Effect of Lipase Activity and Specificity on the DAG Content of Olive Oil from the Shodoshima-Produced Olive Fruits

Olive oils have a higher relative diacylglycerol (DAG) content than other plant oils. The lipase in olive fruits is involved in DAG production and is directly related to the acidity of the olive oil. However, the lipase activity and positional selectivity have not been clarified. To investigate the properties of olive fruit lipase, olive fruits of the Mission variety harvested during mid-December of 2005 on Shodoshima Island (Japan) were stored at 20, 30 or 40 °C for 4 weeks. Changes in the acidity and acylglycerol content of the oils extracted from the stored fruits were analyzed. The acidity and DAG content of the olive oils increased due to triacylglycerol (TAG) hydrolysis during storage. sn-1,2-DAGs preferentially increased during the early stages of storage, indicating that the olive fruit lipase is enantioselective for the sn-3 position, while non-enzymatic isomerization of sn-1,2-DAGs was observed throughout the entire duration of storage. Kinetic analysis revealed that the enantioselectivity of olive fruit lipase for the sn-3 position was approximately four times greater than for the sn-1 position. The lipase was gradually inactivated at temperatures of 30 °C or higher, and the ratios of the rate constant for inactivation to TAG hydrolysis at the sn-3 position was 0.2, 13, and 23 at 20, 30, and 40 °C, respectively.     

Enzymatic Synthesis of Structured Triacylglycerols Containing CLA Isomers Starting from <Emphasis Type="Italic">sn</Emphasis>-1,3-Diacylglycerols

The synthesis of structured triacylglycerols (TAG) by the enzymatic reaction between sn-1,3-diacylglycerols (sn-1,3-DAG) and conjugated linoleic acid (CLA) isomers was studied. Both the substrates of the reaction were produced from vegetable oils, the sn-1,3-DAG from extra virgin olive oil and the CLA isomers from sunflower oil. The enzymatic reactions between these substrates were catalyzed for 96 h by an immobilized lipase from Rhizomucor miehei (Lipozyme IM) and the reactions carried out in solvent were monitored every 24 h by using high-performance liquid chromatography-evaporative light scattering detector (HPLC-ELSD). The enzymatic reactions were carried out in different reaction media (hexane, isooctane and solvent free) and with different CLA/sn-1,3-DAG ratios. Total % acidic composition and structural analysis data were evaluated to verify the presence of CLA isomers in sn-2- position of synthesized TAG. The results showed good levels of CLA incorporation in sn-1,3-DAG, from 19.2% of TAG synthesized in solvent free conditions with a 0.5:1 substrate ratio, to 47.5% of TAG synthesized in isooctane with a 2:1 substrate ratio. It was observed that for all the reaction media, the best sn-2- acylic specificity was obtained with a 0.5:1 substrate ratio.     

Lipolysis of different oils using crude enzyme isolate from the intestinal tract of rainbow trout, <Emphasis Type="Italic">Oncorhynchus mykiss</Emphasis>

Crude enzyme isolate was prepared from the intestine of rainbow trout. Positional specificity of the crude enzyme isolate was determined from both 1(3)- and 2-MAG products after in vitro lipolysis of radioactive-labeled triolein. The ratio of 2-MAG/1(3)-MAG was 2∶1, suggesting that the overall lipase specificity of the enzyme isolate from rainbow trout tended to be 1,3-specific; however, activity against the sn-2 position also was shown. In vitro lipolysis of four different unlabeled oils was performed with the crude enzyme isolate. The oils were: structured lipid [SL; containing the medium-chain FA (MCFA) 8∶0 in the sn-1,3 positions and long-chain FA (LCFA) in the sn-2 position], DAG oil (mainly 1,3-DAG), fish oil (FO), and triolein (TO). MCFA were rapidly hydrolyzed from the SL oil. LCFA including n−3 PUFA were, however, preserved in the sn-2 position and therefore found in higher amounts in 2-MAG of SL compared with 2-MAG of FO, DAG, and TO. Lipolysis of the DAG oil produced higher amounts of MAG than the TAG oils, and 1(3)-MAG mainly was observed after lipolysis of the DAG oil. The positional specificity determined and the results from the hydrolysis of the different oils suggest that n−3 very long-chain PUFA from structured oils may be used better by aquacultured fish than that from fish oils.     

Lipase-Catalyzed Concentration of Stearidonic Acid in Modified Soybean Oil by Partial Hydrolysis

Stearidonic acid (SDA, 18:4 ω-3) content of modified soybean oil (MSO) containing?~25?% SDA, was increased by lipase-catalyzed hydrolysis. Four non-immobilized powdered lipases, Lipase AY 30 (Candida rugosa), Lipase G 50 (Penicillium camembertii), Lipomod? 34P-L034P (Candida cylindracea [rugosa]), Lipomod? 36P-L036P (Rhizopus oryzae), and an immobilized lipase, Lipozyme RM IM (Rhizomucor miehei) were assessed, at various incubation times, for their ability to hydrolyze MSO and specificity toward SDA. The SDA enriched products contained triacylglycerols (TAG), diacylglycerols (DAG) and monoacylglycerols (MAG). Lipase 34P-L034P exhibited specificity towards SDA, while Lipase AY was able to discriminate against it. The highest total SDA content (40.9?mol%) was obtained with Amano AY lipase at 4?h incubation (66.2?% hydrolysis). Unhydrolyzed TAG, 1,3-DAG, 2,3(1)-DAG, and MAG contained 37.7 (56.4 at the sn-2 position), 41.6, 51.5 (54.9 at the sn-2 position), and 49.9?% SDA, respectively. Amano AY lipase was also used to hydrolyze previously SDA-enriched TAG (48.7?% SDA) obtained from low temperature crystallization of MSO. The highest total SDA content (62.7?mol%) was obtained at 12?h incubation (85.9?% hydrolysis). The SDA contents of unhydrolyzed TAG, 1,3-DAG, 2,3(1)-DAG, and MAG were 58.7 (65.7 at the sn-2 position), 71.2, 70.2 (52.9 at the sn-2 position), and 59.4?%, respectively.     

Diacylglycerol acyltransferases from Vernonia and Stokesia prefer substrates with vernolic acid

Genetic engineering of common oil crops for industrially valuable epoxy FA production by expressing epoxygenase genes alone had limited success. Identifying other key genes responsible for the selective incorporation of epoxy FA into seed oil in natural high accumulators appears to be an important next step. We investigated the substrate preferences of acyl CoA: diacylglycerol acyltransferases (DGAT) of two natural high accumulators of vernolic acid, Vernonia galamensis and Stokesia laevis, as compared with a common oilseed crop soybean. Developing seed microsomes were fed with either [¹⁴C]oleoyl CoA or [¹⁴C]vernoloyl CoA in combinations with no exogenous DAG or with 1,2-dioleoyl-sn-glycerol, 1-palmitoyl-2-vernoloyl-sn-glycerol, 1,2-divernoloyl-sn-glycerol, 1,2-dioleoyl-rac-glycerol, or 1,2-divernoloyl-rac-glycerol to determine their relative incorporation into TAG. The results showed that in using sn-1,2-DAG, the highest DGAT activity was from the substrate combination of vernoloyl CoA with 1,2-divernoloyl-sn-glycerol, and the lowest was from vernoloyl CoA or oleoyl CoA with 1,2-dioleoyl-sn-glycerol in both V. galamensis and S. laevis. Soybean DGAT was more active with oleoyl CoA than vernoloyl CoA, and more active with 1,2-dioleoyl-sn-glycerol when oleoyl CoA was fed. DGAT assays without exogenous DAG, or with exogenous sn-1,2-DAG fed individually or simultaneously showed consistent results. In combinations with either oleoyl CoA or vernoloyl CoA, DGAT had much higher activity with rac-1,2-DAG than with their corresponding sn-1,2-DAG, and the substrate selectivity was diminished when rac-1,2-DAG were used instead of sn-1,2-DAG. These studies suggest that DGAT action might be an important step for selective incorporation of vernolic acid into TAG in V. galamensis and S. laevis.     

Parameters affecting diacylglycerol formation during the production of specific-structured lipids by lipase-catalyzed interesterification

Diacylglycerols (DAG) are important intermediates in lipase-catalyzed interesterification, but a high DAG concentration in the reaction mixture results in a high DAG content in the final product. We have previously shown that a high DAG concentration in the reaction mixture increases the degree of acyl migration, thus adding to the formation of by-products. In the present study we examined the influence of water content, reaction temperature, enzyme load, substrate molar ratio (oil/capric acid), and reaction time on the formation of DAG in batch reactors. We used response surface methodology (RSM) to minimize the numbers of experiments. The DAG content of the product was dependent on all parameters examined except reaction time. DAG formation increased with increasing water content, enzyme load, reaction temperature, and substrate ratio. The content of sn-1,3-DAG was higher than that of sn-1,2-DAG under all conditions tested, and the ratio between the contents of the former compounds and the latter increased with increasing temperature and reaction time. The water content, enzyme load, and substrate ratio had no significant effect on this ratio. The DAG content was positively correlated with both the incorporation of acyl donors and the degree of acyl migration.     

Synthesis and Structural Analysis of Structured Triacylglycerols with CLA Isomers in the <Emphasis Type="Italic">sn</Emphasis>-2- Position

The present research deals with the chemical esterification of the sn-2- position of sn-1,3-diacylglycerol (sn-1,3-DAG) with 9cis,11trans (c9,t11) and 10trans,12cis (t10,c12) conjugated linoleic acid (CLA) isomers to obtain structured triacylglycerols (TAG); the sn-1,3-DAG substrates were produced from extra virgin olive oil by means of enzymatic reactions while CLA isomers were obtained using a three-step procedure based on alkaline hydrolysis of sunflower oil, urea purification of linoleic acid (LA) and alkaline isomerization of LA. The results showed good levels of CLA incorporation in structured TAG at the tested temperatures: 37.5% at 4 °C and 39.1% at 14 °C. To evaluate the incorporation of CLA isomers in sn-2- position of sn-1,3-DAG structural analysis of the newly synthesized TAG was carried out using an enzymatic and a chemical method. The results of the structural analysis also showed up the occurrence of acyl migration. The pancreatic lipase method allowed the direct determination of the fatty acid composition of TAG sn-2- position but this enzymatic method showed different results (p < 0.05) in respect to the chemical one; this occurrence could be due to an acylic specificity of the lipase. High incorporation of CLA isomers in sn-2- position of TAG was observed, 77.0% at 4 °C and 81.5% at 14 °C, considering the results of the chemical procedure.     

Digestion and assimilation features of dietary DAG in the rat small intestine

Several recent studies have demonstrated that dietary DAG oil rich in 1,3-species suppresses the postprandial increase of serum TAG level and decreases body fat accumulation, compared with TAG oil. To clarify the mechanisms underlying the beneficial effects of DAG, we investigated the metabolic features of DAG in the small intestine with regard to the digestion pathway in the lumen and the TAG-synthesis pathway in the mucosa. When intraduodenally infused as an emulsion, TAG was digested to 1,2-DAG, 2-MAG, and FFA, whereas 1,3-DAG was digested to 1(3)-MAG and FFA. When assessed by the incorporation of [1-¹⁴C]linoleic acid in lipids, the mucosal TAG-synthesis was significantly reduced by DAG infusion compared with TAG infusion. However, the mucosal 1,3-DAG synthesis was remarkably increased in the DAG-infused rats. The total amount of mucosal 1,3-DAG was also increased (4.5-fold) after DAG infusion compared with that after TAG infusion. Next, we examined the synthesis pathway of 1,3-DAG. In cultures of the everted intestinal sacs, 1,3-DAG production required the presence of 1-MAG, suggesting that the 1,3-DAG synthesis was due to acylation of 1(3)-MAG in the DAG-infused rats. Furthermore, measurements of DAG acyltransferase activity indicated that 1,3-DAG was little utilized in TAG synthesis. These findings suggest that features of 1,3-DAG digestion and assimilation in the intestine may be responsible for the reduction of the postprandial serum TAG level by dietary DAG.     

Effect of filtration on virgin olive oil stability during storage

The effect of filtration and dehydration on the stability and quality of virgin olive oil during storage at room temperature (25 °C) and under accelerated conditions (40 °C) was studied. Different types of monovarietal olive oil, namely unfiltered (UF), filtered (F) and filtered‐dehydrated (FD), were obtained from Arbequina, Colombaia, Cornicabra, Picual and Taggiasca cultivars. Results showed that filtration and dehydration decreased the rate of hydrolysis of the triacylglycerol matrix, especially at the higher temperature and in oils with a higher initial free acidity (e.g. free acidity of 0.82% and 0.63% in UF and FD Colombaia samples, respectively, after 8 months of storage), and delayed the appearance of rancid defects (e.g. UF and FD Arbequina samples lost extra‐virgin grade after 10 and 12 months of storage, respectively). The formation of simple phenols due to the hydrolysis rate of their secoiridoid derivatives was also greater in unfiltered olive oils (e.g. 174 μmol/kg and 137 μmol/kg in UF and FD Picual samples, respectively, after 8 months of storage). Thus, filtration and especially dehydration could help to prolong the shelf life of high‐quality and less stable olive oils like those obtained from the Arbequina and Colombaia varieties.     

Production of Diacylglycerol-Mixture of Regioisomers with High Purity by Two-Step Enzymatic Reactions Combined with Molecular Distillation

Pure diacylglycerol (DAG) is of vital importance for the biomedical and dietetic properties research of DAG. In this study, we aimed to develop an effective process to produce DAG-mixture of regioisomers with high purity. Firstly, DAGs and monoacylglycerols (MAGs) were synthesized by enzymatic esterification of glycerol and free fatty acids (FFAs) from camellia oil with catalysis of Penicillium camembertii lipase, and the obtained reaction mixture was composed of 49.9 % DAG [33.4 % for 1,3-DAG and 16.5 % for 1,2 (2,3)-DAG], 31.6 % MAG and 18.5 % FFA. Secondly, a monoacylglycerol lipase (lipase CBD-MGLP), which was produced by recombinant Escherichia coli in our laboratory, was employed to hydrolyze MAG in the above reaction mixture, and the MAG content decreased to 1.9 % under the optimal conditions with 375 U/g (U/w, with respect to the mass of MAG in the mixture) of CBD-MGLP loading, temperature of 45 °C, mass ratio of esterification mixture to Tris–HCl buffer (w/w) 10:10, and pH of Tris–HCl buffer 9.0. Then, the hydrolytic products were further purified by molecular distillation at low temperature of 130 °C under a pressure of 10 Pa [equivalent to 377 °C at 101.325 kPa (1 atm)], and the DAG purity was up to 98.0 % (66.6 % for 1,3-DAG and 31.4 % for 1,2-DAG) in the final products. This indicated that two-step enzymatic reactions combined with molecular distillation at low temperature could be a feasible and prospective process to produce DAG-mixture of regioisomers with high purity.     

Analysis of diastereomeric DAG naphthylethylurethanes by normal-phase HPLC with on-line electrospray MS

Normal-phase HPLC resolution of sn-1,2(2,3)- and x-1,3-DAG generated by partial Grignard degradation from natural TAG was carried out with both (R)-(−) and (S)-(+)-1-(1-naphthyl)ethylurethane derivatives. The diastereomeric sn-1,2- and sn-2,3-DAG derivatives were resolved using two Supelcosil LC-Si (5 μm, 25 cm × 4.6 mm i.d.) columns in series and an isocratic elution with 0.37% isopropanol in hexane at a flow rate of 0.7 mL/min. The DAG were detected by UV absorption at 280 nm and were identified by electrospray ionization MS in the positive ion mode following postcolumn addition of chloroform/methanol/30% ammonium hydroxide (75∶24.5∶0.5, by vol) at 0.6 mL/min. Application of the method to a stereospecific analysis of the molecular species of TAG of rat VLDL showed that the TAG composition of VLDL circulating under basal conditions differs markedly from that of VLDL secreted by the liver during inhibition of serum lipases. The inhibition of serum lipases resulted in a significant proportional decrease in 16∶0 and PUFA and an increase in 18∶0 and oligoenoic FA in the sn-1-position, whereas the FA compositions in the sn-2- and sn-3-positions were much less affected.     

Stereospecific analysis of TAG from sunflower seed oil

Stereospecific analysis of TAG from a sunflower seed oil of Tunisian origin was performed. The TAG were first fractionated according to chain length and degree of unsaturation by RP-HPLC. The four major diacid- and triacid-TAG fractions were palmitoyldilinoleoyl-glycerol, dioleoyllinoleoylglycerol, oleoyldilinoleoylglycerol, and palmitoyloleoyl-linoleoyl-glycerol, amounting to 7.2, 16.6, 29.5, and 12 mol%, respectively. The TAG of the four fractions were individually submitted to stereospecific analysis, using a Grignard-based partial deacylation, separation of sn-1,2(2,3)-DAG from sn-1,3-DAG by boric acid-impregnated silica gel TLC plates, conversion of the sn-1,2(2,3)-DAG to their 3,5-dinitrophenylurethane (DNPU) derivatives, fractionation of DNPU derivatives by RP-HPLC, resolution of the DNPU-DAG by HPLC on a chiral column, transmethylation of each sn-DNPU-DAG fraction, and analysis of the resulting FAME by GC. The data obtained were used to determine the triacyl-sn-glycerol composition of the main TAG of the oil. Fifteen triacyl-sn-glycerols were identified and quantified, representing, along with the monoacid-TAG, trilinoleoylglycerol and trioleoylglycerol, more than 90% of the total oil TAG. The two major triacyl-sn-glycerols were trilinoleoyl-glycerol and 1-linoleoyl-2-linoleoyl-3-oleoyl-glycerol (18.6 and 18.5% of the total, respectively). Results clearly identified linoleic acid as the major FA at the sn-2 position, whereas oleic and palmitic acids were the major FA at the sn-3 position. The sn-1 position was occupied to nearly the same extent by linoleic and oleic acids, and to a greater extent by palmitic acid, which was practically absent at the sn-2 position.     

Optimization of reaction conditions for the production of DAG using immobilized 1,3-regiospecific lipase lipozyme RM IM

Oils with a high DAG (1,3-DAG) content have attracted considerable attention as a healthful food oil component. In this study, we report on the synthesis of 1,3-DAG from a mixture of FA, constituted largely of oleic and linoleic acids, using an immobilized 1,3-regioselective lipase from Rhizomucor miehei in a solvent-free system. The kinetics of 1,3-DAG production from FA and glycerol were investigated on the basis of a simplified model, taking into consideration the acyl migration reaction, the removal of water, and glycerol dissolution in the oil phase in addition to the esterification reactions. Both the yield of 1,3-DAG and the purity of DAG were evaluated under a variety of experimental conditions, including reaction temperature, pressure, and amount of enzyme present. When either the reaction temperature or the amount of enzyme used was increased, the 1,3-DAG production rate increased, but yield remained relatively constant. The 1,3-DAG yield as well as the purity of DAG gradually decreased because of the enhancement of acyl migration at later stages of the reaction after the 1,3-DAG concentration reached a maximum. Vacuum was important for attaining high yields of 1,3-DAG. Under conditions of a high vacuum (1 mm Hg) at 50°C, 1.09 M 1,3-DAG was produced from 1.29 M glycerol and 2.59 MFA in an 84% yield and in 90% purity.     

Changes in olive oil composition due to microwave heating

The effects of microwave heating on some components of extra-virgin olive oil were studied. Traditional parameters, including free acidity, peroxide value and ultraviolet absorbance values at 232 and 268 nm, were determined in six extra-virgin olive oil samples before and after the microwave treatment. Significant differences (P<0.01) were detected for free acidity, peroxide, and ultraviolet absorbance at 268 nm; also, the absorbances at 232 nm showed significant differences (P<0.05) between treated and untreated samples. The glycerolic fractions, triacylglycerols (TAG), diacylglycerols (DAG), and monoacylglycerols (MAG), were isolated by thin-layer chromatography. The respective percentage fatty acid (FA) composition and percentage amount were obtained by high-resolution gas chromatography with an internal standard. For the most abundant TAG fraction, the stereospecific analysis was carried out to obtain the FA percentage compositions of the three sn-positions. Small but significant modifications were observed regarding the decrease in the TAG percentage and increases in the DAG and MAG percentage amounts. No significant changes were observed for the FA compositions of TAG, DAG, and MAG fractions before and after the treatment. Nevertheless, the results of TAG stereospecific analysis showed losses of unsaturated FA in all sn-positions. Higher percentage changes in the sn-1- than in sn-2-position of TAG were observed. Regarding the volatile fraction, different profiles were obtained after the treatment.     

Study of Some Experimental Parameters in the Synthesis of Triacylglycerols with CLA Isomers and Structural Analysis

The present research deals with the synthesis of structured triacylglycerols (TAG) by enzymatic treatment of sn-1,3-diacylglycerol (sn-1,3-DAG) with conjugated linoleic acid (CLA) isomers using the immobilized lipase from Rhizomucor miehei (Lipozyme^® IM) under different experimental conditions. In particular, the influence of reaction parameters, such as temperature, enzymatic load, reaction time and DAG/CLA ratio has been evaluated using an experimental design software with a screening objective. Two responses have been selected, they are the percentage of CLA isomers in total TAG and in the sn-2- position and a three-level-4-factor fractional factorial experimental design was used to screen the variables. The results showed that the selected experimental variables have an influence on the enzymatic reaction, in particular, the DAG/CLA substrate ratio and the temperature, both of which inversely correlated with CLA incorporation, but also the enzymatic load and the reaction time, both directly correlated with CLA incorporation. The best results for CLA isomer % content both in total TAG (46.3%) and in the sn-2- position (52.2%) were obtained at 40 °C for 96 h, with 20% enzymatic load and a 0.5 reactive ratio.     

The triacylglycerol structure of olive oil determined by silver ion high-performance liquid chromatography in combination with stereospecific analysis

The compositions of positionssn-1,sn-2 andsn-3 of triacylglycerols from “extra-virgin” olive oil (Olea europaea) were determined. The procedure involved preparation of diacyl-rac-glycerols by partial hydrolysis with ethyl magnesium bromide; 1,3-, 1,2- and 2,3-diacyl-sn-glycerols as (S)-(+)-1-(1-naphthyl)ethyl urethanes were isolated by highperformance liquid chromatography (HPLC) on silica, and their fatty acid compositions were determined. The same procedure was also carried out on the five main triacylglycerol fractions of olive oil after separation according to the degree of unsaturation by HPLC in the silver ion mode. Although stereospecific analysis of the intact triacyl-sn-glycerols indicated that the compositions of positionssn-1 andsn-3 were similar, the analyses of the molecular species demonstrated marked asymmetry. The data indicate that the “1-random, 2-random, 3-random” distribution theory is not always applicable to vegetable oils.     

Acyl Migration Kinetics of Vegetable Oil 1,2-Diacylglycerols

The acyl migration kinetics of long-chain 1,2-diacylglycerol (1,2-DAG) to form 1,3-diacylglycerol (1,3-DAG) over the temperature range of 25–80 °C were examined using ¹H-NMR spectroscopy. Lipase-catalyzed ethanolysis of high-oleic sunflower oil, followed by a series of solvent extraction steps, generated high purity 1,2-DAG (0.93 mol fraction of the DAG content). The 1,2-DAG mole fraction of 0.32 at equilibrium was found to be insensitive to temperature, indicating that long-chain acyl group migration is neither endothermic nor exothermic. Determination of the temperature-dependent, first-order reaction kinetic parameters revealed a 1,2-DAG half life (t _1/2) of 3,425 h and 15.8 h at 25 and 80 °C, respectively. A comparison of 1,2-DAG with 2-monoacylglycerol indicated that there is no difference between the two in the potential energy state (ΔG ^‡) of their respective transitions states or cyclic intermediates. Product names are necessary to report factually on available data; however, the USDA neither guarantees nor warrants the standard of the product, and the use of the name by the USDA implies no approval of the product to the exclusion of others that may be suitable.     

Effect of Agronomical Practices on the Nutritional Quality of Virgin Olive Oil at Different Ripening Stages

There is a need to verify the quality of organically produced olive oils and to compare them to conventional ones. The objective of this study was to assess possible differences in nutritional quality between agronomic practices in Picual and Hojiblanca olive oil varieties at different stages of olive ripeness. The results showed that organic versus conventional cultivation did not consistently affect acidity, peroxide index or spectrophotometric constants of the virgin olive oils considered in this study. On the contrary, phenol content, oxidative stability, tocopherol content and fatty acid composition were affected by the agronomical practices. Principal component analysis indicated that linolenic acid and β‐tocopherol were mainly responsible for discriminating Hojiblanca organic oils, whereas total phenols, palmitoleic acid and α‐tocopherol were the major contributors to differentiating Picual conventional oils. Lignoceric and stearic acids were related to oils from unripe and ripe olive fruits, respectively. Long‐term experiments are required to confirm these results.     

Diacylglycerols from butterfat: Production by glycerolysis and short-path distillation and analysis of physical properties

The aim of this paper was to develop a process for the production of DAG from butterfat through glycerolysis and short-path distillation and to evaluate the physical properties of the DAG in comparison with the original butterfat. Chemical glycerolysis produced a mixture of acylglycerols containing DAG together with MAG and TAG. From the mixture of glycerolysis products, MAG were removed through three consecutive distillations (vacuum <0.001 mbar) at 150°C. TAG were separated from DAG by distillation at 210°C, which gave a product with more than 80% DAG in the distillates. Distillation temperatures had significant effects on acyl migration. The formation of desirable 1,3-DAG was favored at higher temperatures. Under 210°C distillation, the equilibrium ratio of 6∶4 was obtained between 1,3-DAG and 1,2(2,3)-DAG. The FA profile of the DAG product was relatively similar to the original butterfat. The total DAG recovery was around 77% in the pilot-scale production. The different patterns of m.p. were observed between butterfat and the DAG fraction produced as well as the MAG fraction collected. Solid fat content profiles of the DAG fraction and its mixtures with rapeseed oil possessed trends similar to those of the corresponding butterfat and its mixtures with rapeseed oil. Compared with butterfat, the DAG fraction behaved differently in its thermal profiles, crystallization patterns, and rheological properties; for example, the dropping point was 13°C higher for the latter than for the former, and the crystal pattern was mostly β form for the latter, whereas the former was the β′ form.     

Enzymatic Synthesis of Diacylglycerols Enriched with Conjugated Linoleic Acid by a Novel Lipase from <Emphasis Type="Italic">Malassezia globosa</Emphasis>

Diacylglycerols (DAG) of conjugated linoleic acid (CLA) were prepared by esterification of glycerol with fatty acids enriched with CLA (FFA–CLA, >95%) in the presence of a novel lipase from Malassezia globosa (SMG1). Lipase SMG1 is strictly specific to mono- and diacylglycerols but not triacylglycerols, which is similar to the properties of lipase from Penicillium camembertii (lipase G 50), but lipase SMG1 showed preference on the production of DAG with the reaction proceeding. Low temperature was beneficial for the conversion of FFA–CLA into acylglycerols, the degree of esterification reached 93.0% when the temperature was 5 °C. The maximum DAG content (53.4%) was achieved at 25 °C. The rate of DAG synthesis increased as the enzyme loading increased. However, at lipase amounts above 240 U/g mixtures, no significant increases in DAG concentration were observed. The molar ratio of FFA–CLA to glycerol and initial water content were optimized to be 1:3 (mol/mol) and 3%. Lipase SMG1 showed no regioselectivity because the contents of 1,3-DAG and 1,2-DAG were 43.1% and 21.2% based on total content of acylglycerols. By calculating the ratio of 9c, 11t-CLA to 10t, 12c-CLA, it was indicated that lipase SMG1 showed a little preference to 10t, 12c-CLA at the sn-1(3) position of monoacylglycerols (MAG), while no selectivity for 9c, 11t-CLA at the sn-2 position of DAG was obviously found.