Online Monitoring of Gravity,FAN and β‐Glucan during Mashing

The paper presents a measurement system that is based on an array of non‐specific sensors and the installation of both in a pilot and in an industrial mash tun. Three calibration strategies were pursued to predict gravity, FAN and β‐glucan during mashing in combination with three different multivariate calibrations (PCR, CPCR, PLS). The over all best calibration had RMSPEs of 0.78%, 1.56 mg/100 mL and 181.73 mg/L for gravity, FAN and β‐glucan, respectively. The measurement system makes it possible to monitor online the three major sub‐processes of mashing (amylolysis, proteolysis, and cytolysis), which is the precondition for a situational control of the mashing process.     

Effect of Mashing Temperatures and Endo-β-Glucanase on β-Glucan Content of Malt Worts

Similar basal levels of β-D-glucans were released into worts produced at 45°C from enzymically active or inactivated flours of milled malts. In contrast, significantly higher levels of β-D-glucans were found in worts derived from either enzymically active or inactivated malt flours mashed at 65°C. In general, mashing temperature may play a more important role in releasing β-D-glucans during mashing than enzymes described as β-glucan-releasing. In this context, the physical release of β-D-glucan during mashing should be separated from the enzymic release and degradation of β-D-glucan which occur during malting.     

Extraction and Isolation of β‐Glucan from Grain Sources—A Review

A collective report on the extraction and isolation of β‐glucan from grain sources, namely, oat, barley, and wheat is presented. An analysis on the effect of medium, pH, and temperature on the purity and yield of the β‐glucan derived under acidic/alkaline/aqueous/enzymatic conditions is also made. Water extraction and alkali extraction processes are preferred as the yield and recovery of extracted β‐glucan were good. Cost‐effective development of the process for deriving high molecular weight β‐glucan is the current requirement for its wide applications in food and pharmaceutical industries.     

Malt Performance is More Related to Inhomogeneity of Protein and β‐Glucan Breakdown than to Standard Malt Analyses

Nitrogen analyses of the grains of samples of commercial malts indicate that β‐glucan breakdown and the uniformity of malt modification are influenced by uniformity of distribution of grain protein. It is proposed that for normal malting barley, variations in malt modification are related to the different percentages of grains which contain high levels and different types of proteins which resist enzymic modification during malting. This kind of inhomogeneity of malt modification can cause brewhouse problems but cannot be detected with precision by standard malt analyses.     

Amylose and β‐Glucan Content of New Waxy Barleys

Starch was isolated from four new waxy barleys and compared with normal and high‐amylose barley starch. The waxy barley samples were selected lines from crosses of Swedish hulled and naked barley cultivars with the cultivar Azhul as donor of the waxy gene. The starches from the waxy barley samples were found to contain 0.7–2.6% amylose when determined iodimetrically by amperometric titration and 0.0–0.9% when determined by size exclusion chromatography after debranching. However, Sepharose CL‐2B elution profiles of the starches detected by iodine staining showed that all four waxy samples were free from detectable amounts of amylose. The amylopectin starches were found to contain a small polysaccharide fraction with molecular size smaller than amylopectin, with an iodine staining λ_max range of 550–600 nm. The water extractable and acid extractable β‐glucan contents in the waxy barley cultivars were generally found to be higher than those in normal barley.     

Effect of Pleurotus eryngii Mushroom β‐Glucan on Quality Characteristics of Common Wheat Pasta

The objective of this study was to evaluate the effect of β‐glucan‐rich fractions (BGRFs) from Pleurotus eryngii mushroom powder on the quality, textural properties, and sensory evaluation of common wheat pasta. Pasta was prepared from semolina flour and common wheat flour by replacing common wheat flour at 2%, 4%, and 6% with BGRFs. Semolina flour showed significantly higher viscosities than common wheat flour samples. However, all viscosities, except the breakdown viscosity, were reduced with increasing percentages of BGRFs. Replacement of the common wheat flour with BGRFs resulted in a reddish brown colored pasta with a lower L* value and a higher a* value. The common wheat pastas containing up to 4% BGRFs were not significantly different from semolina pasta with regard to cooking loss. Addition of up to 2% BGRFs had no significant impact on swelling index and water absorption. The addition of BGRFs in common wheat flour had a positive effect on the quality of common wheat pasta and resulted in hardness values similar to those of semolina pasta. In a sensory evaluation, cooked pasta with 2% BGRFs had the highest overall acceptability score. In summary, the results showed that common wheat flour containing 4% BGRFs could be used to produce pasta with an improved quality and texture properties similar to semolina pasta.     

Effects of malting on β‐glucanase and phytase activity in barley grain

The effects of malting on β‐glucan and phytate were investigated in one naked and one covered barley by a full factorial experiment with three factors (steeping temperature, moisture content and germination temperature) each with two levels. Analysis of total content of β‐glucan in the malted samples showed small changes after steeping at the high temperature (48 °C), while steeping at the lower temperature (15 °C) gave a significantly lower content. This trend was even stronger for β‐glucan unextractable at 38 °C. Analysis of the activity of β‐glucanase for the samples steeped at 15 °C showed a strong increase over the time of germination, while those steeped at 48 °C had a much slower development. The other two factors influenced the outcome to a small extent, mainly because the steeping temperature was the most important factor overall where any changes in β‐glucan and β‐glucanase were observed. When β‐glucan was extracted at 100 °C, a larger yield was obtained, and this was influenced by the steeping temperature in a much stronger way than for β‐glucan extracted at 38 °C. Determination of average molecular weight for β‐glucan extracted at 100 °C gave a lower value for samples steeped at 15 than at 48 °C. The design did not have any large effects on phytate degradation and phytase activity. However, it indicated that selective control of the enzymes might be possible, since phytase activity was barely affected by the parameters studied, while β‐glucanase was heavily affected. © 2002 Society of Chemical Industry     

Variety and germination time effect on total β‐glucan,water‐insoluble β‐glucan,water‐soluble β‐glucan components and β‐glucanase levels in improved sorghum varieties SK5912, KSV8 and ICSV400 before and after malting and their relationships to wort viscosity

The effects of variety and germination time on β‐glucan components – total β‐glucan (TBG), water insoluble β‐glucan (WIBG) and water soluble β‐glucan (WSBG) and β‐glucanase (BG) levels – before and after malting in improved sorghum varieties SK5912, KSV8 and ICSV400 and their relationships to wort specific viscosity (SV) were studied. This study was part of efforts to aid local malting and brewing industries in the application of sorghum varieties that are abundantly available to reduce costs. At the fifth day of germination, variety ICSV400 had the lowest TBG, WIBG and WSBG levels in its raw and malt samples. Variety SK5912 had the highest TBG, WIBG and WSBG levels in its raw samples, while variety KSV8 had the highest levels of TBG, WIBG and WSBG in its malt samples. Similarly, variety ICSV400 malts developed the highest BG levels, while the KSV8 malts gave the lowest level. The effect of variety, germination time and variety × germination time interaction was significant (p < 0.05) on the TBG, WIBG and BG levels and was not significant on the WSBG levels. Weak and significant correlation of TBG levels with SV (0.25, p < 0.05 for SK5912; 0.24, p < 0.05 for KSV8; and 0.31, p < 0.05 for ICSV400) was observed in all the samples, suggesting that the low β‐glucan levels may not be primarily and solely responsible for any viscosity impediments associated with sorghum worts during run‐off. With improvement in the effective utilization of sorghum, ICSV400 appeared the most suitable variety for malting and brewing in Nigeria.Copyright © 2016 The Institute of Brewing & Distilling     

Enzymatic Properties of β‐1,3‐Glucanase from Streptomyces sp Mo.

Streptomyces sp Mo endo‐β‐1,3‐glucanase was found to have hydrolyzing activity toward curdlan and released laminarioligosaccharides selectively. The molecular weight was estimated to be 36000 Da and its N‐terminal amino acid sequence was VTPPDISVTN. The optimal pH was 6 and the enzyme was found to be stable from pH 5 to 8. The optimal temperature was 60 °C and the activity was stable below 50 °C. The enzyme hydrolyzed selectively curdlan containing only β‐1,3 linkages. The enzyme had 89% relative activity toward Laminaria digitata laminarin, which contains a small amount of β‐1,6 linkages compared with curdlan, while Eisenia bicyclis laminarin with a higher amount of β‐1,6‐linkages, was not hydrolyzed. Mo enzyme adsorbed completely on curdlan powder. The enzymatic hydrolysis of curdlan powder resulted in the accumulation of laminaribiose (yield 81.7%). Trisaccharide was inevitably released from the hydrolysis of laminarioligosaccharides with 5 to 7 degrees of polymerization (DP). Although the enzyme cleaved off disaccharide (DP 2) from tetrasaccharide (DP 4), the reaction rate was lower than those of DP 5 to 7. The results indicated that the active site of Mo endo‐β‐1,3‐glucanase can efficiently recognize glucosyl residue chain of greater than DP 5 and hydrolyzes the β‐1,3 linkage between the 3rd and 4th glucosyl residue.     

Effects of Grain and Malt â‐Glucan on Distilling Quality in a Population of Hull‐less Barley

A population of barley lines, derived by mutation in the hull‐less variety, Penthouse, was included in a replicated trial, along with Penthouse and the hulled malting cultivar, Optic. Samples were assessed for a range of grain quality traits, then malted, with germination for either 4 or 5 days, prior to kilning. Most lines had grain β‐glucan contents lower than that of Penthouse, but there was no significant correlation between grain and malt β‐glucan content. Malt β‐glucan levels were indicative of differences in cell wall breakdown between 4 and 5 days germination, but negative associations with distilling parameters Extract and Alcohol Yield, were not statistically significant. It was concluded that the lines differed in the rate and extent of cell wall breakdown and that grain shape may influence modification in distal parts of the grain. However, a malting regime, optimised to suit Optic may be less suited to discriminating between hull‐less lines of reasonable quality.     

Screening of β‐Glucosidase and β‐Xylosidase Activities in Four Non‐Saccharomyces Yeast Isolates

The finding of new isolates of non‐Saccharomyces yeasts, showing beneficial enzymes (such as β‐glucosidase and β‐xylosidase), can contribute to the production of quality wines. In a selection and characterization program, we have studied 114 isolates of non‐Saccharomyces yeasts. Four isolates were selected because of their both high β‐glucosidase and β‐xylosidase activities. The ribosomal D1/D2 regions were sequenced to identify them as Pichia membranifaciens Pm7, Hanseniaspora vineae Hv3, H. uvarum Hu8, and Wickerhamomyces anomalus Wa1. The induction process was optimized to be carried on YNB‐medium supplemented with 4% xylan, inoculated with 106 cfu/mL and incubated 48 h at 28 °C without agitation. Most of the strains had a pH optimum of 5.0 to 6.0 for both the β‐glucosidase and β‐xylosidase activities. The effect of sugars was different for each isolate and activity. Each isolate showed a characteristic set of inhibition, enhancement or null effect for β‐glucosidase and β‐xylosidase. The volatile compounds liberated from wine incubated with each of the 4 yeasts were also studied, showing an overall terpene increase (1.1 to 1.3‐folds) when wines were treated with non‐Saccharomyces isolates. In detail, terpineol, 4‐vinyl‐phenol and 2‐methoxy‐4‐vinylphenol increased after the addition of Hanseniaspora isolates. Wines treated with Hanseniaspora, Wickerhamomyces, or Pichia produced more 2‐phenyl ethanol than those inoculated with other yeasts.     

Purification and physicochemical characterization of ovine β‐lactoglobulin and α‐lactalbumin

Ovine whey proteins were fractionated and studied by using different analytical techniques. Anion‐exchange chromatography and reversed‐phase high‐performance liquid chromatography (HPLC) showed the presence of two fractions of β‐lactoglobulin but only one of α‐lactalbumin. Gel permeation and sodium dodecyl sulfate (SDS)‐polyacrylamide gel electrophoresis allowed the calculation of the apparent molecular mass of each component, while HPLC coupled to electrospray ionisation‐mass spectrometry (ESI‐MS) technique, giving the exact molecular masses, demonstrated the presence of two variants A and B of ovine β‐lactoglobulin. Amino acid compositions of the two variants of β‐lactoglobulin differed only in their His and Tyr contents. Circular dichroism spectroscopy profiles showed pH conformation changes of each component. The thermograms of the different whey protein components showed a higher heat resistance of β‐lactoglobulin A compared to β‐lactoglobulin B at pH 2, and indicated high instability of ovine α‐lactalbumin at this pH.     

Analysis of β‐Glucan in Single Grains of Barley and Malt Using NIR‐Spectroscopy

This paper describes initial experiments carried out in a collaborative study with Perten Instruments, Sweden, using Near‐Infrared spectroscopy to assess β‐glucan content in single grains of barley and malt. In general, the method needs further development, but this study shows that it has potential as a valuable tool for assessing endosperm modification of malt. The method is fast and non‐destructive and therefore allows other parameters related to endosperm modification to be analysed using the same grains.     

A predictive model of the effects of genotypic,pre‐ and postharvest stages on barley β‐glucan levels

BACKGROUND: β‐Glucan is a bioactive component of cereal grains that has many potential uses and health‐promoting benefits. Recent research has focused on improving the nutritional value of food by increasing human exposure to β‐glucan. This study looks at the development of a farm‐level baseline model (including scenario analysis) to evaluate the impact of pre‐ and postharvest stages (including genotypic factors, environmental conditions, agronomic factors and storage) on β‐glucan levels in barley. Monte Carlo simulation techniques were employed to model various stages in pre‐ and postharvest processes and to simulate the factors influencing the level of β‐glucan content in both hulled barley (H_B) and hull‐less barley (H_LB) genotypes. RESULTS: The baseline model found that the mean simulated level of β‐glucan was 40.99 and 56.77 g kg^?1 for H_B and H_LB genotypes respectively. A sensitivity analysis highlighted that genotype was the most important parameter in determining the final β‐glucan content (correlation coefficients of 0.66 and 0.78 for H_B and H_LB respectively), more so than any of the agronomic factors analysed. The scenario analysis highlighted the importance of harvest date (scenario 2) and storage conditions (scenario 3), with a potential 32.6 and 32.7% decrease in β‐glucan (compared with the baseline model) if harvesting is carried out early during physiological maturity (i.e. at growth stage 92) and a potential 20.1 and 19.5% increase in β‐glucan for H_B and H_LB respectively if storage time is minimised. CONCLUSION: This study predicted the influence of genotypic, pre‐ and postharvest operations on β‐glucan content and thus allows strategies to be identified to influence β‐glucan content in barley products. Copyright © 2008 Society of Chemical Industry     

THE DEGRADATION OF β-GLUCAN DURING MALTING AND MASHING: THE ROLE OF β-GLUCANASE

Significant β-glucanolysis takes place during mashing and is catalysed by a β-glucanase which is specific to mixed-linkage β-glucans. The enzyme develops during the germination of barley, but is rapidly and extensively destroyed in kilning. Partially-purified preparations of β-glucanase are protected from denaturation by heat if their solutions are adjusted to pH 4 or if bovine serum albumin is added. However the most effective stabiliser of the enzyme is reduced glutathione. Oligosaccharides containing three and four glucosyl units are produced by the action of β-glucanase and they are further converted during malting and mashing by a different enzyme(s) to disaccharides and glucose.