Evolution of free amino acid content during ripening of Mahon cheese

Evolution of free amino acids (FAA) during ripening (10–300 days) of five batches of Mahon cheese was studied; three batches were made from raw milk and two from pasteurized milk. Major FAA were GLU, VAL, LEU, LYS and PHE (43–67% of total FAA). Relative THR, SER, GLU and GLY contents significantly increased during ripening whereas LEU, PHE and ORN decreased. GLU, ILE, SER, THR, GLY and PHE varied during ripening according to a zero order reaction (r² > 0.99). Principal component analysis showed that the first principal component could be considered representative of the ripening time. The most ripened cheeses showed high GLU, GLY, SER and THR contents and the less ripened cheeses presented high ORN, LEU, PHE and ALA contents. The second component distinguished between cheeses made with pasteurized milk (with high ASN and GLN contents) and raw milk. Indigenous microflora of raw milk showed a strong influence on the proteolytic activity in Mahon cheese.     

Proteolysis in goat cheese made from raw,pasteurized or pressure-treated milk

Primary and secondary proteolysis of goat cheese made from raw (RA), pasteurized (PA; 72 °C, 15 s) and pressure-treated milk (PR; 500 MPa, 15 min, 20 °C) were examined by capillary electrophoresis, nitrogen fractionation and HPLC peptide profiles. PA milk cheese showed a more important hydrolysis (P<0.05) of α_s1-casein than RA milk cheese at the first stages of ripening (15 days), while PR milk cheese had a level between those seen in PA and RA milk cheeses. Degradation of β-casein was more important (P<0.05) in PA and PR than in RA milk cheeses at 15 days of ripening. However, from thereon β-casein in PR and RA milk cheeses was hydrolyzed at essentially similar rates, but at lower rates (P<0.05) than in PA milk cheeses. Pressure treatment could induce proteolysis of β-casein in a way, which is different from that produced by heat treatment. There was an increase in 4.6-soluble nitrogen (WSN) and in trichloroacetic acid (TCASN) throughout ripening in cheeses, but higher contents (P<0.05) in PA and PR milk cheeses at the end of ripening were observed. PR milk cheeses contained considerably higher content (P<0.05) of free amino acids than RA or PA milk cheeses. In general, heat and pressure treatments had no significant effect on the levels of hydrophobic and hydrophilic peptides.     

Effect of high-pressure treatment of ewe raw milk curd at 200 and 300 MPa on characteristics of Hispánico cheese

Hispánico cheese is a semihard variety made from a mixture of cow and ewe milks. Production of ewe milk declines in summer and autumn. To surmount the seasonal shortage of ewe milk and prevent the inactivation of milk enzymes by pasteurization, curd made in spring from ewe raw milk was pressurized at 200 and 300 MPa and stored frozen for 4 mo. Thawed ewe milk curds were added to fresh curd made from pasteurized cow milk for the manufacture of experimental Hispánico cheeses. Control cheese was made from a mixture of pasteurized cow and ewe milk in the same proportions as those used for experimental cheeses. Experimental cheeses exhibited lower dry matter content, higher aminopeptidase activity and total free amino acid concentration, and higher levels of acetic and propionic acids, aldehydes, alcohols, and esters compared with control cheese. In contrast, the concentration of total free fatty acids and ketones and the levels of textural parameters were significantly higher in control cheese. The use of ewe raw milk curd pressurized at 200 and 300 MPa, stored frozen and thawed for Hispánico cheese manufacture, was generally beneficial for cheese characteristics and increased cheese yield because of the lower dry matter content of experimental cheeses.     

Proteolysis, lipolysis, volatile compounds, texture, and flavor of Hispánico cheese made using frozen ewe milk curds pressed for different times

Hispánico cheese is manufactured in Spain from a mixture of cow and ewe milk. Production of ewe milk varies throughout the year, with a peak in spring and a valley in summer and autumn. To overcome this seasonal shortage, curd from spring ewe milk may be frozen and used for cheese manufacture some months later. In the present work, ewe milk curds pressed for 15, 60, or 120 min were held at −24°C for 4 mo, thawed, cut to 1-mm pieces, and mixed with fresh cow milk curd for the manufacture of experimental Hispánico cheeses. Control cheese was made from a mixture of pasteurized cow and ewe milk in the same (80:20) proportion. Cheeses, made in duplicate experiments, were analyzed throughout a 60-d ripening period. No significant differences between cheeses were found for lactic acid bacteria counts, dry matter content, hydrophilic peptides, 47 out of 68 vol.tile compounds, texture, and flavor characteristics. On the other hand, differences of minor practical significance between experimental and control cheeses, unrelated to the use of frozen ewe milk curd or the pressing time of ewe milk curd, were found for pH value, aminopeptidase activity, proteolysis, hydrophobic peptides, free amino acids, free fatty acids, and the remaining 21 vol.tile compounds. It may be concluded that the use of frozen ewe milk curd in the manufacture of Hispánico cheese does not alter its main characteristics.     

HPLC quantification of biogenic amines in cheeses: correlation with PCR-detection of tyramine-producing microorganisms

The consumption of food and beverages containing high amounts of biogenic amines (BA) can have toxicological effects. BA found in foods and beverages are synthesized by the microbial decarboxylation of certain amino acids. This paper reports the concentrations of BAs in a number of commercial cheeses, as determined by HPLC. The cheeses studied were made from raw and pasteurized milk of different origin, and were subjected to different ripening periods. BA concentrations were lower in short ripening period than in long ripening period cheeses, and higher in cheeses made from raw milk than in those made from pasteurized milk. The highest BA concentrations were recorded in blue cheeses made from raw milk. Tyramine was the most commonly recorded and abundant BA. The presence of tyramine-producing bacteria was determined by PCR, and a good correlation obtained between the results of this method and tyramine detection by HPLC. These methods could be used to complement one another in the detection and quantification of tyramine in cheese prevention of tyramine accumulation in cheese.     

Influence of starter and nonstarter on the formation of biogenic amine in goat cheese during ripening

Two commercial starters were investigated for their potential ability to decarboxylate amino acids during goat cheese ripening. Two batches of goat cheese were produced with identical pasteurized milk but different starter cultures. One of them contained Lactococcus lactis subsp. lactis and Lactococcus lactis subsp. cremoris and the other Lactococcus lactis subsp. lactis. The amine contents, microbial counts, proteolysis-related parameters, pH, total solids and salt content were studied in raw materials and cheeses. In raw materials, polyamines were the prevailing amines, whereas the main amines in cheeses were putrescine, tryptamine and, in particular, tyramine (94.59 mg/kg). Aerobic mesophilic microorganisms and Lactococcus counts increased throughout ripening, while Enterobacteriaceae were no longer detectable in cheese after 30 days of ripening. Amine concentration rose during cheese ripening in both batches. Moreover, the decarboxylase activity of microorganisms isolated from samples during cheese ripening was assayed and discussed.     

Microbiological,chemical, textural and sensory characteristics of Hispánico cheese manufactured using frozen ovine milk curds scalded at different temperatures

Hispánico cheese is a semi-hard variety, manufactured in Spain from a mixture of pasteurized bovine and ovine milk. To study one strategy for overcoming a seasonal shortage of ovine milk in summer and autumn, curds made from ovine milk, scalded at 32, 35 or 38 °C, were pressed for 30 min and frozen at ?24 °C for 4 months. After thawing, they were added to fresh bovine milk curd for the manufacture of experimental Hispánico cheeses. Control cheese was made from a mixture of pasteurized bovine and ovine milk in the same (80:20) proportion. No significant effect of the addition of frozen ovine milk curd or scalding temperature was found for lactic acid bacteria counts, dry matter content, hydrophilic and hydrophobic peptides, 45 out of 65 volatile compounds, texture, and sensory characteristics throughout a 60-day ripening period. Differences between cheeses, of low magnitude and little practical significance, were found for pH value, aminopeptidase activity, proteolysis, free amino acids, free fatty acids, and the remaining 20 volatile compounds. Thus, the addition of frozen ovine milk curd to fresh bovine milk curd does not alter the main physicochemical and sensory characteristics of Hispánico cheese.     

Evaluation of biogenic amines and microbial counts throughout the ripening of goat cheeses from pasteurized and raw milk

The effect of the hygienic quality of milk on changes in microbial counts and biogenic amine content was evaluated during ripening of goat cheeses manufactured from pasteurized and raw milks at 1, 14, 30, 60 and 90 d. The original milk, rennet, curd and whey were also included in the study. The pH, salt content and extent of proteolysis in the cheese were also evaluated. Spermidine and spermine were the main amines in raw milk, while they were minor amines in cheeses. Other amines increased markedly during ripening, tyramine being the main amine in cheese made from raw milk and cadaverine and putrescine in those produced from pasteurized milk. Enterobacteriaceae counts decreased during ripening whereas those of lactic acid bacteria increased, especially lactobacilli and enterococci. Cheese made from raw milk showed higher microbial counts during ripening than those made from pasteurized milk, especially for Enterobacteriaceae and enterococci, counts being 2 or 3 log units higher. Raw milk cheese showed remarkably higher biogenic amines compared with pasteurized milk cheeses. Therefore, pasteurization of milk causes a decrease in final biogenic amine content of cheese as a result of the reduction of its microbial counts.     

Effect of pasteurization of Ewe's milk and use of a native starter culture on the volatile components and sensory characteristics of roncal cheese.

The effect of pasteurization of milk and use of a native starter culture on the volatile components and sensory characteristics of a Spanish ewe's-milk cheese were examined. Three cheese batches were made, one from raw milk, another from pasteurized milk, and a third from pasteurized milk with an added native starter culture in addition to the commercial starter. Cheeses were analyzed at 1, 120, and 240 d of ripening. Analysis of the volatile components was by purge and trap connected to a gas chromatograph with a mass spectrometer and disclosed a total of 76 components belonging to the following chemical families: hydrocarbons, fatty acids, esters, sulfur and carbonyl compounds, and, in particular, alcohols. Pasteurization lowered the levels of certain volatile components, especially alcohols, aldehydes, and ketones. The cheeses made from pasteurized milk showed lower scores for attributes of characteristic taste and aftertaste, as well as a characteristic aroma at 240 d of ripening. These results suggest that the components present in higher concentrations in the cheeses made from the raw milk were necessary for development of characteristic Roncal cheese aroma. The new native starter culture tested did not exert a significant effect on any of the parameters considered, with the exception of certain isolated components, for which higher or lower quantities were recorded in the cheeses made with that starter culture, although the differences did not have a definite effect on the sensory characteristics of the cheeses.     

Effect of forage type,season, and ripening time on selected quality properties of sheep milk cheese

The aim of this research was to study changes in the microbial populations, free AA profile, biogenic amine content, and sensory characteristics of ripened cheeses (100 and 180 d) produced in different seasons (summer, autumn, winter, and spring) from pasteurized sheep milk from 8 commercial flocks fed hay or silage diets. Twenty-one individual AA and 6 biogenic amines were determined by ultra-high performance liquid chromatography. Type of conserved forage for sheep feeding did not affect the variables studied, which is of great interest because hay and silage are low-cost ingredients for sheep feeding. Proteolysis led total free AA concentrations ranging between 35,179.26 and 138,063.71 mg/kg of cheese at 180 d of ripening. γ-Aminobutyric acid, which has been associated with beneficial effects on human health, was the second most abundant AA in all cheese samples, accounting for 15% of total free AA. Spring cheeses showed 2-fold higher concentrations of γ-aminobutyric acid than summer and autumn cheeses at the end of ripening. Overall, spring, winter, and autumn cheeses had lower average concentration of biogenic amines (431.99 mg/kg of cheese) than summer cheeses (825.70 mg/kg of cheese) as well as better sensory characteristics. Therefore, this study could provide the dairy industry with useful information for producing cheeses with valuable nutritional and sensory quality for consumers.     

High-Pressure Treatment and Freezing of Raw Goat Milk Curd for Cheese Manufacture: Effects on Cheese Characteristics

High-pressure treatment of raw goat milk curd was investigated as an alternative to thermal treatment of milk in cheese manufacture, and curd freezing as a procedure to surmount the seasonality of goat milk production. Experimental cheeses were made by mixing (70:30) fresh cow milk curd with frozen curd from pasteurized goat milk (PGC), frozen curd from raw goat milk (RGC), or frozen pressurized curd from raw goat milk (PRGC). Control cheese was made from a mixture (70:30) of pasteurized cow and goat milk. RGC cheese showed the highest counts of staphylococci, Gram-negative bacteria and coliforms, whereas PRGC cheese had maximum aminopeptidase activity, esterase activity, and overall proteolysis. Control cheese exhibited the highest dry matter content and peptide levels, the lowest concentration of free amino acids, the highest concentration of volatile compounds such as free fatty acids, alcohols and esters, and the firmest texture. Differences in sensory characteristics between experimental and control cheeses were of minor importance. High-pressure treatment of curd allowed the production of cheese of bacteriological quality similar to that of control cheese made using pasteurized milk, while curd freezing did not alter the sensory characteristics of experimental cheeses with respect to control cheese.     

Possible implications of milk pasteurization on the manufacture and sensory quality of ripened cheese

Cheese made from raw milk represents an important proportion of the traditional cheeses, particularly in South European countries. Besides destruction of pathogenic bacteria, the most significant changes in milk relevant to cheesemaking, which are induced by pasteurization are:

• a partial elimination of the milk microorganisms which may grow in cheese during ripening,

• a partial or total activation or inhibition of the plasmin/plasminogen complex, cathepsin D, lipoprotein lipase and alkaline phosphatase. Enzymes from psychrotrophic bacteria, acid phosphatase and xanthine oxidase, which may be active during ripening, withstand pasteurization.,

• a slight (7%) denaturation of serum proteins and little or no modification of the cheesemaking properties (coagulation, acidification by lactic acid bacteria).

From experimental work carried out on several cheese varieties, comparing pasteurized or microfiltered milk and raw milk cheeses, it was found that facultatively heterofermentative lactobacilli, Micrococcaceae, enterococci, and propionibacteria in Swiss-type cheese, are found at higher levels in raw milk cheese. The main biochemical modification of cheese during ripening concerns the nature and extent of proteolysis. Although there is no clear trend in the breakdown of _s1- and β-caseins, milk pasteurization leads to a significant decrease of the amount of small peptides and free amino acids and to different HPLC profiles. Experiments carried out with sensory analysis show that, in all cases, pasteurized or microfiltered milk cheeses have received lower flavour intensity scores than raw milk cheeses. From this review, it is concluded that the indigenous milk microflora, with its diversity of species and strains, appears to be mainly responsible of the specific sensory properties of raw milk cheeses.     

Lipolysis and proteolysis profiles of fresh artisanal goat cheese made with raw milk with 3 different fat contents

The objective of this study was to describe the proteolysis and lipolysis profiles in goat cheese made in the Canary Islands (Spain) using raw milk with 3 different fat contents (0.5, 1.5, and 5%) and ripened for 1, 7, 14, and 28 d. β-Casein was the most abundant protein in all cheeses and at all ripening times. Quantitative analysis showed a general decrease in caseins as ripening progressed, and degradation rates were higher for α_S1-casein than for β-casein and α_S2-casein. Furthermore, the degradation rate during the experimental time decreased with lower fat contents. The α_S2-casein and α_S1-casein levels that remained in full-fat and reduced-fat cheeses were less than those in low-fat cheese. In contrast, β-casein also showed degradation along with ripening, but differences in degradation among the 3 cheese types were not significant at 28 d. The degradation products increased with the ripening time in all cheeses, but they were higher in full-fat cheese than in reduced-fat and low-fat cheeses. The free fatty acid concentration per 100 g of cheese was higher in full-fat cheese than in reduced- and low-fat cheese; however, when the results were expressed as milligrams of free fatty acids per gram of fat in cheese, then lipolysis occurred more rapidly in low-fat cheese than in reduced- and full-fat cheeses. These results may explain the atypical texture and off-flavors found in low-fat goat cheeses, likely the main causes of non-acceptance.     

Using High-Pressure Processing for Reduction of Proteolysis and Prevention of Over-ripening of Raw Milk Cheese

High-pressure-processing (HPP) at 400 or 600 MPa was applied to cheeses made from ewe raw milk, on days 21 or 35 after manufacturing, to reduce proteolysis and prevent over-ripening. The characteristics of HPP and non-pressurized (control) cheeses were compared during ripening at 8 °C until day 60 and further storage at 4 °C until day 240. HPP and control cheeses showed similar pH values throughout ripening, but on day 240 pH values remained 0.4–0.6 units lower for HPP cheeses than for the control cheeses. Casein degradation was significantly retarded in the 600 MPa cheeses. Their α-casein concentration was 48–52 % higher on day 60 and 30–33 % higher on day 240 than in the control cheeses while β-casein concentration was 25–26 % higher on day 60 and 100–103 % higher on day 240. No significant differences in para-κ-casein concentration between cheeses were found on day 60, but on day 240, it was 22–35 % higher in the 600 MPa cheeses than in the control cheese. Hydrophilic peptides, hydrophobic peptides and total free amino acids evolved similarly in HPP and control cheeses during the 60-day ripening period. However, on day 240 hydrophilic peptides were at 34–39 % lower levels in the 600 MPa cheeses than in the control cheeses, hydrophobic peptides at 7–16 % lower levels and total free amino acids at 25–29 % lower levels. Flavour intensity scores increased at a slower rate in HPP cheeses than in the control cheese. Flavour quality declined markedly in the control cheeses during refrigerated storage while it did not vary significantly in 600 MPa cheeses.     

Texture and flavour development in Ras cheese made from raw and pasteurised milk

Texture, proteolysis and flavour development in Ras cheeses made from raw or pasteurised milk with two different thermophilic lactic cultures were monitored during ripening. Results showed that at day 1 of manufacture, the moisture content and pH were lower in raw milk cheese than in pasteurised milk cheeses. Levels of water-soluble nitrogen, casein breakdown, free amino groups and free fatty acids were higher in cheese made from raw milk than in that made from pasteurised milk. Textural characteristics, such as hardness, cohesiveness and chewines, increased in all treatments during the first 60 days of ripening due to the reduction in the moisture level during the second stage of salting (dry salting during the first 60 days of ripening). Cheese made from raw milk received the highest texture and flavour scores by panellists.     

Influence of an adjunct culture of Lactobacillus on the free amino acids and volatile compounds in a Roncal-type ewe’s-milk cheese

Free amino acids and volatile compounds were analysed in a Roncal-type cheese made from pasteurized ovine milk with and without an added adjunct culture (Lactobacillus paracasei + Lactobacillus plantarum). In both batches, the total free amino acid concentration increased 11–12-fold with ripening time, the main amino acids being Leu, Glu, Lys, Phe, Val, and Ile. At the end of ripening, significant differences were recorded for Leu, Ile, Gaba, Phe, Pser, Ser, Gin, Ala, and Orn.     

Changes of free amino acid content of Teleme cheese made with different types of milk and culture

The evolution of concentration of free amino acids in Teleme cheese made from sheep, goat or cow milk, using a thermophilic, mesophilic or a mixture of a thermophilic, a mesophilic culture throughout ripening was studied. The total free amino acid (TFAA) content increased at all stages of ripening, regardless of the milk and culture used. In general, the TFAA content was higher in cheeses made from cow’s milk than that of the cheeses made from ewe’s milk; cheese from goat’s milk ranged over intermediate levels. Also, higher concentrations of TFAA were found in cheeses made with the thermophilic than with the mesophilic culture. Cheeses made with the mixture of thermophilic–mesophilic culture ranged over intermediate levels. The results of this study have shown that Leu, Glu, Phe, Val and Lys were the major FAA of Teleme cheese at all stages of ripening, regardless of the type of milk and culture used.     

Factors affecting consumers' preferences for and purchasing decisions regarding pasteurized and raw milk specialty cheeses

Eight hundred ninety consumers at a local food festival were surveyed about their specialty cheese purchasing behavior and asked to taste and rate, through nonforced choice preference, 1 of 4 cheese pairs (Cheddar and Gouda) made from pasteurized and raw milks. The purpose of the survey was to examine consumers’ responses to information on the safety of raw milk cheeses. The associated consumer test provided information about specialty cheese consumers’ preferences and purchasing behavior. Half of the consumers tested were provided with cheese pairs that were identified as being made from unpasteurized and pasteurized milk. The other half evaluated samples that were identified only with random 3-digit codes. Overall, more consumers preferred the raw milk cheeses than the pasteurized milk cheeses. A larger portion of consumers indicated preferences for the raw milk cheese when the cheeses were labeled and thus they knew which samples were made from raw milk. Most of the consumers tested considered the raw milk cheeses to be less safe or did not know if raw milk cheeses were less safe. After being informed that the raw milk cheeses were produced by a process approved by the FDA (i.e., 60-d ripening), most consumers with concerns stated that they believed raw milk cheeses to be safe. When marketing cheese made from raw milk, producers should inform consumers that raw milk cheese is produced by an FDA-approved process.     

Influence of microfiltration and adjunct culture on quality of Domiati cheese

The effects of microfiltration and pasteurization processes on proteolysis, lipolysis, and flavor development in Domiati cheese during 2 mo of pickling were studied. Cultures of starter lactic acid bacteria isolated from Egyptian dairy products were evaluated in experimental Domiati cheese for flavor development capabilities. In the first trial, raw skim milk was microfiltered and then the protein:fat ratio was standardized using pasteurized cream. Pasteurized milk with same protein:fat ratio was also used in the second trial. The chemical composition of cheeses seemed to be affected by milk treatment—microfiltration or pasteurization—rather than by the culture types. The moisture content was higher and the pH was lower in pasteurized milk cheeses than in microfiltered milk cheeses at d 1 of manufacture. Chemical composition of experimental cheeses was within the legal limits for Domiati cheese in Egypt. Proteolysis and lipolysis during cheese pickling were lower in microfiltered milk cheeses compared with pasteurized milk cheeses. Highly significant variations in free amino acids, free fatty acids, and sensory evaluation were found among the cultures used in Domiati cheesemaking. The cheese made using adjunct culture containing Lactobacillus delbrueckii ssp. lactis, Lactobacillus paracasei ssp. paracasei, Lactobacillus casei, Lactobacillus plantarum, and Enterococcus faecium received high scores in flavor acceptability. Cheeses made from microfiltered milk received a higher score in body and texture compared with cheeses made from pasteurized milk.     

Changes in the microbiological and chemical characteristics of an artisanal, low-fat cheese made from raw ovine milk during ripening

Changes in the microbial flora of batzos cheese made from raw ovine milk were studied during ripening. Lactic acid bacteria and Enterobacteriaceae were the predominant groups of micro-organisms. Cheeses manufactured in summer had higher microbial counts than those made in spring, with the exception of staphylococci. Nevertheless, Enterobacteriaceae and coliforms decreased more rapidly in cheese made in summer and counts at the end of storage were lower than those in spring cheese.
Enterococci predominated in the ripened curd of cheese made in spring, whereas lactobacilli were the most abundant lactic acid bacteria in cheese made in summer. Enterococcus faecium was the predominant species in spring, and Lactobacillus paracasei ssp. paracasei predominated in cheese made in summer. The pH of the cheeses was > 5.0 throughout ripening, and NaCl-in-moisture content (> 8.0%) permitted the growth and survival of salt-tolerant micro-organisms. α_s1-Casein degraded at a faster rate than β-casein; both caseins were hydrolysed more rapidly in spring than in summer. The free amino acid content became higher in summer cheese (566.24–3460.25 µg/g of glycine equivalent) than in spring cheese because of the progress of ripening. Moreover, the milk fat of the cheese was degraded more in the summer than in the spring. The results suggest that there could be advantages to using starter cultures and improving the level of hygiene during milk and cheese production in order to eliminate undesirable micro-organisms and standardize cheese quality.