Cross-contamination of lettuce with Escherichia coli O157:H7

Contamination of produce by bacterial pathogens is an increasingly recognized problem. In March 1999, 72 patrons of a Nebraska restaurant were infected with enterohemorrhagic Escherichia coli (EHEC) O157:H7, and shredded iceberg lettuce was implicated as the food source. We simulated the restaurant's lettuce preparation procedure to determine the extent of possible EHEC cross-contamination and growth during handling. EHEC inoculation experiments were conducted to simulate the restaurant's cutting procedure and the subsequent storage of shredded lettuce in water in the refrigerator. All lettuce pieces were contaminated after 24 h of storage in inoculated water (2 x 10(9) CFU of EHEC per 3 liters of water) at room temperature or at 4 degrees C; EHEC levels associated with lettuce increased by > 1.5 logs on the second day of storage at 4 degrees C. All lettuce pieces were contaminated after 24 h of storage in water containing one inoculated lettuce piece (approximately 10(5) CFU of EHEC per lettuce piece) at both temperatures. The mixing of one inoculated dry lettuce piece with a large volume of dry lettuce, followed by storage at 4 degrees C or 25 degrees C for 20 h resulted in 100% contamination of the leaves tested. Microcolonies were observed on lettuce stored at 25 degrees C, while only single cells were seen on leaves stored at 4 degrees C, suggesting that bacterial growth had occurred at room temperature. Three water washes did not significantly decrease the number of contaminated leaves. Washing with 2,000 mg of calcium hypochlorite per liter significantly reduced the number of contaminated pieces but did not eliminate contamination on large numbers of leaves. Temperature abuse during storage at 25 degrees C for 20 h decreased the effectiveness of the calcium hypochlorite treatment, most likely because of bacterial growth during the storage period. These data indicate that storage of cut lettuce in water is not advisable and that strict attention must be paid to temperature control during the storage of cut lettuce.     

Fate of Escherichia coli O157:H7 in field-inoculated lettuce

Impact of drip and overhead sprinkler irrigation on the persistence of attenuated Escherichia coli O157:H7 in the lettuce phyllosphere was investigated using a split-plot design in four field trials conducted in the Salinas Valley, California, between summer 2007 and fall 2009. Rifampicin-resistant attenuated E. coli O157:H7 ATCC 700728 (BLS1) was inoculated onto the soil beds after seeding with a backpack sprayer or onto 2- or 4-week-old lettuce plant foliage with a spray bottle at a level of 7 log CFU ml⁻¹. When E. coli O157:H7 was inoculated onto 2-week-old plants, the organism was recovered by enrichment in 1 of 120 or 0 of 240 plants at 21 or 28 days post-inoculation, respectively. For the four trials where inoculum was applied to 4-week-old plants, the population size of E. coli O157:H7 declined rapidly and by day 7, counts were near or below the limit of detection (10 cells per plant) for 82% or more of the samples. However, in 3 out 4 field trials E. coli O157:H7 was still detected in lettuce plants by enrichment 4-weeks post-inoculation. Neither drip nor overhead sprinkler irrigation consistently influenced the survival of E. coli O157:H7 on lettuce.     

Comparative examination of Escherichia coli O157:H7 survival on romaine lettuce and in soil at two independent experimental sites

Little is known about the influence of abiotic factors such as climate and soil chemistry on the survival of Escherichia coli O157:H7 in field lettuce. We applied a nalidixic acid-resistant derivative of strain ATCC 700728 to field-grown romaine lettuce in two regions in Canada characterized by large variances in soil type and climate. Surviving populations in soil and on lettuce leaves were estimated on sorbitol MacConkey agar supplemented with nalidixic acid. Data were fitted with the Weibull decline function to permit comparison of decay rates in the two experimental sites. E. coli O157:H7 populations fell from 10? to <102 CFU/g on leaves, and <103 CFU/g in soil within 7 days after inoculation. Analysis revealed there was no significant difference between decay rates at the two experimental sites in either environment. The results of this study suggest that the inherent ecological fitness of E. coli O157:H7 ATCC 700728 determines the extent of survival in the production environment.     

Switchgrass extractives to mitigate Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium contamination of romaine lettuce at pre- and postharvest

The antimicrobial potential of switchgrass extractives (SE) was evaluated on cut lettuce leaves and romaine lettuce in planta, using rifampicin-resistant Escherichia coli O157:H7 and Salmonella Typhimurium strain LT2 as model pathogens. Cut lettuce leaves were swabbed with E. coli O157:H7 or S. Typhimurium followed by surface treatment with 0.8% SE, 0.6% sodium hypochlorite, or water for 1 to 45 min. For in planta studies, SE was swabbed on demarcated leaf surfaces either prior to or after inoculation of greenhouse-grown lettuce with E. coli O157:H7 or S. Typhimurium; the leaf samples were collected after 0, 24, and 48 h of treatment. Bacteria from inoculated leaves were enumerated on tryptic soy agar plates (and also on MacConkey's and XLT4 agar plates), and the recovered counts were statistically analyzed. Cut lettuce leaves showed E. coli O157:H7 reduction between 3.25 and 6.17 log CFU/leaf, whereas S. Typhimurium reductions were between 2.94 log CFU/leaf and 5.47 log CFU/leaf depending on the SE treatment durations, from initial levels of ∼7 log CFU/leaf. SE treatment of lettuce in planta, before bacterial inoculation, reduced E. coli O157:H7 and S. Typhimurium populations by 1.88 and 2.49 log CFU after 24 h and 3 h, respectively. However, SE treatment after bacterial inoculation of lettuce plants decreased E. coli O157:H7 populations by 3.04 log CFU (after 0 h) with negligible reduction of S. Typhimurium populations. Our findings demonstrate the potential of SE as a plant-based method for decontaminating E. coli O157:H7 on lettuce during pre- and postharvest stages in hurdle approaches.     

Persistence of Escherichia coli O157:H7 on lettuce plants following spray irrigation with contaminated water

Irrigation water collected at farms growing crops for human consumption was artificially contaminated with E. coli O157:H7 and used to irrigate lettuce plants. Plants in a growth chamber were spray irrigated either once or intermittently with water contaminated with 10(2) or 10(4) CFU of E. coli O157:H7 per ml and were then sampled over a 30-day period. Only plants exposed to 10(2) CFU/ml on day 1 did not harbor the pathogen at the end of the sampling period. All other treatments resulted in contaminated plants at harvest. Plants irrigated with 10(4) CFU/ml contained high levels (up to 5 log CFU/g) of the pathogen at harvest. The results obtained in this study underscore the assertion that spray irrigation (the application of water directly to plant leaves) is linked to the contamination of crops and suggest that repeated exposure increases the E. coli O157:H7 level on the plant.     

Influence of surfactant hydrophobicity on the detachment of Escherichia coli O157:H7 from lettuce

The influence of surfactant hydrophobicity on detachment of Escherichia coli O157:H7 from lettuce was determined. Lettuce pieces inoculated with the pathogen were rinsed with Tween and Span surfactants of different hydrophobicity. Of the Tweens, only Tween 85, the Tween with the lowest hydrophile/lipophile balance (HLB), significantly detached the pathogen from lettuce surface. Span 85 (the surfactant with the lowest HLB studied) exhibited the greatest ability among surfactants tested to detach cells from lettuce. This surfactant removed cells attached to the leaf cuticle but not to the cut edge, and caused no detectable reduction in viability of cells remaining on the lettuce. Treatment with Span 85 did not detach cells when they were allowed to attach in the presence of calcium ions. The combination of NaCl/NaHCO3 (pH 10) and Span 85 did not detach cells possibly due to reduced hydrophobicity of the Span at this pH. This study suggests that surfactants of low HLB disrupt hydrophobic interactions between E. coli O157:H7 and the lettuce surface but cannot cause release of cells adhering to hydrophilic structures such as cut or damaged tissue.     

Association of Escherichia coli O157:H7 with preharvest leaf lettuce upon exposure to contaminated irrigation water.

Recent foodborne outbreaks have linked infection by enterohemorrhagic Escherichia coli (EHEC) serotype O157:H7 to the consumption of contaminated lettuce. Contamination via food handler error and on-the-farm contamination are thought to be responsible for several outbreaks. Though recent studies have examined the application of EHEC to store-bought lettuce, little is known about the attachment of EHEC to growing plants. We investigated the association of lettuce seedlings with EHEC O157:H7 strains implicated in lettuce or fruit outbreaks using hydroponic and soil model systems. EHEC strains that express the green fluorescent protein were observed by stereomicroscopy and confocal laser scanning microscopy to determine adherence patterns on growing lettuce seedlings. Bacteria adhered preferentially to plant roots in both model systems and to seed coats in the hydroponic system. Two of five nonpathogenic E. coli strains showed decreased adherence to seedling roots in the hydroponic system. EHEC was associated with plants in as few as 3 days in soil, and contamination levels were dose-dependent. EHEC levels associated with young plants inoculated with a low dose suggested that the bacteria had multiplied. These data suggest that preharvest crop contamination via contaminated irrigation water can occur through plant roots.     

Chlorine inactivation of Escherichia coli O157:H7 in water

Six human isolates of Escherichia coli O157:H7 and E. coli (ATCC 11229) were used to determine the concentrations of free chlorine and exposure times required for inactivation. Free chlorine concentrations of 0.25, 0.5, 1.0, and 2.0 ppm at 23 degrees C were evaluated, with sampling times at 0, 0.5, 1.0, and 2.0 min. Results revealed that five of six E. coli O157:H7 isolates and the E. coli control strain were highly susceptible to chlorine, with >7 log10 CFU/ml reduction of each of these strains by 0.25 ppm free chlorine within 1 min. However, comparatively, one of the seven strains was unusually tolerant to chlorine at 23 degrees C for 1 min, with a 4-, 5.5-, 5.8-, and >5.8-log CFU/ml reduction at free chlorine concentrations (ppm) of 0.25, 0.5, 1.0, and 2.0. respectively. Based on these studies most isolates of E. coli O157:H7 have no unusual tolerance to chlorine; however, one strain was exceptional in being recovered after 1-min of exposure of 10(7) CFU/ml to 2.0 ppm of free chlorine. This isolate may be a useful reference strain for future studies on chlorine tolerance of E. coli O157:H7.     

Suspending lettuce type influences recoverability and radiation sensitivity of Escherichia coli O157:H7

An outbreak strain of Escherichia coli O157:H7 was inoculated onto closely related but structurally distinct types of lettuce (Lactuca sativa): Boston (butterhead lettuce), iceberg (crisphead lettuce), and green leaf and red leaf (colored variants of looseleaf lettuce). The E. coli O157:H7 was inoculated either onto the surface of cut leaf pieces or into a homogenized leaf suspension. Samples were gamma irradiated, and the radiation sensitivity of the inoculated bacteria was expressed as a D-value (the amount of ionizing radiation necessary to reduce the bacterial population by 90% [kGy]). The recovery of bacteria from nonirradiated leaf pieces was also measured. When inoculated onto the leaf surface, E. coli O157:H7 had significantly stronger radiation sensitivity on red leaf lettuce (D = 0.119 +/- 0.004 [standard error]) and green leaf lettuce (D = 0.123 +/- 0.003) than on iceberg lettuce (D = 0.136 +/- 0.004) or Boston lettuce (D = 0.140 +/- 0.003). When E. coli O157:H7 was inoculated into a homogenized leaf suspension, its sensitivity was significantly stronger on iceberg lettuce (D = 0.092 +/- 0.002) than on green leaf lettuce (D = 0.326 +/- 0.012), Boston lettuce (D = 0.331 +/- 0.009), or red leaf lettuce (D = 0.339 +/- 0.010), with a threefold difference. Significantly fewer bacteria were recovered from the surface of iceberg lettuce than from the surfaces of the other types of lettuce examined. Following radiation doses of up to 0.5 kGy, the texture (maximum shear strength) of lettuce leaves was measured along the midrib and along the leaf edge for each type of lettuce. There was no meaningful change in texture for any type of lettuce for either leaf section examined at any dose up to 0.5 kGy. These data show (i) that relatively subtle differences between lettuce types can significantly influence the radiation sensitivity of associated pathogenic bacteria and (ii) that doses of up to 0.5 kGy do not soften lettuce leaves.     

Effect of storage temperature and duration on the behavior of Escherichia coli O157:H7 on packaged fresh-cut salad containing romaine and iceberg lettuce

This study investigated the impact of storage temperature and duration on the fate of Escherichia coli O157:H7 on commercially packaged lettuce salads, and on product quality. Fresh-cut Romaine and Iceberg lettuce salads of different commercial brands were obtained from both retail and wholesale stores. The packages were cut open at one end, the lettuce salad inoculated with E. coli O157:H7 via a fine mist spray, and resealed with or without an initial N(2) flush to match the original package atmospheric levels. The products were stored at 5 and 12 °C until their labeled "Best If Used By" dates, and the microbial counts and product quality were monitored periodically. The results indicate that storage at 5 °C allowed E. coli O157:H7 to survive, but limited its growth, whereas storage at 12 °C facilitated the proliferation of E. coli O157:H7. There was more than 2.0 log CFU/g increase in E. coli O157:H7 populations on lettuce when held at 12 °C for 3 d, followed by additional growth during the remainder of the storage period. Although there was eventually a significant decline in visual quality of lettuce held at 12 °C, the quality of this lettuce was still fully acceptable when E. coli O157:H7 growth reached a statistically significant level. Therefore, maintaining fresh-cut products at 5 °C or below is critical for reducing the food safety risks as E. coli O157:H7 grows at a rapid, temperature-dependent rate prior to significant quality deterioration. PRACTICAL APPLICATION: Specific information regarding the effect of temperature on pathogen growth on leafy greens is needed to develop science-based food safety guidelines and practices by the regulatory agencies and produce industry. Temperature control is commonly thought to promote quality of leafy greens, not safety, based at least partially on a theory that product quality deterioration precedes pathogen growth at elevated temperatures. This prevalent attitude results in temperature abuse incidents being frequently overlooked in the supply chain. This study demonstrates that human pathogens, such as E. coli O157:H7, can grow significantly on commercially packaged lettuce salads while the product's visual quality is fully acceptable. Packaged fresh-cut salads are marketed as "ready-to-eat" while lacking an effective pathogen kill step during their preparation. Thus, maintaining storage temperature at 5 °C or below is critical to prevent pathogen proliferation and mitigate food safety risks should pathogen contamination inadvertently occur during crop growth or postharvest fresh-cut processing.     

A mathematical risk model for Escherichia coli O157:H7 cross-contamination of lettuce during processing

A stochastic simulation modelling approach was taken to determine the extent of Escherichia coli O157:H7 contamination in fresh-cut bagged lettuce leaving the processing plant. A probabilistic model was constructed in Excel to account for E. coli O157:H7 cross contamination when contaminated lettuce enters the processing line. Simulation of the model was performed using @Risk Palisade© Software, providing an estimate of concentration and prevalence in the final bags of product. Three different scenarios, named S1, S2, and S3, were considered to represent the initial concentration on the contaminated batch entering the processing line which corresponded to 0.01, 1 and 100 cfu/g, respectively. The model was satisfactorily validated based on Standard Error of Prediction (SEP), which ranged from 0.00-35%. ANOVA analysis performed on simulated data revealed that the initial concentration in the contaminated batch (i.e., S1, S2, and S3) did not influence significantly (p = 0.4) the E. coli O157:H7 levels in bags derived from cross contamination. In addition, significantly different (p < 0.001) prevalence was observed at the different levels simulated (S1; S2 and S3). At the lowest contamination level (0.01 cfu/g), bags were cross-contaminated sporadically, resulting in very low E. coli O157:H7 populations (mean: ≤2 cfu/bag) and prevalence levels (<1%). In contrast, higher average prevalence levels were obtained for S2 and S3 corresponding to 3.05 and 13.39%, respectively. Furthermore, the impact of different interventions on E. coli O157:H7 cross-contamination (e.g., pathogen testing, chlorination, irradiation, and cleaning and disinfection procedures) was evaluated. Model showed that the pathogen was able to survive and be present in the final bags in all simulated interventions scenarios although irradiation (0.5 KGy) was a more effective decontamination step in reducing prevalence than chlorination or pathogen testing under the same simulated conditions.     

Sanitation and design of lettuce coring knives for minimizing Escherichia coli O157:H7 contamination

This study was undertaken to examine the effect of ultrasound in combination with chlorine on the reduction of Escherichia coli O157:H7 populations on lettuce coring knives. Two new coring devices designed to mitigate pathogen attachment were fabricated and evaluated. The coring rings of the knives were dip inoculated with soil slurry containing 10? E. coli cells and treated with chlorinated water with and without ultrasonication for 30, 60, and 120 s. The rough welding joints on currently used in-field lettuce coring knives provided a site conducive to bacterial attachment and resistant to cell removal during sanitation treatment. The two modified coring knives harbored significantly fewer E. coli cells than did the currently used commercial model, and the efficacy of the disinfection treatment was high (P < 0.05). Ultrasound treatment reduced the E. coli O157:H7 counts to below the detection limit of 1.10 log CFU/cm2 at both the coring ring blade and welding joint within 30 s in 1 ppm of chlorinated water. The redesigned coring knives and an ultrasound plus chlorine combination treatment may provide practical options for minimizing the microbial safety hazards of lettuce processed by core-in-field operations.     

Effect of irrigation method on transmission to and persistence of Escherichia coli O157:H7 on lettuce

In this study, the transmission of Escherichia coli O157:H7 to lettuce plants through spray and surface irrigation was demonstrated. For all treatments combined, the number of plants testing positive following a single exposure to E. coli O157: H7 through spray irrigation (29 of 32 plants) was larger than the number testing positive following surface irrigation (6 of 32 plants). E. coli O157:H7 persisted on 9 of 11 plants for 20 days following spray irrigation with contaminated water. Immersion of harvested lettuce heads for 1 min in a 200 ppm chlorine solution did not eliminate all E. coli O157:H7 cells. The results of this study suggest that regardless of the irrigation method used, crops can become contaminated; therefore, the irrigation of food crops with water of unknown microbial quality should be avoided.     

Escherichia coli O157:H7 shedding in vaccinated beef calves born to cows vaccinated prepartum with Escherichia coli O157:H7 SRP vaccine

Extensive research, intervention equipment, money, and media coverage have been directed at controlling Escherichia coli O157:H7 in beef cattle. However, much of the focus has been on controlling this pathogen postcolonization. This study was conducted to examine the performance, health, and shedding characteristics of beef calves that were vaccinated with an E. coli O157:H7 SRP bacterial extract. These calves had been born to cows vaccinated prepartum with the same vaccine. Cows and calves were assigned randomly to one of four treatments: (i) neither cows nor calves vaccinated with E. coli O157:H7 SRP (CON), (ii) cows vaccinated with E. coli O157:H7 SRP prepartum but calves not vaccinated (COWVAC), (iii) calves vaccinated with E. coli O157:H7 SRP but born to cows not vaccinated (CALFVAC), (iv) cows vaccinated with E. coli O157:H7 SRP prepartum and calves also vaccinated (BOTH). Calves born to vaccinated cows had significantly higher titers of anti-E. coli O157:H7 SRP antibodies (SRPAb) in circulation at branding time (P < 0.001). Upon entry to the feedlot, overall fecal E. coli O157:H7 prevalence was 23 % among calves, with 25 % in the CON treatment group, 19 % in the CALFVAC group, 32 % in the COWVAC group, and 15 % in the BOTH group (P > 0.05). Fecal shedding of E. coli O157 on arrival to the feedlot was not correlated with fecal shedding at slaughter (Spearman's rho = -0.02; P = 0.91). No significant effects of cow or calf E. coli O157:H7 SRP vaccination treatment were found on feedlot calf health or performance (P > 0.05), prevalence of lung lesions or liver abscess (P > 0.05), or morbidity, retreatment, or mortality numbers (P > 0.05). The findings of this study indicate that the timing of vaccination of calves against E. coli O157:H7 may be an important consideration for maximizing the field efficacy of this vaccine.     

Isolation of Escherichia coli O157:H7 from foods in Greece

The presence of Escherichia coli O157:H7 in various foods of animal origin was surveyed in northwestern Greece. Six hundred samples of unpasteurized cows', ewes' and goats' milk, raw minced meat, uncooked frozen beef hamburgers, sandwiches (containing ham or turkey, mixed vegetable salad with mayonnaise and lettuce), fresh traditional Greek pork sausages and swine intestines appropriate for traditional Greek kokoretsi were assayed for E. coli serogroup O157:H7 using the standard cultural method and the immunomagnetic separation technique. The pathogen was detected in 1 out of 100 (1.0%) samples of ewes' milk, 1 out of 75 (1.3%) fresh sausages and 1 out of 50 (2.0%) swine intestines prepared for kokoretsi. The isolated strains were nonsorbitol fermenters, MUG-negative, O157 agglutinating, verotoxin-producing and carried both VT1 and VT2 genes. The three isolated strains were tested for antibiotic resistance and were found to be susceptible to eight antimicrobial agents (ampicillin, chloramphenicol, kanamycin, nalidixic acid, norfloxacin, streptomycin, sulfamethoxazole-trimethoprim and tetracycline).     

Assessment of Escherichia coli O157:H7 transference from soil to iceberg lettuce via a contaminated field coring harvesting knife

The potential for lettuce field-coring harvesting knives to cross-contaminate lettuce heads with pathogens was evaluated. Rings and blades of the harvest knives artificially contaminated with Escherichia coli O157:H7 (EHEC), were used to core three successive heads of iceberg lettuce. The coring rings and blades were inoculated by dipping into soils containing EHEC at concentration ranges of 1-10⁵ MPN/g soil. Factors that influenced EHEC transference from soil to iceberg lettuce via contaminated coring knife blade, included water content (WC) of clay and sandy soils, EHEC concentration, and degree of blade contact (stem, medium, and heavy) with edible tissue. High moisture content clay soil was positively associated with high pathogen transference. No EHEC were detected on any cut heads when clay soil contaminated with 10⁵ MPN/g EHEC had WC of 20% or less, or when the knife blade was dipped into sandy soil contaminated with EHEC at the same level, regardless of percent WC. The extent to which the harvesting knife blade cut across edible lettuce tissues was also an important factor in the amount of pathogen transference that occurred. EHEC were detectable on first and second sequentially cut lettuce heads when medium-contact was made between knife blade and edible tissues and on all three sequentially cut lettuce heads using the heavy-contact cutting scenario, when the blade was contaminated with 10⁴ cfu/g EHEC in clay soil (25% WC). However, when the blade, contaminated at the same soil EHEC level, was used to cut only the stem and had no contact with the edible portion of the lettuce head, no pathogen transference was detected. Under the current CIF harvesting practice, the cutting blade has a higher potential than the coring ring to be contaminated by the soil, but less opportunity to transfer pathogens to harvested lettuce. However, once contaminated, the coring ring has much higher potential than the blade to transfer pathogens to the harvested lettuce.     

Efficacy of adding detergents to sanitizer solutions for inactivation of Escherichia coli O157:H7 on Romaine lettuce

Numerous Escherichia coli O157:H7 outbreaks have been linked to consumption of fresh lettuce. The development of effective and easily implemented wash treatment could reduce such incidents. The purpose of this study was to evaluate the addition of food-grade detergents to sanitizer solutions for inactivation of E. coli O157:H7 on Romaine lettuce. Freshly-cut leaves of Romaine lettuce were dip-inoculated to achieve a final cell concentration of 7.8 ± 0.2 log CFU/g, air-dried for 2 h, and stored overnight at 4 °C. Leaves were then washed for 2 min in an experimental short chain fatty acid formulation (SCFA) or in one of the following solutions with or without 0.2% dodecylbenzenesulfonic acid or 0.2% sodium 2-ethyl hexyl sulfate: 1) deionized water; 2) 100 ppm chlorine dioxide; 3) 100 ppm chlorine; and 4) 200 ppm chlorine. Following wash treatment, samples were blended in neutralizing buffer (1:3) and surface plated on the selective media CT-SMAC. The efficacy of wash treatments, with or without the detergents, in inactivating E. coli O157:H7 cells on lettuce leaves were not significantly different. The most effective wash solution was SCFA, which was capable of reducing E. coli O157:H7 populations by more than 5 log CFU/g. The rest of the wash treatments resulted in a population reduction of less than 1 log CFU/g. The effectiveness of SCFA surpasses that of other sanitizer treatments tested in this study and requires further research to optimize treatments to preserve lettuce quality. Conventional detergents did not enhance the efficacy of any of the wash treatments tested during this study.     

Selection of recently isolated colicinogenic Escherichia coli strains inhibitory to Escherichia coli O157:H7

Escherichia coli strains were screened for their ability to inhibit E. coli O157:H7. An initial evaluation of 18 strains carrying previously characterized colicins determined that only colicin E7 inhibited all of the E. coli O157:H7 strains tested. A total of 540 strains that had recently been isolated from humans and nine different animal species (cats, cattle, chickens, deer, dogs, ducks, horses, pigs, and sheep) were tested by a flip-plating technique. Approximately 38% of these strains were found to inhibit noncolicinogenic E. coli K12 strains. The percentage of potentially colicinogenic E. coli per animal species ranged from 14% for horse isolates to 64% for sheep strains. Those isolates that inhibited E. coli K12 were screened against E. coli O157:H7, and 42 strains were found to be capable of inhibiting all 22 pathogenic strains tested. None of these 42 strains produced bacteriophages, and only 24 isolates inhibited serotype O157:H7 in liquid culture. The inhibitory activity of these strains was completely eliminated by treatment with proteinase K. When mixtures of these 24 colicinogenic strains were grown in anaerobic continuous culture, the four-strain E. coli O157:H7 population was reduced at a rate of 0.25 log10 cells per ml per h, which was fivefold faster than the washout rate. Two strains originally isolated from cat feces (F16) and human feces (H30) were identified by repetitive sequences polymerase chain reaction as the predominant isolates in continuous cultures. The results of this work indicate that animal species other than cattle can be sources of anti-O157 colicinogenic strains, and these results also lead to the identification of at least two isolates that could potentially be used in preharvest control strategies.     

Experimental use of a gas sensor-based instrument for differentiation of Escherichia coli O157:H7 from non-O157:H7 Escherichia coli field isolates

The rapid and economical detection of human pathogens in animal and food production systems would enhance food safety efforts. An instrument based on gas sensors coupled with an artificial neural network (ANN) was developed for the detection of and differentiation between laboratory isolates of Escherichia coli O157:H7 and non-O157:H7 E. coli. The purpose of this study was to use field isolates of E. coli to further evaluate the sensor system. This gas sensor-based, computer-controlled detection system was used to monitor gas emissions from 12 isolates of E. coli O157:H7 and 8 non-O157:H7 E. coli isolates. A standard concentration of each isolate was grown in 10 ml of nutrient broth at 37 degrees C for 16 h, and gas sampling was carried out every 5 min. Readings were continuously plotted to generate gas signatures. A back-propagation ANN algorithm was used to interpret the gas patterns. By analysis of the response of the ANN, the sensitivity and specificity of the instrument were calculated. Detectable differences between the gas signatures of the E. coli O157:H7 isolates and the non-O157:H7 isolates were observed. The instruments degree of sensitivity was high for E. coli O157:H7 isolates, but a lower degree of accuracy was observed for non-O157:H7 isolates because of increased strain variation. The sensitivity of the detection system was improved by the normalization of the data generated from the gas sensors. Because of its ability to detect differences in gas patterns, this instrument has a broad range of potential food safety applications.     

Quantitative determination of the role of lettuce leaf structures in protecting Escherichia coli O157:H7 from chlorine disinfection

Viability of Escherichia coli O157:H7 cells on lettuce leaves after 200 mg/liter (200 ppm) chlorine treatment and the role of lettuce leaf structures in protecting cells from chlorine inactivation were evaluated by confocal scanning microscopy (CSLM). Lettuce samples (2 by 2 cm) were inoculated by immersing in a suspension containing 10(9) CFU/ml of E. coli O157: H7 for 24+/-1 h at 4 degrees C. Rinsed samples were treated with 200 mg/liter (200 ppm) chlorine for 5 min at 22 degrees C. Viability of E. coli O157:H7 cells was evaluated by CSLM observation of samples stained with Sytox green (dead cell stain) and Alexa 594 conjugated antibody against E. coli O157:H7. Quantitative microscopic observations of viability were made at intact leaf surface, stomata, and damaged tissue. Most E. coli O157:H7 cells (68.3+/-16.2%) that had penetrated 30 to 40 microm from the damaged tissue surface remained viable after chlorine treatment. Cells on the surface survived least (25.2+/-15.8% survival), while cells that penetrated 0 to 10 microm from the damaged tissue surface or entered stomata showed intermediate survival (50.8 +/-13.5 and 45.6+/-9.7% survival, respectively). Viability was associated with the depth at which E. coli O157:H7 cells were in the stomata. Although cells on the leaf surface were mostly inactivated, some viable cells were observed in cracks of cuticle and on the trichome. These results demonstrate the importance of lettuce leaf structures in the protection of E. coli O157:H7 cells from chlorine inactivation.