washing step was used instead, this resulted in an injury of only 0.2 to 0.6 log CFU for E. coli O157:H7 and 0.2 to 0.7 log CFU for L. monocytogenes. Both bacteria could survive on strawberry surfaces, but their recovered levels decreased with the increase of storage time at 4 degrees C for both spot and dip inoculation methods. Dip inoculation generally had a lower recovery than spot inoculation. An ideal protocol to recover and enumerate E. coli O157:H7 and L. monocytogenes from strawberries involved shaking and washing samples with 100 ml of PBS for 15 min at 22 degrees C coupled with a MTP enumeration method.     

Fate of Escherichia coli O157:H7 and Listeria monocytogenes in strawberry juice and acidified media at different pH values and temperatures

Survival and growth of Escherichia coli O157:H7 and Listeria monocytogenes in strawberry juice and acidified media at different pH levels (pH 3.4 to 6.8) and temperatures were studied. Sterile strawberry juice (pH 3.6) and acidified trypticase soy broth (TSB) media (pH 3.4 to 6.8) were inoculated with approximately 6.7 log CFU/ml E. coli O157:H7 or 7.3 log CFU/ ml L. monocytogenes, incubated for 3 days at 4 and 37 degrees C. Bacterial levels were determined after 2 h, 1 day, and 3 days using surface plating nonselectively on tryptic soy agar and selectively on sorbitol MacConkey agar for E. coli O157:H7 or modified Oxford agar for L. monocytogenes. A spectrophotometer (660 nm) was also used to study growth inhibition of L. monocytogenes in different TSB and strawberry juice media (pH 3.4 to 7.3). E. coli O157:H7 survived well at pH values of 3.4 to 6.8 at 4 degrees C, but the number of injured cells increased as pH decreased and incubation time increased. At 37 degrees C, E. coli O157:H7 was inactivated at pH of < or = 3.6 but could grow at pH 4.7. L. monocytogenes was quickly injured at pH of < or = 4.7 within 2 h of storage at 4 degrees C and then was slightly and gradually inactivated as storage time increased. L. monocytogenes survived well at pH 6.8 at 4 degrees C and grew well at 37 degrees C. Growth of L. monocytogenes at 37 degrees C was inhibited in TSB by 1% citric acid and 0.5% malic acids at pH 3.4 or by 50% strawberry juice at pH 4.7. Bacterial injury and inactivation appeared to be induced by the acids in strawberry juice. The acids, pH value, temperature, and time were important factors for bacterial survival, inactivation, and growth in the media tested.     

Treatments using hot water instead of lactic acid reduce levels of aerobic bacteria and Enterobacteriaceae and reduce the prevalence of Escherichia coil O157:H7 on preevisceration beef carcasses

Lactic acid has become the most commonly used organic acid for treatment of postevisceration beef carcasses. Many processors have also implemented 2% lactic acid washes on preevisceration carcasses. We previously demonstrated that hot water washing and steam vacuuming are effective carcass interventions. Because of the effectiveness of hot water, we compared its use with that of lactic acid as a preevisceration wash in a commercial setting. A commercial hot water carcass wash cabinet applying 74 degrees C (165 degrees F) water for 5.5 s reduced both aerobic plate counts and Enterobacteriaceae counts by 2.7 log CFU/100 cm2 on preevisceration carcasses. A commercial lactic acid spray cabinet that applied 2% L-lactic acid at approximately 42 degrees C (105 to 110 degrees F) to preevisceration carcasses reduced aerobic plate counts by 1.6 log CFU/100 cm2 and Enterobacteriaceae counts by 1.0 log CFU/100 cm2. When the two cabinets were in use sequentially, i.e., hot water followed by lactic acid, aerobic plate counts were reduced by 2.2 log CFU/100 cm2 and Enterobacteriaceae counts were reduced by 2.5 log CFU/100 cm2. Hot water treatments reduced Escherichia coli O157:H7 prevalence by 81%, and lactic acid treatments reduced E. coli O157:H7 prevalence by 35%, but the two treatments in combination produced a 79% reduction in E. coli O157:H7, a result that was no better than that achieved with hot water alone. These results suggest that hot water would be more beneficial than lactic acid for decontamination of preevisceration beef carcasses.     

Efficacy of cetylpyridinium chloride in immersion treatment for reducing populations of pathogenic bacteria on fresh-cut vegetables.

The efficacy of cetylpyridinium chloride (CPC) immersion to reduce the numbers of three pathogenic bacteria (Listeria monocytogenes, Salmonella Typhimurium, and Escherichia coli O157:H7) on three different fresh-cut vegetables (broccoli, cauliflower, and radishes) was studied. The fresh-cut vegetables were inoculated with one of the three pathogenic bacteria at a concentration of 10(5) CFU/ml for 1 h at room temperature and then treated with 0.1 or 0.5% CPC immersion for 1 min. Both Salmonella Typhimurium and E. coli O157:H7 plates were incubated from 48 to 72 h at 37 degrees C, and L. monocytogenes plates were incubated from 72 to 96 h before being counted. The results of three experiments showed that for the average of the three vegetables treated with 0.1 and 0.5% CPC, L. monocytogenes was reduced by 2.85 and 3.70 log CFU/g, Salmonella Typhimurium by 2.37 and 3.15 log CFU/g, and E. coli O157:H7 by 1.01 and 1.56 log CFU/g, respectively, in comparison with the vegetables treated with water only. The 0.5% CPC treatment was significantly different (P < 0.05) from the 0.1% CPC treatment on reduction of L. monocytogenes, Salmonella Typhimurium, and E. coli O157:H7. The CPC residual on the treated vegetables and their washing solutions were evaluated by using high-performance liquid chromatography.     

Inactivation of Escherichia coli O157:H7 and Listeria monocytogenes on plastic kitchen cutting boards by electrolyzed oxidizing water.

One milliliter of culture containing a five-strain mixture of Escherichia coli O157:H7 (approximately 10(10) CFU) was inoculated on a 100-cm2 area marked on unscarred cutting boards. Following inoculation, the boards were air-dried under a laminar flow hood for 1 h, immersed in 2 liters of electrolyzed oxidizing water or sterile deionized water at 23 degrees C or 35 degrees C for 10 or 20 min; 45 degrees C for 5 or 10 min; or 55 degrees C for 5 min. After each temperature-time combination, the surviving population of the pathogen on cutting boards and in soaking water was determined. Soaking of inoculated cutting boards in electrolyzed oxidizing water reduced E. coli O157:H7 populations by > or = 5.0 log CFU/100 cm2 on cutting boards. However, immersion of cutting boards in deionized water decreased the pathogen count only by 1.0 to 1.5 log CFU/100 cm2. Treatment of cutting boards inoculated with Listeria monocytogenes in electrolyzed oxidizing water at selected temperature-time combinations (23 degrees C for 20 min, 35 degrees C for 10 min, and 45 degrees C for 10 min) substantially reduced the populations of L. monocytogenes in comparison to the counts recovered from the boards immersed in deionized water. E. coli O157:H7 and L. monocytogenes were not detected in electrolyzed oxidizing water after soaking treatment, whereas the pathogens survived in the deionized water used for soaking the cutting boards. This study revealed that immersion of kitchen cutting boards in electrolyzed oxidizing water could be used as an effective method for inactivating foodborne pathogens on smooth, plastic cutting boards.     

Reduction of Listeria monocytogenes and Escherichia coli O157:H7 numbers on vacuum-packaged fresh beef treated with nisin or nisin combined with EDTA.

Nisin or nisin combined with EDTA was used to treat fresh beef. Beef cubes (2.5 by 2.5 by 2.5 cm) that were inoculated with approximately 7 log CFU/ml of Listeria monocytogenes Scott A or Escherichia coli O157:H7 505 B were dipped in the following solutions: (i) H2O, (ii) HCl, (iii) nisin, (iv) EDTA, or (v) nisin combined with EDTA, respectively, for 10 min each, with an exception of one set of control beef samples without treatment. Beef samples were then drip-dried for 15 min, vacuum packaged, and stored at 4 degrees C for up to 30 days. The pH on beef after different treatments was not a key factor in preventing bacterial growth. Treatment with nisin or with nisin combined with EDTA reduced the population of L. monocytogenes by 2.01 and 0.99 log CFU/cm2 as compared to the control, respectively, under the conditions of vacuum package and storage at 4 degrees C for up to 30 days. However, the effect of nisin and nisin combined with EDTA against E. coli O157:H7 505 B was marginal at 1.02 log CFU/cm2 and 0.8 log CFU/cm2 reductions, respectively.     

Inactivation of Escherichia coli O157: H7 and Listeria monocytogenes by PR-26, a synthetic antibacterial peptide.

This study reports the antibacterial effect of PR-26, a synthetic peptide derived from the first 26 amino acid sequence of PR-39, an antimicrobial peptide isolated from porcine neutrophils. A three-strain mixture of Escherichia coli O157:H7 or Listeria monocytogenes of approximately 10(8) CFU was inoculated to a final concentration of 10(7) CFU/ml in 1% peptone water (pH 7.0), containing 50 or 75 microg/ml of PR-26, and incubated at 37 degrees C for 0, 6, 12, and 24 h; at 24 degrees C for 0, 12, 24, and 36 h; or at 10 or 4 degrees C for 0, 24, 72, and 120 h. Control samples included 1% peptone water inoculated with each pathogen mixture but containing no PR-26. The surviving population of each pathogen at each sampling time was determined by plating on tryptic soy agar with incubation at 37 degrees C for 24 h. At 37 degrees C, PR-26 decreased E. coli O157:H7 and L. monocytogenes populations by >5.0 log CFU/ml at 12 h, with complete inactivation at 24 h. At 24 degrees C, PR-26 reduced E. coli O157:H7 and L. monocytogenes by approximately 3.5, 4.0, and 4.5 log CFU/ml at the end of 12-, 24-, and 36-h incubations, respectively. At 4 and 10 degrees C, the inhibitory effect of PR-26 on E. coli O157:H7 and L. monocytogenes was significantly lower (P < 0.05) than that at 37 and 24 degrees C: a 2- to 3-log CFU/ml reduction was observed at 120-h incubation. Results indicate that PR-26 could potentially be used as an antimicrobial agent, but applications in appropriate foods need to be validated.     

Effects of cetylpyridinium chloride, acidified sodium chlorite, and potassium sorbate on populations of Escherichia coli O157:H7, Listeria monocytogenes, and Staphylococcus aureus on fresh beef

The effects of selected food-grade antimicrobial agents at decreasing the number of pathogenic bacteria on fresh beef were determined. Beef cubes inoculated with Escherichia coli O157:H7, Listeria monocytogenes, or Staphylococcus aureus were sprayed with 0.5% cetylpyridinium chloride (CPC), 0.12% acidified sodium chlorite (ASC), 0.1% potassium sorbate (PS), or an equal mix of any two solutions. The beef samples were placed on absorbent tray pads sprayed with each single or mixed solution, wrapped with polyvinyl chloride film, heat sealed, and stored at 4 degrees C for 2 weeks. Surface sanitization using CPC, ASC, or an equal mix of these two agents effectively reduced microbial numbers on the beef during storage. At day 0, ASC and the CPC-ASC mix reduced the number of E. coli O157:H7 by 2.50 and 1.58 log CFU/cm2, respectively. CPC demonstrated a 3.25-log reduction of L. monocytogenes and a 4.70-log reduction of S. aureus at 14 days. The CPC-PS mix reduced E. coli O157:H7 numbers by 1.46, L. monocytogenes by 2.95, and S. aureus by 4.41 log CFU/cm2 at 14 days. PS alone and the mixed solutions, CPC-ASC, CPC-PS, or ASC-PS, were not as effective as ASC or CPC alone. To effectively reduce E. coli O157:H7, L. monocytogenes, or S. aureus numbers, higher (> 0.1%) concentrations of PS were necessary. Loss of redness and light color of beef surfaces consistently coincided with decreases in pH for ASC-treated beef samples.     

Use of hydrogen peroxide in combination with nisin, sodium lactate and citric acid for reducing transfer of bacterial pathogens from whole melon surfaces to fresh-cut pieces

Hydrogen peroxide (2.5%) alone or hydrogen peroxide (1%) in combination with nisin (25 microg/ml), sodium lactate (1%), and citric acid (0.5%) (HPLNC) were investigated as potential sanitizers for reducing Escherichia coli O157:H7 or Listeria monocytogenes populations on whole cantaloupe and honeydew melons. Whole cantaloupes inoculated with E. coli O157:H7 and L. monocytogenes at 5.27 and 4.07 log10 CFU/cm2, respectively, and whole honeydew melons inoculated with E. coli O157:H7 and L. monocytogenes at 3.45 and 3.05 log10 CFU/cm2, respectively, were stored at 5 degrees C for 7 days. Antimicrobial washing treatments were applied to inoculated whole melons on days 0 or 7 of storage and surviving bacterial populations and the numbers transferred to fresh-cut pieces were determined. At days 0 and 7 treatment with HPLNC significantly (p<0.05) reduced the numbers of both pathogens, by 3 to 4 log CFU/cm2 on both types of whole melon. Treatment with HPLNC was significantly (p<0.05) more effective than treatment with 2.5% hydrogen peroxide. While fresh-cut pieces prepared from stored whole melons were negative for the pathogens by both direct plating and by enrichment, fresh-cut pieces from cantaloupe melons treated with 2.5% hydrogen peroxide were positive for both pathogens and pieces from honeydew melons were positive for E. coli 0157:H7. The native microflora on fresh-cut melons were also substantially reduced by HPLNC treatment of whole melons. The results suggest that HPLNC could be used to decontaminate whole melon surfaces and so improve the microbial safety and quality of fresh-cut melons.     

Survival of Salmonella, Escherichia coli O157:H7, and Listeria monocytogenes on Inoculated Almonds and Pistachios Stored at -19, 4, and 24° C

The survival of Salmonella, Escherichia coli O157:H7, and Listeria monocytogenes was determined on almonds and pistachios held at typical storage temperatures. Almond kernels and inshell pistachios were inoculated with four- to six-strain cocktails of nalidixic acid-resistant Salmonella, E. coli O157:H7, or L. monocytogenes at 6 log CFU/g and then dried for 72 h. After drying, inoculated nuts were stored at -19, 4, or 24°C for up to 12 months. During the initial drying period after inoculation, levels of all pathogens declined by 1 to -log CFU/g on both almonds and pistachios. During storage, moisture content (4.8%) and water activity (0.4) of the almonds and pistachios were consistent at -19°C; increased slowly to 6% and 0.6, respectively, at 4°C; and fluctuated from 4 to 5% and 0.3 to 0.5 at 24°C, respectively. Every 1 or 2 months, levels of each pathogen were enumerated by plating; samples were enriched when levels fell below the limit of detection. No reduction in population level was observed at -19 or 4°C for either pathogen, with the exception of E. coli O157:H7-inoculated almonds stored at 4°C (decline of 0.09 log CFU/g/month). At 24°C, initial rates of decline were 0.20, 0.60, and 0.71 log CFU/g/month on almonds and 0.15, 0.35, and 0.86 log CFU/g/month on pistachios for Salmonella, E. coli O157:H7, and L. monocytogenes, respectively, but distinct tailing of the survival curves was noted for both E. coli O157:H7 and L. monocytogenes.     

Comparative survival of Salmonella typhimurium DT 104, Listeria monocytogenes, and Escherichia coli O157:H7 in preservative-free apple cider and simulated gastric fluid

This study compared the survival of three-strain mixtures (ca. 10(7) CFU ml(-1) each) of Salmonella typhimurium DT104, Listeria monocytogenes, and Escherichia coli O157:H7 in pasteurized and unpasteurized preservative-free apple cider (pH 3.3-3.5) during storage at 4 and 10 degrees C for up to 21 days. S. typhimurium DT104 populations decreased by <4.5 log10 CFU ml(-1) during 14 days storage at 4 and 10 degrees C in pasteurized cider, and by > or =5.5 log10 CFU ml(-1) during 14 days in unpasteurized cider stored at these temperatures. However, after 7 days at 4 degrees C, the S. typhimurium DT104 populations had decreased by only about 2.5 log10 CFU ml(-1) in both pasteurized and unpasteurized cider. Listeria monocytogenes populations decreased below the plating detection limit (10 CFU ml(-1)) within 2 days under all conditions tested. Survival of E. coli O157:H7 was similar to that of S. typhimurium DT104 in pasteurized cider at both 4 and 10 degrees C over the 21-days storage period, but E. coli O157:H7 survived better (ca. 5.0 log10 CFU ml(-1) decrease) than S. typhimurium DT104 (> 7.0 log10 CFU ml(-1) decrease) after 14 days at 4 degrees C in unpasteurized cider. In related experiments, when incubated in simulated gastric fluid (pH 1.5) at 37 degrees C, S. typhimurium DT104 and L. monocytogenes were eliminated (5.5-6.0 log10 CFU ml(-1) decrease) within 5 and 30 min, respectively, whereas E. coli O157:H7 concentrations decreased only 1.60-2.80 log10 CFU ml(-1) within 2 h.     

Fate of Escherichia coli O157:H7, Salmonella typhimurium DT 104, and Listeria monocytogenes in fresh meat decontamination fluids at 4 and 10 degrees C.

Bacterial pathogens may colonize meat plants and increase food safety risks following survival, stress hardening, or proliferation in meat decontamination fluids (washings). The objective of this study was to evaluate the ability of Escherichia coli O157:H7, Salmonella Typhimurium DT 104, and Listeria monocytogenes to survive or grow in spray-washing fluids from fresh beef top rounds sprayed with water (10 or 85 degrees C) or acid solutions (2% lactic or acetic acid, 55 degrees C) during storage of the washings at 4 or 10 degrees C in air to simulate plant conditions. Inoculated Salmonella Typhimurium DT 104 (5.4 +/- 0.1 log CFU/ml) died off in lactate (pH 2.4 +/- 0.1) and acetate (pH 3.1 +/- 0.2) washings by 2 days at either storage temperature. In contrast, inoculated E. coli O157:H7 (5.2 +/- 0.1 log CFU/ml) and L. monocytogenes (5.4 +/- 0.1 log CFU/ml) survived in lactate washings for at least 2 days and in acetate washings for at least 7 and 4 days, respectively; their survival was better in acidic washings stored at 4 degrees C than at 10 degrees C. All inoculated pathogens survived in nonacid (pH > 6.0) washings, but their fate was different. E. coli O157:H7 did not grow at either temperature in water washings, whereas Salmonella Typhimurium DT 104 failed to multiply at 4 degrees C but increased by approximately 2 logs at 10 degrees C. L. monocytogenes multiplied (0.6 to 1.3 logs) at both temperatures in water washings. These results indicated that bacterial pathogens may survive for several days in acidic, and proliferate in water, washings of meat, serving as potential cross-contamination sources, if pathogen niches are established in the plant. The responses of surviving pathogens in meat decontamination waste fluids to acid or other stresses need to be addressed to better evaluate potential food safety risks.     

Survival and growth of Listeria monocytogenes and enterohemorrhagic Escherichia coli O157:H7 in minimally processed artichokes

The ability of Listeria monocytogenes and Escherichia coli O157:H7 inoculated by immersion (at 4.6 and 5.5 log CFU/ g, respectively) to survive on artichokes during various stages of preparation was determined. Peeling, cutting, and disinfecting operations (immersion in 50 ppm of a free chlorine solution at 4 degrees C for 5 min) reduced populations of L. monocytogenes and E. coli O157:H7 by only 1.6 and 0.8 log units, respectively. An organic acid rinse (0.02% citric acid and 0.2% ascorbic acid) was more effective than a tap water rinse in removing these pathogens. Given the possibility of both pathogens being present on artichokes at the packaging stage, their behavior during the storage of minimally processed artichokes was investigated. For this purpose, batches of artichokes inoculated with L. monocytogenes or E. coli O157:H7 (at 5.5 and 5.2 log CFU/g, respectively) were packaged in P-Plus film bags and stored at 4 degrees C for 16 days. During this period, the equilibrium atmosphere composition and natural background microflora (mesophiles, psychrotrophs, anaerobes, and fecal coliforms) were also analyzed. For the two studied pathogens, the inoculum did not have any effect on the final atmospheric composition (10% O2, 13% CO2) or on the survival of the natural background microflora of the artichokes. L. monocytogenes was able to survive during the entire storage period in the inoculated batches, while the E. coli O157:H7 level increased by 1.5 log units in the inoculated batch during the storage period. The modified atmosphere was unable to control the behavior of either pathogen.     

Survival and growth characteristics of Escherichia coli O157:H7 in pasteurized and unpasteurized Cheddar cheese whey

The objective of this study was to determine the survival and growth characteristics of Escherichia coli O157:H7 in whey. A five-strain mixture of E. coli O157:H7 was inoculated into 100 ml of fresh, pasteurized or unpasteurized Cheddar cheese whey (pH 5.5) at 10(5) or 10(2) CFU/ml, and stored at 4, 10 or 15 degrees C. The population of E. coli O157:H7 (on Sorbitol MacConkey agar supplemented with 0.1% 4-methylumbelliferyl-beta-D-glucuronide) and lactic acid bacteria (on All Purpose Tween agar) were determined on days 0, 1, 4, 7, 14, 21 and 28. At all storage temperatures, survival of E. coli O157:H7 was significantly higher (P<0.01) in the pasteurized whey compared to that in the unpasteurized samples. At 10 and 15 degrees C, E. coli O157:H7 in pasteurized whey significantly (P<0.05) increased during the first week of storage, followed by a decrease thereafter. However at the same temperatures, E. coli O157:H7 exhibited a steady decline in the unpasteurized samples from day 0. At 4 degrees C, E. coli O157:H7 did not grow in pasteurized and unpasteurized whey; however, the pathogen persisted longer in pasteurized samples. At all the three storage temperatures, E. coli O157:H7 survived up to day 21 in the pasteurized and unpasteurized whey. The initial load of lactic acid bacteria in the unpasteurized whey samples was approximately 7.0 log10 CFU/ml and, by day 28, greater than 3.0 log10 CFU/ml of lactic acid bacteria survived in unpasteurized whey at all temperatures, with the highest counts recovered at 4 degrees C. Results indicate the potential risk of persistence of E. coli O157:H7 in whey in the event of contamination with this pathogen.     

Evaluation of Lactic Acid as an Initial and Secondary Subprimal Intervention for Escherichia coli O157:H7, Non-O157 Shiga Toxin-Producing E. coli, and a Nonpathogenic E. coli Surrogate for E. coli O157:H7

Lactic acid can reduce microbial contamination on beef carcass surfaces when used as a food safety intervention, but effectiveness when applied to the surface of chilled beef subprimal sections is not well documented. Studies characterizing bacterial reduction on subprimals after lactic acid treatment would be useful for validations of hazard analysis critical control point (HACCP) systems. The objective of this study was to validate initial use of lactic acid as a subprimal intervention during beef fabrication followed by a secondary application to vacuum-packaged product that was applied at industry operating parameters. Chilled beef subprimal sections (100 cm(2)) were either left uninoculated or were inoculated with 6 log CFU/cm(2) of a 5-strain mixture of Escherichia coli O157:H7, a 12-strain mixture of non-O157 Shiga toxin-producing E. coli (STEC), or a 5-strain mixture of nonpathogenic (biotype I) E. coli that are considered surrogates for E. coli O157:H7. Uninoculated and inoculated subprimal sections received only an initial or an initial and a second "rework" application of lactic acid in a custombuilt spray cabinet at 1 of 16 application parameters. After the initial spray, total inoculum counts were reduced from 6.0 log CFU/cm(2) to 3.6, 4.4, and 4.4 log CFU/cm(2) for the E. coli surrogates, E. coli O157:H7, and non-O157 STEC inoculation groups, respectively. After the second (rework) application, total inoculum counts were 2.6, 3.2, and 3.6 log CFU/cm(2) for the E. coli surrogates, E. coli O157:H7, and non-O157 STEC inoculation groups, respectively. Both the initial and secondary lactic acid treatments effectively reduced counts of pathogenic and nonpathogenic strains of E. coli and natural microflora on beef subprimals. These data will be useful to the meat industry as part of the HACCP validation process.