Effect of processing and storage time on in vitro digestibility and resistant starch content of two bean (Phaseolus vulgaris L) varieties

Seeds from two commercial bean varieties were cooked and stored for different times and analysed for chemical composition and in vitro starch digestibility. Parallel portions of cooked seeds were dried at 55 °C, milled and stored as flours. In general, protein and ash contents in both samples did not change with storage time, but statistical differences were shown between the two varieties (p < 0.05). Available starch (AS) contents in flours from the ‘negro’ variety did not change (p < 0.05) with storage time and, in general, were higher than in ‘flor de mayo’ samples, whose AS levels decreased during storage. The lower AS in ‘flor de mayo’ flour could be the consequence of formation of resistant starch due to retrogradation. Samples of whole ‘negro’ seeds did not show differences in AS content at 0, 24 and 48 h of storage compared with the corresponding flours, but at 72 and 96 h the AS increased in the whole samples. ‘Flor de mayo’ showed a similar pattern in flour and whole samples, with slightly higher values in the whole seeds. In general, total resistant starch (RS) content in the two varieties was higher in the flours than in ‘whole’ seeds, a fact that is not easy to explain at present. ‘Negro’ flour presented an RS content around 65.0 g kg^?1, and approximately 55.0 g kg^?1 was recorded in ‘flor de mayo’, with slight changes when storage time increased. Whole ‘flor de mayo’ showed significant levels of the retrograded portion of resistant starch (RRS), which did not change with storage time (p < 0.05). However, values were lower than in the flours. A pattern similar to that of the ‘negro’ variety was obtained for ‘flor de mayo’, since the flour exhibited higher amounts of RRS; however, in this variety, the RRS content in ‘whole’ samples decreased after prolonged storage. Flours presented higher amylolysis rates than whole samples, and the ease of digestion increased with storage time. Copyright © 2003 Society of Chemical Industry     

Influence of naturally acid-soluble proteins from beans (Phaseolus vulgaris L.) on in vitro digestibility determination

The in vitro digestibility of bean (Phaseolus vulgaris) protein fractions was studied using a pepsin-pancreatin system. Enzymatic hydrolysis was stopped by adding a strong acid and the extent of proteolysis determined by measurement of free amino groups in the soluble fraction. The in vitro digestibility of bean protein fractions was low when in the native state and was differently affected by denaturation. For phaseolin, the main reserve protein, heating caused a significant increase of susceptibility to hydrolysis, whereas heat had no apparent effect on digestibility of glutelins and albumins (II). For the PIL (protease inhibitor-lectin rich) fraction, which was shown to have a composition similar to total albumins, there was a decrease of digestibility, probably associated to disulfide bond formation upon heating. Results of in vitro digestibility were shown to be strongly dependent on the utilization of a sample blank to account for proteins naturally soluble in the acid used to interrupt hydrolysis, which would otherwise be estimated as digested protein. These proteins are characterized by a high carbohydrate content, probably responsible for their high solubility and low digestibility.     

芸豆凝集素蛋白过敏原的检测及其脱敏食品加工工艺的研究进展

芸豆凝集素是芸豆中主要的过敏原蛋白之一,具有致敏剂量低、致死率高的特点,对芸豆消费安全具有重大隐患。如何快速、准确定量芸豆产品中的凝集素含量,并且在其食品加工中采用有效的脱敏食品加工工艺,是目前食品安全和卫生领域的研究热点。本文介绍了芸豆凝集素蛋白的致敏特点,重点列举、分析了芸豆凝集素的检测技术,主要包括红细胞凝集法、糖结合法、免疫法以及色谱和质谱检测方法,深入探讨了热处理、高压处理、辐照处理以及pH调控等食品加工工艺对芸豆凝集素潜在致敏性的影响,旨在为芸豆凝集素过敏防控及低敏芸豆类食品开发提供一定的理论参考。     

Effect of cooking on the composition of beans (Phaseolus vulgaris L.) and chickpeas (Cicer arietinum L.)

The effect of cooking on levels of nutrients and anti-nutritional factors in beans and chickpeas was investigated. Significant (p < 0.05) variation existed among the beans and chickpeas with respect to their crude protein, starch, soluble dietary fiber (SDF), insoluble dietary fiber (IDF), total dietary fiber (TDF), resistant starch (RS), trypsin inhibitor activity (TIA), mineral, phytic acid, tannin, sucrose and oligosaccharide (raffinose, stachyose and verbascose) contents. Cooking beans and chickpeas in water significantly increased protein, starch, SDF, IDF, TDF, Mn and P contents (on a dry weight basis), whereas reduced ash, K, Mg, TIA, tannin, sucrose and oligosaccharide contents were observed. Colored beans (black, cranberry, dark red kidney, pinto and small red bean) contained tannins, whereas little tannin in white-colored beans (great northern and white pea bean) and chickpeas (Desi and Kabuli type) was detected.     

Total phenolic content and antioxidant properties of eclipse black beans (Phaseolus vulgaris L.) as affected by processing methods

ABSTRACT:  The effects of soaking, boiling, and steaming processes on the phenolic components and antioxidant activity of black beans were investigated. All processed beans exhibited significantly ( P < 0.05) lower antioxidant activities than raw beans in total phenolic content (TPC), DPPH free radical scavenging activity (DPPH), and oxygen radical absorbing capacity (ORAC). Steaming processes resulted in a greater retention of TPC and ORAC values than the boiling processes. Pressure boiling shortened processing time compared to regular boiling, resulted in insignificant differences in TPC, but significantly increased in ORAC as compared to the regular boiling method. Pressure steaming resulted in significant decreases in TPC, DPPH, while significantly increased in ORAC compared to regular steaming. Greater TPC, DPPH, and ORAC values were detected in boiling water than in the soaking and steaming water. Mass balance analysis showed that boiling caused more dry solid loss than steaming. All of these results indicated that processing methods significantly changed contents and activities of antioxidant components of black beans. Steam processing exhibited several advantages in appearance and texture of the cooked product, shortening processing time, and in greater retention of TPC and antioxidant activities. Steam processing may be used to develop high-quality health-promoting black bean products.     

萌发对芸豆酚类物质及抗氧化活性的影响

研究了萌发过程对黑芸豆、奶花芸豆、紫花芸豆中多酚、黄酮含量及抗氧活性的影响,并对多酚、黄酮含量及抗氧化能力做了相关性分析。结果表明:三种芸豆萌发（0⁶ d）后多酚、黄酮含量及抗氧化活性较未萌发的均显著降低（p<0.05）。且浸泡损失的多酚、黄酮高于萌发期间;黑芸豆萌发6 d后多酚、黄酮含量可能由于内切酶的作用开始增加。萌发期间,三种芸豆的DPPH·清除能力（DPPH）、ABTS+·清除能力（ABTS）、铁离子还原抗氧化能力（FRAP）、氧化自由基吸收能力（ORAC）均有降低趋势。多酚、黄酮含量与抗氧化能力极显著相关（p<0.01）,且多酚与ABTS值的相关性最高（r=0.955）。此外,黑芸豆的抗氧化能力萌发4 d后开始增加,萌发6 d时黑芸豆和奶花芸豆的ORAC值高于0 d。合适的萌发条件能更好的保留芸豆的生物活性物质。      

Interpretation of the force deformation curves of soaked red kidney beans (Phaseolus vulgaris L.)

In this study, the textural patterns of red kidney beans soaked in water at 20, 30, 40 and 60 °C are reported. Texture (hardness) was measured instrumentally by cutting with a wedge-type blade mounted on an Instron Universal Testing Machine at a speed of 200 mm min⁻¹. The general trend of the force deformation curves was similar for all of the soaking temperatures studied throughout the soaking process. At initial stages of hydration, textural changes were a function of the soaking time. However, once the hydration process attained equilibrium, changes in texture became minimal and were within the range of 34 ± 2 N, regardless of the soaking temperature and hydration time. The force deformation curves were influenced by the presence of a large cavity between the two cotyledons of red kidney beans. Interpreting textural patterns of soaked beans would provide a better control of the water absorption process, which subsequently influences changes in texture.     

Toxicity of kidney beans (Phaseolus vulgaris L). to conventional and gnotobiotic rats

Raw and irradiated diets containing kidney beans as the sole source of protein and providing 10% crude protein (N × 6.25) produced severe weight loss, followed in some cases by death, in conventional hooded rats. The mean weight loss of the surviving rats exceeded the mean weight loss of control animals fed a non-protein diet. When fed to gnotobiotic rats the irradiated bean diet produced a slight gain in the mean weight of the animals over the 10 day experimental period and a net protein utilisation (n.p.u.) of 16. This figure fell far short of the value of 52 estimated from the chemical score. Diets containing beans + casein, each providing 5% crude protein gave n.p.u. value of 53 in gnotobiotic rats, a figure which approached that anticipated from the chemical score of the diet (=61). In conventional rats the same diet gave n.p.u. values of 14 (non-irradiated) and 16 (irradiated).     

Effect of various processing techniques on digestibility of starch in Red kidney bean (Phaseolus vulgaris) and two varieties of peas (Pisum sativum)

The effect of common domestic processing methods, such as splitting, soaking, boiling and pressure-cooking on the nutritionally significant starch fractions such as rapidly and slowly digestible starches (RDS and SDS), resistant starch (RS) and total starch (TS) in two legumes, Red kidney bean (Phaseolus vulgaris) and Yellow and Green peas (Pisum sativum) were studied. The legumes had comparatively high amount (>30%, dry basis) of RS. Soaking of all legumes resulted in reduced starch fractions, possibly due to leaching of soluble fractions. Ordinary cooking of soaked as well as unsoaked seeds led to a significant (P < 0.01) decrease in RS and increase in RDS, SDS and TS. Pressure-cooking led to even greater reduction in RS and a greater increase in RDS. Cooking of legumes gelatinizes the starch and opens up the starch structure which makes them vulnerable to α-amylase hydrolysis. Splitting of legumes markedly affects the digestibility as well as RS content of raw as well as processed legumes indicating that the seed coat plays a key role in the digestibility of starches in these seeds. Overall, the enzyme resistant starch fraction of legumes was rendered more digestible by all the domestic cooking methods used.     

Influence of natural and controlled fermentations on α-galactosides, antinutrients and protein digestibility of beans (Phaseolus vulgaris L.)

The influence of natural fermentation (NF) and controlled fermentation (CF) in diminishing the content of antinutrients, α‐galactosides and increments in in vitro protein digestibility was investigated. The dry bean (Phaseolus vulgaris) flour was the substrate used in this research study. A decrease in raffinose oligosaccharide, antinutritional components and pH was observed in both types of fermentation. The natural lactic fermentation of ground beans produced significant increase (P < 0.05) in protein digestibility. For all varieties of beans, raffinose concentration reduced significantly to an undetectable level after 96 h of NF. CF did not have any significant effect on the reduction of the α‐galactosides content of the flours during fermentation. NF is an inexpensive method by which consumers can obtain good‐quality protein. Both types of fermentation diminish antinutrients and improve the nutritional value of the bean flour, and indicate the potential to use bean flour as an ingredient for fabricated foods.     

Preparation and characterization of protein isolate from fresh and hardened beans (Phaseolus vulgaris L.)

ABSTRACT:  The purpose of the present work was to determine the effect of accelerated hardening of beans on yield and physicochemical, functional, and toxicological properties. Protein isolates were obtained from fresh and hardened common beans ( Phaseolus vulgaris L.). Acid treatment was an effective method to produce hardened bean. Protein recovery in the isolation procedure for fresh bean isolate (FBI) was 45.5% and 36.15% for hardened bean isolate (HBI); however, the amount of protein was similar in both isolates. In general, the amino acid pattern was similar in both isolates. Electrophoresis analysis showed that the main protein (phaseolin) remained unchanged during the isolation procedure. HBI showed a decrease in the bands of 14 to 26 kDa corresponding to the phytohemagglutinin group, and this was associated with a 56.6% decrease in the concentration of the trypsin inhibitor (TI). Heat treatment of FBI reduced 89.4% of the TI and the hemagglutining activities, and it was reflected in an adequate weight gain of young animals. FBI showed better functional properties than HBI, and both isolates showed the same amount of flavonoids.     

Variability in some texture characteristics and chemical composition of common beans (Phaseolus vulgaris L.)

The increase in the consumption of pulses in developed countries is strongly related to the availability of varieties with high‐quality sensory attributes. Local varieties show variability of this characteristic but the extent is unknown. This study aims to assess the variability in texture and chemical composition among traditional Spanish varieties of common beans. Texture differences among varieties found by panellists correspond to chemical variation, although chemical differences within varieties seem greater than those reported in sensory analyses. It seems reasonable to screen existing information on the chemical composition of common beans to identify promising varieties to be tested in sensory trials. Nevertheless, selection within varieties should be performed only after sensory tests on the degree of differences shown by extreme genotypes for components such as protein or starch. Copyright © 2006 Society of Chemical Industry     

Estimating sensory properties of common beans (Phaseolus vulgaris L.) by near infrared spectroscopy

Near infrared spectroscopy (NIRS) has been widely used to determine food chemical composition and to a lesser extent to evaluate sensory properties. Because sample preparation is relatively simple, NIRS is especially useful in situations where many samples must be analysed, such as gene-bank characterization or breeding. We aimed to assess the feasibility of using NIRS to predict aroma, flavour, mealiness, seed-coat perception, seed-coat brightness, and seed-coat roughness in common beans. Spectra of raw, undried cooked and dried cooked common bean seeds of 55 accessions were registered. Partial least squares (PLS) regression equations were developed between spectra absorbance and sensory properties scored by eleven trained panellists. Spectra registered on dried cooked samples generally yielded the best predictions. The relative ability of prediction (RAP) values were greater than 0.8 for flavour and mealiness and between 0.5 and 0.7 for seed-coat roughness and brightness. However, a suitable model to estimate the seed-coat perception was not found. These results make it possible to screen for samples that are close to the target sensory properties and thus substantially reduce the number of panel sessions needed for gene-bank evaluation or breeding.     

Chemical composition,in vitro starch digestibility and amino acid analysis of a underexplored kidney bean (Phaseolus vulgaris. L.) grown in Chongqing,China

Chemical composition, mineral analysis, in vitro starch digestibility, and amino acid analysis of a kidney bean (Phaseolus vulgaris. L.), grown in Chongqing, China, were carried out in 2011. The results showed that the bean flour contained low reducing sugar (0.79%) and fat (2.72%), but high protein (24.8%) and starch (44.84%). Mineral analysis indicated high Mg and Ca contents with low Na/K ratio (0.04). The proportions of rapidly digestible starch (RDS), slowly digestible starch (SDS) and resistant starch (RS) were 39.64%, 41.46% and 18.90% respectively. And the variation in their proportions, along with prolonged heating time, showed increase in RDS, and decrease in SDS and RS, but the SDS + RS amount can still account for major parts (51.63%) of the total starch after a 90‐min pre‐cooking. Comparing the amino acid contents of the bean sample with recommended profile FAO/WHO/UNU (1985), the results fulfil the standard except threonine and lysine, whose contents are slightly lower than the requirements (0.93 and 0.85).     

Culinary alternatives for common beans (Phaseolus vulgaris L.): sensory characteristics of immature seeds

BACKGROUND: Immature bean seeds feature in several dishes in southern Europe; however, they are not used in all traditional areas of dry beans cultivation. To determine whether differences in the use of immature seeds are due to cultural reasons or intrinsic properties of the seeds, the prestigious varieties of beans cultivated in three areas of Spain with different traditions regarding the use of immature seeds in bean dishes were studied. RESULTS: We found differences in the culinary and sensory traits between beans harvested when mature and those harvested when immature in the three areas. However, the degree and direction of these differences varied according to the area. Moreover, the different varieties tested within each area responded differently. The sum of the genetic, environmental and interaction effects results in complex alternatives to the mature beans; the gastronomic tradition has taken advantage of only some of these alternatives. CONCLUSIONS: A lack of traditional dishes using immature beans does not mean that the local beans harvested when immature lack suitable sensory traits. Specific trials in each area of cultivation can reveal alternative textures and bean flavour intensities in immature seeds. Copyright © 2010 Society of Chemical Industry