Behavior of Escherichia coli O157:H7 during the manufacture and ripening of Fontina Protected Designation of Origin cheese

This study was conducted to describe the cheese-making procedure of Fontina Protected Designation of Origin (PDO) cheese and to evaluate the behavior of Escherichia coli O157:H7 during cheese manufacture and ripening. The study was divided into 2 phases: the production of Fontina PDO cheese was monitored at 3 different dairies in the Aosta Valley and an E. coli O157 challenge was conducted at a fourth dairy. The dairies employ different commercial starter cultures for cheese making. The growth of lactic acid bacilli (LAB) and the decrease in pH were slower in the first hours and the LAB concentrations were overall higher in dairy A than in the other 2 dairies. The pH remained substantially unchanged during ripening (range 5.2 to 5.4) in all dairies. Water activity remained constant at around 0.98 until d 21, when it decreased to around 0.97 until d 80 in dairies A and B and 0.95 in dairy E. Whole raw cow milk was used for making Fontina cheese according to the standard procedure. For the experimental production, the milk was inoculated with E. coli O157:H7 at a concentration of approximately 5 log₁₀ cfu/mL and commercial starter cultures were used according to the Fontina PDO regulation. An increase of 2.0 log₁₀ cfu/g in E. coli O157:H7 was observed during the first 9.5 h of cheese making, followed by a decrease at 46 h when pH decreased to 5.4 in all trials. Fresh cheeses were salted and held at 10°C for ripening for 80 d. Water activity was decreased to 0.952 at the end of the ripening stage. The LAB concentrations declined gradually; this trend was more marked for the lactobacilli than either the thermophilic or the mesophilic lactococci. The increase in LAB count and the decrease in pH in the first hours did not seem to affect E. coli O157 growth. Ripening was found to inhibit pathogen survival, however, as seen in the reduction of 3 log₁₀ from the maximum concentration measured during the earlier stages of production.     

Growth and survival of Escherichia coli O157:H7 during the manufacture and ripening of raw goat milk lactic cheeses

The behaviour of Escherichia coli O157:H7 was studied during the manufacture and ripening of raw goat milk lactic cheeses. Cheese was manufactured from raw milk in the laboratory and inoculated with E. coli O157:H7 to a final concentration of 10, 100 and 1000 cfu ml(-1). E. coli O157:H7 was counted by CT-SMAC (Mac Conkey Sorbitol Agar with cefixim and tellurite) and O157:H7 ID throughout the manufacturing and ripening processes. When the milk was inoculated with 10, 100 or 1000 cfu ml(-1), counts decreased to less than 1 log(10) g(-1) in curds just prior to moulding. However, viable E. coli O157:H7 were found in cheeses throughout processing, and even after 42 days of ripening. Results indicate that E. coli O157:H7 survives the lactic cheese manufacturing process. Thus, the presence of low numbers of E. coli O157:H7 in milk destined for the production of raw milk lactic cheeses can constitute a threat to the consumer.     

Antagonistic effects of Lactobacillus reuteri against Escherichia coli O157:H7 in white-brined cheese under different storage conditions

This study aimed to investigate the survival of the foodborne pathogen Escherichia coli O157:H7 in white-brined cheeses as influenced by the presence of Lactobacillus reuteri. The white cheeses were made from pasteurized bovine milk inoculated with E. coli O157:H7 (cocktail of 3 strains) to achieve ～5 log₁₀ cfu/g with absence or presence of Lb. reuteri (～6 log₁₀ cfu/g). Cheese samples were brined in 10% or 15% NaCl solution and stored at 10°C and 25°C for 28 d. The white-brined cheeses were assessed for salt content, pH, water activity (A_w), and numbers of E. coli O157:H7, Lb. reuteri, nonstarter lactic acid bacteria (NSLAB), yeasts, and molds. Results showed that E. coli O157:H7 survived in cheese stored in both brine solutions at 10°C and 25°C regardless of the presence of Lb. reuteri. A substantial reduction was observed in cheese stored in 10% NaCl brine at 25°C, followed by cheese stored in 15% NaCl brine at 10°C by 2.64 and 2.16 log₁₀ cfu/g, respectively, in the presence of Lb. reuteri and by 1.02 and 1.87 log₁₀ cfu/g, respectively, in the absence of Lb. reuteri under the same conditions. The pathogen in brine solutions survived but at a lower rate. Furthermore, the growth of Lb. reuteri and NSLAB were enhanced or slightly decreased in cheese and brine by 28 d, respectively. The salt concentrations of cheese ranged from 4 to 6% and 5 to 7% (wt/wt), during 28-d ripening in 10 and 15% brine, respectively. Values of pH and A_w slightly increased at d 1 after exposure to brine and reached 4.69 to 6.08 and 0.91 to 0.95, respectively, in all treatments. Therefore, the addition of Lb. reuteri can be used as a biopreservation method to inhibit the survival of E. coli O157:H7 in white-brined cheese when combined with the appropriate temperature, NaCl level, and storage time.     

Survival of Escherichia coli O157:H7 during Manufacture and Storage of White Brined Cheese

Escherichia coli O157:H7 is a major foodborne pathogen that causes severe disease in humans. Survival of E. coli O157:H7 during processing and storage of white brined cheese was investigated. Cheeses were prepared using pasteurized milk inoculated with a 4 strain E. coli O157:H7 cocktail (7 log₁₀ CFU/g) with or without yogurt starter culture (Lactobacillus delbrueckii ssp. bulgaricus and Streptococcus salivarius ssp. thermophilus) and stored in 10% or 15% NaCl brine at 10 and 21 ºC for 28 d. NaCl concentration, water activity (a_w), pH, and numbers of E. coli O157:H7 and lactic acid bacteria (LAB) were determined in cheese and brine. E. coli O157:H7 was able to survive in cheese stored in both brines at 10 and 21 ºC regardless of the presence of starter LAB, although the latter significantly enhanced E. coli O157:H7 reduction in cheese or its brine at 10 ºC. E. coli O157:H7 numbers were reduced by 2.6 and 3.4 log₁₀ CFU/g in cheese stored in 10% and 15% NaCl brine, respectively, in the presence of starter LAB and by 1.4 and 2.3 log₁₀ CFU/g, respectively, in the absence of starter LAB at 10 ºC. The pathogen survived, but at lower numbers in the brines. The salt concentration of cheese stored in 10% brine remained about 5% during ripening, but in 15% brine, the NaCl level increased 1.6% to 8.1% (w/w) by 28 d. Values of pH and a_w slightly decreased 1 d after exposure to brine and reached 5.5 to 6.6 and 0.88 to 0.94, respectively, in all treatments.     

Adaptation of Escherichia coli O157:H7 to acid in traditional and commercial goat milk amasi

Acid resistance of Escherichia coli O157:H7 strains UT 10 and UT 15 were determined in traditional Amasi fermented for 3 days at ambient temperature (ca 30 °C) and commercial Amasi fermented at 30 °C for 24 h and stored at 7 °C for 2 days. Escherichia coli O157:H7 counts in commercial Amasi were detected at 2.7 log₁₀ cfu/ml after 3 days while those in traditional Amasi could not be detected after the same period. There was no significant difference (p ? 0.05) in the survival of acid adapted (AA) and non-adapted (NA) E. coli O157:H7 in traditional Amasi, while in commercial Amasi, the NA strain survived significantly (p ? 0.05) better than its AA counterpart. Regardless of prior adaptation to acid, E. coli O157:H7 can survive during fermentation and storage of fermented goat milk Amasi. Also, the fermentation time, pH and storage temperature affects the survival of E. coli O157:H7 in the fermented milk.     

Survival of a five-strain cocktail of Escherichia coli O157:H7 during the 60-day aging period of cheddar cheese made from unpasteurized milk

The U.S. Food and Drug Administration Standard of Identity for Cheddar cheeses requires pasteurization of the milk, or as an alternative treatment, a minimum 60-day aging at > or =2 degrees C for cheeses made from unpasteurized milk, to reduce the number of viable pathogens that may be present to an acceptable risk. The objective of this study was to investigate the adequacy of the 60-day minimum aging to reduce the numbers of viable pathogens and evaluate milk subpasteurization heat treatment as a process to improve the safety of Cheddar cheeses made from unpasteurized milk. Cheddar cheese was made from unpasteurized milk inoculated with 10(1) to 10(5) CFU/ml of a five-strain cocktail of acid-tolerant Escherichia coli O157:H7. Samples were collected during the cheese manufacturing process. After pressing, the cheese blocks were packaged into plastic bags, vacuum sealed, and aged at 7 degrees C. After 1 week, the cheese blocks were cut into smaller-size uniform pieces and then vacuum sealed in clear plastic pouches. Samples were plated and enumerated for E. coli O157:H7. Populations of E. coli O157:H7 increased during the cheese-making operations. Population of E. coli O157:H7 in cheese aged for 60 and 120 days at 7 degrees C decreased less than 1 and 2 log, respectively. These studies confirm previous reports that show 60-day aging is inadequate to eliminate E. coli O157:H7 during cheese ripening. Subpasteurization heat-treatment runs were conducted at 148 degrees F (64.4 degrees C) for 17.5 s on milk inoculated with E. coli O157:H7 at 10(5) CFU/ml. These heat-treatment runs resulted in a 5-log E. coli O157: H7 reduction.     

Microbiological quality of raw milk used for small-scale artisan cheese production in Vermont: Effect of farm characteristics and practices

This study 1) evaluated the overall milk quality and prevalence of 4 target pathogens (Listeria monocytogenes, Staphylococcus aureus, Salmonella spp., and Escherichia coli O157:H7) in raw milk used for small-scale artisan cheesemaking and 2) examined specific farm characteristics and practices and their effect on bacterial and somatic cell counts (SCC). Raw milk samples were collected weekly from 21 artisan cheese operations (6 organic) in the state of Vermont that manufactured raw-milk cheese from cow (12), goat (5), or sheep (4) milk during the summer of 2008. Individual samples were examined for standard plate counts (SPC), coliform counts (CC), and SCC. Samples were also screened for target pathogens both quantitatively and qualitatively by direct plating and PCR. Overall, 86% of samples had SPC <10,000 cfu/mL, with 42% <1,000 cfu/mL. Additionally, 68% of samples tested were within pasteurized milk standards for coliform bacteria under the United States’ Grade A Pasteurized Milk Ordinance at <10 cfu/mL. Log₁₀ SPC and CC did not differ significantly among species. Similarly, method of sample delivery (shipped or picked up), farm type (organic or conventional), and duration of milking (year-round or seasonal) did not have significant effects on farm aggregated mean log₁₀ SPC, CC, or SCC. Strong positive correlations were observed between herd size and mean log₁₀ SPC and between log₁₀ SPC and CC as well as SCC when data from all animal species were combined. Although SCC for cow milk were significantly lower than those for goat and sheep milk, 98, 71, and 92% of cow, sheep, and goat milk samples, respectively, were within the compliance limits of the United States’ Grade A Pasteurized Milk Ordinance for SCC. Fourteen of the 21 farms (67%) were positive for Staph. aureus, detected in 38% of samples at an average level of 20 cfu/mL. Neither L. monocytogenes, E. coli O157:H7, or Salmonella spp. were detected or recovered from any of the 101 samples tested. Our results indicate that the majority of raw milk produced for small-scale artisan cheesemaking was of high microbiological quality with no detectable target pathogens despite the repeat sampling of farms. These data will help to inform risk assessments that evaluate the microbiological safety of artisan and farmstead cheeses, particularly those manufactured from raw milk.     

Sensitive detection of Escherichia coli O157:H7 by conventional plating techniques

The direct detection and estimation of concentration of Escherichia coli O157:H7 down to 1 CFU/g of cheese was achieved by conventional plating techniques. Cheese was manufactured with unpasteurized milk inoculated with E. coli O157: H7 at 34 +/- 3 CFU/ml. The numbers of E. coli O157:H7 were monitored during cheese ripening by plating on sorbitol MacConkey agar supplemented with cefixime and potassium tellurite (CT-SMAC) and on CT-O157:H7 ID medium. Using the pour plate method, E. coli O157:H7 colonies could easily be distinguished from non-O157:H7 colonies on CT-O157:H7 ID medium but not on CT-SMAC. Higher numbers of E. coli O157:H7 were detectable with O157:H7 ID medium. Latex agglutination and PCR were used to confirm the identification of typical E. coli O157:H7 colonies, and nontypical colonies as not being E. coli O157:H7. As few as 1 CFU/g of cheese could be detected. E. coli O157:H7 also was detected in deliberately contaminated milk at concentrations as low as 4 CFU/10 ml.     

Fate of Listeria innocua during production and ripening of smeared hard cheese made from raw milk

The fate of 2 different Listeria innocua strains was analyzed during the production and ripening of smeared raw milk Greyerzer cheese (Gruyère). These strains were used as surrogates for the pathogenic Listeria monocytogenes, as they are physiologically very similar. Bacterial cells were added to the cheese milk at levels of 10⁵ cfu/mL. During the first 24 h of cheese making, the number of the test strains decreased to a level of below 10² cfu/g. Obviously, the cooking temperature of 56°C and the subsequent slight temperature decrease to 50°C within 70 min contributed to a distinct reduction of Listeria counts. The counts in the cheese cores did not exceed 10³ cfu/g within 12 wk of cheese ripening and Listeria was not detectable after 24 wk. In contrast to the cores of the cheeses of the 4 batches in this study, their rinds always contained a high listerial load of approximately 10⁶ to 10⁸ cfu/g throughout the entire ripening period. The smeared surface showed an increase of pH to alkaline values, corresponding to smear microbiota development. Coryneforms and Staphylococcus counts were stable at >10⁷ cfu/cm² over 175 d, whereas yeast counts decreased to about 10⁵ cfu/cm² at the end of ripening. The study shows that the smear culture had no noticeable anti-listerial potential. When removing the rind or portioning such smeared cheese loaves with a cutting device, a postprocess contamination of the core might occur, thus presenting a major hygienic risk.     

The influence of lactoperoxidase,heat and low pH on survival of acid-adapted and non-adapted Escherichia coli O157:H7 in goat milk

In hot climates where quality of milk is difficult to control, a lactoperoxidase (LP) system can be applied in combination with conventional preservation treatments at sub-lethal levels to inhibit pathogenic microbes. This study investigated the effect of combined heat treatments (55 °C, 60 °C and 72 °C) and milk acidification (pH 5.0) on survival of acid-adapted and non-adapted Escherichia coli O157:H7 strains UP10 and 1062 in activated LP goat milk. Heat treatment at 72 °C eliminated E. coli O157:H7. Acid-adapted strains UP10 and 1062 cells showed resistance to combined LP and heat at 60 °C in fresh milk. The inhibition of acid-adapted and non-adapted E. coli O157:H7 in milk following combined LP-activation, heat (60 °C) and milk acidification (pH 5.0) suggests that these treatments can be applied to reduce E. coli O157:H7 cells in milk when they occur at low numbers (<5 log₁₀ cfu mL^?1) but does not eliminate E. coli O157:H7 to produce a safe product.     

The fate of Escherichia coli O157 : H7 in Myzithra,Anthotyros, and Manouri whey cheeses during storage at 2 and 12°C

Myzithra, Anthotyros and Manouri whey cheeses were inoculated the day after production withEscherichia coli O157 : H7 at concentrations of approx. 1·8×10⁶cfu g⁻¹, and stored at 2 and 12°C for 30 and 20 days, respectively. The pH of the whey cheeses decreased from an initial value of approx. 6·20 to 5·83 or 5·60 (Myzithra) 5·75 or 5·20 (Anthotyros) and 5·80 or 5·30 (Manouri) by the end of the corresponding storage periods at 2 and 12°C, respectively. Escherichia coli O157 : H7 populations in the whey cheeses at the end of the 12°C storage period, had grown with an increase of approx. 1·3 log₁₀cfu g⁻¹. E. coli O157 : H7 populations in whey cheeses at the end of the 2°C storage period did not grow and decreased, with an approx. 2·5 log₁₀cfu g⁻¹reduction. Results showed that E. coli O157 : H7 can grow at 12°C and survive at 2°C storage in Myzithra, Anthotyros and Manouri whey cheeses, and therefore post-manufacturing contamination with this pathogen must be avoided by employing hygienic control programmes such as HACCP.     

Growth and processing conditions affecting acid tolerance inEscherichia coli O157:H7

The impact of growth conditions (anaerobiosis, growth phase, NaCl, pH, and temperature) on the development of acid tolerance in Escherichia coli O157:H7 was investigated directly (D_pH1.15) and indirectly by monitoring the specific activity of acid phosphatase. Anaerobic growth of O157:H7 strain 43895 in synthetic rumen fluid resulted in earlier development of acid tolerance than aerobic growth. However, stationary-phase cells of both aerobic and anaerobic cultures had an equivalent degree of acid tolerance that was greater than that achieved in log-phase cultures grown anaerobically. These results are consistent with the growth-phase regulation of acid tolerance by the stationary-phase sigma factors³⁸. The addition of NaCl (1%) also enhanced acid tolerance of log-phase but not stationary-phase cells of strain 43895. Growth temperature influenced the acid tolerance with progressively greater D_pH1.15values obtained at 15, 25, and 37°1C, in both log and stationary phase. Therefore, the influence of temperature on the subsequent survival and acid tolerance of E. coli O157:H7 strain 43895 in ground beef was evaluated. Numbers of strain 43895 decreased c. 1.14 log₁₀cfu g^-1in inoculated ground beef stored at 4°1C, whereas numbers remained essentially unchanged during storage at -20°C. While pre-incubation at 15°1C for 4 h prior to storage at 4 or -20°C did not influence survival, the acid tolerance of E. coli O157:H7 survivors was significantly decreased (P<0.10001). These results indicate that the processing temperature can influence acid tolerance in E. coli O157:H7.     

Inactivation ofEscherichia coliO157:H7 by combinations of GRAS chemicals and temperature

Reported outbreaks of foodborne illness involvingEscherichia coliO157:H7 have increased in the United States during the last decade, with a variety of food products being implicated as vehicles of infection. Studies were carried out to determine the efficacy of combinations of various GRAS chemicals and moderate temperatures to killE. coliO157:H7. A five-strain mixture ofE. coliO157:H7 of approximately 10⁸cfu ml⁻¹was inoculated into 0·1% peptone solutions containing 1·0 or 1·5% lactic acid plus 0·1% hydrogen peroxide, 0·1% sodium benzoate or 0·005% glycerol monolaurate. The solutions were incubated at 8°C for 0, 15 and 30 min; at 22°C for 0, 10 and 20 min; or at 40°C for 0, 10 and 15 min; populations ofE. coliO157:H7 were determined at each sampling time. At 40°C, the pathogen was inactivated to undetectable levels within 10 min of incubation in the presence of 1·0 or 1·5% lactic acid plus hydrogen peroxide, and within 15 min of incubation in the presence of 1·5% lactic acid plus sodium benzoate or glycerol monolaurate. At 22°C, complete inactivation ofE. coliO157:H7 was observed after 20 min of exposure to 1·5% lactic acid plus 0·1% hydrogen peroxide, whereas a reduction of 5 log₁₀cfu ml⁻¹was observed with a treatment of 1·5% lactic acid plus glycerol monolaurate. None of the treatments resulted in total inactivation of the pathogen at 8°C. The aforementioned treatments could potentially be used to inactivate or reduceE. coliO157:H7 populations on raw produce.     

Influence of gamma irradiation on growth and survival of Escherichia coli O157:H7 and quality of cig kofte, a traditional raw meat product

Cig kofte is a traditional Turkish food containing raw ground meat. Samples inoculated with Escherichia coli O157:H7 were irradiated at 0.5–6 kGy with a ⁶⁰Co source and stored at 4 and 25 °C. Total aerobic mesophilic count decreased with increasing irradiation doses, D₁₀ value was 0.83 kGy. Escherichia coli O157:H7 count decreased from 5.1 log₁₀ CFU g^?1 to an undetectable level (<1 log₁₀ CFU g^?1) after 1‐day storage at 4 °C following irradiation at 2 kGy, D₁₀‐value was 0.29 kGy. Irradiation doses up to 2 kGy did not affect sensory quality after 1 day. There was colour loss in samples irradiated at 2 kGy or above and stored for longer periods. Storage of the irradiated products at abused temperature must be avoided for safety assurance. Irradiation at 2 kGy has a great potential for extending the shelf‐life of cig kofte and assuring safety by decreasing the number of E. coli O157:H7 and other bacteria, but further studies with suitable package designs are needed to decrease quality degradation during extended storage.     

Novel Real-Time PCR Method To Detect Escherichia coli O157:H7 in Raw Milk Cheese and Raw Ground Meat

Raw milk, raw milk cheeses, and raw ground meat have been implicated in Escherichia coli O157:H7 outbreaks. Developing methods to detect these bacteria in raw milk and meat products is a major challenge for food safety. The aim of our study was to develop a real-time PCR assay to detect E. coli O157:H7 in raw milk cheeses and raw ground meat. Well-known primers targeting a mutation at position +93 of the uidA gene in E. coli O157:H7 were chosen, and a specific TaqMan-minor groove binder probe was designed. This probe targets another mutation, at position +191 of the uidA gene in E. coli O157:H7. The first step in the study was to evaluate the specificity of this probe with 156 different O157:H7/NM strains and 48 non-O157:H7/NM strains of E. coli. The sensitivity of the method was evaluated by pre- and postinoculation of cheeses and meat enrichments with different E. coli O157:H7 strains. All the E. coli O157:H7 isolates tested were positive, and none of the other bacteria were detected. Our results indicate that this method is sensitive enough to detect 10(2) E. coli O157:H7 isolates per ml of cheese or meat enrichment broth (24 h at 41.5° C) and is more sensitive than the International Organization for Standardization reference method. We can conclude that this new real-time PCR protocol is a useful tool for rapid, specific, and sensitive detection of E. coli O157:H7 in raw milk and raw ground meat products.     

Raw milk and raw milk cheeses as vehicles for infection by Verocytotoxin-producing Escherichia coli

Raw milk and raw milk cheeses can be a source of food-borne pathogens, including Verocytotoxin (Shiga toxin)-producing Escherichia coli (VTEC/STEC). Outbreaks of VTEC O157: H7 infections have been attributed to the consumption of raw milk and associated dairy products. Although the general prevalence of VTEC O157 in raw milk and raw milk cheeses is low, it can be higher for non-O157 VTEC. The clinical significance of many of these VTEC is unclear, although some are associated with disease. Studies show that E. coli O157 strains can survive the various stages of the cheesemaking process and that raw milk and raw milk cheeses remain a potential vehicle for VTEC infections.     

Microbiology of raw milk in New Zealand

The results of this study demonstrate the occurrence of the non-spore-forming pathogens, Staphylococcus aureus, Escherichia coli (total count and O157:H7), Listeria, Campylobacter and Salmonella, in New Zealand's raw milk supply. Samples of raw milk were collected monthly within five major dairying regions over one year. Each month, samples from five randomly selected farm vats in each region were collected for analysis (297 samples in total). Methods based on plate count techniques were used to enumerate S. aureus and E. coli. Enrichment methods in combination with a modified most probable number detection method were used to monitor samples for the presence of E. coli O157:H7, Listeria, Campylobacter and Salmonella. Salmonella was not detected in this study, and Campylobacter was isolated once (0.34%). E. coli was present at <100 cfu/ml in 99% of samples and exceeded 10(3)cfu/ml in 0.7% of samples. E. coli O157:H7 was not detected whereas non-pathogenic E. coli O157 strains (i.e. lacking genes for stx1, stx2, eae and Hly A) were detected in 1% of samples. S. aureus was not detected (<1 cfu/ml) in 21% of samples; levels were >1 but <100 cfu/ml in 60% of samples and on one occasion (0.34%) S. aureus exceeded 10(4)cfu/ml. L. monocytogenes was isolated from 0.68% of samples and L. innocua was present in 4% of samples. The results demonstrate that raw milk sampled from farm vats in New Zealand, as in other countries, inevitably contains recognised pathogens and, hence, control by pasteurisation or an equivalent treatment of raw milk remains paramount. Even so, the prevalence of most of these pathogens was lower than those reported in many of the studies performed in other countries.     

Survival of micro‐organisms and organic acid profile of probiotic Cheddar cheese from buffalo milk during accelerated ripening

The study aimed to assess the impact of ripening at elevated temperatures on the survival of probiotic micro‐organisms and production of organic acids in Cheddar cheese. Cheese was manufactured from buffalo milk using lactococci starters along with different probiotic bacteria (Lactobacillus acidophilus LA‐5, Bifidobacterium bifidum Bb‐11 and Bifidobacterium longum BB536) as adjunct cultures. The cheeses were ripened at 4–6 °C or 12–14 °C for 180 days and examined for composition, organic acids and microbial survival. The production of organic acids was accelerated at 12–14 °C when compared to normal ripening temperatures. The probiotic bacteria increased production of lactic and acetic acids, compared to cheese made with lactococci alone. The survival of the mesophilic starters was significantly (P < 0.05) reduced in all the cheese samples ripened at the higher temperature. However, the probiotic bacteria remained viable (>7.0 log₁₀ cfu/g) throughout the 180 days of ripening, irrespective of temperature. It was concluded that Cheddar containing additional probiotic cultures can effectively be ripened at elevated temperatures without any adverse effects.     

Behavior of Escherichia coli O157:H7 during the manufacture and ripening of feta and telemes cheeses

Pasteurized whole ewe's and cow's milk was used in the manufacture of Feta end Telemes cheeses, respectively, according to standard procedures. In both cases, the milk had been inoculated with Escherichia coli O157:H7 at a concentration of ca. 5.1 log CFU/ml and with thermophilic or mesophilic starter cultures at a concentration of ca. 5.3 to 5.6 log CFU/ml. In the first 10 h of cheesemaking, the pathogen increased by 1.18 and 0.82 log CFU/g in Feta cheese and by 1.56 and 1.35 log CFU/ g in Telemes cheese for the trials with thermophilic and mesophilic starters, respectively. After 24 h of fermentation, a decrease in E. coli O157:H7 was observed for all trials. At that time, the pH was reduced to 4.81 to 5.10 for all trials. Fresh cheeses were salted and held at 16 degrees C for ripening until the pH was reduced to 4.60. Cheeses were then moved into storage at 4 degrees C to complete ripening. During ripening, the E. coli O157:H7 population decreased significantly (P < or = 0.001) and finally was not detectable in Feta cheese after 44 and 36 days and in Telemes cheese after 40 and 30 days for the trials with thermophilic and mesophilic starters, respectively. The estimated times required for one decimal reduction of the population of E. coli O157:H7 after the first day of processing were 9.71 and 9.26 days for Feta cheese and 9.09 and 7.69 days for Telemes cheese for the trials with thermophilic and mesophilic starters, respectively.     

Low pressure CO2 storage of raw milk: microbiological effects

The effects of holding raw milk under carbon dioxide pressures of 68 to 689 kPa at temperatures of 5, 6.1, 10, and 20°C on the indigenous microbiota were investigated. These pressure-temperature combinations did not cause precipitation of proteins from the milk. Standard plate counts from treated milks demonstrated significantly lower growth rate compared with untreated controls at all temperatures, and in some cases, the treatment was microcidal. Raw milk treated with CO₂ and held at 6.1°C for 4 d exhibited reduced bacterial growth rates at pressures of 68, 172, 344, and 516 kPa; and at 689 kPa, demonstrated a significant loss of viability in standard plate count assays. The 689-kPa treatment also reduced gram-negative bacteria and total Lactobacillus spp. The time required for raw milk treated at 689 kPa and held at 4°C to reach 4.30 log₁₀ cfu/mL increased by 4 d compared with untreated controls. Total coliform counts in the treated milk were maintained at 1.95 log₁₀ cfu/mL by d 9 of treatment, whereas counts in the control significantly increased to 2.61 log₁₀ cfu/mL by d 4 and 2.89 log₁₀ cfu/mL by d 9. At d 8, Escherichia coli counts had not significantly changed in treated milk, but significantly increased in the control milk. Thermoduric bacteria counts after 8 d were 1.32 log₁₀ cfu/mL in treated milk and 1.98 log₁₀ cfu/mL in control milk. These data indicated that holding raw milk at low CO₂ pressure reduces bacterial growth rates without causing milk protein precipitation. Combining low CO₂ pressure and refrigeration would improve the microbiological quality and safety of raw milk and may be an effective strategy for shipping raw single strength or concentrated milk over long distances.