A comparison of the effects of electrical, captive bolt or percussion stunning on the incidence of blood splash in lambs

Three-hundred-and-three lambs were divided into three equal groups. Half the lambs in each group were not weaned before slaughter and the weaned half were slaughtered a week later. Lambs in one group were head stunned electrically before slaughter; in the second group lambs were stunned with a captive bolt pistol and in the third group they were percussion stunned before slaughter. Carcasses, gall-bladders, hearts and duodenums were inspected for blood splash after slaughter. A few small haemorrhages were detected in 57% of the electrically stunned lambs, in 30% of the captive bolt stunned lambs and in only 16% of the percussion stunned animals. Although no splash of commercial significance was found in any carcass, 25% of the electrically stunned lambs had detectably splashed carcasses, whilst only 1% of percussion-stunned lambs had splashed carcasses with captive bolt stunned lambs being intermediate in carcass splash incidence. These results show that stunning method affects the incidence of blood splash.     

Post-mortem variation in pH, temperature, and colour profiles of veal carcasses in relation to breed, blood haemoglobin content, and carcass characteristics

A total of 1764 male calves of the Meuse-Rhine-Yssel (MRY) and Friesian-Holstein (FH) breeds were slaughtered at two commercial slaughterhouses to investigate the variation in pH, temperature, and colour of Dutch veal carcasses processed without electrical stimulation and with a moderate chilling regimen (average temperature of the longissimus lumborum muscle at 45 min, 3, 24, and 48 h post-mortem was 38.4, 23.3, 3.7 and 1.9°C, respectively). Blood haemoglobin content was determined 2 weeks before slaughter. The efficacy of captive bolt stunning was scored and the carcass movements after shackling registered. Temperature and pH measurements were carried out at 45 min, and 3, 24, and 48 h after slaughter in the longissimus lumborum muscle (LL). Muscle surface colour (CieLAB-values) was measured with a colorimeter at the rectus abdominis muscle at the same times post-mortem. Carcass conformation and visual carcass colour classification were determined at 45 min post-mortem. Carcasses with a better EUROP-conformation score and heavier weight showed a higher rate of pH decline and a slower cooling rate. Slight differences in cooling systems between the slaughterhouses caused marked differences in pH and temperature profiles. Significant differences in carcass weight were observed between the MRY and FH breeds, leading to significant differences in pH and temperature profiles. Carcass colour of the two breeds was similar. Veal carcass colour in general was not related to the observed variation in post-mortem pH and temperature in the longissimus lumborum muscle and was shown to be more associated with the blood haemoglobin content. Haemoglobin content of the blood in the period before slaughter was shown to be related to the visually assessed carcass colour at 45 min post-mortem (using a 10-colour scale), as well as to the instrumentally determined L*-value, with significant correlation coefficients of 0.61 and -0.61, respectively. Repeated captive bolt stunning to obtain unconsciousness significantly decreased pH at 3 h post-mortem. The degree of carcass movement after slaughter did not influence pH, temperature, or colour profiles of the carcasses.     

Rate of blood loss and timing of exsanguination on prevalence of ecchymosis in fallow deer (Dama dama)

Blood loss associated with four combinations of stunning and exsanguination methods was determined as part of studying prevalence of ecchymosis in slaughtered fallow deer (Dama dama). A fifth treatment simulated incomplete severance of the extended neck after captive bolt stunning. Predicted mean weights of blood collected from the five slaughter treatments, including electrical stunning followed by the thoracic stick method of exsanguination, captive bolt stunning followed by the thoracic stick, captive bolt stunning followed by the gash cut method of exsanguination, electrical stunning followed by the gash cut, and captive bolt stunning followed by incomplete severance of the extended neck, were 1458.7, 1072.7, 684.5, 463.7, and 228.5 g, respectively. The overall effect of exsanguination method was highly significant (p < 0.001) with the thoracic stick resulting in the greatest weight of blood collection in the 10 s period immediately after initiation. The overall effect of stunning method on blood loss was not significant, although there was a significant (p < 0.05) stunning method by exsanguination method interaction. Ecchymosis of varying severity occurred in some carcases from all treatment groups. Using the total loin and round ecchymosis scores, when little or no ecchymosis (grades 0 or 1) was compared with some ecchymosis (?grade 2) by logistic regression, castrated bucks were 9.8 times more likely (p = 0.002) and does 4.2 times more likely (p = 0.06) to have some ecchymosis than entire bucks. The results indicate that ecchymosis can be reduced in fallow deer carcases by thoracic stick exsanguination incorporated less than 10 s after stunning.     

The residual blood content of meat—A review

There seems to be no unequivocal experimental evidence to support the widely held view that the efficiency of bleeding out of slaughter animals affects the eating or keeping qualities of meat. Neither are the effects of different slaughter procedures on bleeding efficiency clear, due partly to confusion over the relationship between the residual blood content of meat and the amount of blood lost at slaughter and partly to differences in the methodology used by various authors. As yet no really accurate and specific technique for determining whole blood in meat has been described.     

Some aspects of the effectiveness of stunning in sheep by the captive bolt

The effects of penetration depth and the velocity of the bolt on the onset of unconsciousness was investigated in twenty-four sheep of about 45 kg liveweight. The sheeps' state of consciousness was judged from the electrocorticograms recorded via electrodes surgically pre-implanted frontally on the right side of the head. Sixteen sheep were trephined. A commercial captive bolt pistol and an experimental manual bolt, both with variable penetration depths, were used to represent high and low velocity stunning. Stunning by destroying only the cortex or by only penetrating the skull when the experimental bolt or captive bolt pistol, respectively, were used, did not produce unconsciousness. Unconsciousness was obtained after destroying the cortex and deeper parts of the brain with the experimental bolt (low velocity) or after destroying the cortex (and deeper parts of the brain by shockwaves) when using a captive bolt pistol (high velocity). To produce unconsciousness the captive bolt should have sufficient energy and length after penetration of the skull to crush the cortex and deeper parts of the brain, either directly or by shockwaves.     

Residual blood in lamb muscles

The effect of slaughter method on the residual blood content of the M. longissimus dorsi, the microbiological status of the meat and its tenderness was examined with lambs. There were no differences in any of the characteristics examined between the various stunning procedures used, even though there were marked differences in the amount of blood collected after slaughter.     

Post mortem energy metabolism and meat quality of porcine M. longissimus dorsi as influenced by stunning method - A (31)P NMR spectroscopic study

Post mortem changes in phosphorus metabolites and pH were studied in M. longissimus dorsi from pigs (n=10) stunned either by CO(2) (n=3), electrical (n=2), captive bolt pistol (n=2) or by anesthesia (ketamine) (n=3). (31)P-NMR spectroscopy revealed significant effects of stunning method on changes of the various phosphorus metabolites in the muscle post mortem, with the effect being most pronounced on the degradation of phosphocreatine (PCr). Moreover, the four stunning methods gave rise to large differences in the progress of pH as determined by (31)P-NMR spectroscopy. Using anesthesia as the reference showed that the captive bolt pistol caused the highest rates of post mortem degradation of phosphorus metabolites, electrical stunning intermediate, and CO(2)-stunning causing the lowest post mortem degradation rates, even though CO(2)-stunning also was associated with higher post mortem degradation rates compared with anesthesia. Finally, it was demonstrated that the water-holding capacity (WHC) of the meat was affected by the applied stunning method, as CO(2)-stunning, electrical stunning and captive bolt pistol resulted in mean drip losses of 6.4, 8.3 and 8.6%, respectively (P=0.02). The result displays the significance of induction and progress in post mortem changes on WHC in meat.     

Dissemination of brain emboli following captive bolt stunning of sheep: capacity for entry into the systemic arterial circulation

The epidemic of bovine spongiform encephalopathy in the United Kingdom and the recognition of a variant of Creutzfeldt-Jakob disease prompted revision of the guidelines for slaughter of cattle and sheep to prevent contamination of the edible parts of the carcass with central nervous system tissue. We previously showed that captive bolt gun stunning, which is routinely used for the slaughter of cattle and sheep, causes entry of fragments of central nervous system tissue into the jugular vein. To determine whether such tissue can traverse pulmonary capillaries to enter the systemic circulation, we introduced small volumes of brain tissue that had been disrupted by stunning with a captive bolt gun into the jugular vein of sheep sent for slaughter. We examined aortic blood samples by immunocytochemistry for neurofilament and S100 proteins and by enzyme-linked immunosorbent assay for glial fibrillary acidic protein and found fragments of neurofilament- and S100-immunopositive central nervous system tissue in samples from 2 of 11 sheep and elevated glial fibrillary acidic protein in 6 sheep. Our findings suggest that central nervous system tissue that is dislodged during routine captive bolt gun stunning and slaughter of sheep can enter the systemic arterial circulation and that, in some cases, this method of slaughter of an animal infected with bovine spongiform encephalopathy would be likely to contaminate edible parts of the carcass with infective material.     

Observations on the physiological effects of pithing cattle at slaughter

Pithing cattle after captive bolt stunning, by thrusting a rod into the cranial cavity, causes violent muscular activity. The present observations have shown that this does not result in a rapid fall in the muscle pH similar to that occurring after electrical stimulation. The claim that pithing for a greater length than usual down the spinal cord causes marked enlargement of the spleen has not been substantiated.     

Effect of pre-slaughter handling on the quality and microbiology of venison from farmed young red deer

Young stags, castrates and hinds, raised on heathery hill pasture were subjected to three levels of stress prior to slaughter. They were either individually penned overnight and shot, confined in threes in a pen overnight and stunned by captive bolt or confined in threes in a wire fenced pen overnight and then agitated by an older deer for 2 h and finally stunned by captive bolt. Some 30% of the stag and castrate carcasses had high ultimate pH (pH_u≥6.0) and the venison from these exhibited typical dark cutting appearance. The pH_u of the hind carcasses was <5.5. Overall there was no significant difference in pH_u between stressed and unstressed groups, but the incidence of high pH_u was greatest in the severely stressed stags and castrates. Texture of roasted M. semimembranosus pH_u of <6.0 was slightly to moderately tender and the high pH_u venison was very tender. Stress level did not affect the microbiological condition of the freshly skinned carcasses or the total viable counts on joints during storage at 1°C.     

Blood in the respiratory tract during slaughter with and without stunning in cattle

Bovine respiratory tracts were examined for blood following shechita without stunning, halal slaughter without stunning, and captive bolt stunning with sticking. In all three methods the cattle were in the upright (standing) position at the start of bleeding. Those that had not been stunned continued to breathe during the early part of bleeding whilst those that were stunned were not breathing. Nineteen percent of the shechita, 58% of the halal and 21% of the stunned plus stuck cattle had blood lining the inner aspect of the trachea. Thirty six percent, 69% and 31% had blood in the upper bronchi, respectively. Ten percent, 19% and 0% had fine bright red blood-tinged foam in the trachea, respectively. It was concluded that concerns about suffering from airway irritation by blood could apply in animals that are either not stunned before slaughter or do not lose consciousness rapidly whilst blood is present in the respiratory tract.     

The effects of electrical stunning and percussive captive bolt stunning on meat quality of cattle processed by Turkish slaughter procedures

The effects of electrical and percussive captive bolt stunning both on initial and up to 14 days post mortem meat quality of Friesian young bulls were studied. The first group (NS; n=10) were slaughtered without stunning under Turkish slaughter procedure (these animals were slaughtered under conditions acceptable to the appropriate ethics committee) in a modern abattoir. In the second group (ES; n=10) animals were electrically stunned. In the third group (PS; n=10) animals were stunned with percussive captive bolt. Meat quality was assessed by examining muscle glycogen concentration, pH and WHC. Also cooking loss, texture parameters and consumer sensory properties were assessed at 24 h, 4, 7 and 14 days post mortem. Meat colour as L^*, a^*, b^*, C^*, h^* values were evaluated at 0, 48 h, 3, 5, 7, 9 and 14 days post mortem. Pre-slaughter handling affected muscle glycogen concentration (P<0.05). Animals in electrical and percussive captive bolt stunned groups had higher muscle glycogen concentrations compared to animals in the non-stunned group (P<0.05). Although pre-slaughter handling did not affect significantly pH_{24 h} and WHC, differences were significant for cooking loss, colour coordinates and texture parameters at some storage times. For all sensory attributes (odour, flavour, tenderness and overall acceptability) at all ageing periods (24 h, 4, 7 and 14 days) the percussive stunned (PS) group was significantly superior to the non-stunned (NS) group. The electrically-stunned (ES) group also tended to be superior to the NS group although not all differences were statistically significant. These results indicate that percussive captive bolt stunning of cattle improved meat quality compared with cattle electrically stunned using head only tongs and those non stunned under approved Turkish slaughter procedure.     

Relationships between time of stunning and time of throat cutting and their effect on blood pressure and blood splash in lambs

A study based on 84 electrically stunned lambs showed that those gash stuck (transverse incision of the extended neck which almost simultaneously severs the trachea, oesophagus, common carotid arteries and jugular veins and the spinal cord at the occipito-atlantal junction; Blackmore & Newhook, 1976) immediately after removal of the electrical applicator had a lower incidence of blood splash than lambs gash stuck 5-8 sec r stunning. Lambs whose throats were cut immediately before the application of the electrical current had the lowest incidence of blood splash. None of the splash observed was of commercial significance. Systolic blood pressure recordings were made on a further 12 lambs of a similar age, 10 of which were electrically stunned and two shot with a captive bolt pistol. Blood pressure changes observed were related to the blood splash results obtained in the first trial. Electrical stunning raised blood pressures to an average of 3·5 times normal in lambs allowed to recover from stunning. A further seven young unweaned lambs which were electrically or percussion stunned showed a similar pattern of blood pressure change to that reported for older lambs following stunning, except that lower maximum pressures were reached. The authors interpret the results of the present trials as indicating that the application of electrical current to the heads of lambs results in damage to small vessels prior to the elevation of blood pressure. This damage may become apparent in the dressed carcass and organs as small haemorrhages. The subsequent rise in blood pressure following stunning then exacerbates the leakage of blood into tissues and it becomes more apparent in the form of discrete haemorrhages or blood splash.     

Recent concerns about stunning and slaughter

This review summarises information that is relevant to concerns that have recently been expressed about stunning and slaughter. It is known that captive bolt stunning can result in brain material passing to the lungs via the jugular veins. If future studies show that BSE prions pass beyond the lungs to the edible carcass, there will be a move away from captive bolt stunning in large cattle towards electrical stunning. Greater use of electrical stunning in large cattle will increase the importance of blood splash in the beef industry. The theoretical causes of blood splash are reviewed to improve our understanding of this problem. In some situations it can be due to excessive venous pressure causing rupture of a capillary bed some distance from the source of the pressure rise, but it is not known whether this applies to electrical stunning. Gas stunning is replacing electrical stunning for poultry because it can reduce blood spots, which is a similar condition to blood splash. Several gas stunning methods are now being used, but it is not clear which of these is the most humane. Anoxic stunning leads to carcass convulsions and this causes more carcass damage. In fish, recent developments in electrical stunning are showing promise in overcoming problems with carcass damage. It is recommended that rock lobsters should be chilled or frozen before butchery, to ensure a humane death.     

Brain tissue fragments in jugular vein blood of cattle stunned by use of penetrating or nonpenetrating captive bolt guns

Although the incidence of bovine spongiform encephalopathy in cattle continues to decline in the United Kingdom, it remains important to maintain vigilance of all potential routes of transmission of infection to humans. Initial studies have demonstrated a potential risk of carcass contamination with brain tissue following the use of captive bolt gun stunning in cattle. The objective of this study was to further explore these initial findings particularly in regard to captive bolt guns currently in use in the United Kingdom. Brain tissue fragments or elevated levels of a marker protein for brain tissue were detected in venous blood samples from 4% (95% confidence interval, 1.6 to 9.8%) of cattle stunned by penetrating captive bolt gun and from 2% (95% confidence interval, 0.6 to 7%) of those stunned by nonpenetrating captive bolt gun.     

Effect of cardiac arrest at slaughter on residual blood content of hide

Inducing a cardiac arrest between stunning and sticking in cattle had no effect on the residual blood content of the hide. Skin from animals which had been dead for about 15 min, but not bled, contained twice as much blood as skin from animals slaughtered in a normal manner. It is concluded, therefore, that the fellmongering problems which are associated with excessive amounts of blood in the hide should not be a problem when stunning methods which simultaneously induce a cardiac arrest are used. This should hold true provided the animal is stuck promptly after it has undergone heart failure.     

Arrested blood flow during false aneurysm formation in the carotid arteries of cattle slaughtered with and without stunning

The time to onset of arrested blood flow and the size of false aneurysms in the severed carotid arteries were assessed in 126 cattle during halal slaughter without stunning. Thirty six cattle (29%) showed early arrest of blood flow. In 6%, both the left and right carotid arteries in the same animal stopped bleeding before 60 s had elapsed following the neck cut. The time to early arrested blood flow was on average 21 s, and this was accompanied by enlargement with false aneurysms which occluded the arteries. In the arteries which were still bleeding at 60 s after the neck was cut the artery size was normal. Based on comparative data from different slaughter premises it appeared that making the cut in the neck at the first cervical vertebra instead of the second to fourth cervical vertebrae reduced the frequency of false aneurysm formation and early arrested blood flow. This was confirmed in a separate controlled trial where 100 cattle were stunned with a captive bolt and the arteries were examined following neck cutting at either the C1 or C3 positions.     

A note on the reduction in the iron content of meat in relation to iron deficiency

The blood haemoglobin concentration, serum iron levels and muscle iron content of cattle, pigs, lambs and chickens were determined at the time of slaughter. There was a marked reduction in the iron content of pork, beef and chicken when compared with the figures quoted by McCance & widdowson (1960). The possible relationship between a reduction in the iron content of meat and the aetiology of iron deficiency is discussed.     

Effects of fattening on post-mortem pH of beef muscles

The pH of beef psoas major (PM) and longissimus dorsi (LD) muscles at 1·0 h after slaughter were examined among the following four groups: pithed fattening cattle (FP), non-pithed fattening cattle (FN), pithed calves (CP) and non-pithed calves (CN). Differences were observed only in PM muscles. The levels of pH were in the order of FP相似文献   

Effects of pithing on pH, creatine phosphate and ATP-related compounds of beef Psoas major and Longissimus dorsi muscles

The effects of pithing at slaughter on meat quality were studied in M. longissimus dorsi (LD muscle) and M. psoas major (PM muscle) from steers. Ten steers, half of them pithed and the others not pithed at slaughter, were used for determining pH values and concentrations of creatine phosphate (CP), adenosine triphosphate (ATP) and its breakdown products in the muscles at 2·0 h post mortem. CP was not detected in any PM muscles from pithed steers and no significant differences were observed between pithed and non-pithed steers on the mean values of pH and any compounds, but significant differences were observed in the variance of pH value, ATP, (inosine monophosphate IMP) and inosine levels in PM muscles and of (adenosine diphosphate ADP) and IMP levels in LD muscles. When two steers with excitable temperament were excluded from the pithed group significant differences of variance between the treatments were observed only in PM muscles. The pithing procedure thus affects the levels of pH and of some of the ATP-related compounds in the PM but not in LD muscles.