溶胶-凝胶法制备纳米镁铝尖晶石纳米粉

以硝酸镁和硝酸铝为原料,柠檬酸为络合剂,混合后制得柠檬酸盐先驱体,并将脲加到柠檬酸盐先驱体中,得到另一种新的含脲柠檬酸盐先驱体.两种先驱体分别经800 ℃和1000 ℃煅烧,可得到镁铝尖晶石纳米粉.XRD分析表明,800 ℃煅烧已有镁铝尖晶石形成,镁铝尖晶石结晶化程度随煅烧温度的升高而提高,而在同一热处理温度下,含脲柠檬酸盐前驱体比柠檬酸盐前驱体制得的纳米镁铝尖晶石颗粒细.TEM结果表明:800 ℃煅烧含脲柠檬酸盐可得到的镁铝尖晶石纳米粉体,颗粒大小均匀,粒径尺寸在20～30 nm.     

非水解sol-gel法合成MgAl2O4纳米粉体

以无水三氯化铝和无水氯化镁为主要原料,采用非水解sol-gel法合成了镁铝尖晶石纳米粉体,研究了氧供体种类(分别为无水乙醇、无水异丙醇和无水异丙醚)、加料顺序及凝胶化温度(分别为90、110、130℃)对镁铝尖晶石合成的影响.结果表明:1)以乙醇为氧供体合成镁铝尖晶石的产率高于以异丙醇和异丙醚为氧供体合成镁铝尖晶石的产率;2)先将无水氯化镁加入到氧供体与二氯甲烷的混合溶液中,再加入无水氯化铝的加料顺序有利于镁铝尖晶石的合成;3)凝胶化温度为110℃有利于镁铝尖晶石的合成,干凝胶经900℃煅烧可合成出平均粒径为50 nm左右的高纯镁铝尖晶石纳米粉体.     

化学共沉淀法制备纳米铋掺杂氧化锡的影响因素研究

以SnCl4.5H2O和Bi(NO3)3.5H2O为原料,氨水为沉淀剂,采用化学共沉淀法制备了铋掺杂氧化锡（BTO）纳米粉体,研究了反应温度、滴定终点pH值、铋掺杂量,煅烧温度和分散剂PEG-600对所得的纳米BTO粉体物相、晶粒度和形貌的影响,对粉末的前驱体进行综合热分析（TG-DTA）,用X-射线衍射（XRD）,扫描电镜(SEM)对产物的结构和形貌进行表征,得到共沉淀法制备纳米BTO粉体的最佳条件：反应温度60℃,滴定终点pH值为3,煅烧温度600℃;该条件下制得BTO粉体的电阻率最小为3.48Ω•cm。     

非水解溶胶-凝胶法合成镁铝尖晶石纳米粉体及其烧结性能

以无水氯化铝、无水氯化镁为前驱体和无水乙醇为氧供体,采用非水解溶胶-凝胶法合成镁铝尖晶石纳米粉体,利用XRD、SEM和激光粒度等表征了粉体晶相、颗粒粒径与形貌及烧结性能。结果表明,在900℃可合成单一镁铝尖晶石纳米粉体,一次粒子平均粒径为50nm左右,存在可通过球磨消除的软团聚,在1600℃烧结3h可以得到气孔少、颗粒结合紧密、相对致密的镁铝尖晶石烧结体。     

非水解溶胶-凝胶法合成镁铝尖晶石纳米粉体及其烧结性能

以无水氯化铝、无水氯化镁为前驱体和无水乙醇为氧供体，采用非水解溶胶-凝胶法合成镁铝尖晶石纳米粉体，利用XRD、SEM和激光粒度等表征了粉体晶相、颗粒粒径与形貌及烧结性能。结果表明，在900℃可合成单一镁铝尖晶石纳米粉体，一次粒子平均粒径为50nm左右，存在可通过球磨消除的软团聚，在1600℃烧结3h可以得到气孔少、颗粒结合紧密、相对致密的镁铝尖晶石烧结体。     

铝源种类对熔盐法合成镁铝尖晶石的影响

分别以分析纯Al2 O3和AlCl3为铝源,以分析纯MgO为镁源,在NaCl和KCl混合熔盐介质中,分别在1000、1100、1200和1250℃保温3 h合成了镁铝尖晶石粉体,研究了试样的物相组成、微观形貌和化学组成.结果表明:1)温度的升高有利于MgAl2 O4的形成和结晶.2)以Al2 O3为铝源合成的镁铝尖晶石在Al2 O3原料表面成核生长,晶体结构随着温度的升高趋于完善;以AlCl3为铝源合成的镁铝尖晶石颗粒粒径约为3μm且呈正八面体结构.     

炭黑包裹燃烧法制备Al_2O_3-ZrO_2复合粉

研究了采用炭黑包裹燃烧法制备Al2O3-ZrO2复合粉体溶液pH值和炭黑氧化温度对复合粉体制备团聚及粒度组成的影响。结果表明:pH值控制为3,经过500℃×10h+600℃×2h脱炭后制得的粉体粒径最小,通过激光粒度分布仪测定得Al2O3-ZrO2复合粉体粒径分布均匀,d10=0.6μm,d50=2.06μm,平均粒径为2.62μm,复合粉体的比表面积为440m2/cm3。     

化学共沉淀法制备纳米铋掺杂氧化锡

以SnCl4.5H2O和Bi(NO3)3.5H2O为原料,氨水为沉淀剂,采用化学共沉淀法制备了铋掺杂氧化锡(BTO)纳米粉体,考察了反应温度、滴定终点pH、铋掺杂量、煅烧温度和分散剂PEG-600对所得的纳米BTO粉体物相、晶粒度和形貌的影响,对粉末的前驱体进行综合热分析(TG-DTA),用X射线衍射(XRD)、扫描电镜(SEM)对产物的结构和形貌进行表征,得到共沉淀法制备纳米BTO粉体的最佳条件:反应温度60℃,滴定终点pH=3,煅烧温度600℃;该条件下制得BTO粉体的电阻率最小为3.48Ω.cm。     

共沉淀法制备纳米Fe3O4影响因素的研究

利用正交设计的数学方法进行实验设计,采用液相共沉淀法制备纳米级Fe3O4颗粒,考察不同影响因素对微球平均粒径大小的影响,寻找制备纳米颗粒的最佳条件.所考察的因素分别为胶溶化时HCl加入量、Fe3+与Fe2+的比例、共沉淀时的pH值、制备Fe3O4的晶化温度.结果表明,以胶溶化时加入HCl3mL、Fe3+与Fe2+的比例2:3、共沉淀时的pH值11和制备Fe3O4的晶化温度80℃为最佳实验条件为,此时制得的纳米粉体平均粒径可达16.3nm;并利用粒径分析仪和HRTEM对所制备纳米粉进行结构表征.     

燃烧法制备镁铝尖晶石粉体及其烧结活性研究

按Mg(NO3)2.6H2O与A l(NO3)3.9H2O的摩尔比为1∶2配料,分别添加20.120 g尿素、15.015 g尿素+4.500 g甘氨酸、7.987 g尿素+9.980 g甘氨酸为燃烧剂,采用燃烧合成法制备了镁铝尖晶石粉体,分析了镁铝尖晶石粉体的物相组成和显微结构,并用谢乐公式计算粉体的晶粒尺寸;然后,将镁铝尖晶石粉体成型为样块,在1 600℃保温3 h煅烧,计算块体的烧后永久线变化率,并检测烧后块体的吸水率、显气孔率和体积密度,分析其显微结构。结果表明:1)随着燃烧剂中甘氨酸含量的增加,制备的镁铝尖晶石粉体的晶粒尺寸逐渐减小,粒径分布逐渐均匀,但团聚现象逐渐明显。2)随着燃烧剂中甘氨酸含量的增加,由镁铝尖晶石粉体制成的块体在1 600℃保温3 h煅烧后的永久线收缩率逐渐增大,烧后块体的吸水率和显气孔率逐渐减小,体积密度逐渐增大;烧后块体中的颗粒粒径逐渐均匀,异常长大的晶粒逐渐减少。这表明,在燃烧剂中添加甘氨酸有利于提高燃烧合成法制备的镁铝尖晶石粉体的烧结活性。     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料,介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比,介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序,对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。