Polyunsaturated fatty glyceride syntheses by microbial lipases

The degree of glyceride syntheses by lipase TOYO (Chromobacterium viscosum) and lipase OF (Candida cylindracea) using individual free fatty acids C_18∶1, C_18∶2, C_18∶3, C_18∶4, C_20∶4, C_20∶5 and C_22∶6 were compared. Lipase TOYO incorporated each of the fatty acids into glycerol at levels of greater than 89%. Lipase OF incorporated most of the fatty acids at levels above 70% (docosahexaenoic acid incorporation was 63%). It was concluded that these two lipases are feasible for producing glycerides from unsaturated fatty acids.     

The α,β-distribution of oleic,linoleic and linolenic acids in cruciferae seed triglycerides

Correlation studies on lipolysis data from 24 species of Cruciferae seed triglycerides have revealed very regular positional distribution patterns for oleic, linoleic and linolenic acids. When the ratio % 18:1 in β-position/% 18:1 in total triglycerides for each species is plotted vs. the content of Category I acids (16:0, 18:0, plus all C₂₀, C₂₂ and C₂₄ acids) in the total triglycerides, a smooth curve is obtained. Application of suitable statistical procedures yields a best-fitting curve, from which an equation expressing the % 18:1 in the β-position as a function of the fatty acid composition of the total triglycerides can be derived. The % 18:1 in the α-position is then readily calculated by difference. Similar distinctive relationships have also been developed for linoleic and linolenic acids. Comparison of calculated and experimental results shows that the relationships developed here are considerably more accurate than the previous Gunstone-Mattson and Evans hypotheses for estimating the α,β-distributions of 18:1, 18:2 and 18:3 in Cruciferae seed triglycerides. Presented in part at the AOCS meeting in San Francisco, California, April 1969.     

Trans-6-hexadecenoic acid and the corresponding alcohol in lipids in the sea anemoneMetridium dianthus

Trans-6-hexadecenoic acid was found in polar lipids, triglycerides, was esters and diacylglyceryl ethers of the sea anemoneMetridium dianthus from Passamaquoddy Bay. The corresponding alcomaquoddy Bay. The corresponding alcohol also apparently occurs in the wax esters of this species. The long-chain (C₂₀, C₂₂) monoethylenic alcohols reported for other species of sea anemones from neighboring waters were absent and the major alcohol and glyceryl ether chain both had 16∶0 structures. The isomers of C₁₈ and C₂₀ monoethylenic fatty acids in polar lipids and triglycerides were unusual in their high proportion of theω ₇ isomer. These two lipids also contained higher proportion of the polyunsaturated fatty acids than the others.     

Fatty acid metabolism in marine fish: Low activity of fatty acyl Δ5 desaturation in gilthead sea bream (Sparus aurata) cells

Marine fish have an absolute dietary requirement for C₂₀ and C₂₂ highly unsaturated fatty acids. Previous studies using cultured cell lines indicated that underlying this requirement in marine fish was either a deficiency in fatty acyl Δ5 desaturase or C_18–20 elongase activity. Recent research in turbot cells found low C_18–20 elongase but high Δ5 desaturase activity. In the present study, the fatty acid desaturase/elongase pathway was investigated in a cell line (SAF-1) from another carnivorous marine fish, sea bream. The metabolic conversions of a range of radiolabeled polyunsaturated fatty acids that comprised the direct substrates for Δ6 desaturase ([1-¹⁴C]18∶2n−6 and [1-¹⁴C]18∶3n−3), C_18–20 elongase ([U-¹⁴C]18∶4n−3), Δ5 desaturase ([1-¹⁴C]20∶3n−6 and [1-¹⁴C]20∶5n−3), and C_20–22 elongase ([1-¹⁴C]20∶4n−6 and [1-¹⁴C]20∶5n−3) were utilized. The results showed that fatty acyl Δ6 desaturase in SAF-1 cells was highly active and that C_18–20 elongase and C_20–22 elongase activities were substantial. A deficiency in the desaturation/elongation pathway was clearly identified at the level of the fatty acyl Δ5 desaturase, which was very low, particularly with 20∶4n−3 as substrate. In comparison, the apparent activities of Δ6 desaturase, C_18–20 elongase, and C_20–22 elongase were approximately 94-, 27-, and 16-fold greater than that for Δ5 desaturase toward their respective n−3 polyunsaturated fatty acid substrates. The evidence obtained in the SAF-1 cell line is consistent with the dietary requirement for C₂₀ and C₂₂ highly unsaturated fatty acids in the marine fish the sea bream, being primarily due to a deficiency in fatty acid Δ5 desaturase activity.     

Milk fat structure of a patient with type 1 hyperlipidemia

Structural analyses were performed on milk fat samples obtained 3–10 days postpartum from a lactating patient with primary Type 1 hyperlipidemia. The milk triacylglycerols contained 3–7% C₁₀, 14–21% C₁₂, 20–30% C₁₄, 22–26% C₁₆ and 20–30% C₁₈ (largely oleic) acids. Gas liquid chromatographic (GLC) analyses of the X-1,3- and X-1,2-diacylglycerols on polar siloxane columns showed a markedly non-random association of acyl chains. Stereospecific analyses indicated that the short chain length fatty acids were confined essentially to the sn-3-position of the triacylglycerol molecule. Furthermore, these acids were largely absent from the phosphatidylcholines and the endogenous sn-1,2-diacylglycerols of the milk fat. It is concluded that the short chain fatty acids are incorporated into the milk triacylglycerols during the final stage of biosynthesis via the phosphatidic acid pathway, and that the overall fatty acid distribution is consistent with the 1-random 2-random 3-random hypothesis.     

The positional distribution of fatty acids in the phospholipids and triglycerides ofMycobacterium smegmatis andM. bovis BCG

Position 1 of the phospholipid and triglyceride fractions isolated fromMycobacterium smegmatis andM. bovis BCG was esterified principally with C₁₈ related fatty acids (18∶0, 18∶1 and 19Br). Position 2 was occupied principally by C₁₆ fatty acids. The third position of the triglycerides was esterified with a preponderance of C₂₀+fatty acids. Seventysix per cent of position 3 fatty acids in BCG and 43% inM. smegmatis triglycerides contained fatty acids of greater than 20 carbon atoms.     

Enzymatic synthesis of medium‐chain triacylglycerols by alcoholysis and interesterification of copra oil using a crude papain lipase preparation

We have examined the possibility of producing analogs of medium‐chain triglycerides (MCT) from copra oil, i.e. a triacylglycerol mixture with a high content of medium‐chain fatty acid moieties (C₆–C₁₀). A two‐step enzymatic process was used in which copra triacylglycerols were first split with papain lipase by alcoholysis with an alkyl alcohol and then subjected to interesterification with the alkyl esters recovered using papain lipase. Effects of temperature, water activity content, substrate ratio, biocatalyst amount, and alcohol chain length were also investigated. On the one hand, the sn‐3 stereoselectivity of the lipase in the alcoholysis of copra oil with butanol has permitted a direct enrichment of caproic, caprylic and capric moieties in the synthesized butyl esters. Thus, in the batch reactor, the reaction led to about 31% conversion of the oil after 24 h, and the content of C₆–C₁₀ acids in the synthesized esters increased from about 16% in the starting oil to almost 42%. A similar enzymatic alcoholysis in a packed‐bed column bioreactor gave 31% conversion of the oil after 120 min of reactor residence time. The reaction was also very selective because the C₆–C₁₀ fatty acyl groups represented about half of the newly formed butyl esters, whereas they accounted for only 16% of total fatty acids in the starting oil. On the other hand, the transesterification of the alkyl esters recovered (highly enriched in C₆–C₁₀ fatty acyl groups) with native copra oil directly led to an increase in the content of MCT in the oil, from 18 mol‐% at the beginning of the reaction to 61 mol‐% of MCT after a time period of 72 h in the batch reactor.     

Fatty Acid Specificity of Candida cylindracea Lipase

Candida cylindracea lipase (SIGMA) was tested against triglycerides (TG) and wax esters (WE) of marine origin as substrates. Under the same conditions, wax esters were hydrolysed at a lower rate than the triglycerides. The C₁₄ to C₁₈ saturated and monounsaturated fatty acids were preferentially hydrolysed whereas the longer chain monoenes (20:1 and 22:1) and particularly the polyunsaturated fatty acids (18:4,20:5 and 22:6) were resistant to the hydrolysis in triglycerides as well as in wax esters. No specificity was demonstrated for the fatty alcohols in the wax esters.     

Characterization of chilean hazelnut (Gevuina avellana mol) seed oil

The fatty acid composition, tocopherol and tocotrienol content, and oxidative stability of petroleum benzene-extracted Gevuina avellana Mol (Proteaceae) seed oil were determined. Positional isomers of monounsaturated fatty acids were elucidated by gas chromatography-electron impact mass spectrometry after 2-alkenyl-4,4-dimethyloxazoline derivatization. This stable oil (Rancimat induction period at 110°C: 20 h) is composed of more than 85% monounsaturated fatty acids and about equal amounts (6%) of saturated and polyunsaturated (principally linoleic) fatty acids. Unusual positional isomers of monounsaturated fatty acids, i.e., C_16:1 Δ¹¹, C_18:1 Δ¹², C_20:1 Δ¹¹, C_20:1 Δ¹⁵, C_22:1 Δ¹⁷, and presumably C_22:1 Δ¹⁹ were identified. The C_18:1 Δ¹² and C_22:1 Δ¹⁹ fatty acids are described for the first time in G. avellana seed oil. While only minute quantities of α-, γ-tocopherols and β-, γ- and δ-tocotrienols were found, the oil contained a substantial amount of α-tocotrienol (130 mg/kg). The potential nutritional value of G. avellana seed oil is discussed on the basis of its composition.     

Specific distribution of fatty acids in the milk fat triglycerides of goat and sheep

The triglycerides of the fat globules of sheep and goat milk were isolated and separated into short and long chain lengths by silicic acid column chromatography. The short chain lengths comprised major triglycerides with 34–44 acyl carbon atoms and accounted for nearly 50% of the total milk fat. The long chain lengths contained major triglycerides with 40–54 acyl carbons. Stereospecific analyses of the short chain triglyceride fraction showed that of the 20–23 moles per cent of C₄−C₈ fatty acids present, at least 95% were specifically attached to the glycerol molecule in the position corresponding to carbon 3 ofsn-glycerol. The distribution of the other fatty acids (C₁₀ or greater) did not show such marked specificity for either the 1 or the 2 position. Although individual triglycerides were not identified, the specific placement of the fatty acids could best the accounted for by assuming a common pool of long chain 1,2-diglycerides which served as precursors of the bulk of both short and long chain triglycerides during milk fat synthesis. Presented in part at the AOCS Meeting, New York, October 1968.     

A detailed triglyceride analysis ofLesquerella fendleri oil: Column chromatographic fractionation followed by supercritical fluid chromatography

The triglyceride structure of oil fromLesquerella fendleri, a potential new U.S. crop, rich in C₂₀ hydroxy fatty acids, was examined by silica gel column chromatographic fractionation followed by supercritical fluid chromatography. The analysis confirmed previous findings derived by our research group, but provided further detail. The analysis demonstrated the presence of trihydroxy triglyceride, which contained all of the oil’s C₁₈ hydroxy acyl groups (present at less than 0.5% in the oil). Lipolysis indicated that these groups were located solely at the 2-position. In addition, a strong correlation was detected between the presence of α-linolenic (18:3^9,12,15) and auricolic (20:2^11,17 OH¹⁴) acids in triglycerides.     

Preparation and properties of fully esterified erythritol

Pure tetraesters of erythritol with C₁₀, C₁₂, C₁₄, C₁₆, C₁₈ saturated, and C_18:1 unsaturated (oleoyl) fatty acyl chains have been prepared for the first time and characterized using the acylating systems fatty acid/N,N′‐dicyclohexylcarbodiimide/4‐dimethylaminopyridine (DMAP), fatty acid anhydride/DMAP, fatty acyl chloride/pyridine, and fatty acyl chloride/boron trifluoride etherate. For the first three systems the yields were in the range of 80–90% while the fatty acyl chloride/pyridine system has the advantage of lower cost. The fatty acyl chloride/boron trifluoride etherate system gave lower (ca 70%) yields of the tetraesters. The tetraesters of erythritol may have applications analogues to those of triglycerides. In addition, new applications can be envisaged for these compounds, as a result of their differences in physical, chemical, and biochemical properties compared to triglycerides. Practical applications: The tetraesters of erythritol with saturated fatty acyl chains may have applications analogous to those of saturated triglycerides. However, tetraesters with unsaturated fatty acid chains may have greater prospects of having industrial uses after doing chemistry on the carbon–carbon double bonds.     

The monounsaturated acyl- and alkyl-moieties of wax esters and their distribution in commercial orange roughy (Hoplostethus atlanticus) oil

Wax esters were isolated from commercial orange roughy (Hoplostethus atlanticus) oil by column chromatography and fractionated by argentation thin layer chromatography. Following transesterification, the resultant fatty acid methyl esters and fatty alcohols were analyzed by gas chromatography. both acyl- and alkyl-moieties were mainly of the monoene structure within the 16∶1–22∶1 range. After derivatization, the positions of the double bonds of even numbered fatty acid and fatty alcohol isomers were located by chromatography-mass spectrometry and compared. Results of these positional analyses indicate that the primary desaturation reactions takes place in the Δ9 position of pre-existing (C₁₄ to C₂₄) acyl chains. It is proposed that acyl components from 18∶1 are subjected to chain elongation to form a mixture of 24∶1 isomers as the final product. Apart from the 24∶1 acyl moiety of the wax esters, in which the double bond was almost exclusively in the Δ15 position, de novo biosynthetic reactions on acids and alcohols appear to yield related acyl- and alkyl-moieties of resynthesized wax esters.     

Cuticular lipids of insects: V. Cuticular wax esters of secondary alcohols from the grasshoppersMelanoplus packardii andMelanoplus sanguinipes

Wax esters of secondary alcohols constitute 18–20% of the cuticular lipid extract ofMelanoplus packardii and 26–31% of the cuticular lipids ofMelanoplus sanguinipes. The total number of carbons in the wax esters range from 37–54 with 41 predominating in both species. The fatty acids ofM. packardii wax esters are 16∶0, 18∶0, 14∶0, 20∶0 and 12∶0 in decreasing quantity. The fatty acids ofM. sanguinipes wax esters are 18∶0, 20∶0, 16∶0 22∶0, 14∶0, 19∶0 and 17∶0 in decreasing quantity. The secondary alcohols from the wax esters ofM. packardii are C₂₅, C₂₃ and C₂₇ in decreasing quantity, and the secondary alcohols of theM. sanguinipes are C₂₃, C₂₅, C₂₁, C₂₇, C₂₄, C₂₂ and C₂₆ in decreasing quantity. Each secondary alcohol consists of two to four isomers with the hydroxyl group located near the center of the chain. Montana Agriculture Experiment Station, Journal Series No. 332.     

1-O-alkyl-2,3-diacylglycerols in the skin surface lipids of the hairless mouse

A neutral lipid class was isolated by thin-layer chromatography from the skin surface lipids of the hairless mouse. The fraction migrated faster than triglycerides and had a migration rate similar to that of diacyl alkanediols (diester wax). Upon deacylation, however, the long-chain diols were identified as 1-alkylglycerol ethers based on their chromatographic properties and on the mass spectra of their nicotinylidene derivatives. Thus, the skin lipid fraction was identified as 1-O-alkyl-diacylglycerol. The alkyl moieties were all saturated and even-numbered and ranged in chainlength from C₁₆ to C₂₂ with 1-O-hexadecylglycerol amounting to 34% of the total glycerol ether moieties. The fatty acids derived from this lipid fraction were mostly monoenoic with chainlengths ranging from C₁₆ to C₂₄. The major acyl component was eicosenoic acid (20∶1) representing 61% of the total fatty acids.     

Unsaturated fatty acids of mycobacteria

The double bond locations have been determined for the mono-unsaturated fatty acids, C₁₄ to C₂₆ ofM. smegmatis andM. bovis BCG. The 14∶1 and 16∶1 fatty acids fromM. smegmatis are principally Δ¹⁰, while the 17∶1, 18∶1 and 19∶1 fatty acids from both organisms are Δ⁹. In the case ofM. smegmatis, the 20∶1, 22∶1 and 24∶1 fatty acids are principally Δ¹¹, Δ¹³ and Δ¹⁵, respectively, while the 22∶1, 24∶1 and 26∶1 fatty acids of BCG are principally Δ¹³, Δ¹⁵ and Δ¹⁷, respectively.     

Mass spectrometric analysis of the fatty acids and nonsaponifiable lipids ofEimeria tenella oocysts

The fatty acids and nonsaponifiable lipids ofEimeria tenella oocysts were analyzed by gas liquid chromatography and combined gas liquid chromatographymass spectrometry. The fatty acids detected were identified as C_14∶0, C_16∶0, C_16∶1, C_18∶0, C_18∶1, and C_18∶2. Though the wt of the fatty acid fraction decreased during sporulation from 91 μg per 10⁶ oocysts to 47 μg per 10⁶ oocysts, the relative amounts of these fatty acids did not change appreciably. The nonsaponifiable lipids ofE. tenella consisted of cholesterol and unbranched primary alcohols of 22, 24, 26, 28, 30, and 32 carbons. Mass fragmentography demonstrated that each species of alcohol consisted of saturated and monounsaturated derivatives. Trimethylsilyl ethers of fatty alcohols were found to offer several important advantages over free alcohols for mass spectrometric characterization. Before sporulation, most fatty alcohols were in the oocyst wall. During sporulation, the wt of the nonsaponifiable lipids increased from 16 μg per 10⁶ oocysts of 44 μg per 10⁶ oocysts due largely to synthesis of C₂₄ and C₂₆ alcohols. The newly synthesized fatty alcohols were not deposited in the oocyst wall.     

The triglyceride composition,structure, and presence of estolides in the oils ofLesquerella and related species

Members of the genusLesquerella, native to North America, have oils containing large amounts of hydroxy fatty acids and are under investigation as potential new crops. The triglyceride structure of oils from twenty-fiveLesquerella species in the seed collection at our research center has been examined after being hydrolysis-catalyzed by reverse micellar-encapsulated lipase and alcoholysis-catalyzed by immobilized lipase. These reactions, when coupled with supercritical-fluid chromatographic analysis, provide a powerful, labor-saving method for oil triglyceride analysis. A comprehensive analysis of overall fatty acid composition of these oils has been conducted as well.Lesquerella oils (along with oils from two other Brassicaceae:Physaria floribunda andHeliophilia amplexicaulis) have been grouped into five categories: densipolic acid-rich (Class I); auricolic acid-rich (Class II); lesquerolic acid-rich (Class III); an oil containing a mixture of hydroxy acids (Class IV); and lesquerolic and erucic acid-rich (Class V). The majority of Class I and II triglycerides contain one or two monoestolides at the 1- and 3-glycerol positions and a C₁₈ polyunsaturated acyl group at the 2-position. Most Class III and IV oil triglycerides contain one or two hydroxy acids at the 1- and 3-positions and C₁₈ unsaturated acid at the 2-position. A few of the Class III oils have trace amounts of estolides. The Class V oil triglycerides are mostly pentaacyl triglycerides and contain monestolide and small amounts of diestolide. Our triglyceride structure assignments were supported by¹H nuclear magnetic resonance data and mass balances.     

Acidolysis of several vegetable oils by mycelium-bound lipase of Aspergillus flavus link

The ability of mycelium-bound lipase of a locally isolated Aspergillus flavus to modify the triglyceride structure of vegetables oils was studied. The catalysis involved the acidolysis of vegetable oils, such as palm olein, coconut oil, cotton-seed oil, rapeseed oil, corn oil and soybean oil, with selected fatty acids (FA). The reactions were followed against time, and the percentages of FA incorporated were determined by gas chromatography. Percentage of FA incorporated after 20-h reaction was in the range of 13 to 18%. Reaction between cottonseed oil with lauric acid gave the highest percentage of incorporation (18%), followed by soybean oil with lauric acid (16%) and coconut oil with oleic acid (16%). The results indicated that the hydrolytic affinity of A. flavus lipase demonstrates an acyl group specificity toward short-chain FA (C₈–C₁₀). Changes in triglyceride profiles of each oil were also monitored by reverse-phase high-pressure liquid chromatography. In all products, there were increases in the concentrations of several existing triglycerides and formation of new triglycerides. The melting points of all acidolyzed vegetable oils were determined by differential scanning calorimetry, and significant changes in melting profiles were noted.     

Fatty acid metabolism in young oysters,Crassostrea gigas: Polyunsaturated fatty acids

Tetraselmis suecica andDunaliella tertiolecta were grown for 24 hr in the presence of¹⁴C sodium bicarbonate and then fed separately to batches of juvenile oysters,Crassostrea gigas, for 3 days.D. tertiolecta contained fatty acids no longer than C₁₈; 22∶6ω3 was absent inT. suecica. Analysis of the oyster fatty acids by radio gas chromatography (GC) showed that oysters were able to incorporate some of the dietary¹⁴C label into long-chain fatty acids not supplied in the diet, e.g., C₂₀ and C₂₂ mono- and polyunsaturated fatty acids, and particularly 20∶5ω3. However, the low¹⁴C incorporation into fatty acids longer or more unsaturated than those supplied in the diet suggests that elongation and desaturation activity in young oysters is not sufficient to sustain optimum growth.