现代工艺金华火腿中游离氨基酸含量的研究

通过跟踪金华火腿的现代化工艺生产过程,选取原料腿、预腌结束、腌制结束、风干中期、风干结束、成熟前期(成熟1)、成熟中期(成熟2)、成熟结束(成熟3)和后熟结束9 个工艺点对金华火腿股二头肌中游离氨基酸的含量进行测定。结果表明：肌肉中的游离氨基酸(FAA)含量都随金华火腿加工进程逐渐升高;成熟过程中升高最快。FAA 总量比腌制前提高5 倍左右,多数FAA 浓度为腌制前的10 倍,含量较高的FAA 有Glu、Leu、Ala、Arg 等,增加比例较大的有Glu、Thr、Val、Ile 和Pro 等。     

肌肉非蛋白氮和游离氨基酸在金华火腿加工过程中的变化

以60只浙江兰溪当地杂交猪后腿为原料,按传统工艺加工金华火腿,分析了股二头肌中非蛋白氮(Non-proteinnitrogen,NPN)和游离氨基酸(Freeaminoacids,FAA)浓度随加工时间而变化的规律。结果表明,肌肉中的NPN和FAA含量都随金华火腿加工进程逐渐升高;NPN在后熟期和晒腿期间升高速度最快,而FAA在成熟过程中升高最快,成品火腿的蛋白质降解指数在14～20之间;成品火腿中的FAA占NPN的70%以上,其中以Arg、Glu、Leu、Lys、Ala和Val等含量较高。FAA总含量比腌制前提高13.8倍,火腿中大部分FAA浓度为腌制前的10～20倍,其中增加比例较大的FAA有Lys、Asp、Ser、Tyr和Ile等。火腿中大部分游离氨基酸的浓度多倍于其感觉阈值,因此可能对火腿风味的形成有重要贡献。     

金华火腿生产过程中风味成分的变化

取60条杂交猪后腿作为原料，按金华火腿传统生产工艺进行生产，分别在原料、盐后、晒后、成熟中期、成熟结束、后熟（1）、后熟（2）工艺段随机取5条腿的股二头肌作为样品进行风味成分检测．结果显示：原料腿和盐后腿中检出89种风味物质，晒后腿中检测出90种风味物质，成熟中期和成熟结束腿中分别检测出91种和96种风味物质，在后熟（1）和后熟（2）工艺段分别检测出93种和94种风味物质．这些成分可归类为：烷烯烃、芳香烃、醇、醛、酮、酸、酯、含氧杂环化舍物、含氮化合物、含硫化合物、含氯化舍物、酰胺和萜烯类等物质，其生产过程中的变化规律不同．在金华火腿产品的风味成分中，醛类占化舍物总数的45．07％，酸占18．39％，醇占13、93％，酮占9．00％．主成分分析显示，第一主成分主要由5种直链醛组成，第二主成分主要由5种直链醇和支链醇、2种支链酮、甲苯、已烷等组成．第一和第二主成分总计解释了金华火腿风味成分变化总方差的90．6％。     

Proteolysis in biceps femoris during Jinhua ham processing

Sixty experimental Jinhua hams were processed by a traditional method. The nitrogen fractions and free amino acids in biceps femoris were analyzed. Intense proteolysis was found in ham muscle and totally more than 10% of muscle proteins were degraded during the course of Jinhua ham processing. The proteolytic index of Jinhua ham was between 14 and 20. Both insoluble and soluble proteins were degraded to some degree and the later showed more intense degradation. In the soluble fraction, the percentage of non-protein nitrogen (NPN) increased gradually whereas that of protein nitrogen decreased during processing (P<0.05). However, very small amount of peptides larger than 1kDa was accumulated during the whole course of processing, which proved that intense degradation reactions were also happened to them, especially at the post ripening stage when dramatic decrease of nitrogen fraction from all the peptides larger than 1kDa was found. As a result, more than 90% of the NPN products from muscle proteolysis were free amino acids and peptides of MW less than 1kDa that might make important contribution to Jinhua ham taste and provide precursors for the generation of volatile flavor compounds in ham muscle. The pattern of muscle proteolysis coincided with the reported changes of muscle proteolytic enzymes during processing, seemingly indicating that the enzymes could have played important roles in ham muscle proteolysis.     

Studies on time-related changes of dipeptidyl peptidase during processing of Jinhua ham using response surface methodology

Sixty experimental Jinhua hams were processed by traditional methods using green hams from local cross-bred pigs of Lanxi, Zhejiang province, PR China. Biceps femoris was sampled from five hams randomly taken after each processing stage. Potential activities of DPP I and IV in addition to the changes of some enzyme influencing factors were determined. The effects of temperature, sodium chloride content, sodium nitrate content and pH value on the activities of muscle DPP I and IV were evaluated using Response Surface Methodology (RSM) and the actual activities of muscle DPP I and IV during Jinhua ham processing were estimated. The results showed that potential activity of muscle DPP I decreased gradually from 8608.23 to 1842.06 Ug(-1) before loft-aging and then increased gradually from 1842.06 to 12196.60 Ug(-1) at the end, while that of muscle DPP IV decreased continuously and about 11% of the initial potential activity was left at the end of processing. Most of the chemical components analyzed in Biceps femoris as well as physical parameters changed greatly during processing. Temperature, sodium chloride concentration and pH value influenced DPP I and IV activities significantly. However, nitrate concentration from 0 to 50 mgkg(-1) showed little effect. By regression analysis, two quadratic regression equation models were built. The models showed that DPP I could have strong activity during Jinhua ham processing, whereas the activity of DPP IV was always very weak despite its strong potential for activity. In conclusion, muscle DPP I may be a key enzyme responsible for the generation of dipeptides in Jinhua ham processing while the effect of DPP IV was possibly very limited.     

金华火腿质量与原料选择的关系研究

中式火腿如金华火腿与西方地中海地区的干腋火腿都属于高档的肉类制品。金华火腿质量取决于两个主要方面：一是独特的加工方法；二是严格的原料选择。本文从选料着手，分析在金华火腿加工过程中原料的质量对火腿成熟的作用，以及最终对产品质量的影响。     

Changes in flavor compounds of dry-cured Chinese Jinhua ham during processing

Sixty experimental Jinhua hams were processed by a traditional method using green hams from local Liangtouwu cross-bred pigs. Samples of Biceps femoris were taken from five hams randomly at each of the key stages of production, i.e., green ham, end of salting, end of sun-drying, middle of loft-aging, end of loft-aging, post-aging-1 and post-aging-2. Analysis of flavor compounds showed 89 compounds at the green ham stage and at the end of salting, 90 at the end of sun-drying, 91 at the middle of loft-aging, 96 at the end of loft-aging, 93 at the post-age-1 and 94 at the post-age-2. The flavor compounds could be clustered in the following chemical families: alkanes and alkenes, aromatic hydrocarbons, alcohols, aldehydes, ketones, carboxylic acids, esters, oxygenous heterocycle compounds, nitrogenous compounds, sulphur compounds, chloride compounds, amides, and terpenes. During processing, the concentrations of aldehydes and carboxylic acids increased; while the concentrations of alcohols, ketones, alkanes, alkenes, aromatic and cyclic hydrocarbons decreased. Sulphur compounds and pyrazines were formed and increased continuously during processing. In the final Jinhua ham, the contents of aldehydes, carboxylic acids, alcohols and ketones were 45.07%, 18.39%, 13.93% and 9.00% of the total flavor substances, respectively. The first principal component was a group dominated by five unbranched aldehydes; the second principal component was a group dominated by five branched and unbranched alcohols, two branched ketones, toluene, hexane and 4-nitrophthalamide. The two principal components explained 90.6% of the total flavor variance in Jinhua ham.     

Changes of alanyl aminopeptidase activity and free amino acid contents in biceps femoris during processing of Jinhua ham

Sixty experimental Jinhua hams were processed by a traditional method. The potential alanyl aminopeptidase (AAP) activity in biceps femoris was determined. The effects of temperature, salt content, sodium nitrate content and pH on muscle AAP were evaluated using response surface methodology. Porcine muscle was found to possess very strong potential AAP activity that decreased gradually during processing from 201,635 U g⁻¹ before salting to 6147 U g⁻¹ after aging. Temperature, pH and salt content had significant exponential effects on AAP activity (P < 0.001). Both temperature and salt content interacted with pH in their effects on AAP activity (P < 0.01). However, 0–50 mg L⁻¹ sodium nitrate had no detectable effect on AAP activity (P > 0.05). The regression model showed muscle AAP maintaining its activity all through Jinhua ham processing, indicating that muscle AAP may generate free amino acids during the processing and storage of Jinhua ham. The concentrations of free amino acids increased significantly (P < 0.05) during Jinhua ham processing, except for arginine and cystine. The concentrations of most free amino acids were 5–20 times higher in the final product than in hams before salting. Final concentrations exceeded thresholds for sensory detection, thus implicating an important role of free amino acids in the determination of Jinhua ham flavor.     

应用响应曲面法研究金华火腿生产过程中磷脂酶的变化

取 6 0条杂交猪后腿作原料按传统金华火腿生产工艺进行生产 ,分别在原料、盐后、晒后、成熟中期、成熟后期、后熟 (1)、后熟 (2 )工艺段随机取 5条腿的股二头肌作为样品测定潜在的磷脂酶活力 ,结果显示潜在的磷脂酶活力在生产过程中不断下降 ,原料中酶活为 3 0 5 ,到后熟 (1)酶活为 0 . 16 ,在后熟 (2 )已测不到酶活。利用响应曲面法研究磷脂酶在生产过程中实际酶活的变化情况并建立酶活变化数学模型 ,结果表明 ,温度和盐含量是影响磷脂酶活力的显著因子 ,通过模型预测 ,生产过程原料中的实际酶活为 0. 2 1,盐后为 0 . 13,之后酶活不断提高 ,到成熟后期达最高 ,为 0 . 4 1,之后再开始下降。     

金华火腿加工过程中肌肉肌内脂的水解变化研究

研究了金华火腿股二头肌 (bicepsfemoris)肌内脂肪在加工过程中不同时期的水解变化情况。肌内脂使用氯仿 甲醇溶液提取 ,采用固相萃取法将中性脂 (主要为甘油脂 )、游离脂肪酸和磷脂分离 ,用毛细管气相色谱分别分析甘油脂、游离脂肪酸和磷脂脂肪酸的种类与比例。通过比较不同时期样品的色谱结果 ,发现在金华火腿原料中磷脂脂肪酸的不饱和脂肪酸百分含量较高 ,尤其是多不饱和脂肪酸的含量高达 4 9 2 2 %。且在金华火腿成熟过程中 ,磷脂水解作用显著 ,而甘油脂脂肪酸百分比例比较稳定 ,说明甘油脂水解作用相对较弱。     

Influence of partial replacement of NaCl with KCl on formation of volatile compounds in Jinhua ham during processing

The influence of partial replacement of NaCl with KCl on formation of volatile compounds during Jinhua ham processing was evaluated using GC/MS system. Jinhua ham was treated with either 100% NaCl (I) or 60% NaCl and 40% KCl (II). Formation of volatile compounds increased in Jinhua hams during processing for both salt formulations, particularly at the end of the salting period. There were differences in volatile compound formation between formulations I and II after 45 days of processing. Contents of lipid-derived volatiles (hexanal) and Strecker aldehydes (2-methylbutanal and 3-methylbutanal) were higher in Jinhua hams treated with formulation II after 45 days of processing. Partial salt replacement of NaCl with KCl changed formation of volatile compounds in Jinhua hams and may have affected the flavor of finished products.     

原料腿对金华火腿腌制及产品品质的影响

采用传统工艺和新工艺加工金华火腿,研究了原料腿重量、鲜冻状态、皮下脂肪厚度对金华火腿腌制过程和加工品质的影响。结果表明:原料腿重影响腌制用盐量、加工各阶段后的失重率、后熟后的产品质量;皮下脂肪厚度影响腌制进程和腌制失重率;冻腿可以作为金华火腿加工的原料腿,但产品加工质量略差。     

采用同时蒸馏提取法分析不同加工时期金华火腿香味成分

腌制时间对金华火腿的风味与质量十分重要 ,文中采用同时蒸馏提取法比较了成熟火腿(发酵 1a)和生火腿 (未经发酵 )中的风味成分 ,分别得到了 77种和 62种化合物。结果显示 ,成熟火腿中的醛醇类物质 (3 4种 )尤其是烯醛和烯醇的种类和数量明显多于生火腿 (1 5种 )。同时 ,文中还讨论分析了各类组分及它们的风味贡献。     

金华火腿特征风味物质研究进展

金华火腿是我国传统的干腌火腿,以其特殊的风味而著称。通过对金华火腿及其它干腌火腿主要风味物质、形成机理、提取及鉴定方法等研究现状的综述,表明对金华火腿特征风味物质的深入研究有利于了解风味物质形成规律,为金华火腿加工工艺控制及火腿调味料开发应用提供理论基础。     

金华火腿的研究现状及发展趋势

通过对金华火腿产品现状与质量安全控制技术等内容的研究,为进一步完善标准体系,制定与国际接轨的质量标准体系,统一火腿生产企业有关生产工艺、技术设备、过程控制等方面的质量控制规范奠定基础。并以此来完善金华火腿的标准体系,生产符合国际环保标准的"绿色金华火腿",提升金华火腿国际竞争力和金华火腿的新价值。     

近红外光谱法测定金华火腿生产过程中的品质参数

以金华火腿为研究对象,采用傅里叶近红外光谱分析技术检测火腿生产过程中的品质参数.火腿样品经万能机粉碎,在AntarisⅡ傅里叶变换近红外光谱仪上扫描,获得其近红外光谱.参照国标法测定对应样本的过氧化值和水分含量,用Norris导数平滑滤波及一阶导数对光谱预处理,建立火腿过氧化值和水分含量的偏最小二秉(PLS)回归模型.其中过氧化值模型中样品预测值与实测值的相关系数r2=0.99091,预测均方差(RMSEP)0.436,平均相对标准偏差0.34％,与化学测定值无显著差异.水分含量模型中样品的预测值与实测值的相关系数r2= 0.93537,RMSEP为0.0184.本实验结果表明近红外光谱技术可快速检测金华火腿生产过程中的品质参数.     

金华火腿工艺过程蛋白质水解及其相关性研究

本文通过对金华火腿工艺过程总氮、非蛋白氮及游离氨基酸的分析研究,来确定其蛋白质分解与工艺过程产品水分、NaCl含量及温湿度条件的相关性;结果表明:工艺过程中非蛋白氮和游离氨基酸的变化与工艺过程湿度和产品水分的降低、温度和NaCl含量的提高呈正相关,且蛋白质在工艺过程中发生了持续降解。     

金华火腿加工过程中内源脂肪酶活力变化特点研究

以浙江兰溪两头乌杂交猪后腿为原料,按传统工艺加工金华火腿。分别在原料、腌制结束、晒腿结束、成熟中期、成熟结束、后熟-1和后熟-2七个工艺点随机取5条腿的股二头肌为样品,分别测定中性脂肪酶、酸性脂肪酶的活力变化,以及测定pH5.8时脂肪酶综合活力的变化;同时,利用响应曲面法研究温度、盐含量、硝酸盐含量、亚硝酸盐含量对脂肪酶活力的影响,并利用所得回归方程预测金华火腿加工过程中脂肪酶的实际表现活力。结果表明,加工过程中,脂肪酶活力持续降低,在后熟-1工艺点,酸性脂肪酶和中性脂肪酶活力残留分别是8.16%和3.0%,至后熟-2已测不到酶活;温度、盐含量及其交互项是脂肪酶活力的显著影响因子(P<0.05),硝酸盐和亚硝酸盐含量对脂肪酶活力影响不显著(P>0.05)。加工过程中,预测的脂肪酶实际表现活力在成熟中期工艺点之前低于酸性脂肪酶及中性脂肪酶的潜在活力,之后则高于潜在活力,其变化规律与酸性和中性脂肪酶完全不同。     

Changes of arginyl and leucyl aminopeptidase activities in biceps femoris along Jinhua ham processing

Sixty experimental Jinhua hams were processed by a traditional method. The potential arginyl (RAP) and leucyl (LAP) aminopeptidase activities in biceps femoris were determined. The effects of temperature, salt content, sodium nitrate content and pH value on muscle RAP and LAP activities were evaluated using response surface methodology. Porcine muscle was found to possess very strong potential RAP and LAP activities that decreased gradually during processing from 165,980.97Ug(-1) and 89,201.52Ug(-1) before salting to 3164.70Ug(-1) and 5373.66Ug(-1) after aging, respectively. Temperature, pH value and salt content had significant effects on RAP and LAP activities (P<0.0001). They interacted with each other in their effects on RAP activity (P<0.0001) and influenced LAP activity in exponential way (P<0.05). However, 0-50mgL(-1) sodium nitrate had no detectable effect on either RAP or LAP activity (P>0.05). The regression models showed that muscle RAP and LAP maintained their activities all through Jinhua ham processing. LAP could display very strong actual activity during aging and post-aging, indicating that muscle LAP may play the most important role in generating free amino acids during the processing of Jinhua ham.     

不同地域典型干腌火腿肌原纤维蛋白的氧化特性及体外消化性对比

为比较几种典型干腌火腿的可消化吸收性,以巴马火腿、金华火腿、宣威火腿、帕尔玛火腿为原料,研究4 种干腌火腿的肌原纤维蛋白表面疏水性、巯基和二硫键含量、超微结构、蛋白降解程度、消化前后粒径及体外消化率。结果表明：金华火腿肌原纤维蛋白的表面疏水性显著高于巴马、宣威、帕尔玛火腿（P＜0.05）。微观结构分析显示金华火腿肌原纤维蛋白交联和聚集程度最低,肌原纤维排布更为伸展;帕尔玛火腿聚集程度最大,呈现明显聚集状。十二烷基硫酸钠-聚丙烯酰胺凝胶电泳谱图显示金华火腿肌原纤维蛋白在体外消化过程中大幅降解,促进了肌原纤维蛋白粒径的降低。体外模拟消化结果表明,经胃蛋白酶、胰蛋白酶及α-凝乳蛋白酶作用后,金华火腿肌原纤维蛋白水解速率最高（P＜0.05）;帕尔玛火腿肌原纤维蛋白水解速率最低（P＜0.05）。这表明疏水基团的暴露和蛋白结构的伸展为消化酶提供了更多的识别位点,促进了金华火腿中肌原纤维蛋白的水解。综上,肌原纤维蛋白的氧化程度显著影响蛋白的体外消化率。