Fermentation of Cucumbers Brined with Calcium Chloride Instead of Sodium Chloride

ABSTRACT: Waste water containing high levels of NaCl from cucumber fermentation tank yards is a continuing problem for the pickled vegetable industry. A major reduction in waste salt could be achieved if NaCl were eliminated from the cucumber fermentation process. The objectives of this project were to ferment cucumbers in brine containing CaCl₂ as the only salt, to determine the course of fermentation metabolism in the absence of NaCl, and to compare firmness retention of cucumbers fermented in CaCl₂ brine during subsequent storage compared to cucumbers fermented in brines containing both NaCl and CaCl₂ at concentrations typically used in commercial fermentations. The major metabolite changes during fermentation without NaCl were conversion of sugars in the fresh cucumbers primarily to lactic acid which caused pH to decrease to less than 3.5. This is the same pattern that occurs when cucumbers are fermented with NaCl as the major brining salt. Lactic acid concentration and pH were stable during storage and there was no detectable production of propionic acid or butyric acid that would indicate growth of spoilage bacteria. Firmness retention in cucumbers fermented with 100 to 300 mM CaCl₂ during storage at a high temperature (45 °C) was not significantly different from that obtained in fermented cucumbers with 1.03 M NaCl and 40 mM CaCl₂. In closed jars, cucumber fermentations with and without NaCl in the fermentation brine were similar both in the chemical changes caused by the fermentative microorganisms and in the retention of firmness in the fermented cucumbers.     

Effects of Sodium Chloride Concentration on Firmness Retention of Cucumbers Fermented and Stored with Calcium Chloride

The firmness of cucumbers brined at 0.2% CaCl₂ was retained during fermentation (1 month) and storage (12 months) when 2.6, 4.2 or 5.8% NaCl also was present. Firmness retention was not improved (P≥0.05) during storage by increase in NaCl concentration to 11.9% after fermentation. In the absence of added NaCI, cucumbers were firm after fermentation, but firmness was reduced during storage to 69% of initial for whole cucumbers, 64% for mesocarp tissue, and 32% for endocarp tissue. Addition of uncharacterized softening enzymes. extracted from debris collected at a cucumber grading operation, resulted in softening of cucumbers brined at 1.8% NaCl in the absence of added CaC1₂. Addition of CaCl₂ reduced but did not eliminate softening by ths extract. Results indicated that the firmness of brined cucumbers could be retained at appreciably lower NaCl concentrations than those traditionally used but that the lower limit of NaCl required to prevent softening by possible contaminating enzymes is yet to be established.     

Physiological and biochemical changes of different fresh-cut mango cultivars stored at 5 °C

Treatments to inhibit browning, decay and to extend shelf life of ‘Keitt’, ‘Kent’ and ‘Ataulfo’ mango cultivars as a fresh‐cut produce were investigated. Combinations of calcium chloride (CaCl₂), antioxidants [ascorbic acid (AA), citric acid (CA)] and two commercial film coatings resulted in a reduction of browning and deterioration of fresh‐cut mangoes stored at 5 °C, especially for the Ataulfo cultivar. The use of CaCl₂ + AA + CA significantly reduced colour deterioration, loss of firmness and did not affect sensory characteristics of fresh‐cut mango, with a larger effect in the Ataulfo cultivar. In general, these treatments prevented loss of sugar and vitamin C of cubes during storage at 5 °C. Shelf life of this cultivar was 21 days, while that of Keitt and Kent was only 9 and 12 days, respectively. There is a correlation between carotene and vitamin C content of Ataulfo mango and its longer shelf life compared with the other cultivars.     

Anti-oxidant content of different coloured sweet peppers, white, green, yellow, orange and red (Capsicum annuum L.)

Five different coloured sweet peppers (Capsicum annuum cv. Signal), white, green, yellow, orange and red were analysed for total carotenoids, α‐tocopherol, sugars (glucose, fructose and sucrose), organic acids (citric and ascorbic acids) and anti‐oxidant properties. The mature fruits, ‘Signal Red’, ‘Signal Orange’ and ‘Signal Yellow’ contained higher carotenoids, α‐tocopherol, sugars and organic acids than the immature fruits, ‘Signal Green’ and ‘Signal White’. Among the mature fruits, ‘Signal Red’ was the highest in total carotenoids [9.15 mg (100 g)^?1 of fresh weight] while ‘Signal Orange’ was the highest in α‐tocopherol [5.40 mg (100 g)^?1 of fresh weight]. ‘Signal Red’ and ‘Signal Orange’ contained the most sugars and organic acids. The suppression of 2,2′‐azobis (2,4‐dimethylvaleronitrile) (AMVN)‐induced oxidation of methyl linoleate by the acetone extracts from the coloured sweet peppers resulted as follows: ‘Signal Red’ > ‘Signal Orange’ ≈ ‘Signal Yellow’ > ‘Signal Green’ ≈ ‘Signal White’. The order of 1,1‐diphenyl‐2‐picrylhydrazyl (DPPH) radical scavenging activities of the acetone extracts was similar to that of suppression of methyl linoleate oxidation.     

Firmness and Cell Wall Characteristics of Pasteurized Jalapeño Pepper Rings Affected by Calcium Chloride and Acetic Acid

Pepper rings packed in brine containing CaCl₂ were firmer, had higher bound calcium, chelator soluble pectin and pectin DE, and less water-soluble pectin (WSP) than peppers packed in brine containing no CaCl₂. Pepper rings packed in low acid brines (1% and 1.2% acetic acid) were firmer and had less WSP than those packed in high acid brine. Those samples (4% acetic acid) resulted in softening and pectin solubilization, but CaCl₂ resulted in less softening. Monosaccharide composition of cell walls was not affected by CaCl₂ or acetic acid. Firmness retention in CaCl₂ treated samples was probably due to greater association between calcium ions and pectic substances, which resisted acid hydrolysis.     

Effect of heat treatment on physiochemical,colour, antioxidant and microstructural characteristics of apples during storage

Changes in qualities of ‘Red Fuji’ and ‘Golden Delicious’ apples in response to different heat treatments (45 and 60 °C) following cold storage were investigated. Quality indices including firmness, titratable acidity, total phenolic content, antioxidant capacity, colour parameters and microstructure were measured. Results indicated heat treatment at both temperatures for 3‐h hastened loss of titratable acidity in ‘Red Fuji’ and ‘Golden Delicious’ apples, but maintained firmness in both cultivars. However, heat treatment at lower temperature (45 °C) best maintained total phenolic compounds and antioxidant capacity in ‘Red Fuji’ apples throughout storage, whereas there was no difference between heat treatments in ‘Golden Delicious’ apples. Examination by scanning electron microscope (SEM) revealed that the effect of heat treatment at different temperatures on ‘Red Fuji’ and ‘Golden Delicious’ apples was structurally different. Apple tissue that had been heat treated at elevated temperature (60 °C) for 3 h was associated with fractured cell walls and collapse of cells.     

Effect of Calcium Chloride and Alum on Fermentation, Desalting, and Firmness Retention of Cucumber Pickles

The effects of CaCl₂ in cucumber pickle fermentation and storage brines on fermentation, desalting and retention of mesocarp firmness after processing were determined. Also, the influence of post-desalting treatments with alum and CaCl₂ on firmness of processed pickle was evaluated. Fermentation and desalting were unaffected by CaCl₂ treatment of fermentation brines. However, exposure of pickles to CaCl₂ during fermentation and brine storage substantially reduced softening after processing. Post-desalting treatment with alum and/or CaCl₂ of pickles not previously exposed to CaCl₂ also reduced softening. Retention of firmness was maximized in pickles processed from fermentation and storage brines containing CaCl₂ and treated with alum or CaCl₂ after desalting.     

Improving textural quality in frozen jalapeño pepper by low temperature blanching in calcium chloride solution

The effects of low temperature blanching in calcium chloride solution of jalapeño peppers prior to freezing, on firmness retention, pH, methanol, colour and calcium ions of the product, were evaluated by response surface methodology. Texture, methanol content and pH were affected by all of the variables studied (P = 0.05). The optimum response was obtained at temperatures of 63.3–66 °C, calcium chloride concentrations of 0.17–0.21 m , immersion time of 11.6–14.4 min, with a holding time after blanching of 56.6–66.1 min. Microscopic evaluation of the thawed pepper showed that blanching in CaCl₂ solution provided a protective effect in maintaining cell wall integrity.     

Fermentation of Cucumbers in Anaerobic Tanks

A procedure was developed and tested for fermentation of cucumbers at low concentrations of NaCl in experimental, anaerobic tanks. The procedure included washing of the cucumbers, use of a buffered cover brine composed of 0.045M calcium acetate, sodium chloride to equilibrate at 2.7% or 4.6%, Lactobacillus plantarum culture, and N₂ purging to remove dissolved CO₂. The fermentations were predominantly homofermentative, lactic acid accounting for 95% of the cucumber sugars fermented. Firmness retention of the fermented cucumbers during storage for 1 year was improved by heating packaged products to 69°C before storage, but firmness retention was acceptable in un-heated products.     

Apple Quality as Influenced by Fumigation with Methyl Bromide

The use of methyl bromide (MeBr) did not detract from the firmness or skin color of‘Delicious’, ‘Golden Delicious’ or ‘Granny Smith’ apples. Fruit fumigation with MeBr resulted in a darkening of the objective and subjective internal flesh color of ‘Delicious apples, particularly unwaxed apples treated with 48g MeBr/m₃ at 20°C for 2 hr. Internal flesh color of ‘Golden Delicious’ apples was not influenced at 48g MeBr/m³ at 6°C for 2 hr. Fumigation with 32g MeBr/ m³ at 20°C or 56g MeBr/m³ at 6°C for 2 hr did not detract from the firmness or internal color quality of ‘Delicious’, ‘Golden Delicious’ or ‘Granny Smith’ apples after 60 days in storage. MeBr-treated apples displayed greater acidity and less ethylene production than control fruit. Higher MeBr treatment temperature and the use of wax on fruit directly influenced the reaction of apples to MeBr fumigation.     

Quality aspects of fresh‐cut ‘long‐storage tomato’ as affected by package,calcium chloride and storage time

In this research, some quality changes during storage at 4 °C were assessed in fresh‐cut fruits of a ‘long‐storage tomato’ landrace, packaged in biocompostable materials (PLA Ingeo tray/NatureFlex? film) or in conventional plastics (PET tray + polypropylene film). The effects of dipping in CaCl₂ on the shelf‐life extension were also assessed. Plants were cultivated both off‐season (greenhouse) and in‐season (open field). CO₂ and O₂ concentration, fruit weight loss, firmness, colour, microbial load were measured at 0, 4, 7, 12 days of storage. Headspace gas changes and fruit weight loss were minimised in conventional package. BIO package prevented water condensation, led to max 5% weight loss and made fruits less susceptible to spoilage. Dipping in CaCl₂ induced better firmness, especially in biopackage. Off‐season fruits had overall lower quality than in‐season fruits; however, these may contribute to extend the production season, with interesting marketing implications for the agri‐food industry.     

Cold storage of six nectarine cultivars: consequences for volatile compounds emissions, physicochemical parameters, and consumer acceptance

The effects of cold storage and shelf life of ‘Big Top,’ ‘Honey Blaze^cov,’ ‘Honey Royale^cov,’ ‘Venus,’ ‘August Red,’ and ‘Nectagala^cov’ nectarines were evaluated. Volatile compounds, firmness, soluble solids content, titratable acidity, color, and degree of consumer acceptance of the fruit were determined at harvest, after storage at ?0.5 °C for 10, 20, or 40 days and following 3 days at 20 °C. Ten days cold storage plus 3 days at 20 °C produced the highest total ester emission for ‘Nectagala^cov’ and ‘August Red,’ while similar results were obtained after 10 days cold storage for the ‘Big Top’ and ‘Honey Blaze^cov’ and 20 days cold storage for ‘Honey Royale^cov’ and ‘Venus.’ For ‘Nectagala^cov,’ this higher total ester emission coincided with the greatest percentage of satisfied consumers. Increased consumer acceptance was associated with the cultivars and storage time that resulted in firmer fruits and greater concentrations of specific volatile compounds.     

Thermal and Calcium Pretreatment Affects Texture, Pectinesterase and Pectic Substances of Frozen Sweet Cherries

Freezing causes loss of turgidity and firmness in sweet cherries. Thermal pretreatment at 50°C for 10 min followed by immersion in 100 mM CaCl₂ and thermal pretreatment at 70°C/2 min with or without immersion in 100 mM CaCl₂ prevented freezing-induced loss of firmness. Thermal pretreatments increased the pectin fraction soluble in EDTA, reduced the degree of pectin esterification, and increased both the concentration of divalent cations in the cell wall and the pectinesterase activity bounded to the cell wall. Immersion in CaCl₂ increased the concentration of Ca²⁺ cations in the cell wall and enhanced the effect of thermal pretreatments on pectinesterase activity.     

PECTIC SUBSTANCES AND FIRMNESS OF CUCUMBER PICKLES AS INFLUENCED BY CACL2, NACL AND BRINE STORAGE1

The effects of brine treatments (CaCl₂ and NaCl) and storage on pectic substances and texture of cucumber pickles were examined. Firmness of cucumber pickles was closely associated with the solubility characteristics and degree of esterification (DE) of pectic substances. Brining, storage, time of CaCl₂ addition and concentration of NaCl and CaCl₂ were all observed to influence the characteristics of pectic substances. Important to preventing softening was maintenance of pectic substances not extractable (NXP) by conventional methods, i.e., by water (WSP), the chelator sodium hex-ametaphosphate (CSP), and dilute alkali (OHSP). Erosion of NXP consistently resulted in increased levels of CSP and reduced firmness. Reducing the amount of demethylation of pectins was also associated with maintaining firmness. Although the DE declined rapidly during brining, tissues from treatments that enhanced firmness had pectic substances with the highest DE. CaCl₂ added to brine at the beginning of fermentation was most effective in preventing the demethylation of pectins and solubilization of NXP. In contrast, delayed addition of CaCl₂ and storage in low NaCl concentration (5% or less) caused greater pectin demethylation, erosion of NXP with concomitant increases in CSP and tissue softening.     

Canning Quality Evaluation of Pinto and Navy Beans

Thermal processing of pinto and navy beans at 121.1°C for 16 or 14 min in a still retort gave similar sterilization value (F_o= 10) as the processing at 115.6°C for 45 min. The 121.1°C/16 or 14 min process produced beans with greater firmness than the 115.6°C/45 min process. The addition of CaCl₂ and EDTA improved firmness and color of canned beans. Calcium chloride also reduced clumping and splitting of the canned beans. Sensory evaluation showed that the acceptability of canned beans was reduced when CaCl₂ was increased up to 10 mM. High correlation between firmness and soluble pectin in various bean cultivars implied that soluble pectin content could be used as a parameter for screening bean cultivars with desirable firmness.     

Calcium Treatments Affect Storage Quality of Shredded Carrots

Carrot shreds, sticks and slices were dipped in solutions of CaCl₂ alone, or with chlorine and stored at 0, 5 or 10°C to determine the effects of calcium (Ca) on storage quality. A 0.5% or 1% CaCl₂ treatment maintained firmness and reduced microbial growth of carrot shreds at all temperatures. These treatments also resulted in lower tissue pH than in the water-dipped controls. Treatments increased Ca content slightly in sticks and slices and substantially in shreds and had no effect on storage quality of sticks or slices.     

The interaction of pulsed electric fields and texturizing ‐ antifreezing agents in quality retention of defrosted potato strips

The combination of pulsed electric fields (PEF) and texturizing and antifreeze agents on quality retention of defrosted potato strips were studied. Potato strips (10 mm thickness, 100 g) were placed in different solutions (1% w/v) of CaCl₂, glycerol, trehalose as well as NaCl and sucrose, treated with PEF (0.5 kV cm^?1, 100 pulses, 4 Hz). Then, all the samples were soaked in the same solutions for 10 min. After draining, samples were packed into polypropylene pouches and stored at ?18 °C for 12 h. Samples were thawed out at room temperature (20 °C) in 3 h. Untreated controls and PEF treated control samples were also frozen and thawed in similar conditions. To assess the potato strip quality, the thawed samples were analysed for moisture content, weight loss, firmness and colour attributes. The results indicate that PEF treatment by itself is not a suitable pre‐treatment method for frozen potato strips and should be assisted by CaCl₂ and trehalose treatment to prevent softening after defrosting. Firmness analyses determined that application of PEF alone results in 2.38 N. However, PEF in combination with CaCl₂ and trehalose result in 2.97 N and 2.99 N, respectively, which are both significantly firmer than the samples solely treated with PEF. CaCl₂ and trehalose were effective in not only maintaining the structural integrity of the cells, but also retaining colour attributes. The L* value was found to be higher (P < 0.05) in CaCl₂ and trehalose treated samples (58.95 and 57.21, respectively), as compared to PEF treated samples (53.97) denoting a darker colour. Application of CaCl₂ and trehalsoe in combination with PEF also resulted in significantly less weight loss after thawing.     

QUALITY CHARACTERISTICS OF 'BING' AND 'RAINIER' SWEET CHERRIES TREATED WITH GIBBERELLIC ACID, FOLLOWING FUMIGATION WITH METHYL BROMIDE

Methyl bromide (MeBr) fumigation did not significantly influence weight loss, fruit color or soluble solids of either ‘Bing’ or ‘Rainier’ sweet cherries. MeBr increased pitting and reduced objective and subjective stem color of both cultivars. There was a slight advantage in quality (bruising, pitting and stem color) for the 48g/m³ at 12°C over the 64g/m³ at 6°C MeBr treatment. As fumigation temperature increased, bruising and pitting increased and stem color decreased. Use of gibberellic acid resulted in increased firmness for ‘Bing’ cherries and superior fruit and stem color with less pitting for both ‘Bing’ and ‘Rainier’ cherries.     

Carotenoid Retention In Canned Pickled Jalapeño Peppers and Carrots As Affected by Sodium Chloride, Acetic Acid, and Pasteurization

ABSTRACT The combined effect of salt, acetic acid, and pasteurization temperature on the retention of carotenoids in canned pickled carrots and green jalapeño peppers was studied by a central composite design. The results were analyzed by response surface methodology. The carotenoid standards were obtained by open column chromatography and the quantitation was done by HPLC. Only the main carotenoids were quantified: α‐ and β‐carotene in carrots and α‐, β‐carotene, lutein, and violaxanthin in peppers. After analyzing the experimental results and the restrictions of the Mexican Regulations, 2% NaCl and 2% acetic acid concentrations were recommended. The optimal pasteurization conditions were 70 °C/12.45 min for carrots and 83 °C/5.2 min for peppers.     

Pulsed electric field treatment prior to freezing carrot discs significantly maintains their initial quality parameters after thawing

The interaction of pulsed electric fields (PEF) with different cryoprotectant and texturizing agents in quality retention of carrot discs was analysed. Increasing the permeability properties by PEF may lead to better accessibility of intracellular materials to freezing and thus reducing the freezing time, leading to better maintaining the texture after thawing. Carrot discs of 5 mm thickness were immersed in different solutions of CaCl₂, glycerol, trehalose and tap water, and subsequently were treated with PEF (1 kV/cm, 100 pulses, 4 Hz). Then, the samples were drained and packed along with a control group in separate prepared polypropylene pouches. All the samples were frozen at ?18 °C for 24 h and thawed during 3 h at ambient temperature (20 °C) the following day. The quality of the thawed carrot discs was certified by measuring weight loss, firmness, microscopic studies and CIE colorimetric attributes. All the PEF‐treated samples, no matter what solution they were soaked in, could significantly (P < 0.05) maintain the firmness as well as colour attributes. However, it was deducted that application of CaCl₂ in conjunction with PEF can result in a firmer texture. Firmness analyses determined that application of PEF alone results in 5.84 N, while its combination with CaCl₂ leads to higher value of 6.63 N. Firmness in control samples was found to be 3.46 N. The SEM studies supported the results of firmness analysis and depicted more integrity in the cell walls of the samples treated with CaCl₂ and glycerol. The weight loss values varied among different samples, and the highest amount and lowest amount were reported in CaCl₂ and solely PEF‐treated samples, respectively. There was no significant difference between the colour attributes measured in different groups including control sample (P > 0.05).