The effects of pressurized partial pressure suits on operational ergonomics

A study on capstan partial pressure suits (PPSs) was conducted to determine their effects on pilots' operational performance on a series of ergonomic measures at different pressure levels using objective and subjective approaches. Tests of range of motion, operational performance and operational strength were carried out on ten male subjects wearing PPSs under 6 different pressure conditions. Subjective tests related to pressure tolerance and operational performance were also conducted. A video-based motion capture and analysis system was used to record the trajectories of body motions. Analysis of variance was used to test the effects of the different pressures. It was concluded that a pressurized PPS had a significant impact on the pilot's range of motion (ROM) and operational performance, but no significant effect on their operational strength. Range of motion and operational performance decreased as pressure increased, but they were affected differently. The results may provide mission planners, suit designers and human factors engineers with better insight into the understanding of pilots' operational function, mobility and strength capabilities when wearing pressurized PPS.Relevance to industryThis paper presents pilots' range of motion, operational performance and operational strength with pressurized PPS dressed and can help mission planners, suit designers and human factors engineers to improve PPS' performance.     

Effects of age and gender on maximum voluntary range of motion of the upper body joints

The maximum voluntary range of motion (ROM) of the major joints of the upper body was studied in a seated position and compared between young and elderly subjects. A total of 41 subjects (22 young male and female subjects aged 25 to 35 years, 19 elderly male and female subjects aged 65 to 80 years) took part in the experiment. In total, 13 maximum voluntary joint motions were performed by each subject. Age was found to have a non-uniform effect on the ROM of the joints investigated in this study. Its effect on ROM was joint specific and motion specific. The highest loss in ROM was observed in the neck and trunk, especially for neck extension, lateral flexion and axial rotation as well as for trunk lateral flexion and axial rotation. No significant age differences were observed in the elbow and wrist joint ROMs. The effect of gender on joint ROM was much weaker than that of age. Only four among the 26 joint ROMs investigated in this study were significantly different between the two gender groups.     

Experimental investigation of the effect of thermal comfort parameters on cervical range of motion

The most well-known ailment affecting the neck muscles is neck stiffness, caused by sharp changes in temperature, chilling of the muscles by air conditioning or drafts, and consequent painful muscle contractions. A stiff neck is typically characterized by soreness and difficulty in moving the neck – especially when trying to turn the head to the side. A stiff neck may also be accompanied by a headache, neck pain, shoulder pain and/or arm pain. Reduced cervical range of motion (ROM) is a common finding in people with neck pain. Musculoskeletal disorders continue to represent a major source of pain and discomfort as well as a significant source of workday loss and workers' compensation costs.In this study, the effects of parameters in air conditioning such as temperature, humidity and air velocity on cervical ROM have been investigated experimentally. In this investigation, each of the three parameters was used as a variable while the others were kept constant in a controlled laboratory room, and the effects of the parameter variations were investigated. Based on the observation that individuals often enter the air conditioned room perspiring in summer conditions, both dry and sweaty conditions were examined. Finally, experimental data were assessed with ANOVA analyses, and cervical rotation was found to be influenced by temperature and air velocity, but not humidity. It was also determined that parameters (temperature, air velocity and humidity) are not effective factors on cervical motion limitation provided that indoor air conditions remain within comfort limits which are prescribed in current standards of ASHRAE Standard 55 – 2004 and ISO 7730.     

Component contribution of personal protective equipment to the alleviation of physiological strain in firefighters during work and recovery

The purpose of this study was to investigate the components contributions of personal protective equipment on physiological strain in firefighters during exercise and recovery. Eight firefighters participated in trials in which various combinations of personal protective equipment components weighing from 1.3 to 15.1 kg were worn. The results showed that rectal temperature, changes in rectal temperature, mean skin temperature, heart rate, oxygen consumption and blood lactate concentration were smaller in conditions without boots (no-boots) than in other conditions with no helmet, gloves or self-contained breathing apparatus (P < 0.05). Increases in rectal temperature per unit mass of personal protective equipment were approximately twice as small in no-boots condition as the other conditions. These results suggest that the reduction of the boots' mass might be more efficient to alleviate heat strain of firefighters wearing personal protective equipment, rather than the reduction of the mass of self-contained breathing apparatus, helmet or gloves.     

Muscle activity and range of motion during active trunk rotation in a sitting posture

Twisted trunk postures during tractor driving are associated with low-back pain. The purposes of this study were to quantify the muscle activity as a function of twisting angle, to quantify the range of motion (ROM) during active trunk rotation and to determine whether there were any differences between tractor drivers and office workers and between twisting direction for these variables. The subjects performed exertions in a seated position, twisting from the neutral position to the end of the ROM. The results showed that external oblique and erector spinae had significantly different activation patterns depending on twisting direction. For the contralateral external oblique and the ipsilateral erector spinae, the muscle effort required to twist the trunk was low up to about 20° twisting angle, then the muscle effort needed to twist the trunk increased progressively. No significant differences due to occupation or twisting direction were found. The result implies that work in twisted trunk postures might be a risk factor for low-back pain.     

Comparison of three internationally certified firefighter protective ensembles: Physiological responses,mobility, and comfort

BackgroundFire protective ensembles (FPEs) are essential to safely perform firefighting job tasks; however, they are often burdensome to the workers. The aim of this study was to compare three internationally certified fire protective ensembles from the European Union (EU), South Korea (SK), and United States (US) on physiological responses, mobility, and comfort.MethodsTen male professional firefighters performed a battery of exercises in the laboratory following the ASTM F3031-17 standard to evaluate mobility, occupation-specific performance, and physiological responses (body weight, heart rate (HR), core temperature (T_c), breathing rate (BR), and rating of perceived exertion (RPE)) to 20 min of treadmill walking (3.2 mph, 5% incline). All participants carried out the evaluation wearing each FPE in a random order. Mixed effects models examined time (pre-vs. post-) by ensemble (EU, SK, US) interactions for all physiological variables and compared comfort, performance, and subjective variables across ensembles.ResultsNo interaction effects were observed for body weight, HR, T_c, BR, or RPE (p = 0.890, p = 0.994, p = 0.897, p = 0.435, and p = 0.221; respectively). SK had greater trunk flexion than EU (78.4° vs. 74.6°, p = 0.026) and US had lower standing reach than EU (105.5 cm vs. 115.4 cm, p = 0.004). Agility circuit time was lower in US (9.3 s) compared to EU (9.8 s) or SK (9.9 s) (p = 0.051 and p = 0.019, respectively).ConclusionsThe findings suggest that physiological burden remained largely unchanged across the international FPEs. However, mobility, performance, and comfort may be significantly influenced across types. International stakeholders and end users should consider design implications when choosing fire protective ensembles.     

The effects of body armour on the power development and agility of police officers

Abstract

A study was conducted in which 11 police officers wore one of three different types of Individual Light Armour Vests (ILAV), or normal station wear, for an entire day while completing power and agility-based tasks including a vertical jump (VJ), agility test, 20?m sprint and counter movement jump (CMJ). Despite all three ILAVs being significantly (p?<?.05) heavier than normal station wear, there were no significant differences between any of the ILAVs in VJ, time to complete the agility test, 20?m sprint time, peak force, velocity, power and jump distance in the CMJ. There was a significantly (p?<?.05) higher mean force produced in the CMJ while wearing all three ILAVs. The ILAV’s investigated do not appear to be heavy enough to significantly affect the power or agility of police officers. The utilisation of ILAVs by police officers does not appear to hinder policing tasks that involve agility or power development.

Practitioner summary: The addition of the extra load of military-styled body armour is known to decrease performance and mobility. When compared to normal station wear, the wearing of three different ILAV types used in policing do not appear to be heavy enough to affect the power or agility of police officers.

Abbreviations: ILAV: individual light armour vest; VJ: vertical jump; CMJ: counter movement jump; N: normal station wear     

The effect of firefighter personal protective equipment on static and dynamic balance

Abstract

Firefighters work in unpredictable conditions, necessitating the use of personal protective equipment (PPE). However, the additional weight from the PPE and self-contained breathing apparatus (SCBA) alters their centre of mass (COM), restricts movement and limits vision (face mask) contributing to a firefighters’ challenge of maintaining balance. Thus, the purpose of this study was to quantify the effects of firefighter PPE on static and dynamic balance. Participants performed two sets of three functional balance tests: (1) Static Single Leg (SSL); (2) Dynamic Single Leg (DSL); (3) Limits of Stability (LOS). The balance tests were performed under one control and three randomised PPE conditions: (1) athletic clothing; (2) turnouts; (3) turnouts?+?SCBA; (4) turnouts?+?SCBA?+?face mask. Our study found turnouts?+?SCBA both with and without the face mask negatively affected dynamic balance. These findings identify factors in fall-related injuries and strategies to reduce occupational risk.

Practitioner summary: Slips, trips and falls are the most common cause of injury in firefighters. Our study investigated the effects of firefighter personal protective equipment (PPE) on static and dynamic balance utilising a computerised balance instrument. We found that turnouts with a self-contained breathing apparatus (SCBA) with or without face mask negatively affected balance.     

Ranges of dynamic motion of the wrist in healthy young and middle-aged men

The difference in the range of dynamic motion of the wrist between young and middle-aged men was studied. To analyse wrist function easily, a new quantitative evaluation technique for wrist circumduction using a biaxial flexible electrogoniometer was introduced. A phase plane was made from two-channel signals of the electrogoniometer, and the ‘ROM (range of motion) Index’ for wrist circumduction was defined. Twelve healthy young men (age 19-31 years) and twelve healthy middle-aged men (age 45-63 years) were studied. Under forearm fixed conditions, there was no difference of the ROM Index between the two age groups. A significant decrease of the ROM Index in the middle-aged group was found in the non-dominant wrists without forearm fixation. The four quadrantal analysis of wrist circumduction clarified that this difference appeared especially in the radiodorsal direction. These results suggest that in the middle-aged men, the motor function involving the radiocarpal and midcarpal joints does not decrease, but that for the proximal and distal radioulnar joints in the non-dominant side drops.     

Obesity effect on male active joint range of motion

Despite the prevalence of obesity, how obesity affects human physical capabilities is not well documented. As an effort toward addressing this, the current study investigated the obesity effect on joint range of motion (RoM) based on data collected from 20 obese and 20 non-obese males. In total, 30 inter-segmental motions occurring at the shoulder, elbow, knee and ankle joints and lumbar and cervical spine areas were examined. The obesity effect was found to be non-uniform across the joint motions. Obesity significantly reduced RoM for nine of the 30 motions: shoulder extensions and adductions, lumbar spine extension and lateral flexions and knee flexions. The largest significant RoM reduction was 38.9% for the left shoulder adduction. The smallest was 11.1% for the right knee flexion. The obesity-associated RoM reductions appear to be mainly due to the mechanical interposition and obstruction of inter-segmental motions caused by excess fat in the obese body.

Statement of Relevance: Currently, obesity is prevalent worldwide and its prevalence is expected to increase continually in the near future. This study empirically characterised the obesity effects on joint RoM to provide better understanding of the physical capabilities of the obese. The study findings will facilitate designing man–artefact systems that accommodate obese individuals.     

Strength and range of motion of females with carpal tunnel syndrome

An experimental study was conducted to evaluate the grip and fingertip pinch strength, and range of motion of females with carpal tunnel syndrome (CTS). The range of motion of the wrist was measured in the sagittal, frontal, and transverse planes. Strength and range of motion measurements were also conducted on a control group. Results indicate that some strength and range of motion measures of the females with CTS were significantly different from that of the control group. Also, measurements in different planes caused significant differences in some range of motions of the wrist for both the CTS and the control groups.     

Comparison of firefighters and non-firefighters and the test methods used regarding the effects of personal protective equipment on individual mobility

The aims of this study were 1) to evaluate the current pilot test method and ascertain reliable measurements for a standard test method of mobility with personal protective equipment (PPE), such as physical performance and balance ability tests; 2) to compare two participant groups (firefighters versus non-firefighters) and to investigate whether non-firefighters are appropriate as a standard participant group in the field of PPE or not. Totally, 18 participants (nine professional firefighters and nine untrained males) performed the current pilot test method consisting of a balance test, completed prior to and after a performance test. Significant differences were found between PPE conditions and CON (the control clothing ensemble: T-shirt, shorts, and running shoes) for the functional balance test, physical performance test, heart rate, and subjective evaluations in firefighters group. Therefore, the present pilot test method is valid as a standard test method for assessing mobility while wearing PPE. Moreover, the present result shows that firefighters are more reliable than non-firefighters in testing of PPE with current test methods.     

A review of heat transfer phenomena and the impact of moisture on firefighters' clothing and protection

Protective clothing with high insulation properties helps to keep the wearer safe from flames and other types of hazards. Such protection presents some drawbacks since it hinders movement and decreases comfort, in particular due to heat stress. In fact, sweating causes the accumulation of moisture which directly influences firefighters' performance, decreasing protection due to the increase in radiant heat flux. Vaporisation and condensation of hot moisture also induces skin burn. To evaluate the heat protection of protective clothing, Henrique's equation is used to predict the time leading to second-degree burn. The influence of moisture on protection is complex, i.e. at low radiant heat flux, an increase in moisture content increases protection, and also changes thermal properties. Better understanding of heat and mass transfer in protective clothing is required to develop enhanced protection and to prevent burn injuries.

Practitioner Summary: This paper aims to contribute to a better understanding of heat and mass transfer inside firefighters' protective clothing to enhance safety. The focus is on the influence of moisture content and the prevention of steam burn.     

Additional helmet and pack loading reduce situational awareness during the establishment of marksmanship posture

Abstract

The pickup of visual information is critical for controlling movement and maintaining situational awareness in dangerous situations. Altered coordination while wearing protective equipment may impact the likelihood of injury or death. This investigation examined the consequences of load magnitude and distribution on situational awareness, segmental coordination and head gaze in several protective equipment ensembles. Twelve soldiers stepped down onto force plates and were instructed to quickly and accurately identify visual information while establishing marksmanship posture in protective equipment. Time to discriminate visual information was extended when additional pack and helmet loads were added, with the small increase in helmet load having the largest effect. Greater head-leading and in-phase trunk–head coordination were found with lighter pack loads, while trunk-leading coordination increased and head gaze dynamics were more disrupted in heavier pack loads. Additional armour load in the vest had no consequences for Time to discriminate, coordination or head dynamics. This suggests that the addition of head borne load be carefully considered when integrating new technology and that up-armouring does not necessarily have negative consequences for marksmanship performance.

Practitioner Summary: Understanding the trade-space between protection and reductions in task performance continue to challenge those developing personal protective equipment. These methods provide an approach that can help optimise equipment design and loading techniques by quantifying changes in task performance and the emergent coordination dynamics that underlie that performance.     

Effects of restrictive clothing on lumbar range of motion and trunk muscle activity in young adult worker manual material handling

The objective of this study was to examine the effect of wearing restrictive trousers on lumbar spine movement, trunk muscle activity and low back discomfort (LBD) in simulations of manual material handling (MMH) tasks. Twenty-eight young adults participated in the study performing box lifting, liquid container handling while squatting, and forward reaching while sitting on a task chair when wearing tight pants (sizes too small for the wearer) vs. fit pants (correct size according to anthropometry). Each task was repeated three times and video recordings were used as a basis for measuring lumbar range of motion (LRoM). The response was normalized in terms on baseline hip mobility. Trunk muscle activity of rectus abdominis (RA) and erector spinae (ES) muscles were also measured in each trial and normalized. At the close of each trial, participants rated LBD using a visual analog scale. Results revealed significant effects of both pants and task types on the normalized LRoM, trunk muscle activity and subjective ratings of LBD. The LRoM was higher and trunk muscle (ES) activity was lower for participants when wearing tight pants, as compared to fit pants. Discomfort ratings were significantly higher for tight pants than fit. These results provide guidance for recommendations on work clothing fit in specific types of MMH activities in order to reduce the potential of low-back pain among younger workers in industrial companies.     

Effects of seated lumbar extension postures on spinal height and lumbar range of motion during prolonged sitting

Prolonged sitting during sedentary work has been reported as a potential risk factor for low back pain. Furthermore, prolonged sitting can result in both reduced spinal height (SH) and lumbar range of motion (LROM). This study compared the effects of no intervention (control) with two recovery postures on SH and LROM (flexion and extension) during prolonged sitting. Twenty-four participants were randomly assigned to three interventions for three consecutive days. The interventions comprised two seated lumbar extension recovery postures (unsupported sustained and supported dynamic lumbar extension postures) and a control. Both interventions facilitated a relatively short recovery period for both SH and LROM. Supported dynamic lumbar extension conditions significantly helped SH recovery, as compared with control condition, after the first recovery posture intervention, and both postures have potential to maintain LROM. However, both postures failed to induce SH recovery over an extended time.     

The effects of platform motion and target orientation on the performance of trackball manipulation

The trackball has been widely employed as a control/command input device on moving vehicles, but few studies have explored the effects of platform motion on its manipulation. Fewer still have considered this issue in designing the user interface and the arrangement of console location and orientation simultaneously. This work describes an experiment carried out to investigate the performance of trackball users on a simple point-and-click task in a motion simulator. By varying the orientation of onscreen targets, the effect of cursor movement direction on performance is investigated. The results indicate that the platform motion and target orientation both significantly affect the time required to point and click, but not the accuracy of target selection. The movement times were considerably longer under rolling and pitching motions and for targets located along the diagonal axes of the interface. Subjective evaluations carried out by the participants agree with these objective results. These findings could be used to optimise console and graphical menu design for use on maritime vessels.

Statement of Relevance: In military situations, matters of life or death may be decided in milliseconds. Any delay or error in classification and identification will thus affect the safety of the ship and its crew. This study demonstrates that performance of manipulating a trackball is affected by the platform motion and target orientation. The results of the present study can guide the arrangement of consoles and the design of trackball-based graphical user interfaces on maritime vessels.     

多种结构框架在拉压试验机中的应用研究

现代工业的发展对拉压试验机的应用范围和实验性能提出了越来越高的要求。文中介绍了拉压试验机常见的立式和卧式框架结构,分析了其结构形式、应用场合及基本应用方法,并将拓扑优化设计方法引入到拉压试验机的设计中,最终减轻了结构重量,改进了结构的强度、刚度等特性。     

基于时空预测向量相关性的运动估计算法

针对UMHexagonS算法体现出来的问题,利用时间预测向量和空间预测向量的位置映射关系,提出了一种新的运动估计算法--基于时空预测向量相关性的运动估计算法。该算法首先在小范围得到最优点后,继续利用预测矢量的时空方向相关性进行特定方向的扩展搜索,避免了提前落入局部最优点,并减少了搜索点数,从而提高了搜索质量。实验结果表明,与UMHexagonS算法相比,该算法在保持码率基本不变的情况下,能有效地减少运动估计时间,并且能一定程度地提高单帧的峰值信噪比。关键词：