大豆油煎炸过程理化指标与煎炸时间相关性研究

针对食用植物油煎炸过程中理化指标是否可有效反映煎炸油品品质变化这一问题,以大豆油为煎炸油,薯条和鸡排为煎炸物质进行煎炸实验。随煎炸时间延长取不同程度煎炸油检测,研究酸值、羰基值、极性组分、p-茴香胺值、过氧化值和总氧化值等理化指标与煎炸时间相关性。结果表明:所研究理化指标中酸值、羰基值和极性组分3项指标与煎炸时间相关性较好,可有效反映油品变坏程度,p-茴香胺值、过氧化值和总氧化值相关性较差。     

栀子果油煎炸过程中的品质变化及对油条和薯条的感官影响

为了探究栀子果油煎炸过程中的品质变化,本文选择薯条和油条两种代表性煎炸食材,将栀子果油在煎炸20h内每隔2h的酸价、羰基价、过氧化值和极性组分与大豆油、棕榈油在同等条件下煎炸的理化指标进行比较,结果表明：棕榈油煎炸后的品质较高,栀子果油和大豆油比较相似,栀子果油可以作为煎炸油。但栀子果油连续煎炸12 h时极性组分超过国家现有煎炸油的卫生标准,因此其连续煎炸时间不能超过12 h。同时对1、10、20h煎炸出来的油条和薯条进行感官评价,结果表明：煎炸食材相同时,三种食用油的感官评分无显著性差异（P>0.05）,说明栀子果油对油条和薯条的品质无不良影响,适合作为煎炸油。     

稻米油调和油煎炸应用研究

通过与棕榈油对比180℃下炸制薯片以及评估薯片感官喜好度、质构、口感及粘牙性等差异来评价稻米油调和油的煎炸应用性能。结果表明:采用稻米油调和油煎炸的薯片中多不饱和脂肪酸含量显著高于棕榈油(P<0.05),且其薯片的整体感官喜好度、质构口感、酥脆度、粘牙喜好度,均显著优于棕榈油薯片(P<0.05)。在加速氧化条件下,采用稻米油调和油炸制的薯片的酸价、过氧化值均与棕榈油炸制的薯片无显著性差异(P>0.05),且远低于GB 16565-2003的规定。在加速存储过程中,谷维素却得到了很好的保留。总之,稻米油调和油具有良好的煎炸性能。     

Potato Chip Quality and Frying Oil Stability of High Oleic Acid Soybean Oil

High oleic soybean (HOSBO) and low linolenic acid soybean (LLSBO) oils were evaluated individually and in a 1:1 blend along with cottonseed oil (CSO) to determine frying oil stabilities and the flavor quality and stability of potato chips. Potato chips were fried in the oils for a total of 25 h. Potato chips and oils were sampled periodically for sensory data, gas chromatographic volatile compounds, free fatty acids, and total polar compounds. Total polar compounds levels decreased with increasing amounts of oleic acid. The LLSBO had the highest overall increase (17.3%) in total polar compounds from 0 to 25 h of frying. Flavor evaluations of fresh and aged (0, 1, 3, 5, and 7 wk at 25 °C) potato chips showed differences between potato chips fried in different oil types. Potato chips fried in either LLSBO or in the 1:1 blend had significantly higher intensities of deep fried flavor than the chips fried in HOSBO. Potato chips fried in HOSBO, which had 2% linolenic acid and 1.3% linoleic acid, had significantly higher fishy flavor intensity than chips fried in the other oils. The presence of linoleic acid at a level lower than the amount of linolenic acid probably allowed for the fishy flavors from the degradation of linolenic acid in HOSBO to become more apparent than if the linoleic acid level was higher than linolenic acid. Hexanal was significantly higher in potato chips fried in LLSBO than in the chips fried in the other oils, indicating low oxidative stability during storage. Blending HOSBO with LLSBO in a 1:1 ratio not only improved flavor quality of chips compared with those fried in HOSBO, but also improved oil fry life and oxidative stability of chips compared with LLSBO.     

STUDIES ON DEEP FAT FRYING USING BLENDED OILS AND POTATO CHIPS

Dehydrated potato chips were fried in pure coconut and groundnut oils and their blends in order to study the pattern of uptake of oil constituents during frying. Investigations on the analysis of the oil and fatty acid composition in the fried product and the oil remaining in the frying pan suggested a preferential uptake of saturated lipid constituents by the potato chips, while the oil remaining in the frying pan was rich in unsaturated constituents. This effect was accentuated in blended oils, although it was also observed in pure oils.     

Use of natural antioxidants in refined palm olein during repeated deep-fat frying

An optimization study on the use of oleoresin rosemary extract, sage extract and citric acid added into refined, bleached and deodorized (RBD) palm olein before deep-fat frying of potato chips was performed using a constrained mixture design. Results revealed that the use of these natural antioxidants could improve the sensory acceptability of potato chips during a 5-day repeated deep-fat frying. All three antioxidants significantly (P<0.05) improved the sensory characteristics, including appearance, taste, crispiness, odor and overall acceptability. After day 5 of frying, the most acceptable fried potato chips were those fried in oil containing a combination of 0.059% oleoresin rosemary extract, 0.063% sage extract and 0.028% citric acid. The natural antioxidants significantly (P<0.05) lowered the rate of oxidation of oil during deep-fat frying and contributed to measured sensory acceptability of fried potato chips.     

SHELF-LIFE OF FRIED POTATO CHIPS USING RBD PALM OLEIN, SOYBEAN OIL AND THEIR BLENDS

Shelf-life of potato chips fried in refined, bleached and deodorized palm olein (RBDPO), soybean oil (SBO) and their blends was evaluated. Potato slices were fried for 130 s at 180 PT 5C at 30 min intervals over a period of 5 h/day for 5 consecutive days. Indicators of frying oil quality with the shelf-life of fried products chosen were total polar component and acid value. This study indicated that RBDPO was better than SBO for the preparation of fried potato chips in terms of shelf-life of products. The blends were also slightly better than SBO with increasing proportion of RBDPO. However, the effects were minimal on the rate of development of rancidity in fried products beyond the fourth day of frying in the frying medium.     

Quality changes of edible oils during vacuum and atmospheric frying of potato chips

Demand for safe and nutritionally rich fried products is gaining a momentum among consumers, leading to the increased consumption of vacuum fried products. The impact of vacuum frying (VF)(110 °C, 40 kPa) on chemical composition of food, fatty acid profile, microstructure, oxidative stability and sensory attributes was assessed and differentiated with that of atmospheric frying(AF) (180 °C). The potato slices were fried in mustard and soyabean oil used repetitively for 25 h. The oil content of VF potato chips was lower (15.18%) than AF chips (18.98%), however water loss in AF chips was higher than VF chips by 1.63-fold. VF significantly prevented the PUFA degradation, minimizes transfatty acid (TFA) formation and maintain a low C18:2/C16:0 ratio as compared to AF. VF Chips fried in soyabean oil show an increase in TFA content from 2.15 to 2.63% and a decrease in PUFA from 51.57 to 45.16% as compared to AF chips where TFA content increased from 2.15 to 3.72% and PUFA shows a higher reduction from 51.57 to 37.69% at the end of 25 h of frying. This indicate that in AF, oil is safe for use upto 10 cycles of frying, while as in VF, the same oil can be used for upto 40 cycles of frying without quality deteoriation. Sensorial analysis revealed that VF chips retain a better colour, taste and flavour but were less crispy than that of AF chips. These findings validate the application of vacuum frying technology for the production of high-quality foods with lesser degradation of frying oil.Industrial relevanceFood manufacturers are now impelled by the health-conscious consumer base for the production of healthy food products. The toxic effect of foods fried in degraded oils on human health is now widely known and thus the production of safe fried foods is the need of hour globally. In this context, vacuum frying is the most feasible approach for the production of quality fried products retaining the natural colour, flavour, sensory and nutritional properties better than that of atmospheric frying. Vacuum frying causes the least degradation of fatty acid of the frying oil and the fried potatoes, producing healthy potato chips. Therefore, the oil used for vacuum frying have a greater shelf life and oxidative stability than atmospheric frying. However, the higher installation cost of vacuum fryer still limits its use in the street fried food market, where degradation of oil is more likely. Thus, for its widespread commercialisation in developing countries, steps should be taken both by government and manufacturing companies to reduce the installation costs.     

L-半胱氨酸对油炸薯片中有害醛、晚期糖基化终产物的抑制作用及其品质的改善效果

采用不同质量浓度（1、3、5 mg/mL）的L-半胱氨酸（Cys）溶液浸泡鲜切马铃薯片后油炸，结果表明，添加Cys后可显著降低油炸薯片中乙二醛、丙酮醛、3-脱氧葡糖醛酮和5-羟甲基糠醛的含量，由二羰基化合物产生的晚期糖基化终产物也显著降低。同时发现，添加Cys后，油炸薯片中油脂的酸值、过氧化物值和羰基价也呈下降趋势。Cys还会影响油炸薯片的风味，其中挥发性醛类和醇类风味物质含量增加，但吡嗪类风味物质含量减少。由12 名小组成员对不同Cys处理组的油炸薯片进行感官评定表明Cys溶液浸泡处理的油炸薯片的接受度高于非浸泡对照组。     

EVALUATION OF OLEIC SAFFLOWER OIL IN FRYING OF POTATO CHIPS

SUMMARY– A recently introduced variety of safflower, UC-1, produces an oil in which oleic:linoleic acid ratios of ordinary safflower oil are reversed, giving an oil with iodine value 90. This oil was compared with cottonseed oil and hydrogenated vegetable oil (HVD) for frying potato chips. After accelerated storage at ambient temperature under fluorescent light, the quality of chips fried in oleic safflower oil was ranked equal to that of chips fried in hydrogenated oil, Chips fried in either oil were more stable than those fried in cottonseed oil. Effect of propyl gallate antioxidant was negligible.     

马铃薯片常压油炸工艺优化研究

对影响常压油炸马铃薯片品质的工艺参数进行了优化研究。结果表明,在柠檬酸溶液浓度为0.10%～0.25%、预干燥时间为10～40min和油炸温度为170～200℃的范围内,以薯片的丙烯酰胺含量、含油量和脆度为指标,常压油炸薯片的最佳工艺条件为:薯片切片采用柠檬酸溶液浓度为0.20%的柠檬酸水溶液浸泡后,于85℃预干燥30min,最后用180℃恒温油炸至熟。     

Vacuum frying as a route to produce novel snacks with desired quality attributes according to new health trends

Consumers look for products that contribute to their wellness and health, however, even health-conscious consumers are not willing to sacrifice organoleptic properties, and intense full-flavor snacks remain an important trend. The objective of this study was to examine most important quality parameters of vacuum (1.92 inHg) and atmospheric-fried carrot, potato, and apple slices to determine specific advantages of vacuum technology. Slices were fried using equivalent thermal driving forces, maintaining a constant difference between oil temperature and the boiling point of water at the working pressure (ΔT = 60 and 80 °C). This resulted in frying temperatures of 160 and 180 °C, and 98 and 118 °C, for atmospheric and vacuum frying, respectively. Vacuum-fried carrot and potato chips absorbed about 50% less oil than atmospheric-fried chips, whereas vacuum-fried apple chips reduced oil absorption by 25%. Total carotenoids and ascorbic acid (AA) were greatly preserved during vacuum frying. Carrot chips vacuum fried at 98 °C retained about 90% of total carotenoids, whereas potato and apple slices vacuum fried at 98 °C, preserved around 95% of their initial AA content. Interestingly, results showed that the antioxidant capacity of chips may be related to both the presence of natural antioxidants and brown pigments developed at elevated temperatures. PRACTICAL APPLICATION: A way to reduce detrimental effects of deep-fat frying is through operating-pressure reduction, the essence behind vacuum deep-fat frying. In this way, it is possible to remove product moisture at a low temperature in a low-oxygen environment. The objective of this research was to study the effect of oil temperature reduction when vacuum frying traditional (potatoes) and nontraditional products (carrots and apples) on most important quality attributes (vitamins, color, and oil uptake). Results are promising and show that vacuum frying can be an alternative to produce nutritious and novel snacks with desired quality attributes, since vitamins and color were greatly preserved and oil absorption could be substantially reduced.     

低场核磁共振技术检测大豆煎炸油品质的研究

煎炸食品一直受到消费者的喜爱,煎炸食品的质量与煎炸油的品质息息相关。传统评价煎炸油品质的理化方法检验费时、操作繁琐、易接触有毒试剂,不能实现在线检测。低场核磁共振技术(LF-NMR)是一种快速、准确、无损的检测方法。以大豆油和添加抗氧化剂大豆油为原料、薯条为煎炸食品,对大豆煎炸油进行理化指标及低场核磁检测。通过研究LF-NMR检测参数S_(21)及t_(2w)与煎炸时间、酸价、羰基价、极性组分含量的相关性,发现S_(21)与2种大豆煎炸油的上述指标均呈正相关、t_(2w)与之均呈负相关,且相关性良好,相关系数在0.905 8~0.994之间。说明利用低场核磁共振技术检测的S_(21)和t_(2w)可以有效地反映大豆煎炸油品质的变化,且不受抗氧化剂的影响。     

茶油深层煎炸稳定性的研究

以棕榈油作对照,采用精炼茶油进行深层煎炸。测定煎炸用以及薯条中的油脂在煎炸过程中的主要化学指标,即酸值、过氧化值、羰基价、碘价、皂化值、K值及极性化合物含量等的变化;分析煎炸用茶油的挥发性成分的变化;评价薯条的感官品质。试验结果表明:连续煎炸30h(120批次),茶油及棕榈油的酸值、过氧化值、羰基价、极性化合物含量和K值均逐渐升高,碘价和皂化值则逐渐降低;总挥发物含量逐渐增加,而一些小分子质量挥发物呈先升后降的趋势;用新鲜油煎炸的薯条的总体得分较高;除过氧化值外,薯条中茶油的其它测定指标的变化滞后于煎炸用油的变化。对照国标GB7102,24h时除茶油中的羰基价超标外,其它指标至30h时仍处于规定限值范围。茶油的深层煎炸寿命为24h(96批次)。用茶油煎炸的薯条易被消费者接受。     

低温真空油炸薯片生产工艺及其贮藏条件的研究

对马铃薯片进行低温真空油炸生产工艺的基础性研究,分析薯片在贮藏过程中水分、脂肪和VC含量的变化,并探讨等温吸湿规律。通过单因素试验确定最优的油炸工艺参数为温度105℃,时间20min,真空度0.090MPa;离心脱油的最佳条件为脱油转速400～500r/min,时间5～7min,真空度0.090MPa。研究结果对低温真空油炸薯片技术具有很好的指导和促进作用,同时改善了现在油炸薯片的品质和提高了能源利用率。     

Vacuum frying of high-quality fruit and vegetable-based snacks

Sweet potato, green beans, Tommy Atkins mango, and blue potato were fried in a vacuum frying process at a temperature of 120-130 ± 1°C. Before frying, green beans and mango slices were soaked in a 50% maltodextrine 0.15% citric acid solution. The products were also fried in a traditional (atmospheric pressure) fryer at 160-165 ± 1°C for 4 min. A 30-member consumer panel rated the sensory quality of both types of fried snacks using a 1-9 hedonic scale. Compared with traditional frying, oil content of vacuum-fried sweet-potato chips and green beans was 24% and 16% lower, respectively. Blue potato and mango chips had 6% and 5% more oil, respectively, than the traditional-fried samples. Anthocyanin (mg/100 g d.b.) of vacuum-fried blue potato chips was 60% higher. Final total carotenoids (mg/g d.b.) were higher by 18% for green beans, 19% for mango chips, and by 51% for sweet-potato chips. Sensory panelists overwhelmingly preferred (p < 0.05) the vacuum-fried products for color, texture, taste, and overall quality. Most of the products retained or accentuated their original colors when fried under vacuum. The traditional-fried products showed excessive darkening and scorching. These results support the applicability of vacuum frying technology to provide high-quality fruit and vegetable snacks.     

Safety evaluation of individual non‐fried and fried sunflower oil,paraffin oil,jojoba oil and their binary mixtures on rat health

Sunflower, jojoba, paraffin oils and binary oil mixtures of sunflower, jojoba and sunflower–paraffin oils were continuously heated at 180 °C for 12 h. Aliquots of potato chips were fried in the aforementioned oil samples. Organoleptic tests were performed on fried chips and safety limits of the oil samples were measured by certain biochemical tests. Histopathological examinations of rat liver and kidney tissues were microscopically done. Organoleptic results for fried potato chips indicate that all types of chips obtained from heated oils were categorised good. Histopathological examinations indicate changes in rat tissues of liver and kidney paralleled the biochemical data. In general, the results suggest that paraffin oil alone and in mixtures with sunflower oil have to ban its use in frying processes.     

煎炸油在薯片煎炸过程中的品质变化

以煎炸油为研究对象,以薯片为煎炸原料,研究煎炸油煎炸过程中理化指标变化及各指标间的相关性。结果表明:在煎炸过程中,煎炸油的折光指数、色泽、酸值、羰基值和极性值均随时间的延长而增大;过氧化值随着煎炸时间延长先增大后逐渐减小;碘值随时间的延长而降低;比重、黏度、皂化值在煎炸过程中的变化无明显规律。酸值、羰基值、极性值、色泽和折光指数彼此之间有极显著的正相关性,且相关系数均大于0.9;煎炸油极性值的变化可通过色泽和酸值进行预测。     

Oil uptake and texture development in fried potato slices

The objective of this work was to study oil absorption and the kinetics of texture development of fried potato slices during frying. Prior to frying, potato slices were blanched in hot water at 85 °C for 3.5 min. Unblanched slices were used as the control. Control and blanched potato slices (Panda variety, diameter: 37 mm, width: 2.2 mm) were fried at 120, 150 and 180 °C until reaching moisture contents of 1.8% (total basis) and their texture and oil content were measured periodically. Oil uptake was higher in 15% for blanched samples than for control samples after 20 s of frying. Besides, the higher the frying temperature, the lower the oil absorption in control samples. Textural changes in fried potato slices were followed by the parameter maximum force (MF) extracted from the force vs. distance curves corresponding to different sampling times. Normalized maximum force (MF*) was used in modeling textural changes in the potato slices during frying in both the initial tissue softening process and the later crust development process. Higher temperatures accelerated these processes; however neither the temperature nor the pre-treatment had a significant effect (P > 0.05) over the final texture of the fried potato chips.     

COMPARISON OF THE FRYING PERFORMANCE OF REFINED, BLEACHED AND DEODORIZED PALM OLEIN AND COCONUT OIL

The frying performance of refined, bleached and deodorized palm olein (RBDPO) and refined, bleached and deodorized coconut oil (RBDCO) was compared in this study. The oils were studied during intermittent frying of potato chips at 180C for 5 h/day for 5 consecutive days. The indices used for assessment of frying performance of the oils were fatty acid composition (FAC), peroxide value (PV), anisidine value (AnV), % free fatty acid (FFA), iodine value (IV), % polar component, polymer content, color, viscosity, smoke point and foaming tendency. The results showed that RBDPO was superior to RBDCO in frying performance in terms of % FFA, iodine value, foaming tendency and smoke point. However, RBDCO performed better than RBDPO with respect to % polar component, polymer content, resistance to oxidation, color and viscosity. Flavor evaluation showed that potato chips fried in RBDPO were preferred by the panelists.