树脂吸附法处理2-萘酚母液废水的研究

通过废水静态吸附试验,筛选出2-萘酚母液废水处理的吸附树脂,确定了2-萘酚母液废水处理的pH值,考察了废水浓度及温度对树脂平衡吸附量的影响;通过废水动态吸附试验,考察了2-萘酚母液废水流速对一级和二级吸附树脂吸附效果的影响;通过动态脱附试验,考察了脱附剂浓度、脱附剂用量和脱附温度对树脂脱附效果的影响;确定了树脂吸附法处理2-萘酚母液废水的最佳工艺参数和处理后废水的CODCr值。     

超声波对活性炭吸附/脱附Cr(Ⅵ)的影响

研究了超声波对活性炭吸附/脱附Cr(Ⅵ)的影响,结果表明：有无超声波作用下,活性炭对Cr(Ⅵ)的吸附率均随pH值的升高而减小,相对于无超声作用体系,超声作用下的相平衡向吸附量减小的方向移动,且pH值越大,其减小的幅度越大;当Cr(Ⅵ)初始浓度由20 mg·L^-1增至110 mg·L^-1时,超声波作用下的Cr(Ⅵ)去除率由99.9%降至79.8%,平衡吸附量则由3.3 mg·g^-1增至15.0 mg·g^-1,与无超声波作用下的效果接近,但无超声波作用时的吸附率持续上升至平衡,而超声波作用下的吸附率先快速增加至近平衡,再出现小幅下降后又缓慢增至平衡。脱附实验发现,无论有无超声作用,活性炭表面Cr(Ⅵ)在蒸馏水中的脱附率均很小;添加NaOH可显著改善脱附效果,脱附率随NaOH用量的增加而增加,且超声场中NaOH对脱附的促进作用显著高于非超声场中的效果。     

Effects of ultrasound on adsorption and desorption of chromium(Ⅵ) on activated carbon

研究了超声波对活性炭吸附/脱附Cr(Ⅵ)的影响,结果表明：有无超声波作用下,活性炭对Cr(Ⅵ)的吸附率均随pH值的升高而减小,相对于无超声作用体系,超声作用下的相平衡向吸附量减小的方向移动,且pH值越大,其减小的幅度越大;当Cr(Ⅵ)初始浓度由20 mg·L^-1增至110 mg·L^-1时,超声波作用下的Cr(Ⅵ)去除率由99.9%降至79.8%,平衡吸附量则由3.3 mg·g^-1增至15.0 mg·g^-1,与无超声波作用下的效果接近,但无超声波作用时的吸附率持续上升至平衡,而超声波作用下的吸附率先快速增加至近平衡,再出现小幅下降后又缓慢增至平衡。脱附实验发现,无论有无超声作用,活性炭表面Cr(Ⅵ)在蒸馏水中的脱附率均很小;添加NaOH可显著改善脱附效果,脱附率随NaOH用量的增加而增加,且超声场中NaOH对脱附的促进作用显著高于非超声场中的效果。     

吸附-热再生法回收废水中醋酸的研究

针对浓度为3%的醋酸废水,选用YK-15椰壳炭为吸附剂,采用吸附和分步热再生法从废水中分离醋酸,达到了废水处理和醋酸回收的双重目的.系统地考察了动态吸附和分步热再生的工艺条件,结果表明,在温度为30℃,废水流速为7.3×10-5 m·s-1的适宜条件下,YK-15椰壳炭对醋酸的动态吸附容量为161.0 mg·g-1,穿透点处废水的处理能力为4.7 g(废水)·g-1(活性炭).对吸附剂进行分步热再生的适宜条件是,第一步控制温度为110～130℃,脱除吸附柱内35%～40%的残余水,以浓缩醋酸.第二步继续升温至320℃,脱附并回收醋酸,醋酸的脱附率可达96%以上,收率为87%,回收醋酸的浓度为30%左右.吸附–脱附的循环实验表明,活性炭的吸附和脱附性能稳定,数据重现性好.     

活性氧化铝吸附法处理草甘膦生产废水的研究

研究了活性氧化铝处理草甘膦生产废水的工艺过程,得到了较适宜的吸附和脱附工艺条件。研究结果表明,活性氧化铝Al-1对该废水具有良好的吸附-脱附处理效果。在原废水中草甘膦质量浓度为10000mg/L．COD高达30000mg/L时,用10mL Al-1氧化铝吸附处理该废水(处理量为每批次100mL),革甘膦的去除率大于98%,COD去除率大于50%。     

絮凝沉淀-吸附两步法预处理松节油加工废水

采用絮凝沉淀-吸附两步法预处理松节油加工废水。筛选了絮凝剂和树脂类吸附材料,研究了吸附温度、时间、流量对吸附过程的影响,脱附剂及脱附液体积对解吸过程的影响。结果表明:常温下,pH值为7时,PAM为最佳的絮凝剂,废水中CODCr的去除率达36.1%;温度为30℃,pH值为7时,吸附流量为1 BV/h,聚氨酯为最佳的吸附材料,废水中CODCr的去除率可达35.7%;室温下依次以3 BV质量分数为6%的H2SO4溶液和2BV的水作为脱附剂,脱附流量为1 BV/h,脱附液体积为5 BV,脱附率可以达到92.3%;聚氨酯经过5次吸附-脱附后仍保持良好的吸附性能。     

硫辛酸生产废水的处理及资源化研究

通过动态吸附试验,综合考虑吸附量、脱附效果确定资源化硫辛酸生产废水中硫辛酸的最佳树脂是NG-16大孔吸附树脂,最佳的工艺条件为:pH 5～5.5,室温,吸附流量3 BV·h-1,双柱串联处理量25 BV·批-1,在30℃下,用3 BV甲醇+2BV水脱附,流量为1 BV·h-1,高浓度脱附液调pH至7.2～7.8,蒸馏回收硫辛酸和甲醇,低浓度脱附液套用,每吨废水可回收纯度80%左右的硫辛酸1.1 kg.处理后废水中硫辛酸的质量浓度从1 300～1 500mg·L-1降为0,总硫的质量浓度从400～450mg·L-1降为0.05mg·L-1,B/C从0.30提高到0.65,为硫辛酸废水的后续处理提供了良好的条件.     

活性炭对苯酚废水的处理

在静态条件下,研究了活性炭对苯酚废水的处理．比较了不同条件下活性炭对苯酚废水的处理效果,确定了处理废水的振荡时间、活性炭用量、废水pH值、温度、废水中苯酚浓度对处理结果的影响。实验结果表明,活性炭在振荡时间3．5h、用量4．0g、温度30℃、pH值为3．6左右的条件下,对100 mL质量浓度为50mg/L的苯酚废水的吸附效果最好。进行了活性炭处理不同浓度废水的比较实验,结果表明,活性炭处理各种浓度苯酚废水的去除率都很高,适用于对出水要求较高的水处理工艺。     

花生壳制活性炭及其脱六价铬研究

本文研究了用花生壳制备活性炭和用此活性炭去除水溶液中的Cr（Ⅵ）。采用化学活化法,即用H2SO4、H3PO4、ZnCl2、KOH活化花生壳中的炭。同时研究了这些活化剂的浓度和用量、热解时间和温度对活性炭性能的影响。采用亚甲基蓝吸附实验评价活性炭的性能。结果表明H3PO4和ZnCl2是良好的活化剂,KOH和H2SO4效果较差。溶液的pH值对活性炭吸附Cr（Ⅵ）的能力有很大影响。活性炭的吸附能力随着pH值的降低而升高,同时在不同的pH值下,炭的吸附速率也不同。pH值越低,Cr（Ⅵ）被吸附的越快。等温实验结果表明,在pH值等于2时,用H3PO4和ZnCl2活化的活性炭对Cr（Ⅵ）的吸附能力分别达到125．0和83．3mg·g^-1。花生壳活性炭吸附Cr（Ⅵ）的机理比较复杂,与溶液的pH值有关。在pH值等于2时,等温吸附可以用Langmuir模型模拟;在pH值等于2～7时,可以用Freundlich模型模拟。     

活性炭对模拟含酚废水的吸附实验研究

采用振荡平衡法研究了活性炭吸附苯酚的效果,确定了活性炭用量、振荡时间、温度、pH值对模拟含酚废水中苯酚吸附效果的影响。结果表明：活性炭用量1．6g,振荡时间30min,温度30℃,pH值为6的条件下,对50mL质量浓度为60mg／L的苯酚模拟废水处理效果最佳。     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料,介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比,介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序,对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。